PSI VERSA-PAK P50 Specification sheet

Apartment Compactor
PSI Waste Equipment Services, Inc.
Safety, Operaon, and Installaon Manual
11/23/2020
v.P50BA

PSI Waste Equipment Services, Inc.
P50 Apartment Compactor
Table of Contents
Secon1—SafetyandResponsibilies
SafetyDecals‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐1‐2
SafetyandResponsibilies‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐3

Secon2—Installaon
SiteSpaceRequirements‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐4
Electrical/SlabRequirements‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐5

Secon3—Operaon
ChangingContainers‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐6
ControlPanel‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐7
NormalOperaonalCharacteriscs(Manual)‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐8
NormalOperaonalCharacteriscs(Auto)‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐9
FaultCondions‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐10

Secon4—Specificaons
Specificaons‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐11

Secon5—Maintenance
PartsDiagram‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐12
Lock‐OutTag‐Out‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐13
PreventaveMaintenance‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐14
HydraulicSchemac‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐15
ElectricalSchemac‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐16





PSI Waste Equipment Services, Inc.
P50 Apartment Compactor
IntroducƟon
ThankyouforchoosingtheP50fromPSIWasteEquipmentServices,Inc.TheP50isbuiltonafoun‐
daonof30yearsofexperiencebuilding,selling,installingandrepairingwasteequipment.PSIWaste
hasinstalled,repairedandrebuiltthousandsofcompactors.Weknowwhatworksandwhatdoesn’t.
Weknowwhatlastsandwhatdoesn’t.Wetookthebestideas,madethembeer,andbuiltthebest
twincylinderapartmentstylecompactoronthemarket.

Aboutthismanual
Thismanualprovidestheinstaller,ownerandoperatorwithinformaonneededtoinstall,maintain
andoperatetheP50compactor.Youmustalsocomplywithlocal,stateandfederalcodes.ARepair
Manualisavailableatwww.psiwaste.com/P50.html

Compliance
TheP50apartmentstylecompactorisbuilttomeetallANSIZ245.2(1)safetystandards.Pleaseinstall,
maintainandoperatethiscompactorinaccordancewiththismanual,applicablelocal,state,andfed‐
eralcodesandregulaons.IfyouhaveanyquesonsabouttheP50,pleasecallusat352‐742‐4774
Opt.2.

Pleasereadthisenremanualbeforeinstalling,operang,ormaintainingthecompactor!

P50 Apartment Compactor
PSI Waste Equipment Services, Inc.
SecƟon 1, Safety and ResponsibiliƟes1

Safety Decals

Replacementdecalsareavailableuponrequest.
Part#DescriponQty
300004CauonDoorClosed4
300005CauonFederalLaw2
300007CauonKeepOff/DoNotPlay5
300008CompactorSafetyRules‐English2
300010Danger208Volt
300013DangerConfinedSpaceLockOut4
300014DangerCrushing/ShearingHazard 6
300015DangerHazardsCompactor3
300017DangerLockOutPowerUnit1
300018DangerShock/ArcFlash1
300019DangerStartsAutomacally2
Locaon
Doors–insideandoutside
Feedareasandcontrols
Allsidesofcompactor
Feedareasandcontrols

Hopper–allsides
Hopper–allsides,insidedoors,accesspanel
Accesspanelsandadjacentsurfaces.
Controlpanelface(PowerUnit)
Controlpanelface(PowerUnit)
Areasofaccessandfeed
300012Danger460Volt 
300011Danger220‐240Volt Controlpanelface(PowerUnit)1
300009CompactorSafetyRules‐Español Feedareasandcontrols2
ListofSafetyDecals
Pickuphookusedtosafelymove
compactorusingcraneorother
suitableliingequipment.

Note:Removeaerinstall.


PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 1, Safety and ResponsibiliƟes2
Safety Decals

P50 Apartment Compactor
PSI Waste Equipment Services, Inc.
SecƟon 1, Safety and ResponsibiliƟes3
Safety and ResponsibiliƟes
InstallerandServicePersonnel
Danger:Onlyqualifiedandauthorizedpersonnelshouldaempttoinstallorservicethiscompactor!
Highvoltagemaybepresent.Shockandarcflashexplosionhazards!WearproperPPE.SeeNFPA70E.
Usesafeworkpracces.
 Readandunderstandthismanual
 Installcompactorinconformancewithlocal,state,andfederalcodes
 Ensurethecompactorisleinasafecondion
 Ensurethismanualandkeysaregiventotheowner

