ICARO paragliders BATIS User manual

This manual is copyrighted.
Partial reproduction is allowed only
after prior approval by
ICARO paragliders, all other rights
are reserved.

Verification of Checks and repairs
BATIS
Serial number: ……………………….……………
First check by ICARO / date: ….…………………
………………………….
Name/ Stamp
Check (C)
Repair (R) Which repair/ Check?
Check valid until? Performed by/ date
Check (C)
Repair (R) Which repair/ Check?
Check valid until? Performed by/ date
Check (C)
Repair (R) Which repair/ Check?
Check valid until? Performed by/ date
Check (C)
Repair (R) Which repair/ Check?
Check valid until? Performed by/ date

TABLE OF CONTENTS
VERIFICATION OF CHECKS AND REPAIRS .................................................. 1
TO GET TO KNOW YOUR BATIS...................................................... 3
TECHNICAL DATA ............................ FEHLER!TEXTMARKE NICHT DEFINIERT.
POSITION SETTING .......................... FEHLER!TEXTMARKE NICHT DEFINIERT.
FLYING WITH THE BATIS ................................................................. 5
I. CARE AND REPAIR INSTRUCTIONS ........................................... 5
CARE INSTRUCTIONS ............................................................................. 5
REPAIRS............................................................................................... 6
INSPECTION .......................................................................................... 6
II. TERMS OF GUARANTEE............................................................. 6
III. ANNEX ......................................................................................... 8
Beinschlaufen
Umlenkrolle
Schultergurte-
Verstellschlaufe
Brustgurt


- 1 -
Congratulations on buying your
BATIS
harness and welcome the family
of ICARO - pilots!
Before you get to know your system please read the
manual, there is important information inside.
This manual gives you information on the entire specific and general
characteristics of the harness.
All technical data and instructions in this manual were drawn up with great care.
ICARO Paragliders cannot be made responsible for any possible errors in this
manual.
Should you decide to sell this harness at a later date, please pass on this manual
to the new owner.
No guarantee of any kind can be made against accidents, injury, equipment
failure, and/or death. It is assumed that the pilot is in possession of the necessary
qualifications and provisions of any relevant laws are observed.
The use of this harness is entirely at your own risk.
Every pilot bears the responsibility of his/her own safety. The manufacturer or
distributor assumes no responsibility for accidents occurring while using it.
Do not fly unless you are personally willing to assume all risks inherent in the sport
of paragliding and all responsibility for any property damage, injury, or death,
which may result from use of this sport.
Your harness is made with great care and state of the art, tested according
European Standards EN 1651:19991, and Notification of the Federal Aviation
Administration of Germany 2Is pattern tested as harness with foamed rubber
protector is suitable for training and tandem flying.
It is strictly prohibited to fly the harness
•with damaged carbines, belts, buckles or protector
•outside the specified weight range
•in aerobatics
•This product has been designed exclusively for paragliding. Any other
activity such as skydiving or base jumping is absolutely forbidden.
1Harnesses –Requirements and test methods
2„Directives about airworthiness for hang- and paragliders (LTF NfL II 91/09)“.

- 2 -
All technical data and instructions in this manual were drawn up with great care.
ICARO Paragliders cannot be made responsible for any possible errors in this
manual.
Important information in this manual is written in fat cursive writing.
Any important changes to this manual will be published in our home page
(www.icaro-paragliders.de).
Should you decide to sell this harness at a later date, please pass on this manual
to the new owner.
Each alteration is dangerous and reactions are not predictable. Your
harness will lose its pattern test result and guarantee.
The manufacturer or distributor assumes no responsibility for accidents
occurring while using it.
Every pilot must ensure that the harness is properly checked at regular
intervals.
Environmental aspects:
The materials of which a harness is made require a special waste disposal. So
please send disused ICARO - harnesses back to us. We will care about a
professional waste disposal without costing for you.
Please do our nature-near sport in a way which does not stress nature and
environment!
Please do not walk beside the marked ways, do not leave your litter, do not make
unnecessary loud noises and respect the sensitive balance in the mountains.
Especially at the launch site consideration is needed!

