Motoworks MOT-150ATV-RA-RED User manual

Check list before starting the bike
Make sure the tyres are fully pumped up
Make sure all the bolts are tighten
Make sure there is sufficient engine oil
Check above steps again after first riding
Freshengineoilwillkeepyourenginepartsprotected
andlubricated,Onlyuseunleaded91petrol

Westronglyrecommendchangingtheengineoil:
1. Afterridingfirstpetroltanks.
2. Afterridingevery6‐8petroltanks.

Tochangetheengineoil:
1. Unscrewthedrainboltbeneaththeengine.
2. Draintheoldengineoiloutoftheengine.
3. Putaround750ml15w‐404‐strokeengineoil
backintotheengine.(FromOilDipstickHole)


UserGuidefor
110cc/125cc/150cc/250ccQuadBike
Start‐up:ONLYuse91unleadedpetrol
1. FuelTapisat“ON”position(Vertical).
2. KillSwitchisat“OFF”position.(Bottombuttonpressed)
3. (Coldenginestartonly)ChokeLeverisat“ON”position(ToLeft)
4. Gearisin“Neutral”position(Onlyifapplicable)
5. Turnthekeyto“ON”position
6. Holdthebrakeandpressthestartbutton
7. Afterstarting30second,turnChokeLeverOFF(ToRight)
MakesureChokeleverisOFFwhenriding.
8. Alwaysturnkeyto“OFF”afterrunning
9. Pumptyreuptoaround18psi.
Storage
Westronglyrecommendemptythecarburetoreverytimefinish
riding.Forlongtimestorageemptythefueltankaswell.
Thesearestepstoemptythecarburetor:
1. Start‐uptheengine
2. TurnFuelTap“OFF”(Horizontal)
3. Waituntilenginestoppeditself.
4. Turnthekeyto“OFF”position.
5. Disconnectbatteryforlongtermstorage

SAFETY INSTRUCTIONS
1. All the dirt or quad bike for off road use only.
2. Before you attempt to ride the bike, please read and understand the user
manual instructions. You should follow the safety procedures and warnings to
reduce risks and accidents. By you, the user, deciding to operate this scooter,
you are accepting all the terms regulations and safety issues mentioned in the
manual.
3. According to the law, you should always wear a helmet and suitable
protective safety equipment gear when riding a scooter.
4. Children must be under the guidance of an adult when using this scooter.
5. We make no claim to the safety of any product that it sells. Any product can
be dangerous when used improperly or in dangerous conditions, even when
safety gear is properly worn.
6. Upon sale, the purchaser takes full responsibility for the condition, state and
quality of repair of the scooter/s. We will not be liable and will not take
responsibility for any accident or injuries that result from usage of this product
either from the customer or any third party.
7. Children under 10 years of age should always be accompanied and
supervised by an adult.

