BELL LABS INNOVATIONS Lucent Technologies Telica Plexus 9000 Technical manual

Part Number 255-400-003R3.10.1
Issue 18, October 15, 2005
Software Version 3.10.1
Copyright ©2005 Lucent Technologies
All Rights Reserved
Lucent Gateway Platform
Planning and Engineering Guide

Copyright 2005 by Lucent Technologies. All Rights Reserved.
This material is protected by the copyright and trade secret laws of the United States and other countries. It may not be reproduced, distributed, or altered in
any fashion by any entity (either internal or external to Lucent Technologies), except in accordance with applicable agreements,
contracts or licensing, without the express written consent of Lucent Technologies and the business management owner of the material.
For permission to reproduce or distribute, please contact the following:
Product Development Manager 1 888-LTINFO6 (domestic)
1-317-322-6848 (international)
Notice
Every effort has been made to ensure that the information in this document was complete and accurate at the time of printing. However,
information is subject to change.
Mandatory customer information
Safety
Always observe the Safety Instructions when operating the system.
Trademarks
All trademarks and service marks specified herein are owned by their respective companies.
Ordering information
The order number of this document is 255-400-003R3.10.1.
Support
Technical support
Please contact your Lucent Technologies Local Customer Support Team (LCS) for technical questions about the information in this document.
Information product support
To comment on this information product online, go to http://www.lucent-info.com/comments or email your comments to [email protected]m.

Plexus Planning and Engineering Manual Contents
Section 130-050-000 Issue 18, June 4, 2004
Telica, Inc.
Manual Contents
1. Manual Contents
Following is a listing of the tabs and documents of this manual. Documents are
listed by name followed with its section number and its issue number and date on the
same line.
Table of Contents 130-050-100 Issue 5, June 4, 2004
Safety and Regulations
1 Safety and Regulations 130-050-200 Issue 1, Aug. 16, 2002
Introduction
2 Introduction 130-100-000 Issue 8, April 25, 2003
System Overview
3 System Overview 130-110-000 Issue 6, May 14, 2004
System Specifications
4 System Specifications 130-115-000 Issue 6, April 2, 2004
System Description
5.1 Chassis Detailed Description 130-120-100 Issue 4, May 28, 2003
5.2 Front System Processor Timing
Module 1130-120-200 Issue 3, Apr. 23, 2004
5.3 Front Dual System Processor
Timing Module 2 130-120-210 Issue 1, Apr. 23, 2004
5.4 Front Dual System Processor
Timing Module 3 130-120-220 Issue 1, Apr. 23, 2004
5.5 Rear System Processor Module 130-120-250 Issue 2, Apr. 23, 2004
5.6 Rear System Processor 3 130-120-260 Issue 1, Apr. 23, 2004
5.7 Switch Fabric Front Module 130-120-300 Issue 2, Apr. 23, 2004
5.8 Switch Fabric A/B Rear Modules 130-120-350 Issue 1, Apr. 23, 2004
5.8 DS1 I/O Front Module 130-120-400 Issue 4, Apr. 23, 2004
5.10 DS1 I/O Rear Module 130-120-450 Issue 3, Apr. 23, 2004
5.11 Triple DS3/STS-1 I/O Module 130-120-500 Issue 2, Mar. 26, 2004
5.12 Triple DS3 I/O Rear Module 130-120-550 Issue 3, Apr. 23, 2004
5.13 Octal DS3 I/O Front Module 130-120-600 Issue 4, Mar. 26, 2004
5.14 Octal DS3 I/O Rear Module 130-120-650 Issue 2, Apr. 23, 2004
5.15 Voice Server Modules 130-120-700 Issue 2, Apr. 23, 2004
5.16 Quad ATM Network Access Module 130-120-750 Issue 2, May 28, 2004
5.17 Packet Network Access Module 130-120-760 Issue 1, May 28, 2004
5.18 DS3 ATM Network Access Module 130-120-800 Issue 1, Apr. 23, 2004

Manual Contents Plexus 9000 Planning and Engineering Guide
Issue 18, June 4, 2004 Section 130-050-000
Telica, Inc.
5.19 Ethernet Network Access Module 130-120-810 Issue 2, Apr. 23, 2004
5.20 Quad 1000BASE-T Ethernet
Interface Module 130-120-860 Issue 1, Apr. 23, 2004
5.21 Quad 1000BASE-SX Ethernet
Interface Module 130-120-870 Issue 1, Apr. 23, 2004
Planning for Installation
6.1 Planning for Installation 130-200-000 Issue 5, Jan 24, 2003
6.2 Planning for Provisioning 130-200-100 Issue 11, Jan 24, 2003
Interconnect Drawings
7 Interconnect Drawings 130-250-000 Issue 3, Jan 24, 2003
Part Information
8 Part Information 130-400-000 Issue 16, June 4, 2004
Technical Support
9 Technical Support 130-300-000 Issue 2, Aug.16, 2000
Acronyms
10 Acronyms 130-900-000 Issue 7, Jan. 24, 2003
Index
Index 130-900-990 Issue 4, June 4, 2004