- 3 -
Shoulder straps adjustment
Ventral buckles
Leaning setting
Ventral adjustment
Safe T-Bar
Foot straps adjustment
I. To get to know your BATIS
Allowed for training
yes
Allowed /certified for aerobatics
yes / yes
Allowed /certified for aerobatics
no/ no
Allowed /certified for towing
no/ no
Allowed /certified for flying with motor drive
no/ no
Technical data
Pilot size (cm) 160 - 190
Pilot weight (kg) 50 - 100
Size one size
Karabiner highs (cm) 44
Seat length (cm) 47
Harness weight (kg) 3,19
Protektor Airbag
Adjustment of the rescue system back
Check Intervall 2 years
With the BATIS you are equipped with a tandem harness passenger designed with
an Airbag protection and an Anti Balance System which enables a good
dampening and flight stability.

- 4 -
Position setting
The harness can be adjusted in many ways to the individual needs and
likings of each pilot. We advise each pilot to take time to get acquainted to
the harness.
This will reward the pilot with an excellent sitting comfort. To carry out the
adjustments we advise to hang the harness in a simulator.
Leaning angle setting
Pull up to release. Set the angle of leaning by tightening
the snapper (towards a more vertical position) or the
black webbing (towards a more horizontal position),
Shoulder straps adjustment
Tighten the shoulder straps by pulling the finger loop
down.
When adopting a reclined flying posture, the shoulder
straps must enhance in-flight comfort levels by
supporting the upper back. The shoulder straps support,
greatly helps the comfort level.
It should be set precisely. You must find the correct
tension between the side and shoulder straps
adjustments.
Adjustment of leg straps
Pull the leg belts tight before starting, but make sure they do not cut in or squeeze.
Due to a special design the leg belts will not hinder your running at the start.
Because they are tied tight, the front of the seat is lifted up and helps you getting
into the harness. By slipping back in the gear, the leg belts loosen a bit after start.
Adjustment of chest straps
The adjustment of the harness chest strap controls the distance between
karabiners and affects the handling and stability of the glider.
Excessive tightening the chest strap increases stability but also the risk of twists
following glider collapse, and it also increases the frequency of getting collapses
due to poor feedback from the glider.
The risk of twisting is also strongly affected by the seating position of pilot. Flying
in a laid back (reclined) position makes it much more difficult to react in time to
prevent riser twisting.
With the chest strap in a more closed position the glider also has more tendency to
maintain a stable spiral, lengthening of the chest strap gives more feedback from
the glider but decreases stability.
ICARO paragliders recommends 38 – 46 cm.

- 5 -
II. Flying with the BATIS
It is important to perform a preflight check before taking off. Please give the
following points your special attention.
•Check the harness and carabiners completeness.
•Check that the (optional) front parachute pocket is correctly closed.
•Check that your harness adjustments have not changed.
•Check the connection risers / harness as well as the self-locking karabiners
(locked and secured).
•Make certain to close all buckles, pockets and especially the Air-Bag zipper
with its locking mechanism.
•Double check that all buckles are fully locked and secured by pulling firmly on
them. Check that no line, tab or cloth is stuck / jammed in the buckles.
Please set the distance between the two karabiners according to the aerology and
to the wing manufacturer’s recommendations. The average distance / spacing for
most gliders from the center of the right side to the center of the left side where the
risers connect, is between 36 cm and 45 cm.
Tightening the chest strap provides more stability but less harness piloting
efficiency. It increases the risk of riser twisting. On the contrary, loosening the
strap provides more efficiency but can be dangerous in turbulent aerology while
increasing the risk of falling towards the collapsed side of your glider and without
being able to efficiently counteract the situation.
Stand up inside the harness and adopt an upright position in order to run to
dissipate horizontal speed. Do not land whilst in the seated position, this could be
dangerous.
III. Care and repair Instructions
Care Instructions
To maintain your harness in good condition, please ensure that the harness does
not get dragged along the ground, the karabiner does not get hit against rocks and
avoid over exposure to sunlight, heat or humidity.
If you wish to clean your harness it is best to use warm water and a soft sponge.
Store your harness in a dry and dark place, ideally between 5° and 30° Celsius.
Do not store it near chemicals or petrol.
If you will not fly for longer period, take it out of its pack.
Avoid storing your harness for days at a time in a hot car.
If the harness has become wet, lay it out so that air can get to all areas of the
fabric, also your second chance.
It may take several days for your harness and your rescue system to dry out
completely especially the lines of the rescue system, which take longer than
the fabric. Do not fold and store your rescue system prematurely if it not
completely dry. Mildew may damage your harness and your rescue system.

