BOERPLAY SOLE030.222 User manual

SOLE030.222
Trio climbing tumble bar

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE SOL 030 222
Klimduikel trio
Pionier
26-1-2017
BOER
SPEELTOESTELLEN
Obstakelvrije zone Obstacle free zone
Obstakelvrij WAS
Obstacle free WAS
Opvangzone
Impact area
Obstakelvrij EN-1176
Obstacle free EN-1176
4,20 m
3,20 m
3,00m
R1,50 m
R1,50m
0,70m
6,18 m
3,80m

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE SOL 030 222
Klimduikel trio
Pionier
26-1-2017
BOER
SPEELTOESTELLEN
Bodemplan Groundplan
0,60m
Grondmarkering
Ground level marker
6,18 m
4,20 m
R1,50m
R1,50m
4,20 m
0,20 m
0,49m
3,80m

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE SOL 030 222
Klimduikel trio
Pionier
26-1-2017
BOER
SPEELTOESTELLEN
A metingen imensions
0,97m
1,07 m0,97 m1,07 m
0,00 m
0,24 m
0,45 m
0,60 m
0,79 m
0,94 m
1,03 m
1,17 m
1,35 m

Benaming
Title
Opmerking
Comment
Datum
Date
Tekening
Drawing
TOE SOL 030 222
Klimduikel trio
Pionier
26-1-2017
BOER
SPEELTOESTELLEN
Modules Modules
Opmerking
BenamingRev.Bew.
Volgnr
Progr.Type#
Nr
115 cm
Duikelrek
000500PNRMOD21
Pionier
Duikelstang 100 cm
000502
PNR
MOD12
Pionier
Duikelstang 9 cm
000503PNRMOD23
1233
Gelever e mo ules:
Zie tabel
Montageinstructie:
- De hoof maten geven e maten van e staan ers en vloeren aan
- De etailtekeningen geven specifiek e maten van e verbin ingen aan
- De mo ules met buizen zijn op e tekeningen bemaat op bovenkant kopplaat
- Overige mo ules zijn bemaat op e bovenkant (klimwan en, paalkappen, etc.)
Montagevolgor e:
1 - Graaf e gaten volgens het bo emplan
2 - Plaats 1 en 1
3 - Verbin 1 en 1 met 2 en 2x 3
4 - Controleer of het toestel vol oet aan e afmetingen zoals op bla 'afmetingen'
5 - Dicht e gaten en ver icht het zan
Controles:
1 - Correcte opbouw en alle bevestigingsmi elen
2 - Controleer e afmetingen van e valbo em t.o.v. het toestel
Supplie mo ules:
See table
Assembly instruction:
- The main imensions in icate the imensions of the posts an floors
- The etaile imensions show the specific imensions of the connections
- The mo ules which contain tubes are imensione at the top of the flanges
- Other mo ules are imensione at the top (climbing walls, caps for the posts, etc.)
Assembly sequence:
1 - Dig the holes accor ing to the groun plan
2 - Place 1 an 1
3 - Connect 1 an 1 with 2 an 2x 3
4 - Check that the equipment conforms to the imensions shown on sheet ' imensions'
5 - Close the holes an compact the san
Checks:
1 - Correct assembly an all the fasteners
2 - Check the imensions of the safety area with regar to the play equipment
Typeplaatje
Identification plate
B

LOGBOOK
(Onderstaand logboek kan gebruikt worden om te voldoen aan de eisen, gesteld in artikel 14 van het Warenwetbesluit Attractie- en Speeltoestellen)
Type indication Pioneer Play
Product code SOLE030.222
Name of equipment Klimduikel Trio pionier
Maximum height of fall 1,2 m
Year of construction 2017
Certificate 09100312703
inspection authority Liftinstituut B.V.
Buikslotermeerplein 381, A'dam - 1025 XE Amsterdam
Name manufacturer BOERplay
Hyacintstraat 2 - 4255 HX Nieuwendijk
Phone: [phone]
Fax: [phone]
name installer
Description of equipment Trio climbing tumble bar
Location of equipment
Data about the owner of the play equipment
Name:
Address:
Postcode and town:
Contact person:
Telephone number:
Data about the administrator of the play equipment
Name:
Address:
Postcode and town:
Contact person:
Telephone number:
SOLE030.222
Trio climbing tumble bar