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. i
Planning and Engineering Guide
Table of Contents
1Safety and Regulations
1.1 Safety Instructions....................................................................................1-1
1.2 Electrostatic Discharge (ESD)..................................................................1-2
1.3 Laser Safety Notice ..................................................................................1-3
1.4 Exemption ................................................................................................1-4
1.5 Regulatory Compliance Notices...............................................................1-4
2Introduction
2.1 Overview..................................................................................................2-1
2.2 Scope and Audience.................................................................................2-1
2.3 Planning and Engineering Guide Organization........................................2-2
2.4 Using the CD-ROM .................................................................................2-3
2.5 Relationship Between Manuals................................................................2-3
2.6 Plexus 9000 Documentation ....................................................................2-3
3System Overview
3.1 Plexus 9000 Softswitch-Based Switching System Overview ..................3-2
3.2 Functions, Features, and Benefits.............................................................3-3
3.3 System Components...............................................................................3-11
3.4 Single Shelf System Architecture...........................................................3-22
3.5 Network Applications ............................................................................3-25
3.6 System Management ..............................................................................3-26
3.7 Summary ................................................................................................3-29
4System Specifications
4.1 Specifications...........................................................................................4-1
4.2 Regulatory Compliance Notices.............................................................4-13
4.3 Voltage Drop/Wire Size Selection.........................................................4-14
4.4 Alarm Contacts Closure Ratings............................................................4-15

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
ii Telica, Inc.
5System Description
5.1 Chassis
5.1.1 Scope........................................................................................................5-3
5.1.2 Functional Description.............................................................................5-3
5.1.3 Hardware Description...............................................................................5-5
5.1.4 Specifications.........................................................................................5-23
5.2 Front System Processor Timing Module
5.2.1 Scope......................................................................................................5-25
5.2.2 Functional Description...........................................................................5-25
5.2.3 Theory of Operation...............................................................................5-29
5.2.4 Specifications.........................................................................................5-36
5.3 Front Dual System Processor Timing Module 2
5.3.1 Scope......................................................................................................5-39
5.3.2 Functional Description...........................................................................5-39
5.3.3 Theory of Operation...............................................................................5-44
5.3.4 Specifications.........................................................................................5-51
5.4 Front Dual System Processor Timing Module 3
5.4.1 Scope......................................................................................................5-53
5.4.2 Functional Description...........................................................................5-53
5.4.3 Theory of Operation...............................................................................5-57
5.4.4 Specifications.........................................................................................5-64
5.5 Rear System Processor Timing Module
5.5.1 Scope......................................................................................................5-65
5.5.2 Functional Description...........................................................................5-65
5.5.3 Theory of Operation...............................................................................5-69
5.5.4 Specifications.........................................................................................5-75

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. iii
5.6 Rear System Processor 3
5.6.1 Scope......................................................................................................5-77
5.6.2 Functional Description...........................................................................5-77
5.6.3 Theory of Operation...............................................................................5-81
5.6.4 Specifications.........................................................................................5-88
5.7 Switch Fabric Front Module
5.7.1 Scope......................................................................................................5-91
5.7.2 Functional Description...........................................................................5-92
5.7.3 Theory of Operation...............................................................................5-96
5.7.4 Specifications.........................................................................................5-99
5.8 Switch Fabric A/B Rear Modules
5.8.1 Scope....................................................................................................5-101
5.8.2 Functional Description.........................................................................5-101
5.8.3 Theory of Operation.............................................................................5-107
5.8.4 Specifications.......................................................................................5-110
5.9 DS1 I/O Front Module
5.9.1 Scope....................................................................................................5-111
5.9.2 Functional Description.........................................................................5-111
5.9.3 Theory of Operation.............................................................................5-115
5.9.4 Specifications.......................................................................................5-120
5.10 DS1 I/O Rear Module
5.10.1 Scope....................................................................................................5-123
5.10.2 Functional Description.........................................................................5-123
5.10.3 Theory of Operation.............................................................................5-128
5.10.4 Specifications.......................................................................................5-129

