BOSSCO ATV20 User manual

ALL-TERRAIN SOUND SYSTEM
ATV20
USER’S MANUAL
ATV20-UM.indd 1 12/12/2017 12:21:13 PM
ATV20
ATV20

THIS PACKAGE CONTAINS������������������������������������������������������������������������� 2
INFORMATION TO THE USER���������������������������������������������������������������������� 3
BEFORE YOU START ��������������������������������������������������������������������������������� 4
GETTING TO KNOW YOUR ATV20���������������������������������������������������������������� 5
OPERATION���������������������������������������������������������������������������������������������� 6
INSTALLATION������������������������������������������������������������������������������������������ 7
TROUBLE SHOOTING �������������������������������������������������������������������������������� 8
DIMENSIONS��������������������������������������������������������������������������������������������� 8
WIRE DIAGRAM����������������������������������������������������������������������������������������� 9
SPECIFICATIONS��������������������������������������������������������������������������������������� 9
TABLE OF CONTENTS
All rights reserved. No part of this publication may be reproduced, distributed, or transmitted in
any form or by any means, including photocopying, recording, or other electronic or mechanical
methods, without the prior written permission of BOSS AUDIO SYSTEMS.
All other trademarks and trade names are those of their respective owners.
Copyright © 2018 BOSS AUDIO SYSTEMS.
SUPPORT
For the latest information about this product please visit www.bossaudio.com
TECH SUPPORT: 800.999.1236
Tech Support: www.bossaudio.com/support/technical-support/
ATV20-UM.indd 2-3 12/12/2017 12:21:13 PM

2
ENGLISH ENGLISH
3
FCC COMPLIANCE STATEMENT
This device complies with part 15 of the FCC Rules. Operation is subject to the
following two conditions:
(1) this device may not cause interference, and
(2) this device must accept any interference, including interference that may cause undesired
operation of this device.
CAUTION!!
ADJUSTMENT OR ALTERATIONS OF THIS DEVICE MAY RESULT
IN HAZARDOUS OPERATION.
INFORMATION TO THE USER
1- ATV20 All-Terrain Speaker System
2- Mounting Straps + 2 Nylon Zip Straps
1- Power Accessory Extension Adaptor
1- User Manual
1- Warranty Card
USER MANUAL
Thank you for purchasing this
ATV20 All�Terrain Sound System
Please read through these instructions carefully so you will know how to
operate your model properly.
After you have nished reading the instructions, keep this document in a
safe place for future reference.
WARRANTY
CARD
THIS PACKAGE CONTAINS
ATV20-UM.indd 2-3 12/12/2017 12:21:14 PM

4
ENGLISH ENGLISH
5
A
1
2
3
12
A
BOSS AUDIO ATV20
3.5mm AUX-INPUT
CIGARETTE POWER CABLE ADAPTOR
LED POWER INDICATOR
GETTING TO KNOW YOUR ATV20
IMPORTANT SAFETY PRECAUTIONS
●Donotoperatemobileequipmentwhiledrivingamotorizedvehicle–safedrivingandsafetyconsiderationof
othersshouldalwaysbeyourhighestpriority.
●Intheeventyoushouldnoticesmoke,strangenoisesorodorfromthisproduct,oranyotherabnormalsigns,
immediatelyturno󰀨thepowerandconsultyourdealerorthenearestauthorizedBOSS AUDIO SYSTEMS
ServiceCenter.Usingthisproductinthisconditionmayresultinpermanentdamagetothesystem.
●Setyourvolumecontrolatalowsetting,thenslowlyincreasethesounduntilyoucanhearitcomfortably
withoutdistortion,oreardiscomfort.
●BE SURE TO OBSERVE THE FOLLOWING GUIDELINES:
-Donotturnupthevolumesohighthatyoucan’thearwhat’saroundyou.
-Usecautionortemporarilydiscontinueuseinpotentiallyhazardoussituations.
INSTALLATION PRECAUTIONS
WARNING � Always consult a professional installer
●Donotattempttoinstallorservicethisproductbyyourself.Installationorservicingofthisproductbypersons
withoutprofessionaltrainingandexperienceinelectronicequipmentandmotorizedvehicleaccessoriesmay
bedangerousandcouldexposeyoutotheriskofelectricshock,injuryorotherhazards
●ReferanyrepairstoaqualiedBOSS AUDIO SYSTEMSServiceCenter
●The ATV20 canbepoweredfromavehiclescigarettelighter/auxiliarypowerport,orhardwireddirectlyto
thebatterythroughanoptionalrelay/accessoryswitch
●Whenwiringdirectlytothevehiclesbattery,besuretodisconnectthebatteriesnegativeterminalwirebefore
startinganywiringprocedures,itissuggestedthatanoptionalfuseandfuseholder(notincluded)with
minimumratingof15Ampsbeinlinewiththepositivebatteryterminal
●Thegroundcablelengthshouldnotexceed18-inches(Seewiringdiagram)
●TheATV20 hasaweatherresistantdesign,itshouldnotbesubmergedinorunderwaterunderany
circumstances
●UseonlytheinstallationpartsprovidedwiththeATV20
●Washwithamildsoapordetergentandlukewarmwaterusingacleanspongeorasoftcloth.Rinsewellwith
cleanwater.
“Don’ts” � Very Important
●DON’Tcleaninhotsunoronveryhotdays. 
●DON’Tuseabrasiveorhighlyalkalinecleanersonthemainbody
●DON’Tscrapethemainbodywithrazorblades,orothersharpinstruments
●DON’Teveruse,gasoline,acetoneorcarbontetrachloride
CAUTION!!
Using other mounting methods may void this warranty
BEFORE YOU START
3
To avoid battery exhaustion, be sure to occasionally run the
vehicles engine while using this product.
Using this product without running the engine can drain the battery.
Tips:
EN
Nyne Cruiser
USBCHARGE
5V1A
ATV20-UM.indd 4-5 12/12/2017 12:21:16 PM

