grow 'n up SAMSON Series User manual

SAMSON SERIES – SPORTS CENTER SILVER
ASSEMBLY INSTRUCTIONS
CUSTOMER SUPPORT
USA and Canada: 1-888-GNU-9898
Email: serv[email protected]m
Other countries: suppor[email protected]
www.grow-n-up.com
Ages: 3 - 10
No. 8019
SPORTS CENTER SILVER
SAMSON SERIES
MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
1
©2006 Grow’n Up Limited. All Rights Reserved. Tsim Sha Tsui East, Kowloon, Hong Kong. MADE IN CHINA
Product may vary from the illustration.
CAUTION: Choking Hazard - Small parts and sharp points.
Assembly must be conducted by adult only.
Keep unassembled screws, small parts and plastic bags out of children's reach. Contains sharp points, care should be taken
when unpacking and assembling this product. Adult assembly required.
DO NOT DISCARD: IMPORTANT LITERATURE. PLEASE READ & FOLLOW INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLY AND USE OF THIS PLAYGROUND EQUIPMENT. THEY CONTAIN IMPORTANT
INFORMATION FOR USER SAFETY AND FOR THE PROPER USE AND MAINTENANCE OF THIS PLAYGROUND
EQUIPMENT. OBSERVE ALL WARNINGS AND STATEMENTS REDUCES THE RISK OF SERIOUS OR FATAL
INJURY. PLEASE KEEP THIS INSTRUCTION FOR FUTURE REFERENCE OR FOR ORDERING SPARE PARTS.
!
WARNING
!
Please follow all these Safety,
Maintenance and Assembly
Instructions. Failure to do so could
result in serious or fatal injury.

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER
To ensure that you and your children get the safest and most enjoyable use of your purchase,
please follow all these Safety, Maintenance, and Assembly Instructions.
This product is designed for normal residential use only, and is not intended for use in schools,
parks, day care centers, nurseries, or other public places.
This playground equipment is designed for use by
It is not designed for adults or for children weighing more than
45 kg (99 Ibs) per each individual ride. The maximum number of users for this unit is six (6)
children, and the total maximum weight at any one time must not exceed 270 kg (594 Ibs).
This playground equipment conforms to ASTM F1148, Consumer Safety Performance
Specification for Home Playground Equipment, when assembled in accordance to these
Assembly Instructions.
In an effort to continually improve our products, the final setup product may vary from the
illustrations shown in these instructions.
children ages 3 to 10 years old, under
adult supervision at all times.
Safety Instructions ……………………………………………………………………… pa
Maintenance Instructions ………………………………………………………………
Customer Service and Warranty..……………..…………………………………
Assembly Instructions
Parts list…………………..…………………………………….…………….…
Hardware pictures…………………………………………….…………….…
A-Frame assembly (step 1 – 8)..…………………………….…………….…
Climbing frame assembly (step 9 – 13) …..……………….…………….…
Rock climber assembly (step 14 – 15).....………………….…………….…
TABLE OF CONTENTS
IMPORTANTS
ge
page
…… page
page
page
page
page
page
Slide assembly (step 16 – 18)......…………………………………………… page
Trapeze/Swing seat assembly (step 19)…………….………………...…… page
Ground Anchors (step 20 – 22) ……….………………………………..…… page
Final Inspection and Testing..……………………………………………………….… page
3-4
5
6
49
12-14
23-32
33-40
45-48
15-22
50-51
52
41-44
www.grow-n-up.com
2
•
•
•
•
•
WARNING !
!
Please follow all these Safety, Maintenance and Assembly Instructions.
Failure to do so could result in serious or fatal injury.

