MTS Systems FFV2 Pro User manual

Powered By:
1/10 Electric FFV2 Pro Car Kit
Instruction Manual
2 0 1 6

Introducon:
FFV2 Pro is a professional 1:10th front wheel drive car and should be built by aged 14 years or over or that they had experience
building and operang R/C model cars before. This is not a toy intended for use by beginners or by children without any
supervision of a knowledgeable adult. Please read the instrucon manual carefully before building.
Race opt should not be liable for any loss, injury or damages, whether direct, indirect, special, incidental, consequenal, arising
from the use, misuse, abuse of this product or accessories required to operate this product.
Warnings:
◎ This product is not intended for those ages under 14 year without any adult supervision.
◎ Assemble this kit only in places away from the reach of children.
◎ Exercise car when using tools and sharp instrument and take care some parts that may have sharp edges when building.
◎ Please do not touch any electronic equipment on the model such as motor and speed controller that having higher
temperatures after the operaon. Otherwise, it may burn yourself seriously by touching them. Beer to allow 10~15
minutes to let any electronic equipment cool down.
◎ Please complete a successful pre-run check of your radio equipment and model before the run. Make sure to keep the
wheels of the model off the ground when checking the operaon of the radio equipment.
◎ When on the model, please always turn on the transmier before turn on the receiver in the car. When off the model,
please always turn off the receiver before turn off the transmier. Otherwise, the model may become uncontrollable and
cause serious damage.
◎ Disconnect the baery pack before storing your model.
◎ Do not get overcharge for the baery or leave baery unaended while charging. Never let children charge the baery
without adult supervision.
◎ Do not operate it on public places, roads or areas where its operaon can conflict with or disrupt pedestrian or vehicular
traffic.
◎ Do not use your model as shown below:
In places where children and people gather In rain, wind snow or darkness condion
In areas where loud noises can disturb others At anyme your line of sight to the model may be
obstructed or impaired in any way
1

Electrical Precautions:
∧Please do not allow any metal part to short circuit the battery or any electronic part using inside the car kit.
∧Never put batteries into fire.
∧Use the recommended charger for the transmitter battery and battery for electronic speed control. Please follow
the charging instructions carefully. Please do not over charge the battery or choose the wrong charging mode. It
becomes dangerous that causes the explosion and lead to the fire. If battery becomes extremely hot during the
charging, please seek the advice from or get replacement from the corresponding battery supplier.
∧Please unplug charger when not in use.
∧When not using RC model, please always disconnect and remove the battery.
∧Low battery may result in loss of control. Please stop running the car at once when you find its speed start to
slow down.
∧After use the battery, the battery remains heat and please recharges it after the battery is cool down.
∧Never use damaged wires that are dangerous and cause short circuits and may lead to the fire.
Other Equipment Needed (not included):
Radio transmitter & receiver Battery for transmitter
Electronic speed control Steering Servo
540 Type brushes or brushless motor Pinion Gear (48pitch/64pitch)
190mm body shell 7.4V Nimh or Lipo Battery
Touring Car Tire set Battery charger
Tools Needed (not included):
1.5mm, 2.0mm, 2.5mm allen wrench 5.0mm, 5.5mm, 7.0mm hex socket wrench
Modelers craft knife Turnbuckle wrench
Calipers/Ruler Camber gauge
Instant glue/Thread lock glue Shock and Diff Oil
Thrust, Diff and Joint grease Paint for body shell
Notes: All replacement parts can be found from www.race-opt.com and can be purchased from local
hobby shop. If any further information needed, please email to [e-mail].
2

162147
122006
050210
122127
DETAIL + 1.3g
Add 1.3g of oil the diff.
Low-Traction
500 cst
High-Traction
1000 cst
LOCATION
!
163130
045121
090110
043592
121067
090110
017258
121067 060902128202 050210
090110
3

121058
124012
129460
129450
061401 125029 060615 124019
122024 124033
040025
124016
127001 124001
124002
124003
INCORRECT CORRECT 3~5
UP & DOWN
Move the shock shaft up and
down a few times to release the
air bubbles trapped beneath
the piston.
Oil
Low
Medium
High
Alternate shock
rebound setting.
FRONT
REAR
125001
121095
123031
128232
125043
123033
019300
121011
125044
125106
017306
017306
017308
017314
017306
017308
125224
125001
125117
123028
4

2
0
-+
123023
094084
018304
125041
121096 031015
127050
125042
018308
050209
030510
125004
125004
018306
017310
123021
123022
121065
123025
030510
040040
050212
125045
5
1

3
4
015408
017306
125117
121175
121061
050350
017306
125109
121110
121175
018308
017308
040366
128106
128133
121062
015408
050347
6

FRONT 53mm
REAR 59mm
017306
120200
017306
018306
128137
BATTERY
018306
123029
123030
128136
120200
018306
128135
160247
031015
123001
018308
122023
121044
040362
024906
016205
125012
050210
030612
121031
015304
024908
121249
122025
122127
121032
040362
024908
020332
015304
7

63.5mm
018308
025801
015310
121022
018306
121023
018312
040060 018308
121249
121086
020332
019300
121086
121086
017314
018308
125046
024900
024906
024900
030508
125047
040373
128234
123024
018306
018306
018308
018308
125225
123126
017314
018310
8
121049
040365

123027
017308
017308
123026
128205
015325
015304
129118
121149
121110
015314
015310
121110
024901
121095
121074
017312
015304
121074
017310
129214
121074
123027
017308
017308
123026
128205
015325
015304
129118
121149
121110
015314
015310
121110
024901
121095
121074
017312
015304
121074
017310
129214
121074
9
017306
018308
040375
015325
096038
019402
018310
018308