TP Toys active fun TP164 Quick guide

Draft_2
TP164
Pirate Galleon
Instructions for assembly, maintenance and safe use.
Please retain for future reference.
Robovision Ltd t/a TP Toys
Unit 11, Enterprise Way, Flitwick, Bedfordshire, MK45 5BX England
www.tptoys.com
THIS PRODUCT CONTAINS SMALL PARTS AND IS NOT
SUITABLE FOR CHILDREN UNDER 36 MONTHS.
SMALL PARTS ARE A CHOKING HAZARD.
THIS PRODUCT IS INTENDED FOR USE BY CHILDREN AGED
3-10 YEARS.
ONLY FOR DOMESTIC USE. FOR OUTDOOR USE ONLY.
TOY MUST BE ASSEMBLED BY AN ADULT BEFORE USE.
CHILDREN MUST NOT USE THIS PRODUCT UNTIL PROPERLY
INSTALLED. ADULT SUPERVISION REQUIRED.
REMOVE ALL PACKAGING BEFORE GIVING TO YOUR
CHILDREN.
RETAIN PACKAGING FOR FUTURE REFERENCE.
ANCHORS THAT ARE SUPPLIED WITH THIS PRODUCT MUST
BE FITTED BEFORE USE.
WARNING: MAXIMUM COMBINED USER WEIGHT 150KGS
WARNINGS!
x2
5
Hrs
Build Time
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 1 15/05/2018 09:55

Important advice for assembly, maintenance and safe use
1. Toy must be assembled by an adult before use exactly in accordance with the instructions.
2. Children must not use this product until properly installed.
3. Check all parts are present before you start to assemble the product. Place small parts on a tray or similar to ensure
they are not lost. The manufacturing process can very occasionally result in sharp edges/waste material so please take
care when assembling this product.
4. If any parts are missing do not use the product until the replacement parts are fitted.
5. Ensure your product is sited on level ground. Failure to do this may put additional stress on connections and joints and in
time could cause them to fail.
6. Ensure your product is located on a soft impact surface like grass. Never locate your product on a hard surfaces like
concrete.
7. Anchors supplied with this product must be fitted before use.
8. In freezing weather, detachable plastic parts should be stored inside.
9. Avoid locating this product in full sun.
10. Remove all packaging before giving to your children or allowing them to play with this product.
11. Equipment should be checked by an adult at the beginning of each season and at regular intervals during the usage
season to ensure it is safe. Pay special attention to all connections and fastenings .
12. Parts may need to be replaced if they show signs of wear and tear. Replace any defective parts in accordance with
these instructions.
13. Any changes to this toy including changing or adding an accessory, must be done in accordance with our instructions.
Failure to do this will render your guarantee null and void and may make your product unsafe.
14. Ensure children’s clothing is appropriate for the play activity.
15. Never place toys near a fire.
16. Take care in wet weather. Toys can become slippery.
17. In high winds, ensure outdoor toys are moved to a sheltered position and/or securely staked down.
18. The age recommendation for this product is clearly stated on the packaging and in these instructions. Please adhere to
it at all times. Adult supervision is required at all times to ensure children play safely.
19. When you dispose of this equipment please do so responsibly.
Safe play free space area
The safe play area refers to the zone extending
200cm around the toys on all sides and 250cm
above the toy.
The safe play area must be free from all
obstacles.
2Pirate Galleon
2m
2m
2m
2m
2m
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 2 15/05/2018 09:55

300cm
115cm 110cm
Height to front platform: 68cm
Height to rear platform: 88cm
Height to rear guardrail: 140cm
Maxiumum height of this set: 206cm
300cm
115cm 110cm
Height to front platform: 68cm
Height to rear platform: 88cm
Height to rear guardrail: 140cm
Maxiumum height of this set: 206cm
3Pirate Galleon
Know About Wood
Unlike steel, wood is a natural, organic material and each piece will be unique, bearing its own knots, cracks and
variations in colour and, unlike steel, wood will react significantly to changes in atmospheric conditions.
Wood will expand and contract as fluctuations of temperature and humidity affect the water content of the cell structure.
In warm sunny weather it will shrink and in wet weather it will expand. As these physical changes do not, necessarily,
take place uniformly throughout a piece of wood, forces are set up which cause cracks and splits to arise.
It is not necessary to stain your Wooden frame.
It is made from selected wood which has been pressure treated. This is a process by which preservatives are forced
under pressure into the fabric of the timber to protect it from decay and insect damage.
If you do wish to stain your Wooden frame for aesthetic reasons, please use a water-based stain, which is available from
any good DIY store.
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 3 15/05/2018 09:55

4mm
10mm
Tools - You will need: Also Required:
Not
Supplied
Post mix concrete
Béton
Beton
Hormigón
Calcestruzzo
Concreto
4Pirate Galleon
MW2416
350mm
x1
MW2406
245mm
x12
MW2413
511mm
x5
MW2420
264mm
x4
MW2410
193mm
x8
MW2424
288mm
x3
MW2425
146mm
x1
MW2423
285mm
x1
MW2402
694mm
x14
MW2414
590mm
x10
MW2419
520mm
x4
MW2430
455mm
x2
MW2429
355mm
x2
MW2431
551mm
x2
MW2427
152mm
x2
MW2428
255mm
x2
Contents - Please check
Pack - 1
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 4 15/05/2018 09:55