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
3
SAFETY INSTRUCTIONS
IMPORTANT SAFETY INFORMATION: PLEASE OBSERVE! READ THE FOLLOWING
STATEMENTS AND WARNINGS TO AVOID SERIOUS OR FATAL INJURY.
 Before assembly, read and follow these step by step assembly instructions and warnings thoroughly. Failure to do
so could result in serious injury or property damage. DO NOT attempt to assemble this playground equipment
without following the instructions carefully.
 Only adults should assemble or disassemble this playground equipment, contains sharp points and small parts
which are necessary for assembly. Prior to and during assembly of this product, keep all components out of
children’s reach. Small parts pose a choke hazard to children under 3 years.
 On-site adult supervision is required for children of all ages at all times when on or around this playground
equipment. Never leave children unattended.
 The intended age for use of this product is 3 to 10 years old, under adult supervision at all times. Children under 3
years have a higher risk of entrapment, injury or fall.
 Place this playground equipment on level ground not less than 6 feet (1.8 m) away from any structures or
obstructions such as trees, fences, garages, houses, sheds, hedges, overhanging branches, laundry lines or
electrical wires.
 DO NOT install this playground equipment indoors, or over concrete, asphalt, packed earth, grass, carpet, or any
other hard or abrasive surfaces. A fall onto a hard surface can result to serious or fatal injury.
 THIS PRODUCT MUST BE ANCHORED FIRMLY TO SOLID GROUND. Detailed instructions on how anchoring
is to be accomplished below the level of the playing surface or below ground surface to prevent tipping or injury
resulting from a fall. (See page 7, TABLE-1 and page 50 - 52)
 DO NOT allow children to play on the playground equipment unit until it is completely installed and properly
anchored. Serious or fatal injury could occur.
 DO NOT let children use this equipment in any manner other than intended.
 DO NOT allow children to climb on or swing from structural members (top bars, legs, side bars) of the playground
equipment. These are structural components ONLY and NOT play features.
 DO NOT exceed the intended weight limit or maximum number of users for the playground equipment. Designed
to be used safely by up to six (6) children, with a maximum weight of 45 kg (99 lbs) each, simultaneously, not to
exceed a combined weight of 270 kg (594 lbs).
 Limit the number of users to one (1) on each single play.
 DO NOT allow children to stand, walk close to, behind, in front of, or between moving plays. Instruct children to
keep a safe distance away from moving plays to avoid being hit by items in play.
 Dress children appropriately while on and around this playground equipment. Use well-fitting shoes that do not
have slippery soles. DO NOT allow children to wear ponchos, scarves, hoods, jewelry, loose shoes, loose-fitting
clothing, neckties, clothing with loose strings and/or clothing that might be potentially hazardous while using this
product.
 DO NOT twist swing chains, or loop them over the top bar since this may reduce the strength of the chain.
 DO NOT swing empty seats. These may hit other children or yourself.
 DO NOT swing sideways into the path of adjacent swings.
WARNING AND SAFETY INFORMATION
Continued next page

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
4
SAFETY INSTRUCTIONS
 DO NOT allow children to swing too high or at an angle that chains become slack, or above the height of the
swing support.
 Teach and instruct children to sit in the center of the swings with their full weight on the seats. Do not allow
children to stand on the swing seats.
 Instruct children to hold on to swings and climbers with both hands.
 Warn children not to get off the equipment while in motion.
 NEVER slide with head first, always feet first.
 NEVER jump on a slide.
 DO NOT climb, swing or play when the playground equipment is wet. Equipment may be slippery when wet.
 Limit climbing and swinging heights to each child’s ability.
 Parents should periodically check all hardware to be sure it is secured. Bolts can loosen and components can
become detached and cause injuries.
 Parents should check swings, swing chains and climbing net to ensure they are secured and cannot be looped
back on itself.
 Verify that all swings and chains are secured at both ends.
 When the playground equipment is exposed to direct sunlight, check the temperature on the play accessories
before using the playground equipment.
 When temperature falls below 32 ° F/0 ° C, remove the plastic plays (swing seats, trapeze, climbing rocks & slide)
and store indoors. In extreme cold weather, plastic materials lose resilience and may become brittle and crack
upon impact.
 NEVER attach any materials that are not specifically designed for use with this playground equipment, such as
(but not limited to) jump ropes, clotheslines, pet leashes, cables and chains. These pose a potential strangulation
hazards.
 Discard all packaging properly after unit has been assembled.
WARNING AND SAFETY INFORMATION (cont.)

