Whirlpool AVM 210 WH User manual

[~ = -l ~WJ r8j '. Whirlpool Euro~e A VM 210 WH
~ .1 i.'J ~ .Customer Services
~Whirlpool
Service Manual
M icro-wave-oven
AVM 210 WH
Model AVM 210 WH
Version 8538 210 01291
Introduction, safety 481271490015
Technical data 481271458005
Spare parts list 4812 714 80443
Exploded view 4812 714 68005
Wiring diagram 4812 714 78006
Program diagram 481271478007
r-
.! .-,
'.
This documentation is only intended lor qualilied technicians who are aware 01 the respective salety re-
gulations.
Date: 24. tO.1994
Document-No.: 48t2 714 10369 Subjectto modification
Register Nr.:
~--- ~ ---""

481271490015
INTRODUCTION
Before leaving the factory each oven is carefully checked.
It must however, be installed and used correctly.
Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact
the user understands how to use and maintain the oven.
The information in this section should be used as areminder that the oven is safe and that anyone who uses it must
first read the instructions tor use in order to be able to use the oven correctly and obtain best results.
SAFETY
To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.
.Always disconnect the plug tram the mains before starting work.
.If there is no plug switch off the electric supply at the control box.
.When you have finished servicing an oven before you reconnect it to the mains, make sure that:
-all the internal connections are correct
-the wires are insulated and not touching the door or the cabinet or anything sharp
-all the earth connections are electrically and mechanically sound
-do not modify or anyway interfere with the safety devices built-in to the oven
-make sure that each replacement part you use conforms to the manufacturer's specifications
.00 not start arepair if you have any doubt as to your ability to complete it.
CAUTION -MICROWAVE RADIATION
PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE
MAGNETRON, WAVEGUIDE OR ANTENNA IF THEY ARE IMPROPERL Y USED OR CONNECTED. ALL INPUT
AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE
AROUND MAGNETRON AND VISIBLE MICROWAVE CONNECTIONS (WELDING JOINTS).
.00 not operate the oven ifthe following conditions exist:
-the door does not Glose firmly against the door support because of the door being warped or the hing es damaged.
-The door trims or seals are damaged.
-If there is any visible damage to the oven.
-if the door does not Glose properly. "
-.
Avoid operating the oven ifknown components in the interlock system, oven door or microwave
generating assembly are known defective. They must be replaced.
WARNING -HIGH Val TAGE
IT IS POSSIBLE TO GaME IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH
HV TRANSFORMER, HV CAPACITOR AND MAGNETRON. THEREFORE NEVER TRY TO MEASURE
THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING ELECTRIC
MEASUREMENTS INSIDE THE OVEN.

Technical data 481271458005
1. Cabinet dimensions
Height 330 mm
Width 553 mm
Depth 485 mm
2. Cavity dimensions
Height 225 mm
Width 372 mm
Depth 390 mm
Volume 34 I
Turntable diameter 360 mm
3. Weight
Net 23 kg
Packed 26 kg
4. Electrical details
Voltage 230-240/50 V/Hz
Power consumption 2600 W
Current consumption 11 A
Quarzgrill 1200 W
Output power microwave 950 +/- 50 W
Microwave frequency 2450 MHz
Fuse 16 (SA) A
13 (GB) A
Timer 90 min. mec.
5. Accessories
Grill grid
Spacer
Crisp plate
~ -

246 0 245 0 0 002 0
25
264 0~~:D:::t: ~ 452 5
~~., w Iß 52 4 .0
4523 -915 0 , 4526
452 2=~~~~~" ~/ ;562 0 .~h~:~-/=~=
452 1___~f~~~ ~~~~~, .~ 234O
~--~::~~~~.. ..
452 07-;;:;;;;;;~ ~ 041 0 ". " 90 0
4850 5610
1430
1410 4260
f 420 0
4210
1000 l420111
13 4120
1301 0710
3521 651 0
3010
3341 4062--+ 4041
3200 406 O G .
334 4420~ ~l\~:~~q ::::
305 0 q<~5~:l:~~~~;~2~~; '"
5023 ./,.('~ ""';-,.
352 0 971 0 ~/ 4422
502~
622 0 ~~i- -972 0
170
5211
3550 5020 4110 4430 14812 714 68005\

