Marcy ASG-40 User manual

MARCY CARDIO
TRAMPOLINE TRAINER
NOTE:
Please read all
instructions carefully
before using this product
Warning
Care and Maintenance
Assembly Instruction
Exploded Diagram
Warranty
Model ASG-40
Retain This
Manual for
Reference
OWNER'S
MANUAL
IMPORTANT: Please read this manual before commencing
assembly of this product.
Pure-Tec Limited
www.puretecfitness.com
Tel: [phone]
Email: [e-mail]
Monday – Friday 0900 – 1700 GMT

www.puretecfitness.com
1
WARNING
1. Read thewarning notice and instruction prior assembling and using theequipment.
2. This equipment isnot intended to use by children under 12 years ofage.
3. Do not leave children unattended with the equipment.
4. This equipment isintended to use indoor.
5. Position the equipment on a clear, leveled surface. Make sure the surfaces are free of objects that may cause
tipping over. Keep objects away, which could interfere with the performer.
6. Inspect before use. Keep frame padding in place. Never use the equipment if itisnot functioning properly.
7. Always wear appropriate workout clothing when exercising.
8. Do not use the equipment when it is wet.
9. Learn fundamental bounces and body position thoroughly. For skill training, contact a certified trainer.
10. Do not attempt or allow somersaults. Landing on the head or neckcan cause serious injury, paralysis, or death
even landing in the middle of the bed.
11. Do not allow more than one person on the equipment. Use by morethan one person at the same time increase the
chance of injury.
12. Use the equipment only with mature, knowledgeable supervision.
13. Bounce in center of the bed. Avoid bouncing when tired.
14. Do not use the equipment while under influence of alcohol or drugs.
15. While keeping the head erect, focus eyes on the equipment toward the perimeter.
16. Stop bounce by flexing knees as feet come in contact with the bed.
17. Before exercising, always do stretching exercises to properly warm up.
18. Maximum user weight is250 lbs.
19. If the user experience dizziness, nausea, chest pain, or any other abnormal symptoms,
STOP the workout atonce. CONSULT A PHYSICIAN IMMEDIATELY.
Care and Maintenance
1. For equipment information, contact manufacturer.
2. Periodically inspect all parts for tightness and tighten as required.
3. Replace any worn and damaged partimmediately.
4. Use mild household spray cleaners and/or a damp rag to wipe clean. Donot use harsh cleaning chemicals.
5. Sand rusted areas on tubular members and repaint using a non-lead-based paint meeting the requirements of
Title 16 CFR Part 1303.
6. Disposal Instructions – The equipment can be safely disassembled and disposed without unreasonable hazards.
Call your local recycle agency regarding details of recycling.
Save the Instructions.
WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT YOUR PHYSICIAN. THIS IS
ESPECIALLY IMPORTANT FOR INDIVIDUALS OVER THE AGEOF35 OR PERSONS WITH PRE-
EXISTING HEALTH PROBLEMS. READ ALL INSTRUCTIONS BEFORE USING ANY FITNESS
EQUIPMENT. PURE-TEC LIMITED ASSUMES NO RESPONSIBILITY FOR PERSONAL INJURY OR
PROPERTY DAMAGE SUSTAINED BY OR THROUGH THE USE OF THIS PRODUCT.
SAVE THESE INSTRUCTIONS.

www.puretecfitness.com
2
1. Lay the Marcy Trampoline on the floor, in it’s still folded position which looks like an
oval shape as shown in Image 1 (springs are just for illustrative purpose). Push out the
ends according to the arrows on the picture in Image 1, and the trampoline expands into a
semi circle as shown in Image 2. Now ensure the larger outer hinges are touching the floor
as in Image 3.
2. Firmly grasp both halves of the frame at the midpoint of
each half circle according to the arrows and pull out.
Note: Frame will snap open so please read step
no.3 carefully. Please keep all fingers away from
hinge when opening and closing.
3. Using steady pressure, with hands open and fingers
extended, use palm of hands topush top side of frame
up, over and down to open position.
4. With the Marcy Trampoline now open and still upside
down, thread the 6 legs to aperpendicular position (up and
over its holding platform pin).
Note: Be careful not to catch the cover fabric.
5. Turn the Marcy Trampoline right side up, and attach the fabric ofthe skirt
evenly around the jumping mat so that the skirt covers all the strapsinan
even manner. Please note the holes in the fabric skirt should be
underneath the straps.
6. Proceed to page 5for stabilizing bar assembly instructions.
OPENING THE TRAMPOLINE
Image 3

www.puretecfitness.com
3
Important Safety Note:
Always close your Marcy Trampoline with 2 people.
1. Remove fabric skirt to allow easier folding
2. Turn the unit upside down and lay it flat.
3. Remove the 6 legs.
4. Locate the larger hinges on each side of the trampoline. Stand near
the hinges on opposite sides of the Marcy Trampoline facing the upper
half of the frame (Image A).
5. Both people kneel facing the “top half” of the Marcy Trampoline placing
their knees approximately 5cms below the hinge (Image B).
6. Both people lean forward placing their outside hand on the ground and use
their inside hand to grasp the frame at the top of the Marcy Trampoline
(Image C).
7. Together pull up gently on the frame and the top half of the frame will raise
toward the middle. Ensure that your hands are clear of the moving frame
(Image D, Image E). Note: Watch out for your hands, feet and other body
part, etc. Always have 2 people to fold the Marcy Trampoline.
8. Once the Marcy Trampoline is folded (now looks like a half moon), simply
push the two ends inwards to make the rebounder smaller (the shape will
look like a rugby ball). (Image F).
CLOSING THE TRAMPOLINE
Image D
Image F
Image E

www.puretecfitness.com
4
ASSEMBLY INSTRUCTION
Step-1
A.) Unfold the Rebounding Bed
(#12).
B.) Thread six Legs (#10) onto
the Rebounding Bed.
C.) Slide one Handrail Support
(#7) onto one Leg. Skip the
next Leg and slide the
other Handrail Support
onto the 3rd Leg.
Notice: In case of the squeezing
situation,
When opened the trampoline
circle,
please spread the rubber belt
equably.
Step 2
A.) Insert the two Vertical
Handrails (#5) into the two
Handrail Supports (#7).
B.) Secure each Vertical
Handrail with one M8 x 5/8”
Allen Bolts (#8),one Ø5/8”
Flat Washer (#14), one 5/8”
Spring Washer (#15) and
one Lock Knob (#16).
C.) Insert the lock in (#17) into
the hole of Rebounding
Bed (#12).
Note: Please insert the safety lock pin (#17) into the hole on the frame before you begin
to use the trampoline.
When folding up the trampoline, please remove the lock pin (#17)to fold.

www.puretecfitness.com
5
Step 3
A.) Insert the Right Top
Handrail (#2) into
Left Top Handrail
(#1).
B.) Insert the Left and
Right Top Handrail
into the two Vertical
Handrails (#5).

www.puretecfitness.com
6
EXPLODED DIAGRAM
PARTS LIST
Part# Description Qty
1 1
2 1
3 1
4 2
5 2
6 2
7 2
8 4
9 4
10 6
11 6
12 1
13
Left Top Handrail
Right Top Handrail
Double Clip Spring
Handle Grip
Vertical Handrail
Single Clip Spring
Handrail Support
M8 x 5/8” Allen Bolt
Plastic Bushing
Leg
Rubber Base
Rebounding Bed
Cover 1
14 Ø5/8” Flat Washer 2
15 Ø5/8” Spring Washer 2
16 M8 Lock Knob 2
17 Lock Pin 1

www.puretecfitness.com
7
LIMITED WARRANTY
Pure-Tec Ltd warrants this product to be free from defects in workmanship and material, under normal use and
service conditions, for a period of two years on the Frame from the date of purchase. This warranty extends only to the
original purchaser. Pure-Tec Ltd's obligation under this Warranty is limited to replacing or repairing, at Pure-Tec
Limited's option.
All returns must be preauthorize byPURE-TEC LTD.Pre-authorization may beobtained by
contacting Pure-Tec's Customer Solutions Department by email at: [email protected].All
freights onproducts returned to PURE-TEC LTD must be prepaid bythecustomer.
ORDERING REPLACEMENT PARTS
Replacement parts can be ordered by contacting our Customer Solutions Department toll-free at:
[email protected] during our regular business hours: Monday through Friday, 9 am until 5 pm GMT
www.puretecfitness.com
[email protected]
PURE-TEC LTD
Tel: [phone]