5Pirate Galleon
PM2089
Ship Wheel
x1
PM2001
Ground Peg
x2
PM2085
Cabin Window
x2
PM2086
Anchor Window
x2
MW2407
1000mm
x3
MW2404
994mm
x8
MW2418
1240mm
x2
MW2403
994mm
x2
Pack - 2
Pack - 3
MW2422
800mm
x3
MW2421
1240mm
x2
MW2426
1200mm
x1
MW2400
1397mm
x5
MW2408
542mm
x1
MW2409
730mm
x2
MW2415
644mm
x2
MW2411
650mm
x2
MW2417
1500mm
x1
MW2405
2060mm
x1
MW2412
581mm
x1
MW2401
2000mm
x8
FA5095
M6x20mm
x1
FA5192
M6 Dome Nut
x1
FA4521
5x80mm
x2
FA9768
5x60mm
x16
FA5167
M6x60
x1
FA9767
5x40mm
x205
FA9784
6x150mm
x5
FA8274
5x15mm
x40
SP0164
FB3033
Half Main Sail
x1
FB3035
Spinika Sail
x1
SP3010
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 5 15/05/2018 09:55

6Pirate Galleon
FA9768
5x60mm
x4
MW2400
x2
MW2403
x1
MW2404
x8
FA9767
5x40mm
x16
1
2
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 6 15/05/2018 09:55

7Pirate Galleon
FA9768
5x60mm
x6
MW2414
x10
FA9767
5x40mm
x20
MW2407
1000mm
x1
MW2400
1397mm
x3
Fix end boards first Space boards evenly
Assembly Tip
3
4
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 7 15/05/2018 09:55

8Pirate Galleon
MW2408
x1
MW2403
x1
FA9767
5x40mm
x8
FA9767
5x40mm
x8
MW2409
x2
5
6
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 8 15/05/2018 09:55

9Pirate Galleon
FA9784
6x150mm
x4
MW2421
x2
MW2421
MW2411
MW2411
MW2421
MW2411
x2
7
Drill pilot hole x4
4mm
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 9 15/05/2018 09:55

10 Pirate Galleon
FA9768
5x60mm
x2
FA9767
5x40mm
x2
FA9784
6x150mm
x1
MW2416
x1
MW2415
x2
MW2412
x1
MW2415
MW2412
MW2416
5x40mm
6x150mm
5x40mm
5x60mm
5x60mm
8
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 10 15/05/2018 09:55

11 Pirate Galleon
FA9767
5x40mm
x8
FA9767
5x40mm
x4
MW2407
x2
MW2405
x1
9
10
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 11 15/05/2018 09:55

12 Pirate Galleon
MW2413
x2
MW2413
x3
FA9767
5x40mm
x4
FA9767
5x40mm
x6
11
12
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 12 15/05/2018 09:55

13 Pirate Galleon
FA9767
5x40mm
x9
MW2426
x1
MW2418
x2
MW2425
x1
13
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 13 15/05/2018 09:55

14 Pirate Galleon
FA9767
5x40mm
x12
FA9767
5x40mm
x12
MW2401
2000mm
x4
MW2401
2000mm
x4
14
15
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 14 15/05/2018 09:55

15 Pirate Galleon
MW2402
x3
MW2410
x4
FA9767
5x40mm
x10
Assembly Tip
Fix MW2402 boards first.
Use window for spacing.
Space MW2410 boards with
equal gaps.
Use window for spacing.
Equal
spacing
Cabin
Window
1 2
MW2402
MW2402
MW2402
16
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 15 15/05/2018 09:55

16 Pirate Galleon
FA8274
5x15mm
x10
PM2085
Cabin Window
x1
17
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 16 15/05/2018 09:55

17 Pirate Galleon
MW2402
x3
MW2410
x4
FA9767
5x40mm
x10
Assembly Tip
Fix MW2402 boards first.
Use window for spacing.
Space MW 2410 boards with
equal gaps.
Use window for spacing.
Equal
spacing
Cabin
Window
MW2402
MW2402
MW2402
1 2
MW2410
MW2410
18
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 17 15/05/2018 09:55

18 Pirate Galleon
FA8274
5x15mm
x10
PM2085
Cabin Window
x1
19
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 18 15/05/2018 09:55

19 Pirate Galleon
FA8274
5x15mm
x10
PM2086
Anchor Window
x1
Assembly Tip
Fix MW2402 boards first.
Use window for spacing.
Space MW2406 boards
with equal gaps.
Use window for spacing.
Equal
spacing
Anchor
Window
MW2402
x4
MW2406
x6
FA9767
5x40mm
x14
1 2
MW2402
MW2402
MW2402
MW2402
MW2406 MW2406
20
21
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 19 15/05/2018 09:55

20 Pirate Galleon
MW2402
x4
MW2406
x6
FA9767
5x40mm
x14
FA8274
5x15mm
x10
PM2086
Anchor Window
x1
Assembly Tip
Fix MW2402 boards first.
Use window for spacing.
Space MW2406 boards
with equal gaps.
Use window for spacing.
Equal
spacing
Anchor
Window
1 2
MW2402
MW2402
MW2402
MW2402
MW2406 MW2406
22
23
TP164_Pirate Galleon_Instruction Book In0116-E 11.05.18.indd 20 15/05/2018 09:55