ultraPLAY Early play UP151 User manual

Issued/Revised:
1
800.458.5872 www.ultraplay.com
06/12/12
UP151 IN-GROUND PACKAGE FOR LEARN-A-LOT, TWO
PANEL (USED ON MODEL #UP149 AND UP150)
Parts List
PART NUMBERQTYDESCRIPTION
4032023
FOOTING PIPE
INTALLATION INSTRUCTIONS:
UP149 & UP150
1. Dig footing holes as shown in Bottom & Elevation Views. Note: Site must be level and clean of debris.
2. Attach Footing Pipes to Window and Caterpillar Panel using 90° Angel Bracket, 3/8” x 3/ 4” Carriage Bolt, and 3/8” Barrel Nut.
See Detail 051.
3. Plumb & level the entire assembly and tighten all fasteners.
4. Pour concrete footing with 4” to the top and taper away from posts for water drainage. Allow to cure at least 48 hours before
use. Note: Temporary bracing may be required until concrete cures.
Items listed below Hardware Complete line are included with Hardware Complete Number
Warning: During Installation, Hardware And Small Parts Are Choking Hazards For Young Children. Store
Unused Parts Appropriately Until Assembly Is Completed. Once Assembly Is Completed, Remove Any
Unused Parts From The Play Environment And Dispose/Save Them In A Secure Location. Any bolt end
protruding more than two full threads beyond the face of the nut causes risk of clothing entanglement.
Promptly cut-off flush, file smooth, and treat to prevent corrosion.
Unless Otherwise Specified, All Units of Measure are Each
MAINTENANCE PROCEDURE:
Periodically check hardware for tightness, and tighten as necessary. Always check all parts for breakage or wear, and immediately
put equipment out of service until any faulty parts found are repaired or replaced. Also Check all metal parts for rust, paint loss and
touch-up if necessary with paint. Check for welded areas and verify integrity. Check periodically resilient surfacing for appropriate
depth and remove extraneous materials that could cause injury, infection, or disease. Maintain detailed installation, inspection,
maintenance, and repair records for each public-use playground equipment.

Issued/Revised:
2
800.458.5872 www.ultraplay.com
06/12/12
UP151 IN-GROUND PACKAGE FOR LEARN-A- LOT, TWO
PANEL (USED ON MODEL #UP149 AND UP150)
051
=INSTALLATION DETAIL
FINISHED ASSEMBLY
FOR UP149 AND UP150
CATERPILLAR
PANEL
WINDOW
PANEL
051
FOOTING PIPE
(403202)
LEARN-A-LOT, TWO PANEL
HDPE END
SUPPORT HDPE END
SUPPORT

Issued/Revised:
3
800.458.5872 www.ultraplay.com
06/12/12
UP151 IN-GROUND PACKAGE FOR LEARN -A- LOT, TWO
PANEL (USED ON MODEL #UP149 AND UP150)
SHOCK ABSORBING PROPERTIES OF
SURFACING MATERIALS VARY. IF YOU
DETERMINE THAT LESS THAN 10" OF SURFACING
IS REQUIRED, MAKE-UP THE DIFFERENCE IN
ELEVATION WITH EARTH BEFORE APPLYING
SURFACING. IF MORE THAN 10" IS REQUIRED. MAKE
UP THE DIFFERENCE BY REDUCING THE DEPTH OF
THE GROUNDHOLE BY NO MORE THAN 2".
BOTTOM VIEW
ELEVATION VIEW
CONCRETE REQ'D:
0.060 CUBIC YARDS
0.045 CUBIC METERS
RESILIENT SURFACE
23 1/2 in
[59.69 cm]
18 in
[45.72 cm]
6 in
[15.24 cm]
70 13/16 in
[179.81 cm]
70 13/16 in
[179.81 cm]
100 1/8 in
[254.29 cm] n10 in
[25.40 cm]
12" DEEP
[30.48 cm]
TYP.
BRICK OR EQUIVALENT
CONCRETE
FOOTING

Issued/Revised:
4
UP151 IN-GROUND PACKAGE FOR LEARN-A-LOT, TWO
PANEL (USED ON MODEL #UP149 AND UP150)
2
1
34
2
5
1
CM
0
INCH0
10961114815
712 13
4
365
06/12/12
800.458.5872 www.ultraplay.com
051
3/8" x 3/4" CARRIAGE
BOLT (800252)
90° ANGLE
BRACKET
PANEL
FOOTING PIPE
(403202)
3/8" BARREL NUT
(804804)