WINAM PLAY GS-W5002 Installation and operating instructions

INSTALLATION & MAINTENANCE INSTRUCTIONS
Ages: 6 to 12 years
Capacity: 17 children
Size: D: 24' 7" / 7. 50m
H: 4' 11" / 1. 50m
Use zone: D: 34' 5" / 10. 50m
Figure-1: Completed Net
Features
The GS-W5002 features GS Web technology which includes
the highest steel content and the strongest connection materials
in the industry, including a steel-wire core in our edge ropes
and connection points crushed in place with over 75 tons
of preasure to ensure long life of the games and maximum
safety for the children.
GS Web Nets help bring movement, balance,
exercise and fun back into the playground.
WINAM GROUP
The series is a specialty climbing structure featuring
a flexible center area surrounded by netting. It is made of
steel-loaded Nylon cables with UV guard and the landing
surface is a textile-reinforced flexible rubber material.
NET JUMPER MODEL NO.
GS-W5002
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Safety area and Fall Height zone
Figure-2: Install and safety area
Metric/Imperial conversion:
3700mm = 12' 1-3/4"
6100mm = 20' 0-1/4"
11160mm = 36' 7-1/4"
Safety area
The requirements for space and safety clearances are taken from
BS-EN 1176-1/ ASTM-F1487/ CSA Z614
The use zone for stationary play equipment shall extend no less than
72 in.(1830mm) from all sides of the play structure.
Fall Height :1500mm (from surface)
The Fall height on the extennal surface of a pyramid shaped space net
is the highest point attainable on the edge of the structure where an unimpeded fall to
the protective surface is possible. This height is based on the centre of gravity height
of the maximum user.
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Foundation Information
Level Line
P1
P2
Wet concrete
Dry concrete
surface layer
Finished ground
Pole
P1 = Depth below finished Grade (12" / 300mm)
P2 = Depth of concrete footing (19-2/3" / 500mm)
Figure-3: Foundation section view
Foundation
Please refer to GS-W5002 drawing for exact installation dimensions
Figure-4: Excavate enough materials
to allow for proper depth of concrete
footings
Also ensure that there is enough space to
allow the frame to be positioned properly.
Anchor wood support frame to ground with
pickets to prevent the frame from moving
while concrete is poured and sets.
Finished Grade
(Optional)
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002
2000
950250100
600
500 200
4
Foundation Layout
Positioning Anchor plate on footing
[CF] 'L" anchor hole
Front edge of anchor plate must be installed
4" / 100mm from edge of concrete footing.
Figure-5: Concrete footing
and Anchor plate Layout
Note: Total distance from
front of block to front of
block is 11' 5-3/4" (3500mm)
Metric/Imperial conversion:
1750mm = 5' 8-7/8"
3500mm = 11' 5-3/4"
3750mm = 12' 3-5/8"
7500mm = 24' 7-1/4"
Metric/Imperial conversion:
100mm = 4" 950mm = 3' 1-3/8"
250mm = 9-7/8" 2000mm = 6' 6-3/4"
600mm = 1' 11-1/2"
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002
250
190
30 30 530
200100 200 30
200
150
5
Concrete Foundation
Concrete
Pour concrete* into wooden support frame until flush to top edge
Allow 3-5 days for concrete to cure before proceeding to next step.
*Concrete is to be wet concrete with minimum 25 MPA.
Remove wood support frame from dry concrete blocks
After concrete has cured enough, remove frame and replace soil
in area around footing to subgrade level
Figure-6: Concrete footing
Assemble wooden support frames *
4 frames (78-3/4" / 2000mm L x 23-2/3" / 600mm W x 19-2/3" / 500mm H)
*Use ½" (min) plywood; not included in package
NOTE: Use anchor plate as guide for exact
measurements.
Metric/Imperial conversion:
1750mm = 5' 8-7/8"
3500mm = 11' 5-3/4"
3750mm = 12' 3-5/8"
7500mm = 24' 7-1/4"
Metric/Imperial conversion:
25mm / 30mm = 1" 200mm = 7-7/8"
100mm = 4" 250mm = 9-7/8"
150mm = 6" 600mm = 1' 11-1/2"
190mm = 7-1/2"
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Post Plate and Anchor Plate Assembly
Figure-7: Attach Anchor plate to footing
with flat washer, locking washer and nut.
Plate Assembly
Concrete block-clean threads of "L" anchor bolts.
Attach Anchor plate to footing
Metric/Imperial conversion:
350mm = 1' 1-3/4"
700mm = 2' 3-1/2"
950mm = 3' 1-1/2"
1850mm = 6' 0-7/8"
2100mm = 6' 10-3/4"
3050mm = 10'
3650mm = 11' 11-3/4"
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Main rope Assembly
M22 X L110 H/T Bolt
STEP-1
Figure-8: Attach Turnbuckle and rope
Main rope assembly
Step 1: Attach bottom rope with M22 X L110 H/T BOLT as
shown in Figure 9
Step 2: Attach Turnbuckle to anchor plate
with M22 X L110 H/T BOLT.
