BOERPLAY PSTE105.018 User manual

Multi-play equipment
PSTE105.018
Powered by TCPDF (www.tcpdf.org) 1 / 1

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE PST 105 018 B
Palenwoud
Adventure Play
20-9-2019
Afmetingen Dimensions
0,00 m
0,43 m
1,50 m
1,96 m
2,10 m
2,33 m
5,53 m
0,00 m
0,29 m
2,70 m
3,01 m
4,40 m
4,60 m
7,21 m

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE PST 105 018 B
Palenwoud
Adventure Play
20-9-2019
Obstakelvrije zone Obstacle free zone
Obstakelvrij WAS
Obstacle free WAS
Opvangzone
Impact area
Obstakelvrij EN-1176
Obstacle free EN-1176
R1,50m
R1,50m
R1,50m
R1,50m
R1,50m
R1,50m
9,69 m
8,49 m

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE PST 105 018 B
Palenwoud
Adventure Play
20-9-2019
Bodemplan Groundplan
0,44 m
1,53 m
2,31 m
1,84 m
1,38 m
2,06 m 3,04 m
0,51 m
0,20 m
2,22 m
0,85 m
1,22 m
0,20 m
0,42 m
0,31 m
0,42 m
0,97 m
0,63 m
1,62 m
0,22 m
3,34 m
1,66 m 0,45 m
0,45 m
0,60 m
0,52 m
0,83 m
0,47 m
0,92 m
0,46 m
1,10 m
0,51 m
1,34 m
2,21 m
0,91 m
1,64 m
0,69 m
0,75 m
rondmarkering
Ground le el marker

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE PST 105 018 B
Palenwoud
Adventure Play
20-9-2019
Modules Modules
Opmerking
BenamingRev.Bew.
Volgnr.
Progr.Type#
Nr.
Rek H=900Duikel
B
008007PSTOD
11
Lengte element 2,8 mStelt 50
A
021007PSTOD32
Lengte element 3,0 mStelt 70
A
022007PSTOD23
Adventure PlayVerticaal net 3,0 x 1,5
B
008021PSTOD
14
Adventure PlayOpklimnet vlak
024021PSTOD2
5
2
153
3 2 5
2
4
Typeplaatje
Identification plate
B

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE PST 105 018 B
Palenwoud
Adventure Play
20-9-2019
Montage Mounting
Geleverde delen:
A - Paal 2,8m 2x) + paal 3,3m + net
B - Opklimnet vlak
C - Plank 2,5m
D - Stelt 50
E - Stelt 70
F - Stelt 70
G - Opklimnet vlak
H - Plank 2,5m
I - Stelt 50
J - Duikel
K - Stelt 50
Montagevolgorde:
1 - Graaf de gaten volgens het bodemplan en plaats A
2 - Plaats B en verbind deze met A. Verbind C met B
3 - Plaats D en E, verbind deze met B
4 - Plaats F
5 - Plaats G en verbind deze met F. Verbind G met H
6 - Plaats I, verbind deze met G
7 - Plaats J verbind met I
8 - Plaats K
9 - Controleer of het toestel voldoet aan de afmetingen zoals op blad 'afmetingen'
10 - Dicht de gaten en verdicht het zand
Controles:
1 - Correcte opbouw en alle bevestigingsmiddelen
2 - Controleer de afmetingen van de valbodem t.o.v. het toestel
3 - Controleer of alle klimnetten goed gespannen zijn
Supplied parts:
A - Posts 2,8m 2x) + 3,3m + net
B - Climbingnet
C - Plank 2,5m
D - Stilt 50
E - Stilt 70
F - Stilt 70
G - Climbingnet
H - Plank 2,5m
I - Stilt 50
J - Tumble
K - Stilt 50
Assembly sequence:
1 - Dig the holes according to the ground plan and place A
2 - Place B and attach it to A. Attach C to B
3 - Place D and E, attach these to B
4 - Place F.
5 - Place G and attach it to H. Attach G to H
6 - Place I, attach it to G
7 - Place J. Attach it to I
8 - Place K
9 - Check that the equipment conforms to the dimensions shown on sheet 'dimensions'
10 - Close the holes and compact the sand
Checks:
1 - Correct assembly and all the fasteners
2 - Check the dimensions of the safety area compared to the play equipment
3 - Check that all nets are properly stretched
H
DB
C
A
E
F
G
I
J
K

