Whirlpool MD 364/BL User manual

SERVICE Whirlpool Europe
Customer Services
Model MD 364/BL
Version 8538 231 99491 Page
Introduction safety 2
Technical data 3
Spare part list 4
Exploded view 5
Wiring diagram 6
Program diagram 7
Service Manual
Microwave oven
MD 364/BL
MD 364/BL
This documentation is only intended for qualified technicians who are aware of the respec-
tive safety regulations.
Date: 10.10.2000 Subject to modification
Document-No.: 4812 714 13614

SERVICE
10.10.2000 / Page 2 MD 364/BL Whirlpool Europe
Doc. No: 4812 714 13614 8538 231 99491 Customer Service
Introduction safety
INTRODUCTION
Before leaving the factory each oven is carefully checked.
It must, however, be installed and used correctly.
Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact
the user understands how to use and maintain the oven.
The information in this section should be used as a reminder that the oven is safe and that anyone who uses it must
first read the instructions for use in order to be able to use the oven correctly and obtain best results.
SAFETY
To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.
Always disconnect the plug from the mains before starting work.
If there is no plug switch off the electric supply at the control box.
When you have finished servicing an oven before you reconnect it to the mains, make sure that:
- all the internal connections are correct
- the wires are insulated and not touching the door or the cabinet or anything sharp
- all the earth connections are electrically and mechanically sound
- do not modify or anyway interfere with the safety devices built-in to the oven
- make sure that each replacement part you use conforms to the manufacturer´s specifications
Do not start a repair if you have any doubt as to your ability to complete it.
CAUTION - MICROWAVE RADIATION
PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE MAGNETRON,
WAVEGUIDE OR ANTENNA IF THEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUT
AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE
AROUND MAGNETRON AND VISIBLE MICROWAVE CONNECTIONS (WELDING JOINTS).
Do not operate the oven if the following conditions exist:
- the door does not close firmly against the door support because of the door being warped or the hinges damaged.
- The door trims or seals are damaged.
- If there is any visible damage to the oven.
- if the door does not close properly.
Avoid operating the oven if known components in the interlock system, oven door or microwave
generating assembly are known defective. They must be replaced.
WARNING - HIGH VOLTAGE
IT IS POSSIBLE TO COME IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH
HV TRANSFORMER, HV CAPACITOR AND MAGNETRON. THEREFORE NEVER TRY TO MEASURE
THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING ELECTRIC
MEASUREMENTS INSIDE THE OVEN.

SERVICE Whirlpool Europe MD 364/BL 10.10.2000 / Page 3
Customer Service 8538 231 99491 Doc. No: 4812 714 13614
Technical data
Dimensions of cabinet
Height 330 mm
Width 553 mm
Depth 537 mm
Dimensions of cavity
Height 227 mm
Width 372 mm
Depth 395 mm
Cavity volume 34 l
Turntable diameter 360 mm
Weight
Net 25 kg
Electrical
Voltage 230 V
Frequency 50 Hz
Fuse 10 A
Power
Power consumption 3200 W
Output power MW 1000 W
Grill 1200 W
Hot air 1500 W
Microwave frequency 2450 MHz
Timer
90 min
Features
- Quartz grill
- Crisp function
- Jet start
- Jet defrost
- Auto crisp
- 7 power levels
- Cavity inox
- Child lock
- 24 hour clock

