Vesta Vc 100 combi User manual

WARNING

If the information in these instructions is not followed exactly a fire or explosion may result causing, ,

property damage personal injury or death, , .

–Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other

appliance.

–WHAT TO DO IF YOU SMELL GAS

●Do not try to light any appliance.

●Do not touch any electrical switch do not use any phone in your building; .

●Immediately call your gas supplier from a neighbor s phone Follow the gas supplier s instructions’ . ’ .

●If you cannot reach your gas supplier call the fire department, .

–Installation and service must be performed by a qualified installer service agency or the gas supplier, .

–The installation must conform with local codes or in the absence of local codes the National Fuel Gas, ,

Code ANSI Z223 1 NFPA 54 and or CSA B149 1 Natural Gas and Propane Installation Code, . / / . , .

–When applicable the installation must conform with the Manufactured Home Construction and,

Safety Standard Title 24 CFR Part 3280 and or CAN CSA Z240 MH Series Mobile Homes, , / / , .

Keep this manual near this boiler for future reference

whenever maintenance or service is required.

NCB-210E

NCB-240E

Installation Manual

Condensing Combi Boilers-

Model

NCB-150E

Model VC 100 (LP) COMBI

VC 120 (LP) COMBI

VC 140 (LP) COMBI

Requirements for the State of Massachusetts

NOTICE BEFORE INSTALLATION

This appliance must be installed by a licensed plumber or gas fitter in accordance with the Massachusetts Plumbing and Fuel Gas

Code 248 CMR Sections 2 00 and 5 00. . .

IMPORTANT In the State of Massachusetts 248 CMR 4 00 5 00: ( . & . )

For all side wall horizontally vented gas fueled equipment installed in every dwelling building or structure used in whole or in part for,

residential purposes including those owned or operated by the Commonwealth and where the side wall exhaust vent termination is less than,

seven 7 feet above finished grade in the area of the venting including but not limited to decks and porches the following requirements shall( ) , ,

be satisfied:

1. INSTALLATION OF CARBON MONOXIDE DETECTORS At the time of installation of the side wall horizontal vented gas fueled equipment. ,

the installing plumber or gasfitter shall observe that a hard wired carbon monoxide detector with an alarm and battery back up is‐

installed on the floor level where the gas equipment is to be installed In addition the installing plumber or gasfitter shall observe that a. ,

battery operated or hard wired carbon monoxide detector with an alarm is installed on each additional level of the dwelling building or,

structure served by the side wall horizontal vented gas fueled equipment It shall be the responsibility of the property owner to secure the.

services of qualified licensed professionals for the installation of hard wired carbon monoxide detectors

a. In the event that the side wall horizontally vented gas fueled equipment is installed in a crawl space or an attic the hard wired carbon,

monoxide detector with alarm and battery back up may be installed on the next adjacent floor level‐ .

b. In the event that the requirements of this subdivision cannot be met at the time of completion of installation the owner shall have a,

period of thirty 30 days to comply with the above requirements provided however that during said thirty 30 day period a battery( ) ; , , ( ) ,

operated carbon monoxide detector with an alarm shall be installed.

2. APPROVED CARBON MONOXIDE DETECTORS Each carbon monoxide detector as required in accordance with the above provisions shall.

comply with NFPA 720 and be ANSI UL 2034 listed and IAS certified/ .

3. SIGNAGE A metal or plastic identification plate shall be permanently mounted to the exterior of the building at a minimum height of.

eight 8 feet above grade directly in line with the exhaust vent terminal for the horizontally vented gas fueled heating appliance or( )

equipment The sign shall read in print size no less than one half 1 2 inch in size. , ‐ ( / ) , GAS VENT DIRECTLY BELOW KEEP CLEAR OF ALL“ .

OBSTRUCTIONS”.