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
iv Telica, Inc.
5.11 Triple DS3 /STS-1 I/O Front Module
5.11.1 Scope....................................................................................................5-133
5.11.2 Functional Description.........................................................................5-134
5.11.3 Theory of Operation.............................................................................5-137
5.11.4 Specifications.......................................................................................5-141
5.12 DS3 I/O Rear Module
5.12.1 Scope....................................................................................................5-143
5.12.2 Functional Description.........................................................................5-143
5.12.3 Theory of Operation.............................................................................5-146
5.12.4 Specifications.......................................................................................5-147
5.13 Octal DS3/STS-1 I/O Front Module
5.13.1 Scope....................................................................................................5-149
5.13.2 Functional Description.........................................................................5-150
5.13.3 Theory of Operation.............................................................................5-153
5.13.4 Specifications.......................................................................................5-157
5.14 Octal DS3/STS-1 I/O Rear Module
5.14.1 Scope....................................................................................................5-159
5.14.2 Functional Description.........................................................................5-159
5.14.3 Theory of Operation.............................................................................5-163
5.14.4 Specifications.......................................................................................5-164
5.15 Voice Server Modules
5.15.1 Scope....................................................................................................5-167
5.15.2 Functional Description.........................................................................5-167
5.15.3 Theory of Operation.............................................................................5-171
5.15.4 Specifications.......................................................................................5-174

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. v
5.16 Quad ATM Network Access Module
5.16.1 Scope....................................................................................................5-175
5.16.2 Functional Description.........................................................................5-176
5.16.3 Theory of Operation.............................................................................5-179
5.16.4 Specifications.......................................................................................5-182
5.17 Packet Network Access Module
5.17.1 Scope....................................................................................................5-185
5.17.2 Functional Description.........................................................................5-186
5.17.3 Theory of Operation.............................................................................5-189
5.17.4 Specifications.......................................................................................5-192
5.18 DS3 ATM Network Access Module
5.18.1 Scope....................................................................................................5-195
5.18.2 Functional Description.........................................................................5-195
5.18.3 Theory of Operation.............................................................................5-199
5.18.4 Specifications.......................................................................................5-202
5.19 Ethernet Network Access Module
5.19.1 Scope....................................................................................................5-205
5.19.2 Functional Description.........................................................................5-205
5.19.3 Theory of Operation.............................................................................5-209
5.19.4 Redundancy..........................................................................................5-211
5.19.5 Specifications.......................................................................................5-213
5.20 Quad 1000BASE-T Ethernet Interface Module
5.20.1 Scope....................................................................................................5-215
5.20.2 Functional Description.........................................................................5-215
5.20.3 Theory of Operation.............................................................................5-218
5.20.4 Specifications.......................................................................................5-220

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
vi Telica, Inc.
5.21 Quad 1000BASE-SX Ethernet Interface Module
5.21.1 Scope....................................................................................................5-221
5.21.2 Functional Description.........................................................................5-221
5.21.3 Theory of Operation.............................................................................5-225
5.21.4 Specifications.......................................................................................5-227
6.1 Planning for Installation
6.1.1 Introduction..............................................................................................6-4
6.1.2 Location of Plexus 9000...........................................................................6-4
6.1.3 Building Requirements.............................................................................6-4
6.1.4 Chassis Dimensions .................................................................................6-6
6.1.5 Space Requirements.................................................................................6-7
6.1.6 Grounding Requirements .......................................................................6-10
6.1.7 Power Requirements ..............................................................................6-11
6.1.8 System Interfaces....................................................................................6-15
6.1.9 Slot Assignments....................................................................................6-24
6.1.10 Tools and Test Equipment......................................................................6-25
6.1.11 Installation Planning Task Checklist......................................................6-27
6.1.12 Plexus 9000 Configuration.....................................................................6-29
6.2 Planning for Provisioning
6.2.1 Introduction............................................................................................6-35
6.2.2 Plexus 9000............................................................................................6-35
6.2.3 Provisioning the Plexus 9000.................................................................6-37
6.2.4 Tables for Provisioning..........................................................................6-39

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. vii
7Interconnect Drawings
7.1 Scope........................................................................................................7-1
7.2 Overview..................................................................................................7-1
7.3 Power and Ground Cabling......................................................................7-2
7.4 Alarm Cabling..........................................................................................7-5
7.5 Ethernet Cabling of System Processors..................................................7-10
7.6 Craft/Modem Cabling ............................................................................7-12
7.7 DS-1, J1 and E1 Cabling........................................................................7-16
7.8 A-Link and DIAG Connectors ...............................................................7-20
7.9 DS-3/STS-1 Cabling ..............................................................................7-22
7.10 OC-3/12 or STM-1/4 Cabling................................................................7-24
7.11 Test Jacks ...............................................................................................7-26
8Part Information
8.1 Scope........................................................................................................8-1
8.2 Telica Part Number Formats ....................................................................8-1
8.3 Plexus 9000 Base System.........................................................................8-4
8.4 Parts Numbers..........................................................................................8-5
8.5 CLEI Codes............................................................................................8-15
9Technical Support
9.1 Installation Support..................................................................................9-1
9.2 Technical Support ....................................................................................9-1
9.3 Hardware Repair and Return....................................................................9-3
10 Acronyms