SERVICE
10.10.2000 / Page 4 MD 364/BL Whirlpool Europe
Doc. No: 4812 714 13614 8538 231 99491 Customer Service
Spare part list
Model MD 364/BL
Service No. 853823199491
Version 853823199491
Pos. No. 12NC Code Description
001 0 4819 442 38007 Cabinet BL
011 0 4819 462 79423 Foot
040 0 4819 417 19384 Hinge upper
041 1 4819 417 19379 Hinge,lower
100 0 4812 462 68034 Door cpl. BL
110 0 4812 462 68032 Door handle WH
110 1 4812 462 68033 Insert door handle
117 0 4819 498 78366 Handle for crisp plate
120 0 4819 442 38004 Door,inner
121 0 4819 459 48703 Door frame inner door
130 0 4819 276 38171 Unit,pushbutton cpl.
130 1 4812 466 88482 Slide block
131 0 4819 535 98529 Door latch
141 0 4812 450 58461 Oven glass outer
143 0 4812 459 48098 Door frame outer BL
203 0 4819 325 18058 Insulation
203 1 4819 325 18057 Insulation
204 0 4819 442 38039 Plate,protect.
204 1 4819 466 89241 Plate,protect. heat left
204 2 4819 466 89242 Plate,protect. heat right
245 0 4819 458 19981 Grid high
245 1 4819 458 58581 Grid low
245 2 4819 458 58562 Grid defrost
246 0 4819 310 18537 Crisp plate VIP34
251 0 4819 462 79799 Cover,lamp
251 1 4819 468 18076 Gasket
251 2 4819 505 18238 Nut self tap
255 0 4819 466 78348 Turntable glass
264 0 4819 520 18029 Ring,set
264 1 4819 462 38767 Crosspiece
301 0 4812 404 78412 Button assy BL
305 0 4812 256 98035 Bracket
320 0 4812 453 59265 Panel,control BL
331 0 4812 410 78074 Knob timer BL
331 9 4812 492 58033 Shaft
333 0 4812 401 18503 Button start/stop BL
352 0 4812 130 38711 Display
352 1 4812 491 48009 Frame hood for display
355 0 4819 280 18029 Buzzer
404 0 4819 131 58019 Magnetron
406 0 4819 361 18381 Motor TT
406 1 4819 502 18372 Screw for TT-Motor
406 2 4819 532 68686 Gasket ring for TT
411 0 4819 148 68076 Transformer electronics
412 0 4819 145 78207 Transformer,HT 230V
412 1 4819 462 48431 Shock absorber
420 0 4819 121 18299 Capacitor 1,15µF-2100V
421 0 4819 121 18162 Filter,mains
426 0 4819 218 38039 Diode HV
440 0 4819 361 18356 Motor hot air
441 0 4819 361 18361 Motor Blower
441 1 4819 462 58146 Bottom fan
441 2 4819 466 98922 Casing
443 0 4819 515 28224 Fan wheel
451 0 4819 259 28767 Heating element FA
Pos. No. 12NC Code Description
451 1 4819 515 28223 Fan wheel FC
451 2 4819 532 28256 Washer for motor
452 0 4819 259 98385 Heating element quarz
452 1 4819 404 78841 Holder quarz tube
452 2 4819 458 58522 Reflector quartz tube
452 3 4819 418 79082 Cover bar
452 4 4819 532 58263 Washer
452 5 4819 532 58262 Washer ceramic
452 6 4819 505 18248 Nut
485 0 4819 321 18133 Cable HT
490 0 4819 321 18231 Cable,mains cpl.SA w.clamp
500 0 4812 214 78492 Control unit
500 9 4819 113 88001 Resistor 100 Ohm
505 0 4812 209 88008 Microprocessor
531 0 4812 101 08807 Potentiometer
561 0 4819 282 48247 Thermostat 145 ˚C
562 0 4819 282 48277 Thermostat 160 ˚C
564 0 4819 282 48275 Thermostat 165 ˚C
566 0 4812 282 48255 Thermostat FC 145 ˚C
571 0 4819 360 58589 Valve
571 1 4819 502 98002 Screw to valve FC
571 2 4819 360 58588 Valve
617 0 4812 280 68342 Relay 24V DC
617 1 4812 280 68349 Relay
622 0 4819 276 18273 Switch VKS
633 0 4812 271 38406 Microswitch
651 0 4812 134 18008 Lamp
651 1 4819 380 28017 Reflector
691 0 4819 210 78081 Sensor temp.
741 0 4819 462 79801 Cover
741 1 4819 466 89243 Heat shield FC
741 2 4819 532 68722 Shaft seal for motor
741 3 4819 418 79213 Cover FC
743 0 4819 458 58527 Air guide grill
770 0 4819 462 79803 Cover
770 1 4819 462 79797 Air guide
770 2 4819 462 38742 Air guide magnetron
770 3 4819 462 79798 Air guide
774 0 4819 462 79721 Cover upper
774 1 4819 462 79934 Cover lower
774 3 4819 530 28914 Conveyor
900 0 4812 404 78409 Holder capacitor
900 1 4819 492 68729 Clip
900 3 4819 492 68558 Clip,fix
900 4 4819 502 18374 Screw for magnetron,not shown
901 9 4819 453 49874 Recipe guide General
901 9 4819 453 49875 Recipe guide Europe
971 0 4819 252 28125 Fuse T10A
971 1 4819 256 38016 Bracket for fuse
972 0 4812 452 28129 Fuse T160mA

SERVICE Whirlpool Europe MD 364/BL 10.10.2000 / Page 5
Customer Service 8538 231 99491 Doc. No: 4812 714 13614
Exploded view

SERVICE
10.10.2000 / Page 6 MD 364/BL Whirlpool Europe Doc. No: 4812 714 13614 8538 231 99491 Customer Service
Wiring diagram
1120 Cavity lamp
1130 Thermostat cavity
1140 Thermostat magnetron
1170 Thermostat hot air
1180 Heating element grill
1190 Heating element hot air
1305 Sensor temperature
2000 HT capacitor
5000 HT transformer
6000 HT diode
OVEN IN OFF POSITION
WITH DOOR CLOSED
BL Blue
BLK Black
BR Brown
GY Grey
RD Red
WT White
YW Yellow
Y/G Yellow-Green
1003 Control system
1010 Magnetron
1020 Fuse T10A
1030 Mainsfilter
1040 Doorswitch secondary
1050 Doorswitch monitor
1060 Doorswitch primary
1070 Motor fan
1075 Motor hot air
1080 Motor turntable

SERVICE Whirlpool Europe MD 364/BL 10.10.2000 / Page 7
Customer Service 8538 231 99491 Doc. No: 4812 714 13614
Program diagram