Owner
 Ensurethecompactorinstallaonconformswithalllocal,state,andfederalcodes.
 Ensuretheuseandmaintenanceofthecompactorconformswithalllocal,state,andfederal
codesandregulaons.
 Provideproperinstruconandtrainingtoemployees.
 EnsureemployeesunderstandandfollowOperatorResponsibiliesandsafetydecals.
 Ensureonlyauthorizedandqualifiedemployeeshaveaccesstothecompactor.
 Properlymaintaincompactorandsurroundingareasprovidingadequatespaceforuseand
maintenance.
 Ensurethecontainersusedwiththecompactorareadequatelyratedandfitproperly.
 SeeANSIZ245.2fordetailedOwnerandOperatorResponsibilies.

Operator/Employee
 Youmustbe18yrsoldoroldertooperatethiscompactor.
 Donotusethecompactorunlproperlytrainedandauthorized.
 Read,understandandfollowallsafetydecalsandthismanual.
 Makesureallsafetyswitchesandsafeguardsareinplaceandworking.
 Ensureallpersonsareclearofhopper,charge‐boxareasandendofcontainer.
 Usethecompactorcarefullymaintainingawarenessofpotenalsafetyissues.
 Reportanydamageormalfunconimmediately.
 Ifcompactorisunsafetooperateuselockout/tagoutprocedurestoshutitdown(ifpossible)and
reportsituaonimmediately.


PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 2, InstallaƟon4
Site Space Requirements

PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 2, InstallaƟon

5
Electrical Requirements
MotorSizeVAC
Phase
NEC
FLA
DualElement
FuseMax
Circuit
BreakerMax
Minimum
WireSize(60degC)
3HP208/1Ph18.7355010
3HP230/1Ph17304510
5HP208/3Ph16.7304510
5HP230/3Ph15.2304012
5HP460/3Ph7.6152012
TheP50controlpanelisratedNEMA3RforindoororoutdooruseULListed.Seethechartbelowfor
branchcircuitinformaon.
Slab Requirements


PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 3, OperaƟon6
Changing Containers
Beforeunhookingcontainer,makesureramisinrearposion.PresstheE‐Stopbuonandturnthe
keyswitchtotheOffposion.
 Unlatchcontainerasshown.Removecontainerandplaceinstagingarea.
 Rollnewcontaineruptocompactor.Latchasshown.
 Followinstruconsonthenextpagestooperatecompactor.

PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 3, OperaƟon

7
Control Panel



PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 3, OperaƟon8
Normal OperaƟonal CharacterisƟcs (Manual)
Operangthecompactor
Beforerunningyourcompactor,makesurethecontainerisproperlysecured.Makesuretheareais
clearandthecompactorissafetorun.Followinstruconsbelow.

Manual
WiththeKEYSWITCHinMANUALposion,pressSTARTtostartthecycle.Themotorwillimmediate‐
lyturnon.Aer3seconds,theramwillmoveforwardandconnueforwardunleithertheforward
mer(T0)mesoutorthepressureswitchturnsonfor1.25seconds.Theramwillthenshitore‐
verseandconnueinreverseunlthereversemer(T1)mesoutorthepressureswitchturnson
for1second.Ifthemulcyclemer(T2)hasmedoutthemotorwillstopandtheprocessisover.
Ifthemulcyclemerhasnotmedouttheramwillimmediatelymoveforwardtobeginanother
cycle.

IftheE‐STOPispressed,adoorisopened,ortheKEYSWITCHisturnedoff,thecyclewillstopandthe
motorwillshutoff.WhentheSTARTbuonispressedagain,thecompactorwillstartforward.

IftheREVERSEbuonispressedandheldthemotorwillstartandtheramwillshiintoreverseor
connueinreverse.OncetheREVERSEbuonisreleasedthecyclewillstopandthemotorwillturn
off.

IftheSTARTbuonispressedduringanormalcycletherewillbenoeffect.IftheSTARTbuonis
pressedatthemethatT1mesoutortheramdeadheadsinreversefor1secondthecompactor
willbeginanothercycleregardlessofmul‐cyclemervalue.

Ifthepressureswitchisactuatedfor1/2seconforwardstroketheFULLlightwillcomeon.Thecon‐
tainershouldbechangedoutsoon.NOTE:ResetbypressingtheE‐STOPbuon.

Ifthepressureswitchisactuatedfor1secontheforwardstroketheFULLlightwillstayonandthe
compactorwillshutdown.NOTE:ResetbypressingtheE‐STOPbuon.

PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 3, OperaƟon

9
Normal OperaƟonal CharacterisƟcs (Auto)
Auto(normaloperaon–complieswithANSI)
WiththeKEYSWITCHintheAUTOposion,pressSTARTtocyclethemachineandiniateAUTOmode.
Theaudiblewarningwillsoundfor5seconds,thewarninglightwillflash,andthecompactorwillcom‐
pleteacycle.WarninglightwillconnuetoflashaslongasthecompactorremainsinAUTOmode.If
thelightturnsoff,thecompactorisnolongerinAUTOmodeandtheSTARTbuonwillhavetobe
pressedtoreturntoAUTOmode.

Ifthephotoeye“sees”somethingattheendofthecyclethemotorwillconnuetorunbuttheramwill
pausefor3secondstoallowtrashinthehoppertofallintothechargebox.Aerthe3secondpause
theramwillconnueforwardandcompleteanothercycle.

Attheendofthecycle,iftheeyedoesnot“see”anymoretrashthemotorwillstopandtheprocessis
over.Theeyewillconnueto“look”formoretrash.

Momentaryblockingoftheeye(fallingtrash)willhavenoeffect.Whentheeyeisblockedfor5fullsec‐
ondsthewarninghornwillsound.Iftheeyeconnuestostayblockedforthenext6secondsthewarn‐
inghornstopsandthecompactorwillstart.Iftheeyeisclearedbeforethecompactorstartsthecom‐
pactorwillnotstartandtheprocessisreset.

Autowith“NOWARNING”set(DoesNOTcomplywithANSI)
Therearesomeinstanceswhereanaudiblewarningpriortoeachintermientstartmaynotbepossible.
Theownerandinstallermusttakeaddionalsafetyprecauonstoinsureitissafetoturnthisoff.NOTE:
Theinialaudiblewarningcannotbeturnedoff.

Danger:Onlyqualifiedandauthorizedpersonnelshouldaemptthefollowing!
Toturnoffaudiblewarningpriortoeachintermientstart,openthepanelandlocatetheZencontroller
(figureAbelow).Gotostatusscreenbypressing[ESC0].ThetoplineofStatusScreenwillhavethepro‐
gramversion(e.g.“V‐PV6.0EX”).Pressandrelease[4]and[ALT7]atthesameme.Youshouldsee
“NoWarning”ontheboomline.Ifnot,releaseanddoitagain.Thesebuonstogglethefeatureon
andoff.Seeimagebelow.


PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 3, OperaƟon10
Fault CondiƟons
SolidLightonE‐STOP
Thephotoeyeisblocked.Cleanthephotoeyeandmakesureitisproperlyaligned.PressE‐STOPand
pullitbackout.PressSTART.

FlashinglightonE‐STOP
Callqualifiedcompactorrepairtechnician.Downloadrepairmanualforlistofpossiblecauses.Oncere‐
solvedpressE‐STOPandpullitbackout.PressSTART.

SolidAMBERLIGHT
Thecompactorisfull.Makesuretheramisinthefullybackposion.Changeoutthecontainer.Press
START.

KEYSWITCHisinAUTO,warninglightisnoton,compactorisnotrunning
Thecyclewasinterrupted.MakesurealldoorsareclosedandE‐STOPispulledout.PressSTART.

SleepMode
If“SleepMode”isusedthecompactorwillnotoperateinAUTOduringthisme.“SleepMode”willap‐
pearonthestatusscreen.Thispreventsthecompactorfromrunningautomacallylateatnightanddis‐
turbingresidents.ThecompactorcansllbeoperatedusingtheSTARTbuon.Oncethecompactor
“wakesup”itwillresumenormaloperaon.Seesengsbelowformoreinformaon.

Danger:Onlyqualifiedandauthorizedpersonnelshouldaemptthefollowing!
Touse“SleepMode”you’llhavetosettheclockontheVersa‐Paksystemandthenthemerstotellthe
Versa‐PaksystemwhentoturntheautomacoperaonONandOFF.Seepage12foraviewofthe
screen.

Settheclockbypressing[OK1][2][2][2]toSETCLOCK.Press[OK1][OK1].Youarenowon
thedate/me.DateisarrangedYY/MM/DD.Timeisin24hrs.So1pmwouldbe13:00.Thedate/me
areallonefieldandarechangedatthesameme.Press[OK1].Use[3]and[4]toscrollbetween
dateandme.Use[5]and[2]tochangethevalues.Confirmthedateandmearecorrect.
Press[OK1][OK1].