6
ENGLISH ENGLISH
7
INSTALLATIONOPERATION
AUX�IN OPERATION
1)PowerontheATV20 byplugginginthemalecigarettelighteradaptorinto 2a
femalepoweraccessoryreceptacle.
2)Connecttheintegrated3.5mmAUX�IN cable 1toyourdevicesheadphonejack
3)RoutethewirebacktoATV20,andsecureyourdevice
VOLUME CONTROL
4)Toraise or lower thevolumeuseyourdevicevolumecontrols
For maximum audio performance, ensure your device headphone
volume is set to a minimum 75% level before stowing
ATV20canplayaudiofromanydevice
thathasa3.5mmheadphoneaudiojack.
Tips:
EN
Nyne Cruiser
USBCHARGE
5V1A
2
1
FOR ILLUSTRATION PURPOSES
YOUR VEHICLE MAY VARY
NO SPECIAL TOOLS REQUIRED
1) Use the supplied adjustable straps to secure to rails or roll bars
2) Always recheck straps before every ride
ATV20-UM.indd 6-7 12/12/2017 12:21:18 PM

8
ENGLISH ENGLISH
9
TROUBLE CAUSE SOLUTION
Unit will not turn on
The fuse is blown Check / replace the fuse
Main acc switch not engaged Turn switch to on position
No sound is heard
Device volume is low / muted Turn the volume level up
Device is paused or muted Check your Devices playing / volume status
The audio quality is poor The Device headphone level is too low
Raise the headphone level
to higher level on the main
Device
Unit has become
unresponsive Power glitch or interference Disconnect power for 10 seconds to reset
(66.0cm)
25.98”
(17.8cm)
7.00”
(26.8cm)
10.55”
DIMENSIONS
SUPPORT
For the latest information about this product please visit www.bossaudio.com
TECH SUPPORT: 800.999.1236
Tech Support: www.bossaudio.com/support/technical-support/
TROUBLE SHOOTING WIRE DIAGRAM
SPEAKERS
 •Dimensions:6.5”/165.1mm
 •ConeType:PPCARBON+RUBBERSURROUND
 •TweeterSize:1”PEISOFTDOME
AMPLIFIER
 •ClassD
 •MaximumOutputPower:450Watts
 •Inputimpedance:10kΩ
 •FrequencyResponse:45Hz-22kHz
10A
Fuse and fuse holder
(not included)
Chassis
ground
point
BATTERY
Fuse is located inside the power adaptor
Turn counter clockwise to open
Replace with 10A AGC Fuse type only
INSERT
Normally open switch
(not included)
INSERT
OPTIONAL DIRECT BATTERY WIRING CIRCUIT
RED
BLACK
Chassis
ground
point
QUICK RELEASE
POWER ADAPTOR
(INCLUDED)
POWER ADAPTOR
10A
Ground wire
Metal frame
Recommended 12 ~ 14ga Wire
(not included)
GENERAL
 •OperationalPower:12VDC(10-16Vallowable)
 •MAXCurrentDraw:10A
 •ReplacementFuse:10AAGCTYPE
 •Color:Black
 •Weight:10lbs/4.54Kg
 •DimensionscmWxHxD:66.0x17.8x26.8
 •DimensionsInchesWxHxD:25.98x7.00x10.55
SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
SPECIFICATIONS
ATV20-UM.indd 8-9 12/12/2017 12:21:22 PM

ATV20
USER MANUAL
ALL-TERRAIN SOUND SYSTEM
PRINTED IN CHINA
VER:1.0 EN
iPod / iPhone are trademarks of Apple Inc. registered in the U.S. and other countries.
BOSS Audio Systems is not a󰀩liated with Apple Inc.
0218
BOSS Audio Systems
3451 Lunar Court • Oxnard, CA 93030
www.bossaudio.com | 800.999.1236
Tech Support: www.bossaudio.com/support/technical-support/
All rights reserved. No part of this publication may be reproduced, distributed, or transmitted in any
form or by any means, including photocopying, recording, or other electronic or mechanical methods,
without the prior written permission of BOSS AUDIO SYSTEMS Inc.
Copyright © 2018 BOSS AUDIO SYSTEMS Inc.
ATV20-UM.indd 10 12/12/2017 12:21:22 PM