- 6 -
Repairs
The seal of approval can only be preserved if original parts are used. If you
discover any damaged parts to the harness which might impede
deployment, pleases end it back to the manufacturer to be repaired.
Repairs can only be carried out by the manufacturer or from the
manufacturer authorized persons.
The aluminum karabiners should be changed every two years at the latest as the
aluminum might get micro cracks from impacts during use.
Inspection
After 24 months, it is important to have your harness inspected by a trained
ICARO technician.
Without regular certified inspections, your harness will lose its certification
and guarantee.
Only an authorized technician who has been trained by ICARO paragliders is
authorized to sign and date the harness certification label and sign the manual.
IV. Terms of guarantee
ICARO paragliders guarantees 24 month for the proper processing, an operation
within the allowable limits of proper operation and the fulfillment of the eligibility
criteria of harness equipment at the time of first delivery by ICARO paragliders.
Guarantee is only valid for ICARO
products with LTF/ EN certification.
What is covered by the guarantee?
Provided that ICARO paragliders accept the fault the guarantee contains all
necessary spare parts related to the replacement or repair of defective parts and
working time.
ICARO paragliders accept no freight costs (outbound and return transportation).
What are the conditions of the guarantee?
Provided that ICARO paragliders accept the fault the guarantee contains all
necessary spare parts related to the replacement or repair of defective parts and
working time.
•ICARO paragliders needs to be informed immediately after the discovery of a
defect and the defective product must be sent to us for testing.
•The harness was used in normal circumstances and maintained according to
the instructions. This includes in particular the careful drying, cleaning and
storage.

- 7 -
•The harness was used only within the applicable guidelines and all rules have
been complied with all times.
•All flights must be accounted for within the flight book.
•There were only original spare parts used and checks, exchange and / or
repairs were conducted by an authorized dealer or by ICARO Paragliders
company / person and properly documented.
•A fully and correctly completed guarantee card must be sent at least 6 weeks
after buying the glider to ICARO paragliders commercial. Alternatively can this
be sent via the appropriate online form on www.icaro-paragliders.com.
What is excluded from guarantee?
•Harnesses
•that are used for training purposes, Acro or other official competitions,
•which were involved in an accident,
•which have been changed by yourself,
•that were not purchased from an authorized dealer / flight school,
•where the required inspection intervals were not met and the verification of
the harness was not conducted by a ICARO paragliders authorized
operation / person
•Damage
•which has occurred due to improper treatment (i.e. storage in humidity, heat
or direct sunlight)
•caused by solvents, salt water, insects, sun, sand, humidity or “debag-
jumps”.
•caused by force majeure.
•caused by the paramotor (Oil, fuel, damage in cause of the prop)
•Parts that need to be replaced due to normal wear and tear,
•Discoloration of the cloth material used,
In case of a concluded claim the period of guarantee carries on. The period of
guarantee and the connected claim are not prolongated and are only valid until the
original date of expiry. The freight costs (transport to and from) are not paid by
ICARO paragliders.

- 8 -
V. Annex
Please fill in the guarantee card which you find on our homepage
www.icaro-paragliders,com and send it to us.
Check sheet for harnesses
Client (Name, Address):
Type / size / year of construction :
Serial number:
Certification number:
Date of last inspection:
Memos
yes
no
Seat strap
system
Visible damages?
Areas of abrasion?
Seat board
Visible damages?
Positioning of the straps ok?
Straps
Visible damages?
Course of the straps?
Seams ok?
Buckles and
carbines
Visible damages?
Condition (closing properties,
operation) ok?
main carbines (condition, age)
Operativeness ok?
Protectors
Airbag -/
Foamed
material
Visible damages?
Seams ok?
Valve ok?
Tightness airbag/ foam protector
sheeting?
Conditions of any reinforcements ok?
Speed bar
Visible damages?
Fixing rubber ok??
Return pulleys ok?
Lines ok?
Rescue system
Visible damages?
Identification plate ok?
V-lines
Handle fitted and connected?
Container properly closed?
Backpack
(reversible
harnesses)
Visible damages?
Zip ok?
Buckles ok?
Seams ok?
Compatibility check effected?
Additional repairs carried out? Which?
Type label affixed?
Inspection stamp affixed?
Overall result
Next inspection:
As new
Very good
Next inspection when using
the harness commercial:
Used
Much used
certification only for one year
not airworthy
Date, name and signature of the checker

- 9 -
Dispatch protocol / Delivery content
Handle
Seat Board
Carbineers
Manual
....................... ..............................
Date Signature
Table of contents