Nowyouneedtosetthesleepmodemer.Thismeisalsoin24hrs.So11:00pmwouldbe23:00.
Press[ESC0][5].YoushouldnowbeonPARAMETER.Press[OK1][OK1][3].Youshouldnow
beontheTofT0.TheTshouldbeblinkingoffandon.Press[2].Youshouldnowbeon“@0”.
Press[OK1][2][2].Youshouldnowbeon“ON00:00”.Theisthemethecompactor“wakes
up”inthemorning.Press[OK1].Use[5]and[2]tochangethevaluesand[3]and[4]to
scrollbetweenMMandHH.WhentheONmeisset,press[OK1].Use[2]togototheOFFme.
Press[OK1].Thisisthemethecompactor“goestosleep”.



PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 4, SpecificaƟons

11
SpecificaƟons
P50 SpecificaƟons: 5HP
Charge box
Manufacturer Rang (cy) 0.43
Standard Industry Rang (cy) 0.29
Clear Top Opening (in) 22.63L x 28W
Capacity Per Hour (cy) 52
Performance
Cycle Time (secs) 20
Normal Force (lbs.) 15,708
Pack‐Out Force (lbs.) 18,221
Normal Ram Face Force (psi) 27.1
Pack‐Out Ram Face Force (psi) 31.5
Ram Penetraon (in) 5
Weight (lbs.) 1,876
Electrical
Tri‐Volt Motor 208/230/460 5HP
Electric Control Voltage 120 VAC
Hydraulic
Hydraulic Pump Capacity (gpm) 6
Normal System Pressure (psi) 1250
Maximum System Pressure (psi) 1450
Oil Capacity (gal) 12
Hydraulic Cylinder (1) 4" bore
2" rod
Structural
Charge box Sides 1/4" Plate
Charge box Floor 3/8" Plate
Ram Sides 1/4" Plate
Ram Floor 3/8" Plate
Ram Top and Slider Plate 1/4" Plate
Ram Face 3/8" Plate
Hopper Flare 3/8" Plate
Hopper Sides 10GA Sheet


PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 5, Maintenance12
Parts

PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 5, Maintenance

13
Lockout / Tagout
Beforeenteringanyporonofthecompactor,besurethatallsourcesofenergyareremoved.The
followinginstruconsareprovidedasaminimumprocedure.Otherstepsmaybenecessary!Ifyou
arenotaqualifiedpersonSTOP!WeartheproperPPEandfollowsafeworkpracces.

Lockout
1)Nofyallaffectedpersonnelofcompactorbeingshutdownandlockedout.
2)Iftheramispushingagainstthetrash,presstheREVERSEbuontobringitbacktotheretracted
posion.PresstheE‐StopbuonandturnkeyswitchtotheOFFposion.Keepthekeywithyou.
3)Turnthemainpowerdisconnectoff.Ensurethepowerwasdisconnected.
4)Placeapadlockandaproperlycompletedandapprovedlockouttagonthedisconnect.Make
surethepadlockpreventsthedisconnectfrombeingturnedon.Keepthekeywithyou.
5)Nowmakesureyoucannotstartthecompactor.
6)Relievepressurefromhydraulicsystembypushinginoneachsideofdireconalvalvefor3full
seconds.(seeillustraonbelow)
7)Ifcompactorischutefed,closeoffthechute.
8)Besuretocompleteanyotherstepsthatmaybenecessarytoremoveallenergyfromthecom‐
pactor.
9)Beforestarngelectricalwork,checkforincomingvoltagewithameter.
10)Onlyqualifiedandauthorizedpersonnelshouldperformmaintenanceandrepairtasks.

ReturntoService
1)Doublechecktheworkareafortoolsandpersonnel.Checktosothatallconneconsaremade
andghtandthatcoversareinplaceandallsafetyswitchesareinplace.
2)RemoveLockoutdevices
3)Reenergizecompactorandfollowoperanginstruconsinthismanual.
4)Testallsafetydevicesandcheckforleaksandproperoperaonofallcontrolsandcompactor.
5)Nofyallaffectedpersonnelthatcompactorisoperaonal.


PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 5, Maintenance14
PreventaƟve Maintenance
EachContainerChange
 Makesureallcontrolbuons,doorinterlocks,andwarninglightandalarmworkproperly.
 Listentocompactor.Itshouldrunquietlyandsmoothly.
 Makesurecontainerratchetandlatchoperatesmoothly.
 Lookforobviousoilleaksorunsafecondions.
 Correctdeviaonsbeforepungthecompactorbackinservice.