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
5
MAINTENANCE INSTRUCTIONS
CHECK ALL NUTS AND BOLTS TWICE MONTHLY DURING THE USAGE SEASON FOR
TIGHTNESS AND TIGHTEN AS REQUIRED. IT IS PARTICULARLY IMPORTANT THAT THIS
PROCEDURE BE FOLLOWED AT THE BEGINNING OF EACH SEASON.
 Never use pliers to tighten up screws – these can cause damage to both the paintwork and the special anti-
corrosion plating.
 Tighten all nuts and bolts securely. Replace as needed. If not checked regularly, bolts can be loose or missed and
components can become detached and cause injuries.
 Check the swing seats, metal chains, slide, climbing net and rock climber at the beginning of the usage season
and monthly thereafter for evidence of deterioration. Immediately remove and replace any items that appear to be
weak or broken. Contact Customer Support for replacement parts.
 Check all covers designed for bolts and sharp edges regularly to be certain they are present and in good condition.
Replace as needed. It is particularly important that all covers are checked prior to the first use each season.
 Inspect chains, s-hooks, brackets, eyebolts, swing bearings, hardware and ground anchors, and etc., for proper
closure and for signs of wear, deterioration, rust and/or damage. Replace as needed.
 Lubricate all metallic moving parts monthly during the usage season.
 Check all metal tubing and slide chute for damage and sharp edges. Replace as needed.
 Applying a light coat of automobile wax to all metal tubing surfaces will help protect your unit and add to its
longevity.
 Sand any rusted areas of the metal tubing and repaint using a non-lead based paint meeting the requirements of
Title 16 CFR Part 1303.
 If slide chute is exposed to direct sunlight, always check to make sure it is not too hot for children to use. If the
slide chute is hot, pour cold water on the slide chute until it cools. Check slide chute periodically during use.
 Remove plastic plays (swing seats, trapeze, rock climber & slide) and store indoors, or do not use when the
temperature drops below 32 ° F/0 ° C.
 Check unit for scuffs, burrs, sharp edges and any other defects that may occur from assembly, abuse, shipping or
everyday use. Burrs and sharp edges may be filed down until smooth and covered with duct tape if necessary.
 If the warning sticker is illegible, destroyed or removed, contact Customer Support for a replacement.
 To help maintain the products appearance, occasionally clean the seats and metal framework with a damp cloth
lightly – but DO NOT use abrasive chemical cleaners. NEVER apply any type of polish – this can cause slippery
surfaces which can be hazardous.
 When the time comes to disassemble and dispose of this playground equipment, please completely disassemble
the unit and discard of it in a safe place and manner so as not to present any hazard to any individual.
CARE AND MAINTENANCE

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
6
CUSTOMER SERVICE & WARRANTY
Care has been taken during the manufacturing and packing of this product to ensure that you receive quality
merchandise. In case you have any questions about any damaged or missing parts on your purchase, we
recommend you to keep the entire unit and contact our Customer Support for assistance.
Should you have any questions or comments pertaining to our product, missing parts and/or maintenance of your
purchase, please contact us.
USA and Canada:
Toll Free Hotline: [phone] (Weekdays 10:00 – 17:00 EST)
Email: [email protected]
Other countries:
Email: [email protected]
Our products are covered under warranty to the original purchaser for a period of 180 days from the date of original
purchase, under normal use and service, against defective workmanship and material which compromises the
structural integrity of the product when used for the purpose intended, normal conditions, and provided it received
proper care and maintenance. Surface rust is not covered under warranty.
If you have recently purchased this product and found it to be defective in anyway, please contact our Customer
Support for assistance.
This warranty is extended only to the original consumer purchaser and is non-transferable for non-commercial use.
GROW’N UP LIMITED, IS NOT RESPONSIBLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGE. THIS
LIMITED WARRANTY DOES NOT COVER ANY PERSONAL INJURIES, DAMAGE TO, OR, FAILURE OF THE
PRODUCT OR ANY OTHER LOSSES DUE TO ACCIDENT, ABUSE, MISUSE, ALTERATION, NEGLECT,
NORMAL WEAR AND TEAR, IMPROPER ASSEMBLY, IMPROPER FIT, IMPROPER MAINTENANCE OR USE OF
UNAUTHORIZED REPLACEMENT PARTS NOT DESIGNED FOR THE PRODUCT.
REPLACEMENT PARTS & SERVICE
LIMITED WARRANTY