4. INSPECTION The state or local gas inspector of the side wall horizontally vented gas fueled equipment shall not approve the installation.

unless upon inspection the inspector observes carbon monoxide detectors and signage installed in accordance with the provisions of, ,

248 CMR 5 08 2 a 1 through 4. ( )( ) .

Contents 3

Contents

Safety Information 4

1 About the Boiler. 7

1 1 Items Included. 7

1 3. Specifications 8

1 4. Components 9

1 5. Dimensions 11

1 6. Rating Plate 13

2 Installing the Boiler. 14

2 1 Choosing an Installation Location. 14

2 2. How to Install 15

3 Installing the System Piping. 16

3 1 Installing a Space Heating System. 16

3 2 Installing a Domestic Hot Water DHW System. ( ) 18

3 3 Condensate Discharge. 20

3 4. Installing a Space Heating System 20

4 Connecting the Gas Supply. 21

4 1 Gas Pipe Sizing Tables. 21

4 2 Measuring the Inlet Gas Pressure. 23

5 Venting the Boiler. 24

5 1 Selecting a Vent Type. 24

5 2 Selecting Vent Pipe Materials. 28

5 3. Vent Terminal Installation Precautions 28

6 Setting the DIP Switches. 32

7 Connecting the Power Supply. 33

8 Installation Check list. 34

9 Operating the Boiler. 37

9 1 Turning the Boiler On or Off. 37

9 2 Adjusting the CH(Space Heating) Temperature. 37

9 3. Setting DHW Outlet Temperature mode 38

9 4. Setting FAN revolutions per minute (RPM) 38

9 5. Check the Hmode value 38

10 Appendixes. 39

10 1. Wiring Diagram 39

10 2. Component Assembly Diagrams and Parts Lists 40

5 4 Terminating the Vent. 29

1 2. Accessories 7

4 Safety Information

WARNING

If you do not follow these instructions exactly a fire or explosion,

may result causing property damage personal injury or loss of,

life.

This appliance does not have a pilot It is equipped with an.

ignition device which automatically lights the burner Do.

not try to light the burner by hand.

BEFORE OPERATING smell all around the appliance area for

gas Be sure to smell next to the floor because some gas is.

heavier than air and will settle on the floor.

WHAT TO DO IF YOU SMELL GAS

●Do not try to light any appliance.

●Do not touch any electric switch do not use any phone;

in your building.

●Immediately call your gas supplier from a neighbor s’

phone Follow the gas supplier s instructions. ’ .

●If you cannot reach your gas supplier call the fire,

department.

●Do not return to your home until authorized by your

gas supplier or the fire department.

Use only your hand to push in or turn the gas control knob.

Never use tools If the knob will not push in or turn by hand. ,

don t try to repair it call a qualified service technician’ , .

Force or attempted repair may result in a fire or explosion.

Do not use this appliance if any part has been under water.

Immediately call a qualified service technician to inspect

the appliance and to replace any part of the control system

and any gas control which has been under water.

Safety Information

The cautions issued by this installation manual include critical

information for the safety while using the product. When the

user fails to adhere to the following requirements can cause

For safety, according to the level of danger, we have indicated

by “DANGER”,“WARNING”,“CAUTION”and the definitions for

these terms are as follow

The definitions of the symbols indicated on the product and

installation manual are as follows

death, serious damages, and a great property loss.

DANGER

WARNING

CAUTION

When the required terms are not followed, it

indicates an urgent danger that may cause

death or serious bodily injury

When the required terms are not followed, it

indicates latent danger that may cause death

or serious bodily injury

When the required are not followed, it indicates

latent danger that may cause light injury or

semi-serious injuries

Safety Information 5

CAUTION

●Do not turn on the boiler unless the water and gas

supplies are fully opened.

Doing so may damage the boiler.

●Do not turn on the water if the cold water supply shut-

off valve is closed.

Doing so may damage the boiler.

●Do not use this boiler for anything other than its

intended purpose as described in this manual, .

●Do not remove the front cover unless the power to the

boiler is turned off or disconnected.

Failure to do so may result in electric shock.

●When servicing the controls label all wires prior to,

disconnecting them.

Failure to do so may result in wiring errors which can lead to,

improper or dangerous operation Verify proper operation.

after servicing.

●Do not use unapproved replacement or accessory parts.

Doing so may result in improper or dangerous operation

and will void the manufacturer s warranty’ .

