manuals.online logo
Brands
  1. Home
  2. •
  3. Brands
  4. •
  5. Wesco
  6. •
  7. Rack & Stand
  8. •
  9. Wesco DR-2 Service manual

Wesco DR-2 Service manual

Description
The Wesco Drum Rack is designed specifically for
economical stacked storage of 55 gallon drums in the
horizontal position. It features easy access from all four sides,
providing easy movement and placement.
This product is distributed by:
Wesco Industrial Products, Inc
1250 Welsh Road
North Wales, PA 19454
Tel: 215-699-7031 Fax: 215-699-3836
Contact the factory for parts information and ordering.
Visit us on the web at www.wescomfg.com
Unpacking
When unpacking the Wesco Product, check carefully for
shipping damage and missing parts. If damage has occurred
or any parts are missing, file a claim with the delivering carrier
within 24 hours and notify the dealer from whom the unit was
purchased. Warranty Repairs
If the unit does not work properly, contact your dealer or the
factory (215-699-7031) for units less than 90 days old.
Non-Warranty Service
If units are older than 90 days, repairs can be made easily on
site with factory supplied parts.
NOTE: Do not send units to the factory for service without
first obtaining a “Return Merchandise Authorization” (RMA)
number from the customer service department. We will not
be responsible for merchandise returned without proper
authorization.
Figure 1
LIMITED WARRANTY
WESCO INDUSTRIAL PRODUCTS (WESCO) warrants to the purchaser of this product for a period of ninety (90) days from the date of purchase that this product shall be free of
defects in material and/or workmanship, as follows:
1. WESCO will supply, at no charge, new or rebuilt replacements for any part that fails through a defect in material and/or workmanship during the warranty period. To obtain warranty
service, you must deliver the product prepaid, to the WESCO factory.
2. This warranty does not cover any product or product part which has been subject to accident, misuse, abuse or negligence. WESCO shall only be liable under this warranty if the
product is used the manner intended by the manufacturer as specified in the written instructions furnished with this product.
REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER. ANY EXPRESS WARRANTY NOT PROVIDED IN
THIS WARRANTY DOCUMENT, AND ANY REMEDY FOR BREACH OF CONTRACT THAT, BUT FOR THIS PROVISION, MIGHT ARISE BY IMPLICATION OR OPERATION OF LAW,
IS HEREBY EXCLUDED AND DISCLAIMED. UNDER NO CIRCUMSTANCES SHALL WESCO BE LIABLE TO PURCHASER OR ANY OTHER PERSON FOR ANY INCIDENTAL OR
CONSEQUENTIAL DAMAGES, WHETHER ARISING OUT OF BREACH OF WARRANTY, EXPRESS OR IMPLIED, A BREACH OF CONTRACT OR OTHERWISE. EXCEPT TO THE
EXTENT PROHIBITED BY APPLICABLE LAW, ANY IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR ANY PARTICULAR PURPOSE ARE EXPRESSLY LIMITED
IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
Some states do not allow the exclusion or limitation of incidental or consequential damages, or allow limitations on how long any implied warranty lasts, so the above limitations may not
apply to you. This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.
Drum Racks DR-2 & DR-3
(Part # 240026 & 240027)
Operating Instructions and Parts Manual
ATTENTION: TO INSURE SAFE AND EASY USE OF YOUR WESCO DRUM
RACK, READ THESE INSTRUCTIONS BEFORE USING.
General Safety Information
Warning: The Wesco Drum Racks are intended for
specific functions. Please adhere to the following
instructions to insure safe and proper use.
(1) Maximum capacity including drums:
- 1600 lbs. (2 Drums) (For DR-2 P/N 240026 units)
- 2400 lbs. (3 Drums) (For DR-3 P/N 240027 units)
(2) Maximum Stack Height (immobile): 4 high.
(3) Maximum Stack Height when moving: 2 high.
(4) Do not exceed rated capacity. Injury to persons or
property may result from overloading and misuse.
(5) Do Not use on Plastic Drums
Warning
Make sure all drums are in good condition.
Only stack racks on fully loaded racks. Never stack on to
a rack containing only one drum.
Do Not move stacks of 3 or more high under any
conditions.
When using fork trucks to move loaded racks make sure
forks are set at maximum usable width to insure stability
It is strongly recommended to stack racks one at a time.
Periodically check for loose, damaged or worn hardware;
If found replace at once.
Intended for use with most currently available 55 gallon
steel drums. Minimum recommended drum wall thickness
for the bottom layer of drums on a 3-high stack is 20
gauge; on 4 high stack it is 18 gauge. Use of drums with
walls that are too thin may not be safe.
Note: Check with your supplier(s) if you are not sure of
the specifications for your drums.
Figure 2
Industrial Products, Inc.
Assembly
(1) Place the Flat Washer (5) on the Bolt (3)
(2) Insert the Bolt (4) through the hole in the
Side Frame Weldment (1), then through the
Cross Brace Weldment (2). Put the Nut (4)
on the end of the Bolt (3).
Note: Be sure the Flat Washer is on outer
side of the Side Frame Weldment.
(3) Assemble the unit together in this manner,
loosely using all Bolts.
(4) Tighten all Bolts, however do not over
tighten.
Drum Racks DR-2 & DR-3
(Part # 240026 & 240027)
Operating Instructions and Parts Manual
ATTENTION: TO INSURE SAFE AND EASY USE OF YOUR WESCO DRUM
RACK, READ THESE INSTRUCTIONS BEFORE USING.
Industrial Products, Inc.
Figure 3 Figure 4
DR-2 DR-3
Assembly Parts
Item Part No. Description Qty. For
DR-2 Qty. For
DR-3
1 051822 Side Frame Weldment 2
051824 Side Frame Weldment 3
2 051823 Cross Brace Weldment 2 3
3 108158 Hex Head Bolt 8 12
4 108176 Hex Nut 8 12
5 108200 Flat Washer 8 12
Replacement Parts
Item Part No. Description Qty. For
DR-2 Qty. For
DR-3
1 051809 Saddle 2 3
2 054802 Cross Brace 2 3
3-5 108530 Hardware Kit 2 3