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE PST 105 018 B
Palenwoud
Adventure Play
20-9-2019
Montage Mounting
0,00 m
0,43 m
0,63 m
0,93 m
1,91 m
2,33 m
0,00 m
1,43 m
1,90 m
2,10 m
0,00 m
0,43 m
0,63 m
2,10 m
2,13 m
2,33 m
0,00 m
0,43 m
0,63 m
0,93 m
1,75 m
2,13 m
2,33 m

LOGBOOK
Type indication Adventure Play
Article number PSTE105.018
Product Name Multi-play equipment
Maximum fall height 2,0 m
Construction year 2023
Certificate 033411
Inspection body TUV Nederland QA BV
Ekkersrijt 4401
5692 DL Son
Manufacturer name Boer Speeltoestellen
Hyacintstraat 2 - 4255 HX Nieuwendijk
Phone: [phone]
Fax: [phone]
Installer name _______________________________________________________
_______________________________________________________
_______________________________________________________
Playground location _______________________________________________________
Information about the owner of the playground
Name: _______________________________________________________
Address: _______________________________________________________
Zipcode and city: _______________________________________________________
Contact: _______________________________________________________
Phone number: _______________________________________________________
Information about the manager of the playground
Name: _______________________________________________________
Address: _______________________________________________________
Zipcode and city: _______________________________________________________
Contact: _______________________________________________________
Phone number: _______________________________________________________
Powered by TCPDF (www.tcpdf.org)

LOGBOOK
Inspection and maintenance
Date of
inspection
maintenance
Time of
inspection
maintenance
Name
executor of
inspection
Name
executor of
maintenance
Found defects Parts to be
replaced
Accidents
Date
accident
Age of
victim Probable cause of injury Occurred injury Measures taken after accident

Inspection and maintenance intervals
Nr Inspection Maintenance
months
between
inspections
1
Verify equipment's stability, junctions and
missing parts Inspect bolts, screws and nuts for
absence, jams, corrosion and wear
Add missing parts, secure joints, apply
missing fixing agent and replace
corroded parts
1
2
Check suspension for wear Replace worn parts and/or remove non-
functioning parts
1
3
Inspect rotating parts such as hinges, rolling-
element bearings, etc for wear and acceptability
Replace worn parts and/or remove non-
functioning parts
1
4
Check wood for splinters, unacceptable damage
and signs of rot, especially at ground level
Repair damage Replace affected wood
Smoothen splintered wood and sharp
edges
1
5
Inspect foundation for stability, tearing and
coverage
Restore foundation and covering
material
3
6
Examine rubber and synthetic parts for wear,
damage and breakage Replace for OEM original parts
3
7
Examine fibre reinforced plastic parts, especially
slides, for wear
Replace for OEM parts if the fibres are
visible
6
8
Inspect metal for corrosion and damage in the
coating
Restore any damaged coating (after
removing rust and applying primer)
6
9
Check ropes, cables, chains and nets for wear
and damage Steel cables and nets which are
tensioned must be checked for tension
Replace parts where necessary Steel
cables and nets must be tensioned
3
10
Inspect equipment for unsafe changes and
additions
Remove unsafe additions and correct
unsafe changes
1
11
Inspect safety surfaces Restore and repair where necessary
1
Remarks
1 If used intensively, all points require extra attention
2 Extreme weather conditions and locations may require a higher inspection frequency Discuss this with the
supplier
3 Vandalism-sensitive locations require stricter inspections, possibly daily
4 Re-tighten all connections in Robinia equipment two months after first use
5 Re-span spatial networks two months after first use
6 Check the terrain regularly for items that do not belong there, are unsafe or may be used wrongly Examples
are poisonous plants, glass shards, etc Frequency depends on strain

7 Remember that bad maintenance leads to unsafe conditions and notably faster impoverishment of the
playground area
8 Replacement parts can be ordered at the manufacturer with the OEM part numbers on the module drawing
Drawings can be found in the user guide
9 The impact area shall be provided with impact attenuating surface according to the specified falling height
•Up to 0,6m height of fall: no requirements regarding impact attenuation
•Turf, topsoil: suitable up to 1000mm height of fall
•Loose fill (sand, gravel, bark, woodchips): up to 3000mm height of fall Layer thickness is height
of fall / 10 +100mm, with a minimum of 300mm
•Synthetic surfaces (Rubber tiles, artificial turf, wetpour, tigermulch etc ): height of fall and layer
thickness according to the information of the supplier
10 This list is conform the CEN-standard "playground equipment and surfacing NEN-EN 1176-7"
Improving the
foundations
(for equipment without concrete in the standard
foundation)
If the impact area is loose fill (sand, gravel, bark,
woodchip, etc ), or if the soil itself does not add to
stability of the equipment (i e sand, pumice, peat soil)
pour 50l of concrete per post
For instance:
Square: 0,6 x 0,6 x 0,16m
Round: ø0,35 x 0,5m
Round: ø0,50 x 0,2m