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
viii Telica, Inc.
Planning and Engineering Guide
Table of Contents
List of Figures
Figure 3-1. Rack-up of Three Plexus 9000s....................................................3-12
Figure 3-2. Plexus 9000, Front View..............................................................3-14
Figure 3-3. Plexus 9000, Rear View ...............................................................3-15
Figure 3-4. 85-3004 Plexus Chassis, Front View............................................3-16
Figure 3-5. 85-3004 Plexus Chassis, Rear View.............................................3-17
Figure 3-6. Protection and Midplane I ............................................................3-18
Figure 3-7. Protection and Midplane II and III................................................3-19
Figure 3-8. Plexus 9000 Chassis, Lower Rear View.......................................3-20
Figure 4-1. Monitor Jacks ...............................................................................4-11
Figure 5.1-1. Telica Plexus 9000 13-RU Chassis .............................................5-5
Figure 5.1-2. Telica Plexus 9000 14-RU Chassis .............................................5-6
Figure 5.1-3. Three rack-mounted chassis ........................................................5-7
Figure 5.1-4. Front Module locations................................................................5-8
Figure 5.1-5. Rear Module locations...............................................................5-10
Figure 5.1-6. Rear View of 85-3004/3007/3008 Chassis................................5-11
Figure 5.1-7. Protection for 85-3000 Chassis..................................................5-12
Figure 5.1-8. Protection for 85-3004/3007 Chassis ........................................5-13
Figure 5.1-9. Front Module Slot Labeling.......................................................5-14
Figure 5.1-10. LED and push button locations ...............................................5-15
Figure 5.1-11. Fan tray....................................................................................5-18
Figure 5.1-12. Fan Filter..................................................................................5-19
Figure 5.1-13. Cable management ..................................................................5-20
Figure 5.1-14. Power and Ground Locations for 85-3000/3004 Chassis........5-21
Figure 5.1-15. Power and Ground Locations on 85-3007 and
85-3008 Chassis ...................................................................................5-22
Figure 5.2-1. System Processor Timing Module.............................................5-27
Figure 5.2-2. Block Diagram of SP/TMG Module .........................................5-29
Figure 5.2-3. Monitor Jacks and the Front System Processor.........................5-31
Figure 5.2-4. Craft Connection to Terminal/PC or Modem for Remote
Connection ...........................................................................................5-34
Figure 5.3-1. Dual System Processor Timing Module....................................5-42
Figure 5.3-2. Block Diagram of Dual System Processor and Module............5-44
Figure 5.3-3. Monitor Jacks and the Front System Processor.........................5-46
Figure 5.3-4. Craft Connection to Terminal/PC or Modem for Remote
Connection ...........................................................................................5-49