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
7
ASSEMBLY INSTRUCTIONS
The U.S. Consumer Product Safety Commission (CPSC) estimates that about 100,000 playground equipment related
injuries resulting from falls to the ground surface are treated annually in U.S. hospital emergency rooms. Injuries
involving this hazard pattern tend to be among the most serious of all playground injuries, and have the potential to
be fatal, particularly when the injury is to the head. The surface under and around playground equipment can be a
major factor in determining the injury-causing potential of a fall. It is self evident that a fall onto a shock-absorbing
surface is less likely to cause a serious injury than a fall onto a hard surface. Playground equipment should never be
placed on a hard surface such as concrete or asphalt and while grass may appear to be acceptable it may quickly
turn to hard packed earth in areas of high traffic. Shredded bark mulch, wood chips, fine sand or fine gravel are
considered to be acceptable shock absorbing surfaces when installed and maintained at a sufficient depth under and
around playground equipment.
The following table lists the maximum height from which a child would not be expected to sustain a life-threatening
head injury in a fall onto different loose-fill surfacing materials if they are installed and maintained at depths of 6, 9
and 12 inches. However, it should be recognized that all injuries due to falls cannot be prevented no matter what
surfacing material is used.
TABLE 1 - FALL HEIGHT IN FEET FROM WHICH A LIFE
THREATENING HEAD INJURY WOULD NOT BE EXPECTED
Type of Material 6 in. depth 9 in. 12 in.
Double Shredded Bark Mulch
6 10 11
Wood Chips
6 7 12
Fine Sand
5 5 9
Fine Gravel
6 7 10
Shredded Tires***
10 -12 N/A N/A
It is recommended that a shock-absorbing material should extend a minimum of 6 ft. in all directions from the
perimeter of stationary equipment such as climbers and slides. However, because children may deliberately jump
from a moving swing, the shock-absorbing materials should extend in the front and rear of a swing a minimum
distance of 2 times the height of the pivot point measured from a point directly beneath the pivot point on the
supporting structure.
This information is intended to assist in comparing the relative shock-absorbing properties of various materials. No
particular material is recommended over another. However, each material is only effective when properly maintained.
Materials should be checked periodically and replenished to maintain correct depth as determined necessary for your
equipment. The choice of a material depends on the type and height of the playground equipment, the availability of
the material in your area and its cost.
¹ This information has been extracted from the CPSC publications “Playground Surfacing—Technical
Information Guide” and “Handbook for Public Playground Safety.” Copies of these documents can be
obtained by sending a postcard to the: Office of Public Affairs, U.S. Consumer Product Safety Commission,
Washington, DC 20207 or by calling the toll free hotline: [phone].
Note: The maximum fall height for this product is 7 feet 9 ½inches. (93.5”)
We recommend using 12” of Double Shredded Bark Mulch.
The minimum ground clearance between the bottom of the suspended plays
and the playing or ground surface MUST be 8 inches.
CONSUMER INFORMATION FOR PLAYGROUND SURFACING
MATERIALS¹

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
8
ASSEMBLY INSTRUCTIONS
It is very important that you take care in placement of the playground equipment. Place this product on level ground
NOT LESS THAN 6 feet (1.8 m) away from any other hard or fixed object.
Do not place this playground equipment underneath electrical wires. If you must, ensure that there is a MINIMUM
overhead clearance of 6 feet (1.8 m).
SAMSON SERIES – SPORTS CENTER SILVER DIMENSIONS:
15.5’ width x 10’ depth
Recommended play area:
28’ width x 28’ depth
Please note the CPSC surfacing materials recommendations above on page 7.
SPACE REQUIREMENTS
6 feet
6 feet
28 feet
14 feet 14 feet
28 feet
6 feet
6 feet

