Coolster CHALLENGER GK-6125A 2018 User manual
www.coolster.com
OWNER’S MANUAL
CHALLENGER
GK-6125A
P1P1
Safety Foreword......................................................................
Pre-Ride Checklist...................................................................
Safe Riding Guidelines.............................................................
Safety Alerts............................................................................
Warning Signs..........................................................................
......................................................
Regular Maintenance and Minor Repairs................................
..............................
........................................
..........................
TABLE OF CONTENTS
P2
P3
P4
P7
P8
P9
P10
P11
P14
P17
P20
P29
P33
P36
P41
P42
P43
P2
Thank you for choosing Coolster Vehicles, courtesy of MAX-
TRADE LLC.
-
training purposes, please call ASI at 800-887-2887. We also have
Thank you once again for choosing Coolster products. We wish
P2
SAFETY FOREWORD
P3P3
have/understand the following:
- Proper safety googles,
-
sion.
around you when you ride.
PRE-RIDE CHECKLIST
P4
SAFE RIDING GUIDELINES
turning or driving on hills or obstacles.
Please read the following safe riding guidelines thoroughly, as doing
-
ing procedures as described.
-
riders to operate without the right guidance.
3. Individuals below 16 years old CAN NOT drive this vehicle.
4. This vehicle is designed to carry the driver and one passenger
5. It is illegal to drive this vehicle on paved roads, including side-
walks, public streets, highway/freeways, parking lots, and even paved
, ,
gloves, boots, long-sleeved shirts and long sleeve pants.
8. Never operate at unsafe speeds. Always travel at a speed that is
experience.
P4
P5
10. Always inspect the vehicle
the steering wheel when driving.
13. Never operate on excessively rough, slippery, or loose terrain.
14. When turning, always follow proper procedures as described in
15. Never operate on hills too steep for
16. Always follow proper procedures for ascending and braking on
17. Always follow proper procedures for descending and braking on
terrain before going downhill, and keep center of gravity backwards.
Do not go at high speeds downhill and avoid turning when descending
Go-Kart
hill where possible.
P5
P6P6
18. Always follow proper procedures for crossing the side of hills
Avoid hills wiht slippery or
19.
reverse, follow the special procedures for braking as described in this
21. Be careful of skidding or sliding. Learn to control braking to
-
23. When reversing, please ensure that there are not obstacles or
turns.
of accessories.
26. Do not overload the load capacity.
27. Do not touch the vent pipe as this can cause severe burns.
P7
SAFETY ALERTS
WARNING
page.
1. When approaching corners or turning, reduce speed. You can
riding.
4. Please dry the oil inside the carburetor and the oil tank
！DANGER
！NOTICE
！
CAUTION
！WARNING
-
P7
P8
DESCRIPTION
Spare tire
Seat
Steering wheel
Windshield
Kill switch
(1) (2) (3) (4) (5)
(6)
(7)
(8) (9) (10)
(11) (12)
(13) (14) (15) (16)
(17)
(18) (19)
P9
⑤
⑥
⑦
⑧
①
②
③
④
⑨
WARNING SIGNS
The warning signs with the word "WARNING" indicate the
P10
12
VEHICLE RECOGNITION
1. See left picture
2. See right picture
Please use the pictures located below for reference.
P11
1.
CONTROL FUNTIONS
All circuits disconnected Pull out
Not pull out
2. Kill switch
This is the whistle button，When the vehicles
or pedestrians need to whistle when clicking.
3. Head light switch
Locaon Funcon
P12
5. The Fuel Cover
1
2
4. Front & Rear Brake Pedal
The front & rear brake pedal is the
rear brakes. Using this pedal will
should be securely fastened to
avoid gas leakage.
6. The Fuel Valve
fuel tank to the carburetor. The fuel valve
When the engine is not running, always
-
for the engine to run.
P13
7. Start
The green light shows that "N" is neutral. The
red light shows "R" for reverse gear and red "1",
-
N
RD
(3 2 1)
To use the electric start, step on the brake pedal, then press the
start switch.
8.
P14P14
PRE-RIDE INSPECTION CHECK
Prior to the use of this vehicle, please check the following:
Noral checks
Brake
accelerator
C
Check to see whether the accelerator operates
Chain - driven
-
necessary.
necessary.
necessary. Make sure there is no looseness.
-
Make sure the fuel tank has enough fuel before
riding. Ensure that there are no leaks.
should be added.
Tire / wheel
Steering
Parts / Fasteners
Fuel tank
P15
1 2
The reserve tank on the rear is for
AETHESTIC PURPOSES ONLY. No fuel or
fluids of any kind should be filled inside
of this tank. There is no ventilation on
Reserve oil tank total capacity: 10L
Fuel Check
Warning:
Fuel tank capacity:
Total: 4L
Oil Check
See left
picture
1.
2.
Tire Check
1. Tire pressure
Warning:
Recoended oil
-20°-10°0°10° 20°30°C
SAE 20W40 SF Engine oil
SAE 10W30 SF Engine oil
SAE 5W30 SF Engine oil
Oil:
Total: 0.9 L
Regular replaceent of oil: 0.8 L
Oil Filters replaceent: Does deforaon, daage.
P16
Spare tire
18×7.00-8
18×7.00-8
18×7.00-8
Pressure
10~24 psi
10~24 psi
10~24 psi
P17
OPERATION AND RIDING RULES
Cold Start and engine preheang
5. Press the start switch.
P18
Brake
obstacles, pedestrians, or other vehicles. Braking is broken into
-
gency brake.
The parking brake is only enabled when the vehicle has been
parked and if the riders are leaving it. Never have it enabled when
-
be caused by regular braking. When braking, exercise extra cau-
1
Hand brake
2
1. When the car is running, always ensure hand brake is released.
2.
Table of contents