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. ix
Figure 5.4-1. Dual System Processor Timing Module 3.................................5-55
Figure 5.4-2. Block Diagram of SP 3 Dual System Processor and Module....5-57
Figure 5.4-3. Monitor Jacks and the Front System Processor.........................5-59
Figure 5.4-4. Craft Connection to Terminal/PC or Modem for Remote
Connection ...........................................................................................5-62
Figure 5.6-1. System Processor Timing Rear Module....................................5-66
Figure 5.6-2. SP/TMG Rear Module Block Diagram .....................................5-69
Figure 5.6-3. Craft Connection to Terminal/PC or Modem for Remote
Connection ...........................................................................................5-71
Figure 5.6-4. Plexus 9000 Connected to a LAN Network ..............................5-71
Figure 5.6-5. Monitor Jacks ............................................................................5-73
Figure 5.6-6. Monitor Jacks, System Processor and IOM...............................5-74
Figure 5.7-1. 89-0417 System Processor 3 Rear Module................................5-78
Figure 5.7-2. 89-0417 SP3 Rear Module Block Diagram...............................5-81
Figure 5.7-3. Craft Connection to Terminal/PC or Modem for Remote
Connection ...........................................................................................5-83
Figure 5.7-4. Plexus 9000 Connected to a LAN Network ..............................5-84
Figure 5.7-5. Monitor Jacks ............................................................................5-85
Figure 5.7-6. Monitor Jacks, System Processor and IOM...............................5-86
Figure 5.9-1. Switch Fabric Module ...............................................................5-94
Figure 5.9-2. Block Diagram of the Switch Fabric Module............................5-96
Figure 5.12-1. Switch Fabric A Rear Module...............................................5-102
Figure 5.12-2. Switch Fabric B Rear Module...............................................5-103
Figure 5.12-3. Block Diagram of Rear Switch Fabric Module.....................5-107
Figure 5.11-1. DS-1 I/O front module...........................................................5-113
Figure 5.11-2. DS-1 IOM Block Diagram.....................................................5-115
Figure 5.11-3. DS1 Line Loopbacks (1.544 Mb/s) at the Near-end..............5-118
Figure 5.11-4. DS1 Line Loopbacks (1.544 Mb/s) at the Far-end ................5-118
Figure 5.11-5. DS1 Payload Loopbacks at the Near-end..............................5-119
Figure 5.11-6. DS1 Payload Loopbacks at the Far-end.................................5-119
Figure 5.12-1. Rear DS-1 IOM......................................................................5-125
Figure 5.12-2. Block Diagram of Rear DS1 IOM.........................................5-128
Figure 5.13-1. Front Triple DS-3/STS-1 IOM ..............................................5-135
Figure 5.13-2. Triple DS-3/STS-1 IOM Block Diagram ..............................5-137
Figure 5.13-3. DS-3 Near-end Loopback......................................................5-140
Figure 5.13-4. STS-1 Near-end Loopback....................................................5-140
Figure 5.14-1. Rear DS-3 IOM......................................................................5-145
Figure 5.14-2. Block Diagram of Rear DS-3 IOM........................................5-146
Figure 5.15-1. Front Octal DS-3/STS-1 IOM ...............................................5-151
Figure 5.15-2. Octal DS-3/STS-1 IOM Block Diagram................................5-153
Figure 5.15-3. DS-3 Near-end Loopback......................................................5-156
Figure 5.15-4. STS-1 Near-end Loopback....................................................5-156
Figure 5.16-1. RearDS3/STS-1 IOM ............................................................5-161
Figure 5.16-2. Rear Protection DS-3/STS-1 IOM.........................................5-162
Figure 5.16-3. Block Diagram of Rear Octal DS-3 IOM..............................5-163

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
x Telica, Inc.
Figure 5.17-1. Voice Server Module.............................................................5-169
Figure 5.17-2. Voice Server Module Block Diagram ...................................5-171
Figure 5.18-1. ATM Network Access Module..............................................5-177
Figure 5.18-2. Quad ATM Network Access Module Block Diagram...........5-179
Figure 5.17-1. Packet Network Access Module (P501-AA).........................5-187
Figure 5.17-2. Packet Network Access Module Block Diagram (P497-AA)5-189
Figure 5.20-1. Front Octal DS-3 ATM Network Access Module.................5-197
Figure 5.20-2. Octal DS-3 ATM Network Access Block Diagram...............5-199
Figure 5.21-1. Ethernet Network Access Module.........................................5-207
Figure 5.21-2. Ethernet Network Access Module Block Diagram................5-209
Figure 5.22-1. Rear Quad 1000BASE-T Ethernet Module...........................5-216
Figure 5.22-2. Quad 1000BASE-T Ethernet Interface Module
Block Diagram ...................................................................................5-218
Figure 5.23-1. Rear Quad 1000BASE-SX Ethernet Interface Module .........5-223
Figure 5.23-2. GBIC 1000BASE-SX Ethernet Interface Block Diagram.....5-225
Figure 6.1-1. Chassis (P107-AA).....................................................................6-6
Figure 6.1-2. Rack details (P104-AA)..............................................................6-8
Figure 6.1-3. Protection for 85-3000 Chassis (P413-AA)..............................6-24
Figure 6.1-4. Protection for 85-3003/3004 Chassis (P414-AA) ....................6-25
Figure 6.2-1. Plexus 9000 front view (P101-AA)..........................................6-36
Figure 7-1. Power and Ground Cabling ............................................................7-2
Figure 7-2. Bay Alarm Cable ............................................................................7-5
Figure 7-3. Bay Alarm Cabling.........................................................................7-6
Figure 7-4. Alarm Contacts Cable.....................................................................7-7
Figure 7-5. Alarm Contact Closure Cabling .....................................................7-9
Figure 7-6. Plexus 9000 Connected to Hub and LAN Network......................7-10
Figure 7-7. Ethernet Cabling for a Rack .........................................................7-11
Figure 7-8. Ethernet Cable ..............................................................................7-12
Figure 7-9. Cabling to Craft Port on Front SP/TMG ......................................7-13
Figure 7-10. Cabling to the Rear Craft Port Connector ..................................7-13
Figure 7-11. DB-9 to DB-25 Craft Modem Cable Pinouts .............................7-14
Figure 7-12. DB-9 to DB-9 Craft Terminal (Null Modem) Cable Pinouts.....7-14
Figure 7-13. DB-9 to DB-25 Craft Terminal (Null Modem) Cable Pinouts...7-14
Figure 7-14. Plexus 9000 Connected to Hub and LAN Network....................7-15
Figure 7-15. Ethernet Crossover Cable...........................................................7-15
Figure 7-16. Rear DS1 IOM............................................................................7-16
Figure 7-17. 64-pin AMP-style Cable – Connector to Wire-wrap..................7-19
Figure 7-18. 64-pin AMP-style Cable – Connector to Connector...................7-19
Figure 7-19. Cabling of IOMs.........................................................................7-20
Figure 7-20. DB-15 A-Link Connector...........................................................7-21
Figure 7-21. DB-9 DIAG connector................................................................7-21
Figure 7-22. Triple DS3 IOM..........................................................................7-22
Figure 7-23. Octal DS3/STS-1 IOM ...............................................................7-22
Figure 7-24. Triple DS3 Cable, Part Number 44-3XXX ................................7-23
Figure 7-25. Octal DS3 Cable, Part Number 44-8XXX..................................7-23