Warning:
Please read below information before you use your new dirt
or quad bike.
AlotofpeoplehaveahardtimestartingandrunningtheChineseATV ’swhennewand
alsowhencold.MostofthesecomewithagelPacintheCarbiefloatbowlforshipping
soitdoesnotruinthefloatduringshipping.Itissupposedtodissolvewhenfuelmixes
withit.ManymakethemistakeofdrivingtheATVoncestarted.Thisisamistake.You
mustletitidleforabout3minsforthegeltodissolve.Ifyoudonotdothisyouwillrisk
thechanceofcloggingthejetsandtheinitialadjustmentswillnotworkanditwillnot
runrightuntilallthegelisgone.Mostofthetimethesewillstartwiththemovementof
thechokethenyoucanlightlyfeatherthethrottletokeepitrunning.Ifyoucanreachthe
idlescrewyoucanturnituptillyoudon’thavetofeatherthethrottle.Afterabout30
minyoucanmakethefinaladjustments.CHANGETHEOILBEFOREYOURIDE!!!These
comewithcheapshippingoilandMUSTbechangedorenginedamageWILLoccur.The
idlescrewontherightsideoftheCarbieisusuallyaPhillipsheadscrewontheCarbie
withaspringaroundit.Theair/fuelscrewistheflatheadscrewusuallyontheleftsideof
theidlescrew.Herearesomebasicadjustmentstogetitstartedandtotuneitonce
brokein.Themixturescrewhadbeenset‐upatthefactorybeforeshipmentandshould
nothavetobereset.Ifnecessary,refertotheadjustmentasbelow:
1.Makesuretheaircleanerisclean.
2.makesurethechokeleverisOFFwhilerunningoncewarm.
3.Warmtheengineupfor3‐5minutes.
4.Turnthemixturescrewclockwiseuntilfullyclosed,andthenturnthemixturescrew2
fullturnsout.
5.AdjusttheidlingscrewuntiltheengineidlesEASILY.
6.Turnthemixturescrewslightlyclockwiseandcounterclockwiseuntilthehighest
engineRevs’obtained.
7.AdjusttheidlingscrewagainuntiltheengineidlesEASILY.
8.Repeatthestepof6&7tillgettingthebestperformance...

*ENGINEIDLESEASILYmeans:Theengineidlingscrewmustbesetcorrectlytogeta
slowestengineidle(1500rpm‐1600rpm),butdoesnotcutoutifyoupressthe
acceleratorquickly.

Coldweatherstartingwillneedanadditionaladjustmenttohelpaidthestartingprocess.
MostofthemanualchokeCarbiehasanadjustableneedleinsidetheCarbie.Lowering
theclip(raisingtheneedle)youwillbeabletoopenthethrottleandgetmorefuelinto
theintakequicker.Thishelpsinthecoldweatherbecausethecoldertheweatherthe
leanerthemixtureis.Youwantricherinthecolderweather.

1‐UnscrewandpullthetopoftheCarbieoffwiththecableandtherewillbeaslidewith
theneedleinthecentre.
2‐Disconnectthecablethroughasmallslotinthesideoftheslide.
3‐Nowyoucantaketheneedleoutfromtheslide.
4‐Theneedlewillhaveaverysmalleclipinaslotontheneedle.Theneedlewillhave5
slots.Loweringtheclipisrichertheandraisingtheclipwillleanitout.
5‐Putthecliponthelowestsettingforcoldweather.DONOTDROPTHECLIP!Theyare
verysmallandhardtofind.
6‐Reversetheprocesswithinstallingtheneedlebackintotheslide,installingthecable,
slidetheslidebackintotheCarbieandscrewthecaptight.
7‐NowmakeanyadjustmentsasstatedaboveintheCarbietuning.
8‐Oncetheweatherwarmsupyoumayneedtolowertheneedleforthehottertemps
oritwillruntoorich.

Thesestepswillworkon99%oftheseATV ’s.Theyareveryhardtogetrunningand
peoplegetupsetwhentheyturnthekeyanditdoesnotrun.Don’tforgetthesearenot
setupatadealerlikethenamebrandssothemostbasicadjustmentsaredonefromthe
factory.Thesearebuiltinchinaandthetempsarehotsothat’showtheadjustmentsare
done.Thetempsvaryandthesearenotsetatallforcoldtemps.

Hopefullythishelpseveryonewiththeseconcerns.Thesereallydorungoodoncetuned
properlyandwithpropermaintenancetheywilllastalongtime.

GoodLuck!


ASSEMBLY INSTRUCTION
Models w/ rack(s)
1st Mount the handle bar (rear view mirrors)
2nd Mount the front suspensions
3rd Mount the turn rods / front drum brakes / front wheels

4th mount the rear wheels
5th Mount the dust covers

6th Mount the front bumper
7th Mount the rear frame part
8
th Mount the rear rack

9th Mount the bracket
10th Mount the turn lights (front & rear) and plug in
11th Connect the battery wire
12th key switch