Bravo SearMagic Quick guide

FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open Lid.
4. If odor continues, immediately
call your gas supplier or your fire
department.
FOR YOUR SAFETY
1. Do not store or use gasoline or
other flammable vapors and liq-
uids in the vicinity of this or any
other appliance.
2. An LP cylinder not connected for
use shall not be stored in the vi-
cinity of this or any other appli-
ance.
FOR YOUR SAFETY
Follow all leak-test procedures care-
fully in this manual before using. Do
this even if the grill was dealer as-
sembled. Do not try to light this ap-
pliance without reading the
“Lighting” instructions in this manu-
al.
“California Proposition 65 Warning”
Chemicals known to the State of Cal-
ifornia to cause cancer and birth de-
fects or other reproductive harm are
created by the combustion of pro-
pane, charcoal, wood products or
natural gas used with this grill and
in the preparation of grilled foods.
Assembly and Maintenance Instructions
THIS GAS APPLIANCE IS
DESIGNED FOR OUTDOOR
USE ONLY.
YOU MUST READ THIS OWNERS MANUAL
BEFORE OPERATING YOUR GAS GRILL.
THESE INSTRUCTIONS SHOULD BE LEFT
WITH THE CUSTOMER. KEEP THESE IN-
STRUCTIONS FOR FUTURE REFERENCE.
Infrared Side Grill
Pros of SearMagic
Infrared Side Grill
 Uniform Heating Surface
 High Temperature Option
 Energy Efficiency
 Extremely Hot, Sealing in
Meat Juices
 Tasty and Juicy Food

Congratulations on your purchase of Bravo SearMagic Infrared Side Grill, providing your Kamado Grill with greater versatili-
ty. This unique searing system gets hot extremely fast sealing in meat juices quickly without drying out. Meat juices will be
sealed inside keeping the chicken, steak or another cut of meat juicy and tender. The high intense heat reduces flare-ups
by vaporizing juices instantly. Also, the fast heat-up and faster cooking, makes your Bravo SearMagic Infrared Side Grill
more energy efficient.
Getting to Know Your SearMagic Infrared Side Grill and Assembly
COVER
DRIP PAN
ELECTRONIC
IGNITOR BURNER
CONTROL
SearMagic
COOKING GRID
INFRARED BURNER IGNITOR
ELECTRODE
 Remove the left shelf & shelf mounting
hardware from the kamado grill by re-
moving the 4 acorn nuts that hold it to
the band while facing the grill.
 Install BRAVOSEAR re-using the 4
acorn nuts removed in step 1 shown in
figure 1.
 Level Bravo SearMagic Side Grill by
turning lower cap screws as shown in
figure 2.
(Fig. 2)
(Fig. 1)

Installing Portable LP Bottle
IMPORTANT: Be Sure the burner
control is “OFF” before attaching the
propane bottle.
SearMagic Infrared Side Grill Cover
When burner is in
use, remove lid and
hang on the left
side of the unit.
Infrared Burner Lighting Instructions
1. Always remove the cover before lighting.
2. Keep your head and body at least 1 foot away when
lighting the burner. Do not lean over an open burner.
3. Turn the burner on the “HIGH” position, and depress the
electronic ignitor until the burner lights.
4. If the burner fails to light, turn control knob “OFF”, wait 5
minutes for gas to clear and try lighting again.
5. If the ignitor doesn’t spark, check the gap between the
wire probe burner screen. It should be approximately
3/16 inches wide. If it is too small, the spark may be inef-
ficient. Gently readjust the wire probe as needed. If the
gap is normal, check the wire connections at the spark
module and ignitor probes, located underneath the con-
trol panel.
6. If the ignitor still doesn’t work, try replacing the battery.
Remove the collar around the ignitor button by turning it
counter-clockwise. Replace the AAA battery, “+” side
down. Fig. 5
7. In the unlikely event these previous measures don’t
work, you can light the burner manually. Turn the burner
control knob to “OFF”. Remove the cooking grid from
above the burner and ignite a match. Place the match
directly on the burner screen, remove your hand from
above the burner and turn the burner control knob on
“HIGH”. Once the burner is lit, you can replace the cook-
ing grid.
Fig. 5
Push
Button
Spring
AAA Battery
+Electronic
Ignitor
Infrared Care and Maintenance
1. After each use, remove the cover and light the burner on
“HIGH” and burner for 5 minutes. This will burn off any food
drippings and enhance the burner performance and increase
the burner longevity.
2. Never use water or liquid chemicals to clean the ceramic burn-
er. Burner may be damaged. Burner failure caused by im-
proper care and maintenance is not covered under war-
ranty.
3. If the burner develops ash over the surface, clean it gently with
a vacuum cleaner. Use a brush attachment so as not to dam-
age the burner.
4. If the burner should get wet, it is important to dry it out com-
pletely before attempting to use the burner. IMPORTANT:
Replace Cover When Burner Is Not In Use.
5. Never let anything heavy, hard or sharp fall onto the burner.
The ceramic is very fragile and can easily be damaged.
*Portable LP bottle not included
Connecting LP Bottle
Use propane bottle with capacity of 14.1 oz.
1. Make sure the burner control valve is in the off position before
attaching propane bottle.
2. Attach the propane bottle to the infrared side grill by pushing the
bottle slightly while turning clockwise into the regulator. Turn
until a snug fit is obtained.
Check For Gas Leaks
1. Check the connection between the tank and the regulator for gas
leaks. Mix a couple of tablespoons of liquid detergent with an
equal amount of water.
2. Be sure to leave the control valve in the off position. Wet the con-
nection with the soap solution and watch for bubbles. If bubbles
form or if a bubble grows, there is a leak.
3. If there is a leak, check the fitting, make sure it is tight, recheck
connection for leaks.
4. Check for gas leaks each time you disconnect or connect the gas
supply.