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
9
ASSEMBLY INSTRUCTIONS
Included: Allen wrench (3/16”)
Not Included: Flat-headed / slotted screwdrivers Adjustable wrench
Tape measure Hammer
Safety glasses Knife
Protective gloves Pliers
 Before assembly, read these instructions in their entirety. This will help ensure an easy and safe installation.
 Remove all parts from carton and arrange in an orderly fashion. Check carton for additional instructions and
hardware bags.
 We recommend that you identify and check the contents against the Parts List (page 12 - 14) before starting.
 Check all the parts and contents of each Fitting Pack – the contents of these are detailed within the Parts List
(page 12 - 14) and Hardware Pictures (page 15 - 22). Do this by laying them out on a flat surface – but not on
grass, as small items can easily be lost.
 Only adults should set up the playground equipment, contains sharp points and small parts which are necessary
for assembly. Prior to and during assembly of this product, keep all components out of children’s reach. Small
parts pose a choke hazard to children under 3 years.
 DO NOT allow children to play on or around the setup area until it has been completely and correctly assembled
and anchored.
 Please save all packaging materials until assembly is complete to ensure no parts are discarded.
 Always wear approved safety glasses during assembly.
TOOLS REQUIRED FOR ASSEMBLY
PREPARE FOR THE INSTALLATION










MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
10
ASSEMBLY INSTRUCTIONS
 During the manufacturing process of punching holes in the tubular
metal, the metal “tabs” occasionally remain attached. To ease
assembly, check all metal tubing and clear holes with a
screwdriver (not included) per Diagram A.
 If there are burrs or rough parts, you will need a metal file to
remove them prior to use.
 To ease assembly with tubing interlocks, holes have to be aligned.
Insert crimped (swaged) tubing inside second tubing and align
holes. Insert screwdriver to align holes correctly before inserting
hardware. See Diagram B.
 Align the inner hexagonal nut and the lock washer in a straight line
and insert these to the holes of the joined tubing. Then, insert the
screw from the other end of the hole and hand thread to fasten
them together. Now, use Allen wrench (included) and screwdriver
(not included) to tighten fully. See Diagram C.
 Extra nuts and bolts are included for spare parts and replacement.
Please save for future use. Some of the components are small
and may contain sharp points, care should be taken when
unpacking and assembling this product. Keep small parts out of
children’s reach. Small parts pose a choke hazard to children
under 3 years.
 Should you have any questions about the assembly of your
purchase, contact our Customer Support at 1-800-374-1262.
TIPS FOR EASY ASSEMBLY
Diagram A
Diagram B
Diagram C
Screw
Lock
washer
Inner
hexagonal
nut

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
11
ASSEMBLY INSTRUCTIONS
Please make sure the product orientation of the assembled model will be as follows:
BEFORE YOU START
Rock
climber
Trapeze
Climbi
ng
net
Swing seat Swing seat
Slide
FRONT
BACK
Climbing
net

