Acer aHornet Aspire R3600 User manual

I
aHornet Aspire R3600
Service Guide
Service guide files and updates are
available on the AIPG/CSD web; for
more information please refer to
http://csd.acer.com.tw
PRINTED IN TAIWAN

II
Revision History
Please refer to the table below for the updates made on aHornetAspire R3600
Service Guide.
Date Chapter Updates

III
Copyright
Copyright © 2007 by Acer Incorporated. All rights reserved. No part of this publication may be
reproduced, transmitted, transcribed, stored in a retrieval system, or translated into any language
or computer language, in any form or by any means, electronic, mechanical, magnetic, optical,
chemical, manual or otherwise, without the prior written permission of Acer Incorporated.
Disclaimer
The information in this guide is subject to change without notice.
Acer Incorporated makes no representations or warranties, either expressed or implied, with
respect to the contents hereof and specifically disclaims any warranties of merchantability or
fitness for any particular purpose. Any Acer Incorporated software described in this manual is
sold or licensed "as is". Should the programs prove defective following their purchase, the buyer
(and not Acer Incorporated, its distributor, or its dealer) assumes the entire cost of all necessary
servicing, repair, and any incidental or consequential damages resulting from any defect in the
software.
Acer is a registered trademark of Acer Corporation.
Intel is a registered trademark of Intel Corporation.
Pentium 4 and Celeron are trademarks of Intel Corporation.
Other brand and product names are trademarks and/or registered trademarks of their respective
holders.

IV
Conventions
The following conventions are used in this manual:
SCREEN
MESSAGES
Denotes actual messages that appear on screen.
NOTE Gives bits and pieces of additional information
related to the current topic.
WARNING Alerts you to any damage that might result from
doing or not doing specific actions.
CAUTION Gives precautionary measures to avoid possible
hardware or software problems.
IMPORTANT Remind
y
ou to do s
p
ecific actions relevant to the
accomplishment of procedures.

V
Preface
Before using this information and the product it supports, please read the following general
information.
1. This Service Guide provides you with all technical information relating to the BASIC
CONFIGURATION decided for Acer's "global" product offering. To better fit local market
requirements and enhance product competitiveness, your regional office MAY have decided to
extend the functionality of a machine (e.g. add-on card, modem, or extra memory capability).
These LOCALIZED FEATURES will NOT be covered in this generic service guide. In such cases,
please contact your regional offices or the responsible personnel/channel to provide you with
further technical details.
2. Please note WHEN ORDERING FRU PARTS, that you should check the most up-to-date
information available on your regional web or channel. If, for whatever reason, a part number
change is made, it will not be noted in the printed Service Guide. For ACER-AUTHORIZED
SERVICE PROVIDERS, your Acer office may have a DIFFERENT part number code to those
given in the FRU list of this printed Service Guide. You MUST use the list provided by your
regional Acer office to order FRU parts for repair and service of customer machines.

VI
Chapter 1 System Specifications 1
Features……………………………………………………………………………………………... 1
Block Diagram…………………………………………………………..………………...………..4
Aspire R3600 side cover…………………..…………………………….……………………5
Aspire R3600 Rear Panel…………………..…………………………….……………………6
Hardware Specifications and Configurations………………….…….……..7
Power Management Function (ACPI support function)…………………………..…...14
Chapter 2 System Utilities 15
Entering Setup…………………………………………………………………………..16
Product Information………………………………………………………..18
Standard CMOS Features……………………………….……………………………………19
Advanced BIOS Features………………………………………..……………………21
Advanced Chipset Setup…………………………...…………………………………………..22
Integrated Peripherals…………………………...…………………………………………..23
Power Management…………………………………………………………24
PC Health Status……………………………………………………………...25
Frequency/Voltage Control……………..………………………….…….26
BIOS Security Features………………………………………………..……. 27
Load Default Settings………………………………………………..……. 28
Save & Exit Setup………………………………………………….…………29
Exit Without Saving………………………………………………….……..30
Chapter 3 Machine Disassembly and Replacement 31
General Information………………………………………………………. 32
Disassembly Procedure……………………………………………………33
Aspire R3600 Disassembly Procedure…………….…..……34
Chapter 4 Troubleshooting 41
Chapter 5 Jumper and Connector Information 42
Jumper Setting…………………………………………………..………………..42
Chapter 6 FRU (Field Replaceable Unit) List 44
Exploded Diagram………………………………………………………….45

1
System Specifications
Features
Operating System
Microsoft Windows Vista Home Premium SP2
Microsoft windows Vista Home Basic SP2
Ubuntu Linux
Processor
Socket Type: None
Processor Type:
Intel Atom 230
TDP below 8W(include 8W)
Chipset
Nvidia MCP7A-ION
PCB
170mm*170mm (Proprietary)
Memory
Memory Type: DDRII SO-DIMM 667/800
Support single channel 64 bit mode with maximum memory size up to 4GB
Support SO- DIMM (MCP7A-ION)
DIMM Slot: 2
Memory Max: 512MB to 4GB DDRII memory technologies
Capacity: Up to 2GB per DIMM with maximum memory size up to 4GB
PCI
Mini PCIe interface via mini card slot
Slot Quantity: 1
SATA
Slot Type: SATA slot ( Default AHCI mode )

2
Slot Quantity: 1
One eSATA support on front
Audio
Audio Type: HD audio codec
Audio Channel: 7.1 channel
Audio Controller /Codec: ALC662
Connectors support:
Audio jacks color coding: should meet Microsoft Windows Logo Program
Device Requirements: Audio-0002
Front 2 jack follow HD audio definition
S/N ratio: 90 dB at rear output jack
LAN
MAC Controller: MCP7A-ION
Should be worked under 10M/100M/1000Mbs environment
PHY: Intel 8211CL
USB
Controller Type: MCP7A-ION
Ports Quantity: 8
4 back panel ports
2 ports for front daughter board
Connector Pin: standard Intel FPIO pin definition
Data transfer rate support:
USB 2.0/1.1
BIOS
BIOS Type: AMI Kernel with Acer skin
Size: 8Mb
Note:
Boot ROM should be included (PXE function should be built in with default

3
and RPL function is optional by service BIOS)
Rear I/O Connector
1 HDMI port
1 D-sub port
4 USB ports
1 DC-in Jack
1 RJ45 port
1 Kensington lock
On-board connectors
2 DDRII SO-DIMM memory sockets
1 Mini PCIe slot
1 SATA connectors
Board to board design for Power Switch, Power Indicator and 2*USB 2.0
audio connector one line-out and one MIC
1 5V power ports for HDD
1 4 pin CPU Fan connector
1 3 pin clear CMOS header
1 on board buzzer
Color management for on board connecter
Power Supply
Adapter Mounting Features
Universal AC adapter, 90~264V AC, 47~63HZ
3-pin 65W with 19VDC output
Small DC jack

4
Block Diagram