Infrared Cooking Tips.
1. Infrared burners get very hot. Do not leave food unattended on the grill for any length of time.
2. Estimate cooking times to be 30% to 50% less than a conventional grill.
3. Always thaw food thoroughly before cooking to achieve better, more predictable results.
4. Always use long handled grill tools for grilling. A grilling mitt may be useful for handling hot items.
5. The use of a fork is not recommended for grilling on your new SearMagic Infrared Side Grill. A fork may mar the surface of the
cooking grid. Piercing foods while cooking will allow the juices to escape, causing the finished product to be drier than may be
desired.
6. To minimize flare-up, trim fat from meats or remove skin from poultry.
7. If a flare-up occurs, don’t try to control it with water. Water can cause burner damage. Instead, move the food to another part of
the cooking grid, lower the heat setting or remove the food. Burner Failure Caused By Water Damage Is Not Covered Under
Warranty.
8. Allow the burner to heat up for 5 minutes on “HIGH” before cooking.
9. Place the food on the SearMagic cooking grid while the grill is on “HIGH” to sear the food thoroughly. Searing is the key to locking
in the juices for that delicious grilled flavor.
10. After searing for 2-3 minutes per side, lower the temperature to finish cooking the food as desired.
11. The SearMagic cooking grid allow for greater versatility when grilling. Chicken breasts, steaks, pork chops or hamburgers can be
seared over the ribbed side at a higher temperature. Delicate foods like seafood and vegetables can cooked over a lower temper-
ature with the smooth side up.
12. To clean the SearMagic Infrared Zone after cooking, burn at “HIGH” for at least 5 minutes. With the grill still on “HIGH”, clean the
cooking grid with a long-handled brass bristle brush. Regular cleaning will ensure optimum performance of your SearMagic Infra-
red Side Grill.
WARRANTY
LIFETIME WARRANTY: SearMagic Cooking Grid
10-Year Warranty: Stainless Steel Enclosure and Cover
5-Year Warranty: Infrared Burner
1-Year Warranty: Ignitor System • Gas Valve
WHAT IS NOT COVERED:
 Transportation and shipping costs.
 Labor for replacement or repairs.
 Damage from accident, misuse, alteration, abuse, improper installation or storage.
 Removal and reinstallation cost.
 Finishes on surfaces that are damaged by improper installation, improper storage, accident, misuse, abuse or alteration.
 Inoperable due to improper installation or storage.
 The costs of a service call to diagnose a problem.
 All warranties are non-transferable and apply only to the original purchaser.
There is a 1 year warranty on all parts if grills are put into commercial, multi-unit or community use.
This warranty does not imply or assume any responsibility for consequential damages that might result from
use, misuse, or improper installation of this cooking appliance. This warranty does not cover claims which do
not involve defective workmanship or materials. A bill of sale, cancelled check, or payment record should be
kept to verify purchase date and establish warranty period.
5565 N. 124th St. • Butler, WI 53007
Phone: [phone] • 800.781.4657
Fax: [phone]
Email: [e-mail]
Web Site: www.bravokamadogrills.com
Other Quality Products From Modern Home Products
©2012 Modern Home Products Corp. MHP configuration, SearMagic, ProFire Grills are registered trademarks of Modern Home Products Corp.
Because of constant product improvement, ProFire Grills reserves the right to change specifications without notice. 6/16