This manual suits for next models

3

Popular Rack & Stand manuals by other brands

Vivo DESK-AC06-2P instruction manual

Vivo

Vivo DESK-AC06-2P instruction manual

Panasonic UE-608030 operating instructions

Panasonic

Panasonic UE-608030 operating instructions

Tannoy Back Can S quick start guide

Tannoy

Tannoy Back Can S quick start guide

Steren MTR-100 user manual

Steren

Steren MTR-100 user manual

Philips STS9510/00 quick start

Philips

Philips STS9510/00 quick start

Kohler PA-228609 installation instructions

Kohler

Kohler PA-228609 installation instructions

Biamp Apprimo 8-WMA installation guide

Biamp

Biamp Apprimo 8-WMA installation guide

Panasonic EB-HF20/E user guide

Panasonic

Panasonic EB-HF20/E user guide

GRAVITY GMATRAY2 quick start guide

GRAVITY

GRAVITY GMATRAY2 quick start guide

MSW MSW-EMS-200 user manual

MSW

MSW MSW-EMS-200 user manual

peerless-AV SMARTMOUNT Series Assembly and installation instructions

peerless-AV

peerless-AV SMARTMOUNT Series Assembly and installation instructions

LesMills SMARTBAR Assembly & user instructions

LesMills

LesMills SMARTBAR Assembly & user instructions

Videology 78V0004 instruction manual

Videology

Videology 78V0004 instruction manual

Pilgrim Utility Outdoor Wood Rack 18565 Assembly instructions

Pilgrim

Pilgrim Utility Outdoor Wood Rack 18565 Assembly instructions

Kuat NV 2.0 user guide

Kuat

Kuat NV 2.0 user guide

Vivo MOUNT-VW100F VW100F instruction manual

Vivo

Vivo MOUNT-VW100F VW100F instruction manual

Atdec AD-TVAC-CM installation guide

Atdec

Atdec AD-TVAC-CM installation guide

Havis-Shields Heavy Duty Telescoping Computer Mounts... brochure

Havis-Shields

Havis-Shields Heavy Duty Telescoping Computer Mounts... brochure

manuals.online logo
manuals.online logoBrands
  • About & Mission
  • Contact us
  • Privacy Policy
  • Terms and Conditions

Copyright 2025 Manuals.Online. All Rights Reserved.