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. xi
Figure 7-26. Optical Connectors.....................................................................7-24
Figure 7-27. Single Mode Fiber Optic Cable with Duplex SC Connectors....7-25
Figure 7-28. Monitor Jacks .............................................................................7-26
Figure 7-29. Monitor Jacks, System Processor and IOM................................7-27
List of Tables
Table 2-A. Plexus 9000 Manuals and Part Numbers ........................................2-4
Table 4-A. Chassis Slots ...................................................................................4-1
Table 4-B. Dimensions......................................................................................4-2
Table 4-C. Environmental Specifications .........................................................4-2
Table 4-D. Plexus 9000 POWER SPECIFICATIONS.....................................4-3
Table 4-E. IOMs, Framing and Line Codes......................................................4-4
Table 4-F. DS1 Specifications ..........................................................................4-5
Table 4-G. J1 SPECIFICATIONS ....................................................................4-6
Table 4-H. E1 SPECIFICATIONS....................................................................4-7
Table 4-I. DS3 Specifications ...........................................................................4-8
Table 4-J. STS-1 Specifications........................................................................4-8
Table 4-K. OC-3 / STM-1 Mb/s Optical Signal Transmission Specifications..4-9
Table 4-L. OC-12 / STM-4 Mb/s Optical Signal Transmission Specifications 4-9
Table 4-M.Optical Signal Specifications for GBIC Single-Mode ENA..........4-10
Table 4-N. Optical Signal Specifications for GBIC Multi-Mode ENA..........4-10
Table 4-O. Wire Sizes For Home Run............................................................4-14
Table 4-P. Wire Sizes To Power And Alarm Panel........................................4-14
Table 4-Q. Relay Contact Closure Ratings .....................................................4-15
Table 5.1-A. Slot Numbers and Names...........................................................5-13
Table 5.1-B. Functions of Pushbuttons...........................................................5-14
Table 5.1-C. Chassis Leds...............................................................................5-15
Table 5.1-D. Environmental Specifications....................................................5-22
Table 5.1-E. Mechanical Specifications..........................................................5-23
Table 5.1-F. Plexus 9000 Power Specifications..............................................5-23
Table 5.2-A. LEDs of the System Processor...................................................5-28
Table 5.2-B. Ethernet Connector.....................................................................5-28
Table 5.2-C. Craft Connector..........................................................................5-28
Table 5.2-D. Reset Button...............................................................................5-28
Table 5.2-E. Plexus 9000 Access Levels ........................................................5-33
Table 5.2-F. Craft Terminal Parameters..........................................................5-35
Table 5.2-G. Environmental Specifications....................................................5-36
Table 5.2-H. RS-232 Craft Port Specifications...............................................5-37
Table 5.3-A. Dual System Processor (89-0389) and Switch Fabric Modules.5-40
Table 5.3-B. LEDs of the SP/TMG.................................................................5-43
Table 5.3-C. Ethernet Connector.....................................................................5-43