Loosen Turnbuckle all the way (about 100mm), leaving
only 4 or 5 threads attached
Main Post Plate
Anchor Plate
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Post Assembly
Note: Rubber mallet
may be required to
insert cap into post.
Figure-9: Post cap assembly.
Figure-10: Post assembly.
STEP-3
Post assembly
Step 3: Attach Post Cap to Post (Figure 10)
Step 4: Attach Post to Post base with M22 X L80 H/T BOLT
(Figure 11)
A B C B
C
M22 X L80 H/T BOLT
AB
STEP-4
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Attaching Turnbuckle to Anchor Plates
It is strongly recommended
that 3-4 workers lift the net into place.
Figure-11: Tightening Turnbuckles
(a)
(b)
Tighten Rope with Turnbuckles at the Same time
Tighten Rope with Turnbuckles at the Same time
(a) + (a)
(c) + (c)
NOTE: Make sure post is level before tightening and remains level during process.
(b)
(c)
(c)
Tighten Rope with Turnbuckles at the Same time
(b) + (b)
(a)
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002
Figure-12: completed Net
Tensioning & Maintenance information
Maintenance information
Please tighten rope with Turnbuckle properly.
If you strain the net too much, it may cause damage.
It is also recommended that subsequent checks on tension
should be carried out at monthly intervals and adjusted as required.
This will increase the overall longevity of the product.
Checking: 1 month
Refer to IPEMA and TUV maintance system.
After Net structure tension is completed, the net will
stretch slightly over the first four weeks of use.
Following this initial period, the net needs
to be fully re-tensioned by Turnbuckle
after 1 year.
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002PARTS LIST
1: Main post
2: Multi compound rope
3: Post cap
4: Turnbuckle
5: H/T bolt, nut, washer (for Main Post Plate)
6: H/T bolt, nut, washer (for Anchor Plate)
7: Main Post Plate
8: Anchor plate
9: L-anchor bolt, nut, washer
1
2
9
5
8
6
4
7
3
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Maintenance Installation
A weekly check of the activity net is recommended to ensure
that no acts of vandalism have damaged the rope.
Periodic checks on tension will assist in the durability of the product.
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Maintenance
A. General safety measures
On the playground there should be a sign(pictogram) giving the following information:
a) general emergency telephone number;
b) telephone number to contact maintenance personnel;
c) name of the playground;
d) address of playground; and
e) other relevant local information, if applicable.
The entry, exit and emergency paths to and from a playground, intended for use by the public and emergency services, should be accessible and free of
obstacles at all times.
NOTE Attention is drawn to local regulations.
B. Procedures
Defects that occur during operation and which put safety at risk should be corrected without delay. If this is not possible, the equipment should be secured
against use e.g. by immobilization or removal.
There should be written operational procedures covering the measures to be taken in the event of accidents, fire and the like.
Until unsafe equipment is repaired and released for use, access by the public should be prevented. Information about accidents brought to the attention of
the manager should be recorded on a form that includes the following details:
a) date and tie of accident;
b) age and sex of victim and clothing worn, Including footwear;
c) equipment involved;
d) number of children on site at the time of the accident;
e) description of accident;
f) injury sustained including part(s) of body affected;
g) action taken;
h) witness statements;
i) any subsequent equipment modification;
j) weather conditions; and
k) any other relevant information.
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam

NET JUMPER MODEL NO.
GS-W5002Maintenance
C. Routine maintenance
To reduce accidents, the owner or operator should ensure that an appropriate routine maintenance schedule is established, implemented and maintained.
This should take into account local conditions and the manufacturer's instructions that can affect the necessary inspection frequency. The schedule should
list the components to be maintained and should also give procedures for dealing with complaints and breakdowns.
The routine maintenance of playground equipment and surfaces should consist of preventative measures to maintain their level of safety, performance and
compliance with the relevant part(s) of EN 1176. Such measures should include:
a) tightening of fastenings;
b) re-painting and re-treatment of surfaces;
c) maintenance of any impact attenuating surfaces;
d) lubrication of bearings;
e) markig of equipment to signify loose fill finished surface level;
f) cleaning;
g) removal of broken glass and other debris or contaminants;
h) restoring loose fills to the correct level; and
i) maintenance of free space areas.
D. Corrective maintenance
Corrective maintenance should include measures to correct defects, or th re-establish the necessary levels of safety of the playground equipment and
surfaces. Such measures should include:
a) replacement of fastenings;
b) welding of welding repairs;
c) replacement of worn or defective parts; and
d) replacement of defective structural components.
E. Personal safety
Repairs during operation that could put the safety of maintenance personnel of the public at risk, should be avoided.
F. Equipment alterations
Alterations to parts of a piece of equipment or structure that could affect the essential safety of the equipment should only be carried out after consultation
with the manufacturer or a compete person.
WINAM GROUP
WINAM GROUP
E-mail) [email protected]
Tel) (028) 22 494 333
Web site) www.playground.com.vn
Room 101, 226/4A Le Trong Tan, Tay Thanh
ward, Tan Phu district, Ho Chi Minh city, Viet Nam