LOGBOOK
Inspection and maintenance intervals
Nr.
Inspection Maintenance
months
between
inspections
1
Verify equipment's stability, junctions and missing parts.
Inspect bolts, screws and nuts for absence, jams, corrosion
and wear.
Add missing parts, secure joints, apply missing fixing
agent and replace corroded parts.
1
2
Chec suspension for wear. Replace worn parts and/or remove non-functioning
parts.
1
3
Inspect rotating parts such as hinges, rolling-element
bearings, etc. for wear and acceptability.
Replace worn parts and/or remove non-functioning
parts.
1
4
Chec wood for splinters, unacceptable damage and signs of
rot. Especially at ground level.
Repair damage. Replace affected wood. Smoothen
splintered wood and sharp edges.
1
5
Inspect foundation for stability, tearing and coverage. Restore foundation and covering material.
3
6
Examine rubber and synthetic parts for wear, damage and
brea . Replace original parts.
3
7
Inspect metal for corrosion and damage in the coating. Restore any damaged coating (after removing rust and
applying primer).
6
Chec ropes, cables, chains and nets for wear and damage.
Steel cables and nets which are tensioned must be chec ed
for tension.
Replace parts where necessary. Steel cables and nets
must be tensioned.
3
9
Inspect equipment for unsafe changes and additions. Remove unsafe additions and correct unsafe changes.
1
10
Inspect safety surfaces. Restore and repair where necessary.
1
Remarks
1. If used intensively, all points require extra attention.
2. Extreme weather conditions and locations may require a higher inspection frequency. Discuss this with
the supplier.
3. Vandalism-sensitive locations require stricter inspections, possibly daily.
4. Check the terrain regularly for items that do not belong there, are unsafe or may be used wrongly.
Examples are poisonous plants, glass shards, etc. Frequency depends on strain.
5. Remember that bad maintenance leads to unsafe conditions and notably faster impoverishment of the
playground area.
6. Replacement parts can be ordered at the manufacturer with the part numbers on the module drawing.
Drawings can be found in de user guide.
7. The impact area shall be provided with impact attenuating surface according to the specified falling
height.
. This list is conform the CEN-standard "playground equipment and surfacing NEN-EN 1176-7".

B
BB
Be
ee
en
nn
na
aa
am
mm
mi
ii
in
nn
ng
gg
g
Title
O
OO
Op
pp
pm
mm
me
ee
er
rr
rk
kk
ki
ii
in
nn
ng
gg
g
Comment
D
DD
Da
aa
at
tt
tu
uu
um
mm
m
Date
T
TT
Te
ee
ek
kk
ke
ee
en
nn
ni
ii
in
nn
ng
gg
g
Drawing
MOD PNR 500 000
Duikelrek
115 cm
9-10-2008
BOER
S
SS
SP
PP
PE
EE
EE
EE
EL
LL
LT
TT
TO
OO
OE
EE
ES
SS
ST
TT
TE
EE
EL
LL
LL
LL
LE
EE
EN
NN
N
Samenstelling module Assembly module
115 cm
Duikel frame
A320201PNRSME
1
2
E 05
Submodule
000005PNRSMD21
OPMERK NGBENAM NG
RBEH.
NR.PROJ.
TYPE
NPOS
1
2
1,17m
Grondmarkering
Ground level marker

B
BB
Be
ee
en
nn
na
aa
am
mm
mi
ii
in
nn
ng
gg
g
Title
O
OO
Op
pp
pm
mm
me
ee
er
rr
rk
kk
ki
ii
in
nn
ng
gg
g
Comment
D
DD
Da
aa
at
tt
tu
uu
um
mm
m
Date
T
TT
Te
ee
ek
kk
ke
ee
en
nn
ni
ii
in
nn
ng
gg
g
Drawing
MOD PNR 502 000
Duikelstang 100 cm
Pionier
3-10-2008
BOER
S
SS
SP
PP
PE
EE
EE
EE
EL
LL
LT
TT
TO
OO
OE
EE
ES
SS
ST
TT
TE
EE
EL
LL
LL
LL
LE
EE
EN
NN
N
Samenstelling module Assembly module
EI 05Submodule 000005
PNR
S D22
Lengte 1020 cm HOHKlimstang PNR 33.7x2 102130
PNR
O E
11
OP ERKINGBENA ING
RBEH.NR.
PROJ.
TYPEN
POS
21

B
BB
Be
ee
en
nn
na
aa
am
mm
mi
ii
in
nn
ng
gg
g
Title
O
OO
Op
pp
pm
mm
me
ee
er
rr
rk
kk
ki
ii
in
nn
ng
gg
g
Comment
D
DD
Da
aa
at
tt
tu
uu
um
mm
m
Date
T
TT
Te
ee
ek
kk
ke
ee
en
nn
ni
ii
in
nn
ng
gg
g
Drawing
MOD PNR 503 000
Duikelstang 98 cm
Pionier
6-10-2008
BOER
S
SS
SP
PP
PE
EE
EE
EE
EL
LL
LT
TT
TO
OO
OE
EE
ES
SS
ST
TT
TE
EE
EL
LL
LL
LL
LE
EE
EN
NN
N
Samenstelling module Assembly module
EI 05Submodule 000005
PN
SMD22
Lengte 1000 cm HOHKlimstang PN 33.7x2 100130
PN
OME
11
OPME KINGBENAMING
BEH.N .
P OJ.
TYPEN
POS
2
1