r~ =.l ~.J "Al I. Whirlpool Europe
~ 81 ~J ~ l- Customer Services 481271480443
Model AVM 210 WH
Service No. 853821001291
Version 853821001291
Pos. No. 12 NC Code Description trom to
001 1 481945349874 Recipe guide General
001 1 481945349875 Recipe guide Europe
0020 481944238042 Cabinet WH
0022 481946279721 Cover upper
0022 481946279722 Cover lower
0130 481946279423 Foot
041 0 481941719384 Hinge oben
041 1 481941719379 Hinge,lower
071 0 481946698922 Casing
1000 481944238041 Doorcpl. WH
1100 481949869967 Grip WH
1200 481944238004 Door,inner
1210 481945948662 Frame,breakerinner
1300 481927638171 Unit,pushbutton cpl.
1301 481946689172 Clip
1310 481953598529 Doorlatch
141 0 481945069809 Oven glass WH
1430 481945948669 Frame,breaker WH
2340 481944238039 Plate,protect.
2440 481946698789 Stand plastic
2450 481945819981 Grid
2460 481941838334 Plate
246 1 481949869875 Grip tor crispplate not shown
2550 481946678348 Turntable glass
2640 481953578151 Crosspiece,drum tumtable
301 0 481927638327 Unit,pushbutton WH
301 1 481946238751 Frame tor pushbuttons not shown
3050 481940478851 Holder
3200 481945349813 Panel,control WH
3340 481941258404 Knob WH
3341 481941338126 Clip Knob inner
3520 481913038072 Display
352 1 481945069808 Pane tor Display
3550 4819280 18019 Buzzer
4040 4819131 58019 Magnetron
404 1 481946238742 Air guide magnetron
4060 4819361 18292 Motor tor rotary plate
4062 481953268686 Gasket ring
4110 481914868076 Transformer
4120 481914578168 TransformerHT
4200 4819121 48016 Capacitor HT
420 1 4819404 78839 Bracket capacitor
421 0 4819121 18162 Filter,mains
4260 481921838039 Diode HV
4420 4819361 18361 Motor Blower
4421 481946258145 Cover fan
442 2 4819462 58146 Container fan
4430 481951528224 Fan wheel "
4520 481925998385 Heating element quarz "
452 1 481940478841 Holder quarz tube
4522 481945858522 Reflector quartz tube
4523 481941879082 Cover bar
4524 4819532 58263 Washer
452 5 4819532 58262 Washer ceramic
452 6 481945858527 Air guide grill
468005

r~ =-l ~WJ r8 =Whirlpool Europe
~J .1 ~'j ~ Customer Services 481271480443
Model AVM210WH
Service No. 853821001291
Version 853821001291
Pos. No. 12 NC Code Description from to
4850 481932028023 Cable,HT HT
4852 4819466 98742 Guide paper
4900 4819321 18231 Cable,mains cpl. with clamp
5020 481921478456 Control unit
502 1 481920988041 Microprocessor
5023 4819101 48142 Potentiometer
5211 481911388001 Resistor 100 Ohm
561 0 481928248276 Thermostat 120C
5620 481928248277 Thermostat 160C
5640 481928248275 Thermostat 165C
6170 481928068323 Relay 24V
6220 481927618273 Switch
6330 481927138145 Microswitch
651 0 481913428029 Lamp cavity
7430 481946238749 Air guide
9122 481950218369 Screw
9150 481950518315 Nut
971 0 481925338019 Fuse T8 A
9720 481925338006 Fuse T100mA
,
"
468005
5
-