MonthlyOrMoreFrequentlyAsNeeded
 Greasechargeboxfloor,walls,andsliderplatetracktopreventprematurewearandtokeepunit
runningsmoothandquiet.
 Wipephotoeyecleanwithadamppapertowel.Usesoapandwaterifneeded.Donotusesol‐
ventsorabrasivematerials!
 Checkoillevelusingthedipsckonthebreather/dipsck.Withtheraminthebackposion,oil
levelshouldbewithin1‐1/2”oftopofsck.Ifmorethan1gallon(5/8”)ofoilisbeinglostper
year,callaqualifiedcompactorrepaircompanyandhavethemcheckthecylindersandhosesfor
leaks.
 Cleantrashfromunderandaroundcompactor.

Every5Years
 Changeoil,cleanreservoir,cleanorreplacesuconscreen(insidetank).Makesuresucontube
isght.UseaqualityAW46hydraulicoil(8gallons).Thisserviceshouldbeperformedbyquali‐
fiedtechnician.

Formoreinformaononrepairs,refertoourrepairmanualatwww.psiwaste.com/P50.html
Warning:Lockout/Tagoutbeforeenteringanyporonofcompactor!
Onlyqualifiedandauthorizedpersonnelshouldworkonthemachine!
YourP50isdesignedtolastmanyyearswithlilemaintenance.Withthatsaid,itisprudenttokeep
yourcompactorcleananddry.Thoughtheelectricalcomponentsaresealedandcangetwet,you
shouldNOTpressurewashthepanel,photoeyeorotherelectricalcomponents.Makesuretheexte‐
riorofthecompactorhasagoodcoatofpaintonitandfollowthemaintenanceschedulebelow.

PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 5, Maintenance

15
Hydraulic SchemaƟc


PSI Waste Equipment Services, Inc.
P50 Apartment Compactor SecƟon 5, Maintenance16
Electrical SchemaƟc

31130IndustryDriveBldg.A
Tavares,FL32778
352‐742‐4774opt2
[e-mail]
Term:
TheP50comeswitha3‐yearsstructural,2‐yearsparts,and1‐yearlaborlimitedwarranty.TheTermbegins
onthedayofshipmentunlessnoficaonismadeofthedayofinstall.Thetermwillbeginnolaterthan
threemonthsfromthedayoftheinvoice.

LimitedWarranty‐What’sCovered:
1Year–Parts,labor,andupto2hourstraveltorepairactualdefectsinmaterialsorworkmanship.
2Years–Partstorepairactualdefectsinmaterialsorworkmanship.
3Years‐Partsandlabortorepairactualstructuralfailuresproventobecausedbydefectsinmaterialsor
workmanship.
Warranty“VOID”ifcoveredequipmentisnotpaidforinfull.
WarrantylimitedtothepricepaidtoPSIWasteforcoveredequipment.

What’sNOTCovered:
·Modificaons,opons,orequipmentnotprovidedbyPSIWaste.
·Damage,wearandtear,misuse,negligence,orotherlossesnotcausedbydefectsinmanufacturing.
·Normalmaintenance,cleaning.
·Abrasionordamagetoexteriorhoses.
·Lossofuse,temporaryservice,consequenalorincidentaldamages.
·Overmeandtravelover2hours.
·Casters,ratchets,twistedlatches,anchors,fuses,andkeys.
·Repairorreplacementofpropertyotherthanthecoveredequipment.
·WorkdonewithouttheauthorizaonofPSIWasteorbyanunauthorizedcompany.
·PartsnotprovidedbyPSIWasteunlessotherwiseauthorized.

MakingaClaim:
·Claimsmustbemadewithintendaysofasuspecteddefectandmustincludeaserialnumber.
·NofyPSIWastebyemailorphoneofaclaimassoonasadefectissuspected.
·Uponapprovaloftheclaim,PSIWastewillauthorizerepairstobemade.Condionsmayapply.
·Condionsmustbemetforaclaimtobepaid.(E.g.picturesofrepairs,returnedparts,etc.)

FormoreinformaonaboutourP50compactorvisitwww.psiwaste.com/P50
RepairManual|Downloads|InstruconalVideos|PartsList|Gallery
Youcanalsocall352‐742‐4774forTechSupport(Opt‐4)orSales(Opt‐2).
www.psiwaste.com
Warranty