hestan Aspire ECD User manual

OUTDOOR COOKING
Grill Cart
ECD
Use & Care Manual
Installation & Operation

©2017 Hestan Commercial Corporation
2
EN
IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED
EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Do not try lighting this appliance without reading the LIGHTING
INSTRUCTIONS section of this manual.
For outdoor use ONLY. This cooking appliance is not intended to be
installed in or on recreational vehicles, and/or boats.
Flammable Gas - disconnect all propane or natural gas supplies to this
unit before servicing.
Electrical Parts & Components – disconnect all power supplies and
batteries before servicing.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
DANGER
1. Do not store or use gasoline or
other flammable liquids or vapors
in the vicinity of this or any other
appliance.
2. An LP cylinder not connected
for use shall not be stored in
the vicinity of this or any other
appliance.
READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE USING
YOUR GRILL TO REDUCE THE RISK OF FIRE, BURN HAZARD, OR
OTHER INJURY. KEEP THIS MANUAL FOR FUTURE REFERENCE.

©2017 Hestan Commercial Corporation
3
EN
4 MODEL NUMBERS
5 INTRODUCTION
5 PRECAUTIONS
6 REGULATORY / CODE REQUIREMENTS
7 PORTABLE LP CYLINDERS
8 CART & GRILL ASSEMBLY
16 GAS CONNECTIONS
17 PARTS LIST
17 SERVICE
17 WARRANTY
TABLE OF CONTENTS

©2017 Hestan Commercial Corporation
4
EN
CART MODELS
Model No. Description
ECD30 30” DOUBLE DOOR TOWER CART
ECD36 36” DOUBLE DOOR TOWER CART
ECD42 42” DOUBLE DOOR TOWER CART
MODEL NUMBERS

©2017 Hestan Commercial Corporation
5
EN
INTRODUCTION
Thank you for choosing the Aspire by Hestan Outdoor Grill Cart. We have written this Installation Guide
to help you properly install an Aspire Grill for years of safe and enjoyable use.
Keep this guide handy, as it will help answer questions that may arise as you use your new Cart.
Inspect the product to verify that there is no shipping damage. If any damage is detected, call the shipper
and initiate a damage claim.
Hestan Commercial Corp. is not responsible for shipping damage. DO NOT discard any packing material
(box, pallet, straps) until the unit has been inspected.
PRECAUTIONS - BEFORE YOU USE YOUR GRILL CART
When properly cared for, your Aspire grill cart will provide safe, reliable service for many years. However,
extreme care must be used since the grill produces intense heat, which can cause serious injury or even
death if the instructions are not followed carefully. When using this appliance, basic safety practices must
be followed as outlined below.
1. NEVER LEAVE THE GRILL UNATTENDED WHILE COOKING.
2. Children should not be left alone or unattended in an area where the grill is being used. Never allow
them to sit, stand, or play on or around the grill. Do not store items of interest to children around or
below the grill or in the cart. Never allow children to crawl inside of the cart.
3. The grill and cart shall be used only outdoors and shall not be used in buildings, garages, sheds,
breezeways, or any enclosed areas. Do not operate the grill under unprotected, combustible
construction. Use only in well-ventilated areas. See the INSTALLATION section of the Aspire Grill
manual for more information.
4. Do not use the grill unless a leak check has been performed on all gas connections. See the GAS
CONNECTIONS section of the Aspire Grill manual.
5. Portable LP cylinders - Always shut off the main valve on the liquid propane (LP) cylinder after each
use. Never use a dented or rusted LP cylinder. Never attach or disconnect an LP cylinder, or move or
alter gas fittings when the grill is in operation or is hot.
6. Inspect LP gas supply hose prior to each use of the grill. The hose must be kept away from heated
areas of the grill. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be
replaced before using the grill. The hose and LP regulator are supplied as a complete assembly and
must be replaced together. Do not attempt to repair or replace the hose itself. Contact your Hestan
dealer for genuine replacement P/N 014309.
7. Keep any electrical supply cord away from the heated areas of the grill. The cord is provided with a
3-prong grounding plug which should not be removed or altered. Do not use this appliance with an
ungrounded, 2-prong adapter. The cord must be plugged into a properly grounded GFCI-protected
outlet. See INSTALLATION section of the Aspire Grill manual.
8. Keep the areas surrounding the grill free from combustible materials, trash, or combustible fluids and
vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion gases (rear)
and ventilation airways (front). Keep the rear area free and clear of debris, extra LP cylinders, etc. Do
not block the ventilation louvers of the cart.
9. If your grill is stored indoors, ensure that it is cool before moving. If propane is used, the LP cylinder
must be disconnected and stored OUTSIDE in a well-ventilated area, out of the reach of children. A
grill cover is recommended, even when stored indoors.