Kenmore 767.8577000 User manual

TECHNICAL FLASH
T.F. 22-381
Department 731A Toronto
BASIC SERVICE MANUAL
FOR
MICROWAVE OVEN
MODEL 767.8577000
November, 2006
삼흥
정판

CAUTION
SAFETY PRECAUTIONS
PRECAUTIONS TO BE OBSERVED BEFORE AND
DURING SERVICING TO AVOID POSSIBLE EXPOSURE
TO EXCESSIVE MICROWAVE ENERGY
a. Do not operate or allow the oven to be operated with the door open.
b. Make the following safety checks on all ovens to be serviced before activating the
magnetron or other microwave source, and make repairs as necessary; (1) Interlock
operation, (2) proper door closing, (3) seal and sealing surfaces (arcing, wear, and
other damage), (4) damage to or loosening of hinges and latches, (5) evidence of
dropping or abuse.
c. Before turning on microwave power for any service test or inspection within the
microwave generating compartments, check the magnetron, wave guide or
transmission line, and cavity for proper alignment, integrity, and connections.
d. Any defective or misadjusted components in the interlock, monitor, door seal, and
microwave generation and transmission systems shall be repaired, replaced, or
adjusted by procedures described in this manual before the oven is released to the
owner.
e. A Microwave leakage check to verify compliance with the Federal Performance
Standard and CSA Standard should be performed on each oven prior to release to the
owner.
• Proper operation of the microwave ovens requires that the magnetron be assembled to the
wave guide and cavity. Never operate the magnetron unless it is properly installed.
• Be sure that the magnetron gasket is properly installed around the dome of the tube whenever
installing the magnetron.
• Routine service safety procedures should be exercised at all times.
• Untrained personnel should not attempt service without a thorough review of the test
procedures and safety information contained in this manual.

TABLE OF CONTENTS
1. Adjustment Procedures -------------------------------------------------------------------------------------------------------------------------- 3
2. Precautions on Installation ---------------------------------------------------------------------------------------------------------------------- 5
3. General Precautions in Use ------------------------------------------------------------------------------------------------------------------- 5
4. Trial Operation ------------------------------------------------------------------------------------------------------------------------------------- 5
5. Features and Specifications ---------------------------------------------------------------------------------------------------------------- 5-6
6. Overall Circuit Diagram
----------------------------------------------------------------------------------------------------------------------- 7-8
7. Operating Procedures
----------------------------------------------------------------------------------------------------------------------- 9-10
8. Procedure for Measuring Microwave Energy Leakage --------------------------------------------------------------------------- 11-12
9. Disassembly Instructions
------------------------------------------------------------------------------------------------------------------ 13-20
10. Precautions and Repair Service Tips
---------------------------------------------------------------------------------------------------- 21
11. Test and Checkout Procedures, and Troubleshooting
A. Test Procedures
------------------------------------------------------------------------------------------------------------------------ 22-26
B. Checkout Procedures ----------------------------------------------------------------------------------------------------------------- 26-29
C. Troubleshooting
------------------------------------------------------------------------------------------------------------------------ 30-34
12. Exploded View ------------------------------------------------------------------------------------------------------------------------------ 35-41
13. Part Reference list
------------------------------------------------------------------------------------------------------------------------- 42-44
FOREWORD
Read this Manual carefully. Failure to adhere to or observe the information in this Manual may result in exposing
yourself to the Microwave Energy normally contained within the oven cavity.
MECHANICAL SERVICE INFORMATION