<0
0
r , 0
, 00
I 0 I '"
"..,... ' ~
I 0 I T-
, '"
I> I '0 ,C C\J
I CI --I lOT- ,l(") 00: ' ..-00
l(\j I -a:; ~
, ...', ,..c >- c
I 1\ Z "' m I () "!::: 0>
1\ ~ - 0>0 .0- ~ ~ ...(1j= Q)I 00: I ::~~ -"' E"- Z I" I I- (/)~~ 0 () 0> "-E
! 0 I I ~ , c"- C:'.~ o~ ..-E g- ro ro ro ..g <5
IW Ö 01 I ~ I E~(1j(/)(/)..Q~(1j"'ijj"'ijj"'ijj ~"iijQ)
.Z::& 01 I ~ -:+= "0 ..-C:' 0 ..0 -0 0 0 Co C "0 I 01 I I ~(/)c..Q(1jE(1j>-EEE (1j(1j.Q
, lJJ (\j I C 0 0- ()..- "0
I .-L , 0>.- () c E cE.> Q) Q) Q) = -
, (1j(1jQ)o.'::(1j:J(1j..c..c..c°.::1--1-1-
I '~~OO~~~I-OI-I--I--~III i :r: 0 I
,CJ 00:
I 000000000000000
'I .! T-~~~<O"'OOC\J~~<Oooooo
L J ---~ ~ ~ ~ ~ ~ ~ ~ ;: ;:;: ;: ;: ~ g g
gC===============~~
(;)
'" .0.::> 0 >-
-J <-'
-J
m ,.m
0 () "
-""0'.
~ .
'" I
:I::::
-J l-
m >- ~
<-' -J
(\ja ...m
S ~
-J
0"" ~ (m
J I- 00:
0 m ~ 01- m
J a>
m 0
>- ...
<-' z
0
I .,., ('), -= 0 '- I 0. 0.' :x!:j W Z I ...I u, 0 F W W
, I ~ 0 -< :I: , ...,0 n.dJ:ZJu
I 0.,0>- uoZw
, (\j10<-, "'Q:(I)-,-<~
I ~ '50 WJ: Q:o: I I'""' 0 ou a1w I I Zo a1(/) W...
, -' --< W 0 , ~, J: 0 W , 0.1 -J zo- 0 Q:'-
."'- m (\jJ. ",-o:a::)a: , :J -u :> J: W:) 00 I ' 03: J:"-""'- I I I ' I ' I II ' I I 0'"
, ,...
, I , I
, ' ~ , ~"'I -J J: , = 0. m U
.-J:J: , ,- U " I , ~ -~
, "I I ~ ~ ~
I 0 ., .,
' ' 0 ~ ~
I I "0 0 0
, 0 0
,0' , >0 "0 "0
, (\j ~
""0 : ~ ~ ~
, I C ~ ..
I 1 0 .-E I I U a -
I 1 ~ ~ a:
,~ '., .000
'0' ~ ...00U)
'0 I -J 000
' 1 m ---
, I
'E...I
I I Im -0 ,
,~ -cr> ", ~Oo:...~
, >- , , ., 1 ~
:0 ~I ~ ä:: ~ w () W
I~ W Z Z <-'(/) ZOo:::> ,~ -J ::> <::> -=' -w
:c , ~ ::> < -JOOo: 00: O-J
18 : ...= 0 0 -.m 00: <-' m Z m
1 1"'.- W a> ()
: a: I (?J:I: :::
1 W
Q N
CI:
W z<
CI: ~ Dm(/) ='='~::> m;::L I- $?;-J!!:?I-«:I:<m 3: ~WWOOo:CI:()-Jg ~ 3: 00:~ m w m
I (') -i -~ I .,
>- ~ ...,..
I Q Q I ~
0' I 0
(')1 I 0 01 )(, ~
Q m
I' a:
~I' < 3: Z
-I '" I ...0 W >- ~ ~
--JI- ~~W
~' I -J -Q wO< ='
I I w:I:w"'Oo:-J-J
.", ~ >- 3: a: ~ m m m CI' 0
.~ I -' -' , ()
~, ,
,I 00:
, (\j I ::>
0
-J ~
0~1-0>-00:-J-J (»-3:a:~mmm
-J Z
!;r~~g_=======-, -=-=---~ --= =====

t--
:! ~:! E 8
:! Q)OO
:: :: a}} -~~~ ~t--
~ -; -I 1- ---~ -" :: :; -.t t ->.-
, ---~.~...~--- --~ ~ '"
iR~"ill c~~iri~ir~~~i~~E .!!J.T-
_.~.~. I:R;'R~~~~..2~""~~ et--
-C\j
CT-
000
O.q-
j
~
~ D D
-;:;:
,~
~
~
H
~
~
~
~~~~IA~ra~ -~.~.~._~=,,:g~_8 Rio
~JjfSBi~ ~~~~~~S~~~~~~~~~ e Bi
.~~:J!~~; ~~~~L~~Lf~~~~.~:a
§~
a :: ,
~~ , ~'
Sie ~ i : e
~..~ N, ,
--", J
-~ i! ~
2="~ -i :: -~ ~ ~ ? e ~ ~ ~ --
,
B
~~
, j
,
! j
~ i ~ ~ ~ ~1 ~1 ~ ~ ~ j
r r r Irr r. r r r .
.-.~g ~ ~ ~;~ --.~
.~ i i
~ 8!
lli ~ i ~ C
Q.~ Q..
'..
--.
2h.2h.
@
---
;; i i
..
...c c",..Q.Q.
lli : : --
k.h.22
~a
d0000~ g)~0-
--8888
"J ~~~~~- ~ ~ .~~~~ .
~ 5 N ~ I NB -r -~ ~ ~ ~
"0/ 8~ '" '" '" '"
x

Controlsystem
481271478007
!/!
j,
(fr
r
~.~
'\I
~ '" .
() \) 'i
~
, "'i..
~ t ~
0' '" '"
<\I \J ~
II..Z1 '<I I. ~
~ ~
<:) ~ Q
0- ()~ '\I I') I')
'\)()()~
~ ~ ~ ~
~ ~ ~ ~
" ~'a~
~ ~ ~
~ 11'\ ~ "-
~
~