Adexa EHP-2S User manual



GasCountertopstove
































Thismanualcontainsimportantinformationregarding
yourpurchasedequipment.Pleasereadthemanualthoroughly
priortoequipmentset‐up,operationandmaintenance.
Failuretocomplywithregularmaintenanceguidelines
outlinedinthismanualmayvoidthewarranty.Pleasekeepitforfuture
referenceafterinstallationanddonotthrowitaway!
Thisisauniversalinstallationandoperationinstructionbookwhich
wouldapplytodifferentmodels.
PLEASEREAD!!!

WARNINGS
•Donotstoreorusegasolineorotherflammablevaporsorliquidsinthevicinityofthisoranyother
equipment.
•Improperinstallation,adjustment,alteration,serviceormaintenancecancausepropertydamage,
injuryordeath.
•Readtheinstallationandmaintenanceinstructionsthoroughlybeforeinstallingorservicingthis
equipment.
•Havetheequipmentinstalledbyaqualifiedinstallerinaccordancewithallfederal,stateandlocal
codes.
•Donotinstallorusewithoutall4legs.
•Thisequipmentisforuseinnon‐combustiblelocationsonly.
•Donotobstructtheflowofcombustionandventilationair.
•Donotspraycontrolsortheoutsideoftheequipmentwithliquidsorcleaningagents
•Allowforhotpartstocoolbeforecleaningormoving.
•Thisequipmentshouldonlybeusedinaflat,levelposition.
•Donotoperateunattended.
•Anyloosedirtormetalparticlesthatareallowedtoenterthegaslinesonthisequipmentwill
damagethevalveandaffectitsoperation.
•Ifyousmellgas,followtheinstructionsprovidedbythegassupplier.Donottouchanyelectrical
switch;donottrytolighttheburner;donotuseatelephonewithincloseproximity.
•Neverattempttomovegrateswhilecooking.
SETUP
1.Removeallpackingmaterialandtape,aswellasanyprotectiveplasticfromtheequipment.
2.Placetheequipmentinthedesiredpositionandheight.
3.Installthefour(4)legsontotheequipment.
4.Cleananddrytheequipmentthoroughlybeforeusing.
INSTALLATION:
Theinstallationofthisequipmentmustconformwithlocalcodes,orwiththeNationalGasCode,
ANSIZ223.1/NFPA54,orthe
NaturalGasandPropaneInstallationCode,CSAB149.1,asapplicable.
•Theequipmentanditsindividualshutoffvalvemustbedisconnectedfromthegassupplypiping
systemduringanypressuretestingofthatsystemattestpressuresinexcessof½psi(3.5kPa).
•Theequipmentmustbeisolatedfromthegassupplypipingsystembyclosingitsindividualmanual
shutoffvalveduringanypressuretestingofthegassupplypipingsystemattestpressuresequaltoor
lessthan½psi(3.5kPa).
Clearanceandpositioningaroundtheequipment:
•Thisequipmentmustbeinstalledadjacenttonon‐combustiblesurfacesonlywithaminimum
spacingof6”fromallsides.Thisequipmentmustbeadistanceof6”fromotherequipment.The
equipmentmusthavethe4”legsinstalledandbeplacedonanoncombustiblesurface.
AirSupplyandventilation:
•Theareainfrontandaroundtheequipmentmustbekeptcleartoavoidanyobstructionoftheflow
ofcombustionandventilationair.
•Adequateclearancemustbemaintainedatalltimesinfrontofandatthesidesoftheequipment
forservicingandproperventilation.

PressureRegulator:
•Allcommercialcookingequipmentmusthaveapressureregulatorontheincomingservicelinefor
safeandefficientoperation.Pleaseconsultthelocalgascompanytosourcepropergasregulator.

Checkthegassupplypressureafterinstallation.
Gassupplypressurecanbemeasuredwithaliquid‐filledpressuregauge(e.g.aU‐shaped
pressuregauge,minimumscaledivision0.1mbar)oradigitalgauge.Procedureasfollows:

Removethepanel,unscrewthescrewonthepressureport(Picture1);
Placethepressuregauge;
Startuptheappliancebyfollowingtheinstructionsintheuser’smanual;
Checkthesupplypressure;
Afterthecheck,removethepressuregauge;
Replacethesealingscrew.



PROPANEGASCONVERSION
Thishotplateisshippedfromthefactoryequippedwithfixedburnerorificesfornaturalgasoperation.
Theburnerorificesrequiredtoconvertthehotplatetopropanegasareshippedwiththehotplatein
theshippingpackaging.Itisrecommendedthatatrainedgasservicetechnicianwiththenecessary
tools,instrumentsandskillsperformtheconversion.
Toconverttopropane,followingstepsmustbecompleted:

Switchoffthegasatthemainsupplyvalveandallowtheunittocooldownbeforecommencing
withtheconversion.
Takeoffthefrontplatetoexposetheinjectorandcontrolvalve.
Changethemainburnerinjector:
Loosenandremovethebrassorificelocatedontheendoftheburnerwithawrench.
Replacewiththeneworificefromtheconversionkit,firstapplyingasmallamountofjointing
pastetothethreadontheendofthenozzleholder,thiswillensureagoodgastightseal.