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
xii Telica, Inc.
Table 5.3-D. Craft Connector..........................................................................5-43
Table 5.3-E. Plexus 9000 Access Levels ........................................................5-48
Table 5.3-F. Craft Terminal Parameters..........................................................5-49
Table 5.3-G. Environmental Specifications....................................................5-51
Table 5.3-H. RS-232 Craft Port Specifications...............................................5-52
Table 5.4-A. LEDs of the SP/TMG.................................................................5-56
Table 5.4-B. Ethernet Connector.....................................................................5-56
Table 5.4-C. Craft Connector..........................................................................5-56
Table 5.4-D. Plexus 9000 Access Levels........................................................5-61
Table 5.4-E. Craft Terminal Parameters .........................................................5-63
Table 5.4-F. Environmental Specifications.....................................................5-64
Table 5.4-G. RS-232 Craft Port Specifications...............................................5-65
Table 5.5-A. LEDs of the Compute Module...................................................5-69
Table 5.5-B. Environmental Specifications ....................................................5-74
Table 5.6-A. Craft Connector..........................................................................5-78
Table 5.6-B. Ethernet Connector.....................................................................5-78
Table 5.6-C. DS1 Test Jacks, J7, J8, J9 AND J10..........................................5-78
Table 5.6-D. Plexus 9000 Access Levels........................................................5-82
Table 5.6-E. Environmental Specifications.....................................................5-85
Table 5.6-F. RS-232 Craft Port Specifications ...............................................5-86
Table 5.7-A. CRAFT and COM Connector........................................................5-90
Table 5.7-B. ENET Connectors.........................................................................5-90
Table 5.7-C. DS1 Test Connectors ....................................................................5-90
Table 5.7-D. Plexus 9000 Access Levels........................................................5-97
Table 5.7-E. Environmental Specifications.....................................................5-98
Table 5.7-F. RS-232 Craft Port Specifications ...............................................5-99
Table 5.8-A. Typical Ethernet Connectors....................................................5-106
Table 5.8-B. Environmental Specifications ..................................................5-109
Table 5.9-A. Functions and Limitations of the Switch Fabric Module.........5-113
Table 5.9-B. SW/FAB LED Indicators .........................................................5-115
Table 5.9-C. Environmental Specifications ..................................................5-119
Table 5.10-A. Bay Alarm Out Connector .....................................................5-124
Table 5.10-B. BITS Timing Connector.........................................................5-124
Table 5.10-C. Bay Alarm In Connector ........................................................5-124
Table 5.10-D. Alarm Contacts Connector.....................................................5-125
Table 5.10-E. BITS Timing Connector.........................................................5-126
Table 5.10-F. Alarm Contacts Connector .....................................................5-129
Table 5.10-G. Environmental Specifications................................................5-130
Table 5.11-A. LEDs of Front I/O Module.....................................................5-134
Table 5.11-B. DS-1 Specifications................................................................5-140
Table 5.11-C. Environmental Specifications ................................................5-141
Table 5.12-A. Pins and Wires 64-pin In and Out Cables..............................5-146
Table 5.12-B. DS1 Specifications.................................................................5-150
Table 5.12-C. Environmental Specifications ................................................5-151
Table 5.13-A. LEDs of Front Module...........................................................5-156

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. xiii
Table 5.13-B. Environmental Specifications ................................................5-161
Table 5.13-C. DS-3 Specifications................................................................5-162
Table 5.13-D. STS-1 Specifications..............................................................5-162
Table 5.14-A. DS-3 Specifications ...............................................................5-167
Table 5.14-B. STS-1 Specifications..............................................................5-167
Table 5.14-C. Environmental Specifications ................................................5-168
Table 5.15-A. LEDs of Front IOM................................................................5-172
Table 5.15-B. DS-3 Specifications................................................................5-177
Table 5.15-C. STS-1 Specifications..............................................................5-177
Table 5.15-D. Environmental Specifications................................................5-178
Table 5.16-A. DS-3 Specifications ...............................................................5-184
Table 5.16-B. STS-1 Specifications..............................................................5-184
Table 5.16-C. Environmental Specifications ................................................5-185
Table 5.17-A. LEDs of Voice Server Module...............................................5-190
Table 5.17-B. Environmental Specifications ................................................5-194
Table 5.18-A. LEDs of Network Access Module .........................................5-198
Table 5.18-B. Environmental Specifications ................................................5-202
Table 5.18-C. OC-12 / STM-4 Mb/s Optical Signal Transmission
Specifications.....................................................................................5-203
Table 5.18-D. OC-3 / STM-1 Mb/s Optical Signal Transmission
Specifications.....................................................................................5-203
Table 5.19-A. Packet Network Access Module LEDs..................................5-208
Table 5.19-B. Environmental Specifications ................................................5-212
Table 5.19-C. OC-3 / STM-1 Mb/s Optical Signal Transmission
Specifications.....................................................................................5-213
Table 5.19-D. OC-12 / STM-4 Mb/s Optical Signal Transmission
Specifications.....................................................................................5-213
Table 5.23-A. LEDs of Front IOM................................................................5-218
Table 5.23-B. DS-3 Specifications................................................................5-222
Table 5.23-C. Environmental Specifications ................................................5-223
Table 5.21-A. LEDs of ENET Module .........................................................5-228
Table 5.21-B. Environmental Specifications ................................................5-233
Table 5.22-A. LEDs of Ethernet Ports..........................................................5-237
Table 5.22-B. 1000BASE-T Connector........................................................5-237
Table 5.22-C. Environmental Specifications ................................................5-240
Table 5.23-A. LEDs of GBIC Ethernet Ports................................................5-244
Table 5.23-B. Environmental Specifications ................................................5-247
Table 5.23-C. Single-Mode Optical Signal Transmission Specifications.....5-248
Table 5.23-D. Multi-Mode Optical Signal Transmission Specifications......5-248
Table 6.1-A. Environmental Specifications......................................................6-5
Table 6.1-B. Chassis Dimensions .....................................................................6-6
Table 6.1-C. Rack and Hardware......................................................................6-7
Table 6.1-D. Space Requirements.....................................................................6-9
Table 6.1-E. Auxiliary Equipment....................................................................6-9
Table 6.1-F. Plexus 9000 Power Specifications..............................................6-11