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
12
ASSEMBLY INSTRUCTIONS
ID Item Description Qty Check
A-FRAME ASSEMBLY
A1 Top bar 01, blue 1 □
A2 Top bar 02, blue 1 □
A3 Top metal join, yellow 2 □
A4 Top middle join, yellow 1 □
A5 Side connection bar, yellow 2 □
A6 Curvy leg top, red 3 □
A7 Curvy leg bottom, red 2 □
A8 Curvy leg bottom (middle), red 1 □
A9 Curvy leg top (climbing wall front), red 1 □
A10 Curvy leg top (climbing wall back), red 1 □
A11 Curvy leg bottom (climbing wall front), red 1 □
A12 Curvy leg bottom (climbing wall back), red 1 □
A14 Anchor, blue 7 □
A15 Leg cover, yellow 5 □
A16 Climbing net, shamrock green 1 □
A17 Slide support bar, red 1 □
FITTING PACK for A-FRAME (Bag #700-223)
FA1 Side bar cover 4 □
FA2 5/16" x 1-1/4" inner hexagonal nut 8 □
FA3 5/16" x 1-1/2"screw 8 □
FA4 3/8" lock washer 8 □
FA5 1/4" x 7/8" inner hexagonal nut 17 □
FA9 1/4" x 1-9/16" screw 15 □
FA10 1/4" x 2-3/4" screw 2 □
FA11 11/32" lock washer 17 □
FITTING PACK for ANCHORS (Bag #700-224)
FA7 1/4" flat washer 7 □
FA8 1/4" x 2-1/32" screw 2 □
FA10 1/4" x 2-3/4" screw 5 □
FA12 1/4" Acorn nut 7 □
FA13 1/4" lock washer 7 □
PARTS LIST
Continued next page

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
13
ASSEMBLY INSTRUCTIONS
ID Item Description Qty Check
CLIMBING FRAME ASSEMBLY
C1 Climbing wall top bar, red 1 □
C2 Climbing wall bottom bar (front), red 1 □
C3 Climbing wall bottom bar (back), red 1 □
C4 Climbing wall side bar (front), red 1 □
C5 Climbing wall side bar (back), red 1 □
C6 Climbing wall connection bar, red 1 □
FITTING PACK for CLIMBING FRAME (Bag #700-225)
FA1 Side bar cover 2 □
FA5 1/4" x 7/8" inner hexagonal nut 10 □
FA11 11/32" lock washer 10 □
FC2 1/4" x 11/16" screw 2 □
FC3 1/4" x 3-5/32" screw 4 □
FC6 1/4" x 2-1/4" screw 4 □
ROCK CLIMBER ASSEMBLY
C7 Climbing wall top, yellow 1 □
C8 Climbing wall middle, yellow 1 □
C9 Climbing wall bottom, yellow 1 □
C10 Climbing rock A: red, green, blue (assorted) 4 □
C11 Climbing rock B: red, green, blue (assorted) 4 □
FITTING PACK for ROCK CLIMBER (Bag #700-226)
FA5 1/4" x 7/8" inner hexagonal nut 16 □
FA7 1/4" flat washer 12 □
FA9 1/4" x 1-9/16" screw 2 □
FA11 11/32” lock washer 16 □
FA12 1/4" Acorn nut 12 □
FA13 1/4" lock washer 12 □
FC6 1/4" x 2-1/4" screw 6 □
FC7 1/4" x 1-1/4" screw 14 □
FC10 1/4" x 3-7/32" screw 6 □
FC11 11/32" flat washer 16 □
PARTS LIST (cont.)
Continued next page

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
14
ASSEMBLY INSTRUCTIONS
ID Item Description Qty Check
SLIDE ASSEMBLY
S1 Slide chute, blue 1 □
S2 Hand rail top, red 2 □
S3 Hand rail bottom, red 2 □
S4 Ladder rail, red 2 □
FITTING PACK for SLIDE (Bag #700-227)
FA1 Side bar cover 4 □
FA5 1/4" x 7/8" inner hexagonal nut 6 □
FA8 1/4" x 2-1/32" screw 2 □
FA10 1/4" x 2-3/4" screw 4 □
FA11 11/32" lock washer 6 □
FA12 1/4" Acorn nut 4 □
FC2 1/4" x 11/16" screw 4 □
FS6 1/4" flat washer 4 □
TRAPEZE / SWING SEAT ASSEMBLY
T1 Trapeze, red 1 □
T2 Swing seat, red 2 □
PARTS LIST (cont.)