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
MOD PST 007 008 B
Duikel
Rek H=900
9-4-2019
Samenstelling module Assembly module
Opmerking
BenamingRev.Bew.
Volgnr.
Progr.Type#
Nr.
5 x 70 - RVS A2-70
Schroef Assy
070005002BSR21
5 x 50 - RVS A2-70
Schroef Assy
050005002BSR22
RVS FA ETKRAALRING 015005036BSR23
Lengte =1600Paal 14-16 016160PSTOHO
14
Lengte = 500Standaard plank 120x20 050211PSTOHO
15
Adventure PlayDuikelbuis
A
320076PSTSME16
6
4
1
5
2 3
0,00 m
1,51 m
1,62 m

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
MOD PST 007 021 A
Stelt 50
Lengte element 2,8 m
19-7-2018
Samenstelling module Assembly module
OpmerkingBenamingRev.Bew.Volgnr.Progr.Type
#
Nr.
5 x 70 - RVS A2-70
Schroef Assy
070005002BSR
51
Lengte = 500St nd rd pl nk 120x20 050211PSTOHO32
Lengte element 2,8 mStelt 50-70
002102PSTSHO13
Grondmarkering
Ground level marker
0,62 m 0,50 m
2
3
1

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
MOD PST 007 022 A
Stelt 70
Lengte element 3,0 m
19-7-2018
Samenstelling module Assembly module
OpmerkingBenamingRev.Bew.Volgnr.Progr.Type
#
Nr.
5 x 70 - RVS A2-70
Schroef Assy
070005002BSR
1
Lengte = 500Standaard plank 120x20 050211PSTOHO32
Lengte element 3,0 mStelt 70
003102PSTSHO13
0,62 m
Grondmarkering
Ground level marker
0,48 m
0,70 m
3
2
1

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
MOD PST 021 024
Opklimnet vlak
Adventure Play
1-2-2019
Samenstelling module Assembly module
Opmerking
BenamingRev.Bew.
Volgnr.
Progr.Type#
Nr.
M12, L= 240, RVS A2- 0
Draadeind+borgm.+ringen+dop
240M12SETBMR31
ø10 X 60 - RVS A2- 0
Houtdraadbout
060010022BSR42
Lengte =4600
Paal 14-16
046160PSTOHO
14
Lengte =4300
Paal 14-16
043160PSTOHO1
5
Lengte = 2500Standaard plank 120x20 250211PSTOHO
1
6
Adventure PlayOpklimnet vlak 123016PSTSNT
1
8
Touw 16 mm
Bus + VZ schroef
RVS002BUSSMD101
4,4 m
0,47m
0,37m
5
8
4
6
1
17
Gaten >230mm
440
379
310
256
343
1497
1546
2

A ( 1 : 4 )
B ( 1 : 2 )
C ( 1 : 10 )
Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
MOD PST 021 008 B
Verticaal net 3,0 x 1,5
Adventure Play
26-7-2019
Samenstelling module Assembly module
Opmerking
BenamingRev.Bew.
Volgnr.
Progr.Type#
Nr.
M12, L= 260, RV A2-70
Draadeind+borgm.+ringen+dop
260M12ETBMR21
5 x 70 - RV A2-70
chroef Assy
070005002B R82
ø10 X 60 - RV A2-70
Houtdraadbout
060010022B R23
M6 - VZ 8.8
Borgmoer
006006010B V
44
M6 x 40 - VZ 8.8
Zeskantbout
040006020B V
45
Pin-Torx - VZ 8.8
Veiligheidsschroef
030006025B V106
M6 x 20 - VZ 8.8CARRO ERIERING 020006035B V87
Lengte =3300
Paal 14-16
033160P TOHO18
Lengte =2800
Paal 14-16
028160P TOHO29
Lengte = 500
tandaard plank 120x20
050211P TOHO
4
10
Lengte = 1000Plank 120x20 100212P TOHO2
11
touw d16
Bus RV schroefdraad
RV002BUOME1012
Adveture PlayKlimet 3x1.6 mtr
E
015016P TNT113
A
B
C
8
9
Grondmarkering
Ground level marker
0,62 m
3,21 m
2,81 m
8
13
7 5
7
4
12
6
11
10
2
3
Powered by TCPDF (www.tcpdf.org)