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
xiv Telica, Inc.
Table 6.1-G. Wire Sizes To Power And Alarm Panel ....................................6-12
Table 6.1-H. Power and Alarm Panel Power Connections .............................6-12
Table 6.1-I. Plexus 9000 Power Connections .................................................6-13
Table 6.1-J. Wire Sizes For Home Run ..........................................................6-14
Table 6.1-K. DS-1 Cables ...............................................................................6-16
Table 6.1-L. DS-3/STS-1 Cables ....................................................................6-17
Table 6.1-M. BITS Timing Connector............................................................6-19
Table 6.1-N. Required AlarmCables...............................................................6-19
Table 6.1-O. Alarm Contacts Connector.........................................................6-20
Table 6.1-P. Bay Alarm Out Connector..........................................................6-21
Table 6.1-Q. Craft Connector..........................................................................6-22
Table 6.1-R. Required Miscellaneous Cables.................................................6-22
Table 6.1-S. Ethernet Connector.....................................................................6-23
Table 6.1-T. Tools Required for Installation...................................................6-26
Table 6.1-U. Installation Planning Task Checklist..........................................6-27
Table 6.1-V. Plexus 9000 Base System ..........................................................6-30
Table 6.1-W. AUXILIARY EQUIPMENT.....................................................6-30
Table 6.1-X. Plexus 9000 Module Part Numbers ...........................................6-31
Table 6.1-Y. Plexus 9000 Spares (Not Modules)............................................6-32
Table 6.1-Z. Required Miscellaneous Cables .................................................6-33
Table 6.1-AA. Configuration Worksheet........................................................6-34
Table 6.2-A. Configuration Worksheet...........................................................6-40
Table 6.2-B. Plexus 9000 Access Levels........................................................6-41
Table 6.2-C. Chassis Provisioning..................................................................6-41
Table 6.2-D. Timing Provisioning ..................................................................6-41
Table 6.2-E. Security Provisioning .................................................................6-42
Table 6.2-F. IOM Provisioning.......................................................................6-43
Table 6.2-G. Point Codes and Signaling Provisioning....................................6-43
Table 6.2-H. Trunk Group Provisioning.........................................................6-44
Table 6.2-I. Routing Provisioning...................................................................6-44
Table 6.2-J. Numbering and Carrier Provisioning..........................................6-44
Table 6.2-K. Subscriber Provisioning.............................................................6-45
Table 7-A. Wire Sizes To Power And Alarm Panel .........................................7-3
Table 7-B. Wire Sizes For Home Run ..............................................................7-4
Table 7-C. BAY ALARM IN CONNECTOR ..................................................7-5
Table 7-D. Bay Alarm Out Connector ..............................................................7-6
Table 7-E. Alarm Contacts Connector..............................................................7-8
Table 7-F. Ethernet Connector........................................................................7-12
Table 7-G. Pins and Wires 64-pin In and Out Cables.....................................7-17
Table 8-A. “A” Field of Cables.........................................................................8-3
Table 8-B. “Y” Field of Cables.........................................................................8-3
Table 8-C. Plexus 9000 Base System................................................................8-4
Table 8-D. Documentation................................................................................8-5
Table 8-E. Software Version and Support of Modules .....................................8-6
Table 8-F. Chassis and Modules......................................................................8-8

Plexus Planning and Engineering Guide Table of Contents
Section 130-050-100 Issue 4, June 4, 2004
Telica, Inc. xv
Table 8-G. Switch Fabric and System Processor ............................................8-11
Table 8-H. Module Part Numbers...................................................................8-11
Table 8-I. System and Ancillary Parts Numbers.............................................8-13
Table 8-J. Cable Part Numbers .......................................................................8-14
Table 8-K. CLEI Codes...................................................................................8-15

Table of Contents Plexus 9000 Planning and Engineering Guide
Issue 4, June 4, 2004 Section 130-050-100
xvi Telica, Inc.
NOTES: