PGF GO FAN-V User manual

OWNERS MANUAL
Copyright © 2015 CYNWARK Corporation
www.PGFfan.com 888-938-6672
One (1) Year Limited Warranty
Service Instructions:
DO NOT attempt to repair or modify any mechanical or electrical parts of the PGF-V. Doing so
will VOID this warranty.
1. This warranty applies Only to the original owner of the PGF-V
2. This warranty only applies to the repair or replacement of any of the manufactured parts
of the PGF-V. Cynwark Corp reserves the right to determine if repair or replacement is
warranted.
3. Operating the PGF-V under conditions or usage not specified in the warnings, instructions,
or care directions; or attempts to repair or modify the fan in anyway will render this
warranty void.
4. Unless other wise prescribed by law, Cynwark Corp. will not be liable for any personal
injury, property, incidental, or consequential damage of any kind (including water damage)
resulting from defects, malfunctions, improper installation or alterations of this product.
5. All parts of the PGF-V are guaranteed for a period of one (1) year from the date of
purchase.
6. If you experience any other problems or have a claim with the PGF-V, please call or contact
our customer service department at [phone].
Warranty Claim Instructions:
Please follow the directions below when initiating a Warranty Claim:
1. Please call 888-938-6672 to discuss your warranty claim.
2. We will instruct you on how to proceed with your warranty issue.
This warranty gives you specific legal rights and you may have other rights that vary from state to state. The
provisions of thisWarranty are in addition to and not a modification of, or subtraction from the statutory warranties
and other rights or remedies contained in any applicable legislation.To the extent that any provision of thisWarranty
is inconsistent with any applicable law, such provision shall be deemed voided or amended as necessary to comply
with such law.
Register your PGF-V Fan at PGFfan.com to activate your warranty.
This requires the serial number found on the bottom of the fan by the battery door.
Cynwark Corporation 6700 Woodlands PKWY, Ste. 230-139 The Woodlands,TX 77382
Cynwark Corporation
6700 Woodlands Parkway, Ste. 230-139
The Woodlands,TX 77382
personal go fan
Patented
Page 11
Repairs:
Is your PGF-V out of warranty? Did something happen that caused damage to your PGF-V? If so, don’t
worry. Repairs can be made at a cost of $25. Please call our customer service number, 888-938-6672,
and discuss your issue with one of our customer service representatives.They will instruct you on
how to proceed with the repair process.
PGF is a trademark of Cynwark Corporation

IMPORTANT SAFETY INSTRUCTIONS
Copyright © 2015 CYNWARK Corporation
The PGF-V is designed to operate in a cup holder in golf carts, recreational vehicles
and boats.The PGF-V, like all special electronic devices should be handled with care
and not dropped.
USE CAUTION:This fan is very powerful. Operating the fan while it is standing on an uneven
surface, with a base adapter installed, COULD cause the fan to blow over!
Before charging the battery or using the PGF-V please read all the instructions and
precautions in this manual. Use only the charger supplied with the PGF-V
When using an electrical appliance, basic precautions should always be observed,
including the following:
• DO NOT rely exclusively upon the safety devices built into this unit.
• DO NOT insert anything into the fan shroud.This includes tools such as screwdrivers
or body parts such as fingers, toes or tongues. Caution should be used when operated
around small children.
• DO NOT expose the PGF-V and charger directly to rain or wet conditions.Treat the
fan as you would any other electronic device, such as a cell phone or radio.
• DO NOT disassemble, incinerate or pierce the battery with any sharp object.
• DISPOSAL:The lithium-ion (NMC) battery in this fan is generally considered to be
landfill safe. Check local regulations for disposal.
• Unplug the charger when it is not in use.
PGF is a trademark of Cynwark Corporation
1. High airflow for outdoor and indoor use.
2. Designed to fit in the cup holder of golf carts, recreational vehicles and
boats.
3. Fan blade has winglets to increase airflow.
4. Efficient, high power, long lasting ball bearing brushless motor.
5. New Chemistry Lithium-Ion Battery.
6. The Battery and Charger have built in safety circuits.
7. Approximate run time of 40 hours on low, 16 hours on medium and 3 ¾
hours on high speed.
8. Approximate charge time is under 3 hours for a fully discharged battery.
9. Overall height of 16 inches and a weight of approximately 2 lbs.
10. (1) One Year Warranty
Main Features
Congratulations on the purchase of your Personal Go Fan-V!
We are pleased to announce the PGF Personal Golf
Fan/Personal Go Fan-V was the recipient of the 2013
PGA Inventor’s Spotlight
This Manual lists the main features along with how to operate and properly maintain
the PGF-V.
www.PGFfan.com 888-938-6672
Page 1 Page 2

Copyright © 2015 CYNWARK Corporation
PGF-V Battery Installation
Operation
The power switch is a round knob that is turned clockwise to power the fan on.The fan
speed is controlled by how far the knob is rotated so that the volume of air can be regulated.
To turn the fan off the knob needs to be rotated fully counter clockwise until a click is heard.
To adjust the position of the fan head; loosen the thumb screw, adjust the fan head position
and retighten the thumb screw. Do not over tighten the thumb screw.
NOTE: The Thumb Screw needs to be loosened before tilting the head. Failure to do so
could damage the adjusting mechanism or break the head of the PGF-V!
Motor Housing 1. Using a Phillips screw driver remove the screw on the
battery door cover.Then remove cover exposing the
battery connection
2. Plug the wire leading from the PGF-V into the plug on
the battery wire. This battery connection is a one way
plug and can only be installed in a specific direction.The
red and black wires will line up with each other when
properly aligned.
personal go fan
Patented
www.PGFfan.com 888-938-6672
Thumb Screw for Tilting Fan
Variable Speed On/Off Knob
Screw on Cup Adapter
Charging Port / Dust Cover
3. Slide the battery into the holder.Then tuck the power
cord into the extra space around the battery.
4. Re-attach the battery door using the removed screw
and Phillips screw driver. Simply reverse steps 1 through
4 to remove the battery.
Page 3 Page 4

Copyright © 2015 CYNWARK Corporation www.PGFfan.com 888-938-6672
Golf Cart Compatibility
The PGF-V comes with the two main adapters
shown to the right and left. They are designed to
fit in the stock O.E.M. cup holders shown. They are
numbered on the bottom.
E-Z-GO RXV
Use E-Z-GO (#1) cup adapter with
black polymer ring.
Place in upper cup holders only.
Black Polymer
Ring
#1
E-Z-GO
Cup Adapter
#2
Club Car /
Yamaha
Cup Adapter
Please Note: It’s very important to use the correct
adapter to properly secure the PGF-V into your
cart.
Club Car DS
Use (#2) Club Car/Yamaha cup adapter
in either cup holder.
Club Car Precedent
Use (#2) Club Car/Yamaha cup adapter
in large inner cup holders only.
Adapter (#1) can be used in the smaller
outer cup holders.
Columbia ParCar (2010 and Newer)
Use (#2) Club Car/Yamaha cup
adapter in any cup holder. Use (#2) Club Car/Yamaha cup adapter
with back polymer ring in any cup holder.
Columbia ParCar (2009 and Older)
Black Polymer
Ring
E-Z-GO 48 (2014 and Newer Models)
Use E-Z-GO (#1) cup adapter with
black polymer ring in any cup holder.
Black Polymer
Ring
Star Cart
Use E-Z-GO (#1) cup adapter with tall black
boat polymer ring
Place in outer cup holder only.
Yamaha
Use (#2) Club Car/Yamaha cup adapter
with red polymer ring.
Place in upper large cup holders only.
Red Polymer
Ring
E-Z-GO TXT Freedom
E-Z-GO 48 (2010-2013 Models)
Use E-Z-GO (#1) cup adapter in any
cup holder.
Black Polymer
Boat Ring
Is your PGF-V a little loose?
Every eort has been made to supply cup
adapters that t into the O.E.M. cup
holders. However, due to manufacturing
tolerances the sizes can vary slightly.
If needed, you can use one of the following
methods to create a more secure t:
1. Wrap duct tape around the cup adapter
to increase the width.
2. Add a piece of velcro to the bottom of
the cup adapter and the cup holder.
Page 5 Page 6

Copyright © 2015 CYNWARK Corporation www.PGFfan.com 888-938-6672
Boat Cup Holder Compatibility
Please Note: It’s very important NOT to have the PGF-V installed in the cup holder
when under power at higher speeds and/or in rough water.
#1#2
Polymer Boat
Ring
We have done our very best to engineer a system of adapters that will fit into most
O.E.M. boat cup holders. However, there are so many different versions on the
market today it is impossible to insure they fit into every single one. Two cup adapters
and one polymer ring are supplied with the PGF-V that fit into most boat cup holders.
These adapters are shown below. Each adapter is numbered on the bottom for easy
identification.
Cup holders designed with LEDs, tangs, or smaller diameters will use adapter number
2 without the polymer boat ring as shown below.
Most cup holders found in boats will utilize the number 1cup adapter with the boat
polymer ring added. This combination of adapter/polymer ring and examples of the
cup holders it fits are shown below.
Cup Adapter (1)
Polymer Boat Ring
Cup Adapter (2)
Tangs
Is your PGF-V a little loose?
Every eort has been made to supply cup adapters that t into the O.E.M. cup holders.
However, due to manufacturing tolerances the sizes can vary slightly. If needed, you can use
one of the following methods to create a more secure t:
1. Wrap duct tape around the cup adapter
to increase the width.
2. Add a piece of velcro to the bottom of
the cup adapter and the cup holder.
Page 7 Page 8

Copyright © 2015 CYNWARK Corporation
Make sure the fan is turned off before cleaning. Clean parts with a duster or damp cloth.
Use care around the motor housing to prevent liquid from coming in contact with motor.
Prior to resuming use make sure the PGF-V is dry and all moisture has been eliminated. Do
not immerse the PGF-V in any type of liquid or use abrasive cleaning solutions. When
storing the PGF-V in the off season, make sure it is in a dry environment and follow the
battery storage instructions on page 9.
Page 9 Page 10
Care & Cleaning
Specifications *
Motor Brushless; ball bearing; 12V DC
Motor Speed 5000 RPM under load
Approximate Charge Time (Battery fully discharged) Less than 3 hours
Approximate Run Time (Battery fully charged) 40 hrs on Low, 16 hrs on Medium, 4 hrs on High
Battery 11.1 V; 4.4 amp hour; lithium-ion (NMC)
Battery Charger Input 100–240V; 50/60 Hz; 0.4A
Battery Charger Maximum Output 12.6V DC; 2A
Overall Height 16 inches
Overall Weight 2 lbs.
*All specifications are based on the latest product information available at the time of
printing.We reserve the right to make changes at any time without notice.This device
complies with part 15 of the FCC Rules.
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause
harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired
operation. Note:This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of
the FCC Rules.These limits are designed to provide reasonable protection against harmful interference in a residential installation.This
equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may
cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the
equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.
Charging The Battery
The battery should be charged in a cool, dry place. Charging should be done with the fan off to avoid
the fan from running once the charger is removed.The built in safety circuit turns the fan off once the
charger is plugged into the PGF-V.The battery does not have to be fully discharged before recharging.
The battery will not develop a memory.
Approximate charge time is under 3 hours if the battery is completely discharged.
**Prolonged Storage of the PGF-V:To maintain maximum Battery Power and Longer
Service life of the PGF-V, the battery should be stored with a 50% charge. If the
charge level is unknown, then fully discharge the PGF-V and then add a charge for 1
½ hours.We suggest repeating this process every 3 months during non-usage**
1. Plug the charger into an AC wall outlet.The LED on the front of the charger will illuminate green.
2. Plug the charger output into the charging receptacle on the fan.
3.The LED on the charger will switch to red indicating that the battery is charging.
4. Once the battery is fully charged the LED on the charger will turn green.
5. Unplug the charger from the fan and the wall socket.The safety circuits in the charger and the battery
will discontinue the charge once the battery is fully charged.
6. It is recommended to unplug the charger when not in use and not rely solely on safety circuits.
NOTE: Lithium-Ion batteries, while in use, will continue to provide full power with very little power
fade unlike typical batteries.When the battery is fully discharged, the battery safety circuits will immediately
cut power to the fan motor.The battery circuits will not allow the fan to run until the battery has been
recharged.
Note: It is recommended that the PGF-V be charged on a non-flammable surface. The PGF-V is
supplied with an engineered charger and this is the ONLY charger that should be used
when charging the Lithium-Ion battery. Additional chargers can be purchased thru our web site.
Charging Indicator Light
Red when charging
Green when fully charged
www.PGFfan.com 888-938-6672

OWNERS MANUAL
Copyright © 2015 CYNWARK Corporation
www.PGFfan.com 888-938-6672
One (1) Year Limited Warranty
Service Instructions:
DO NOT attempt to repair or modify any mechanical or electrical parts of the PGF-V. Doing so
will VOID this warranty.
1. This warranty applies Only to the original owner of the PGF-V
2. This warranty only applies to the repair or replacement of any of the manufactured parts
of the PGF-V. Cynwark Corp reserves the right to determine if repair or replacement is
warranted.
3. Operating the PGF-V under conditions or usage not specified in the warnings, instructions,
or care directions; or attempts to repair or modify the fan in anyway will render this
warranty void.
4. Unless other wise prescribed by law, Cynwark Corp. will not be liable for any personal
injury, property, incidental, or consequential damage of any kind (including water damage)
resulting from defects, malfunctions, improper installation or alterations of this product.
5. All parts of the PGF-V are guaranteed for a period of one (1) year from the date of
purchase.
6. If you experience any other problems or have a claim with the PGF-V, please call or contact
our customer service department at [phone].
Warranty Claim Instructions:
Please follow the directions below when initiating a Warranty Claim:
1. Please call 888-938-6672 to discuss your warranty claim.
2. We will instruct you on how to proceed with your warranty issue.
This warranty gives you specific legal rights and you may have other rights that vary from state to state. The
provisions of this Warranty are in addition to and not a modification of, or subtraction from the statutory warranties
and other rights or remedies contained in any applicable legislation.To the extent that any provision of thisWarranty
is inconsistent with any applicable law, such provision shall be deemed voided or amended as necessary to comply
with such law.
Register your PGF-V Fan at PGFfan.com to activate your warranty.
This requires the serial number found on the bottom of the fan by the battery door.
Cynwark Corporation 6700 Woodlands PKWY, Ste. 230-139 The Woodlands,TX 77382
Cynwark Corporation
6700 Woodlands Parkway, Ste. 230-139
The Woodlands,TX 77382
personal go fan
Patented
Page 11
Repairs:
Is your PGF-V out of warranty? Did something happen that caused damage to your PGF-V? If so,
don’t worry. Repairs can be made at a cost of $50. Please call our customer service number,
888-938-6672, and discuss your issue with one of our customer service representatives.They will
instruct you on how to proceed with the repair process.
PGF is a trademark of Cynwark Corporation