●Do not place anything in or around the vent terminals,

such as a clothes line that could obstruct the air flow in,

or out of the boiler.

●This boiler has been approved for use in the USA and

Canada only.

Using the boiler in any other country will void the

manufacturer s warranty’ .

WARNING

●Do not store or use gasoline or other flammable liquids

near this boiler.

Doing so may result in fire or explosion.

●Do not place combustibles such as newspapers or,

laundry near the boiler or venting system, .

Doing so may result in a fire.

●Do not place or use hair sprays spray paints or any other, ,

compressed gases near the boiler or venting system,

including the vent termination.

Doing so may result in fire or explosion.

●Do not operate the boiler with the front cover opened.

Doing so may result in fire or carbon monoxide CO( )

poisoning which may result in property damage personal, ,

injury or death, .

●Do not operate this boiler without proper venting.

Doing so may result in fire or carbon monoxide CO( )

poisoning which may result in property damage personal, ,

injury or death, .

●Do not touch the power cord or internal components of

the boiler with wet hands.

Doing so may result in electric shock.

6 Safety Information

DANGER

This boiler s water temperature is set to 120 49 at the’ ( )℉ ℃

factory for your safety and comfort Increasing the temperature.

increases the risk of accidental scalding Water temperatures at.

or above 125 52 can cause instant scalding severe burns( ) , ,℉ ℃

or death Before you decide to change the temperature setting. ,

read the following charts carefully.

Water

Temperature

Time in which a young child can suffer a

full thickness 3rd degree burn( )

160 70( )℉ ℃ Less than 1 second

140 60( )℉ ℃ 1 second

130 55( )℉ ℃ 10 seconds

120 49( )℉ ℃ 10 minutes

100 37( )℉ ℃ very low scald risk

DANGER

HOT

BURN

To prevent burns:

●Use the lowest operating temperature setting necessary to

provide comfortably hot water- .

●If your household has children or elderly or disabled

residents consider using a lower temperature setting, .

●Read all the instructions in this manual carefully before

changing the temperature setting.

●Feel the water before using it on children the elderly or the, ,

disabled.

●If it is necessary to set the water temperature above 120 ℉

(℃), -52 consider installing a thermostatically controlled

mixing valve or temperature limiting valve Contact a- .

licensed plumber or your local plumbing authority for more

information.

About the Boiler 7

1 1 Items Included.

When you open the box you will find the following items with,

.the boiler Check the box for each of the following items before

WARNING

If the information in these instructions is not followed exactly a fire or explosion may result causing, ,

propertydamage personalinjury ordeath, , .

–Donot store or use gasoline or other flammable vapors and liquids in the vicinity of this or anyother

appliance.

–WHATTO DO IF YOU SMELL GAS

●Donot try to light any appliance.

●Donot touch any electrical switch do not use any phone in your building; .

●Immediatelycall your gas supplier from a neighbors phone Followthe gas suppliers instructions’ . ’ .

●Ifyou cannot reach your gas supplier call the fire department, .

–Installationand service must be performed by a qualified installer service agency or the gas supplier, .

–Theinstallation must conform with local codes or in the absence of local codes theNational Fuel Gas, ,

Code ANSI Z223 1 NFPA 54 and or CSA B149 1 NaturalGas and Propane Installation Code, ./ / . , .

–Whenapplicable theinstallation must conform with the Manufactured Home Construction and,

SafetyStandard Title24 CFR Part 3280 and or CAN CSA Z240 MH Series Mobile Homes, , / / , .

Keepthis manual near this boiler for future reference

whenevermaintenance or service is required.

NCB-210E

NCB-240E

User’s Manual

CondensingCombi Boilers-

Model

NCB-150E

Model VC100 (LP) COMBI

VC 120 (LP)COMBI

VC 140 (LP)COMBI

Installation Manual,

User’s Manual Wall Mounting Bracket

1 About the Boiler.

.installing the boiler

Pressure Relief Valve Heating,

1 2. Accessories

The following optional accessories are available for the boiler

Plumb Easy Valve Set

Tapping screws & anchors