OPERATION:
sealing screw
pressure port
Picture 1

Beforeinitialuse,depresstheknobandturnthegascontrolknobtothemaximumsettingandhold
ittopurgetheairinsidethemanifoldpipeout.Itwouldtakeabout20seconds.Aftertheairinside
themanifoldpipeispurgedout.Pressthebatteryignitertostarttheflame.Holdtheknobfor20
secondsuntiltheflameisstable.Thenreleasetheknob.Iftheflamegoesout,rotatetheknobto
startingposition.Waitfor10minutesandthenrepeatabovesteps.Aftertheflameisstable,allow
theequipmenttoburn‐infor20minutes.
Seeingsmokecomingfromtheburnersorgratesisnormalduringburn‐in.After20minutesof
burn‐in,equipmentisreadyforuse.
1.Toignitetheburners,depressandturnthegascontrolknobtohighpositionandholdittopurge.
2.Youcanadjusttheflameheightbyrotatingtheknob.Therearetwoflamepositions.bigflame.
smallflame.
3.Aftercookingisdone,pleaseturnthevalvetooffposition.
CLEANING:
Tomaintaintheappearanceandincreasetheservicelife,cleanyourequipmentdaily.
DONOTcleanequipmentwithsteelwool.
1.Allowtheequipmenttocoolcompletelybeforecleaning.
2.Usingawirebrush,scrapethegrillgrate(s)toremoveanyfoodresidue.
3.Tocleanequipment,useeitheradampcloth,spongewithsoapywaterorametalscraper.
4.Drygratesthoroughlytopreventrusting.
5.Emptyandcleanthedriptray.
MAINTENANCE:
•Aqualifiedservicecompanyshouldchecktheunitforsafeandefficientoperationonanannual
basis.
•Gaspipingshallbeacertainsizeandinstalledtoprovideasupplyofgassufficienttomeetthefull
gasinputoftheequipment.
•Amanualshutoffvalveshouldbeinstalledupstreamfromthemanifoldwithin4ft.(1.2m)ofthe
equipmentandinapositionwhereitcanbereachedintheeventofanemergency.
•Checkentiregaspipingsystemforleakseverysooften.Usingagasleakdetectororsoapywater
solutionisrecommended.
•Installequipmentunderefficientexhausthoodwithflameprooffilterswithadistanceofnoless
than4feetbetweenthetopoftheequipmentandthefiltersoranyothercombustiblematerials.
*ShippedsetupforNaturalGasandincludesakitforconversiontoLPG.

Toubleshooting：
Burnerdoesnotcomeonwhenthe
controlknobisturnedon
A.Problemwithgasvalve.(Callforservice).B.Pilot
burnernotlit.C.Lowgaspressure.(Callforservice)
Toomuchheat
A.BurnervalvesadjustedtoohighB.Faultyventilation
C.OverratedgaspressureD.Improperlyadjustedburner
Unevenheatsidetoside
A.BurnervalvesimproperlyadjustedB.Applianceisnot
levelsidetosideC.Improperlyadjustedburner
Unevenheatfronttoback
A.ApplianceisnotlevelfronttobackB.Faulty
ventilationC.Improperlyadjustedburner

Pilotburnerwillnotstaylit
A.Pilotflameissettoolow.Adjustpilottoallowforgas
flow.B.ObstructioninpilotorificeC.Lowgaspressure.
(CallforService).
Yellowburnerflames A.Openburnershuttersuntilflamesareblue
Liftingburnerflames A.Closeburnershuttersuntilflamestouchburner
Fluctuatinggaspressure A.Checkforcloggedventonregulator


ProductSpecificationSheet
Gasorificedia.Gaspres.Totalpower
EHP‐6SEHP‐4SEHP‐2S
G301.3mm29mbar6.3kWx66.3kWx46.3kWx2
G301.2mm37mbar6.7kWx66.7kWx46.7kWx2
G301.1mm50mbar6kWx66kWx46kWx2
G202mm20mbar7kWx67kWx47kWx2
G25.32mm25mbar6kWx66kWx46kWx2


























Explodeddiagramandpartlist
EHP‐2S

EHP‐4S


EHP‐6S



ADEXADIRECTLIMITED
GROUNDFLOORUNIT1214PURLEYWAYCROYDONCR04XGLONDONUNITEDKINGDOM
T: [phone] [email protected] www.adexa.co.uk
ECDeclarationofConformity


AdexaDirectLimiteddeclaresthat:

EquipmentType:  GasCountertopstove


Model:EHP‐2S,EHP‐4S,EHP‐6S

ImportedBy:ADEXADIRECTLIMITED
GROUNDFLOORUNIT1214PURLEYWAYCROYDONCR04XG
LONDON,UNITEDKINGDOM
SerialNumber:

YearofManufacture:

Brand:ADEXA

ApplicationofCouncilDirective(s):(EU)2016/426(9March2016)

Standards:
EN203‐1:2014,EN203‐2‐1:2015
EN203‐3:2009


I,theundersigned,herebydeclarethattheequipmentspecifiedaboveconformstotheabove
Directive(s)andStandard(s).

Date:  20.10.2020
Signature: 

FullName:HakanBaykal

Position:PurchaseManager