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
15
ASSEMBLY INSTRUCTIONS
HARDWARE PICTURES – A Frame Assembly
A1
Top bar 02, blue x 1
A2
A3 A4
A5
Top metal join, yellow x 2
A6
A7
A9
A12
Curvy leg bottom (climbing wall back),
red x 1
A11
A14
A15
A8
A10
Curvy leg top (climbing wall back), red
x 1
Side connection bar, yellow x 2
Curvy leg top (climbing wall front), red
x 1
Top middle join, yellow x 1
A17
A16
Climbing net, shamrock green x 1
Top bar 01, blue x 1
Curvy leg top, red x 3
Curvy leg bottom (climbing wall front),
red x 1
Anchor, blue x 7
Leg cover, yellow x 5
Slide support bar, red x 1
Curvy leg bottom, red x 2 Curvy leg bottom (middle), red x 1

ASSEMBLY INSTRUCTIONS
HARDWARE PICTURES - Fitting Pack (for A-Frame)
Shown in Actual Sizes (Bag #700-223)
MODEL#8019 SAMSON SERIES - SPORTS CENTER SILVER www.grow-n-up.com
FA1 FA2
FA3 FA4
FA5 FA9
FA10 FA11
X4 X8
X8
X15
X8
X17
X2 X17
Side bar cover 5/16 x 1-1/4” inner hexagonal nut
3/8” lock washer
1/4 x 1-9/16” screw
11/32” lock washer
5/16 x 1-1/2” Screw
1/4 x 7/8” inner hexagonal nut
1/4 x 2-3/4” screw
16

ASSEMBLY INSTRUCTIONS
HARDWARE PICTURES - Fitting Pack (for Anchors)
Shown in Actual Sizes (Bag #700-224)
MODEL#8019 SAMSON SERIES - SPORTS CENTER SILVER www.grow-n-up.com
FA7 FA8
FA10 FA12
FA13
X7
X2
X7
X5
X7
1/4” flat washer 1/4 x 2-1/32” screw
1/4” Acorn nut
1/4” lock washer
1/4 x 2-3/4” screw
17

MODEL# 8019 SAMSON SERIES – SPORTS CENTER SILVER www.grow-n-up.com
18
ASSEMBLY INSTRUCTIONS
HARDWARE PICTURES – Climbing Frame & Wall Assembly
C1
Climbing wall top bar,
red x 1
C2
C4
C5
C3
Climbing wall bottom
bar (back), red x 1
Climbing wall bottom
bar (front), red x 1
C6
Climbing wall
connection bar,
red x 1
Climbing wall side bar (front), red x 1
Climbing wall side bar (back), red x 1
C7
C8
C9
Climbing
wall top,
yellow x 1
Climbing
wall middle,
yellow x 1
Climbing
wall
bottom,
yellow x 1
C10
Climbing rock A x 4
red, green, blue assorted
C11
Climbing rock B x 4
red, green, blue assorted

ASSEMBLY INSTRUCTIONS
HARDWARE PICTURES - Fitting Pack (for Climbing Frame)
Shown in Actual Sizes (Bag #700-225)
MODEL#8019 SAMSON SERIES - SPORTS CENTER SILVER www.grow-n-up.com
FA1 FA5
FA11 FC2
FC3 FC6
X2
X10
X2
X4
X10
X4
Side bar cover
1/4 x 11/16” screw
1/4 x 2-1/4” screw1/4 x 3-5/32” screw
11/32” lock washer
1/4 x 7/8” inner hexagonal nut
19

ASSEMBLY INSTRUCTIONS
HARDWARE PICTURES - Fitting Pack (for Rock Climber)
Shown in Actual Sizes (Bag #700-226)
MODEL#8019 SAMSON SERIES - SPORTS CENTER SILVER
20
www.grow-n-up.com
FA5 FA7
FA9
FA12
X16 X12
X12
X2
1/4” Acorn nut
FC11
X16
11/32” flat washer
1/4 x 1-9/16” screw
1/4 x 7/8” inner hexagonal nut 1/4” flat washer
FA13
X12
1/4” lock washer
FC6
X6
1/4 x 2-1/4” screw
FC7
X14
1/4 x 1-1/4” screw
FA11
X16
11/32” lock washer
FC10
X6
1/4 x 3-7/32” screw