Whirlpool AMW 201/WHITE User manual

SERVICE Whirlpool Europe
Customer Services
Model AMW 201/WHITE
Version 8587 201 10291 Page
Introduction safety 2
Technical data 3
Spare part list 4
Exploded view 5
Wiring diagram 6
Service Manual
Microwave oven
AMW 201/WHITE
AMW 201/WHITE
This documentation is only intended for qualified technicians who are aware of the respec-
tive safety regulations.
Date: 16.01.2004 Subject to modification
Document-No.: 4812 714 14999

SERVICE
16.01.2004 / Page 2 AMW 201/WHITE Whirlpool Europe
Doc. No: 4812 714 14999 8587 201 10291 Customer Service
Introduction safety
INTRODUCTION
Before leaving the factory each oven is carefully checked.
It must, however, be installed and used correctly.
Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact
the user understands how to use and maintain the oven.
The information in this section should be used as a reminder that the oven is safe and that anyone who uses it must
first read the instructions for use in order to be able to use the oven correctly and obtain best results.
SAFETY
To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.
Always disconnect the plug from the mains before starting work.
If there is no plug switch off the electric supply at the control box.
When you have finished servicing an oven before you reconnect it to the mains, make sure that:
- all the internal connections are correct
- the wires are insulated and not touching the door or the cabinet or anything sharp
- all the earth connections are electrically and mechanically sound
- do not modify or anyway interfere with the safety devices built-in to the oven
- make sure that each replacement part you use conforms to the manufacturer´s specifications
Do not start a repair if you have any doubt as to your ability to complete it.
CAUTION - MICROWAVE RADIATION
PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE MAGNETRON,
WAVEGUIDE OR ANTENNA IF THEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUT
AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE
AROUND MAGNETRON AND VISIBLE MICROWAVECONNECTIONS (WELDING JOINTS).
Do not operate the oven if the following conditions exist:
- the door does not close firmly against the door support because of the door being warped or the hinges damaged.
- The door trims or seals are damaged.
- If there is any visible damage to the oven.
- if the door does not close properly.
Avoid operating the oven if known components in the interlock system, oven door or microwave
generating assembly are known defective. They must be replaced.
WARNING - HIGH VOLTAGE
IT IS POSSIBLE TO COME IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH
HV TRANSFORMER, HV CAPACITOR AND MAGNETRON. THEREFORE NEVER TRY TO MEASURE
THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING ELECTRIC
MEASUREMENTS INSIDE THE OVEN.

SERVICE Whirlpool Europe AMW 201/WHITE 16.01.2004 / Page 3
Customer Service 8587 201 10291 Doc. No: 4812 714 14999
Technical data
Product dimensions
Height 285 mm
Width 456 mm
Depth 392 mm
Cavity dimensions
Height 196 mm
Width 295 mm
Depth 292 mm
Cavity volume 17.8 l
Turntable 272 mm
Weight
Gross 15.2 kg
Net 13.6 kg
Electrical
Voltage 230 V
Frequency 50 Hz
Current consumption 8 A
Power
Power consumption 1250 W
Output power Microwave 800 W
Microwave frequency 2450 MHz
Timer
electronic 99 min.
7 power levels

SERVICE
16.01.2004 / Page 4 AMW 201/WHITE Whirlpool Europe
Doc. No: 4812 714 14999 8587 201 10291 Customer Service
Spare part list
Model AMW 201/WHITE
Service No. 858720110291
Version 858720110291
Pos. No. 12NC Code Description
001 0 4812 442 69211 Cabinet WH
011 0 4819 902 00694 Foot
011 1 4812 462 79806 Support front/back
121 0 4812 459 48126 Door, inner
121 1 4812 459 48128 Door frame inner
130 0 4812 310 38706 Switch holder
130 6 4812 450 58714 Door lock
141 0 4812 450 58611 Oven glass outer
142 0 4812 459 48132 Door inner foil
142 2 4812 459 48129 Support door glass
143 0 4812 459 48131 Door frame outer
255 0 4812 466 78398 Turntable glass
264 0 4812 535 78063 Rail Driver TT
301 1 4812 404 78688 Support button A WH
301 2 4812 404 78687 Support button B WH
320 0 4812 453 59929 Panel, control WH
331 1 4812 411 28998 Knob rotacode WH
333 1 4812 411 28989 Knob stop WH
334 1 4812 411 28993 Knob defrost WH
334 3 4812 411 28988 Knob power WH
352 1 4812 130 38727 Lens
352 2 4812 130 38731 Plate PC
352 3 4812 130 38729 Cover lens
404 0 4812 131 58803 Magnetron
406 0 4812 361 58369 Motor TT
412 0 4812 145 28021 Transformer HV
412 9 4812 529 18057 Shock absorber
420 0 4812 121 58135 Capacitor HV
421 0 4812 121 18265 Filter, mains board
426 0 4812 218 38134 Diode HV
443 0 4812 515 28091 Fan wheel (five)
443 1 4812 515 28093 Air guide fan
444 0 4812 361 18383 Motor fan
490 0 4812 321 18235 Cable, mains
500 0 4812 214 79218 Control board
561 0 4812 282 48265 Thermostat (145˚C)
562 0 4812 282 48264 Thermostat (165˚C)
632 0 4819 902 00845 Microswitch
633 0 4819 271 38271 Microswitch
633 2 4819 271 38269 Microswitch
651 0 4812 134 28074 Lamp (20W)
652 0 4812 134 28073 Lamp holder
770 0 4812 526 48119 Air guide
774 0 4812 442 29264 Cover mica plate
900 5 4819 404 79411 Bracket for cable
910 1 4819 902 00565 Pin
930 1 4819 902 00868 Spring
950 1 4812 532 68104 Seal water proof

SERVICE Whirlpool Europe AMW 201/WHITE 16.01.2004 / Page 5
Customer Service 8587 201 10291 Doc. No: 4812 714 14999
Exploded view

SERVICE
16.01.2004 / Page 6 AMW 201/WHITE Whirlpool Europe
Doc. No: 4812 714 14999 8587 201 10291 Customer Service
Wiring diagram
B Black BL Blue BR Brown G Green OR Orange R Red W White Y Yellow
Door open
FM Fan motor L Lamp T.T Turntable motor