Govaplast Play Podium 1,2,3 User manual

Govaerts Recycling NV | Kolmenstraat 1324 | B-3570 Alken | [email protected] | www.govaplast.com 1
+/- 78 kg
60
178
52
User manual GP42
“Podium 1,2,3”
( version 2015-01)
Latest version can always be found at www.govaplay.com
According to EN1176, this podium is not considered as being a play equipment.
Therefore, a TÜV-certificate is not required.
Material
ŸSolid posts and planks made of recycled plastic (PE), coloured
throughout.
ŸStainless steel screws and nail plugs
ŸVirgin PE sheets (19 mm), UV-resistant
Mounting
The Podium is delivered fully assembled.
Maintenance
Maintenance of the recycled plastic material is very limited.
Cleaning with a soapy water and a sponge or soft brush. Rinse with
water to remove all dirt and soap. As the water absorption of the
material is less than 0,29%, it will not get stained by oil, grease and
other products. Besides, mosses and algae will have difficult to
adhere to the material and are very easy to remove.
Cleaning with high-pressure (max. 100 bar) is possible but is not
recommended and mostly not needed. If anyway, then spray with a
fan-shaped jet at minimum 30 cm from the plastic surface.
Painting or staining is useless as the paint will not stick attach to
the material.

4 x
Govaerts Recycling NV | Kolmenstraat 1324 | B-3570 Alken | [email protected] | www.govaplast.com
2
Anchorage
Can be done as follows:
ŸPosition the Podium on its exact place
ŸMark the perimeter of the Podium
ŸFix the 4 plastic blocs onto the surface using the nail plugs in the way that the Podium just fits over
these blocs.
ŸPut the Podium over the blocs
ŸDrill the holes (4 mm drill bit) for the screws into the Podium and fix the screws.
Important suggestion
To drill the holes in the ground, use a sharp drill and just put the plastic plug into the hole. It is better to screw the nail into the plug than to hammer. This
way, you don't damage the head of the nail and unfixing will be easy.
Installation
The Podium is delivered fully assembled. Anchorage on a hard surface is easy using the plastic blocs and nail plugs. When supervision of the
playground is assured it is not necessarily required to anchor the Podium.
This equipment is not suited to be installed on a loose underground (e.g. sand, bark, woodchips, …).
No need for safety zone and safety surface
As this product is being considered as furniture there is no need to respect a safety zone. A safety surface is also not requested.