Alva GDH200 User manual

• THIS IS A LOW PRESSURE APPLIANCE TO BE USED
ONLY WITH A 2.8kPa SANS 1237 APPROVED REGULATOR AND
SANS 1156 APPROVED HOSE, BOTH NOT INCLUDED.
• FOR YOUR OWN SAFETY, PLEASE READ THIS MANUAL
CAREFULLY AND ALWAYS OPERATE THIS PRODUCT
ACCORDING TO THE INSTRUCTIONS
• IT IS ILLEGAL AND DANGEROUS TO CHANGE OR MODIFY
ANY PART OF THIS APPLIANCE
APPROVED FOR USE IN
SOUTH
AFRICA
/AlvaGas
GLASS
GASHOB
Manufactured for
and distributed by:
TOLL FREE NUMBER: 086 100 ALVA (2582)
|[phone] [e-mail] | www.alva.co.za
A division of Stingray Accessory Manufacturers (Pty) Ltd | .O. Box 30014, Tokai, 7966P
GDH200 60cm
GDH201 90cm
GDH202 30cm
/alvagas

IMPORTANT SAFETY INFORMATION
• Read these instructions carefully before using your gas hob.
• The operator must understand all safety requirements as
detailed in this manual before using the unit.
• The operator is responsible for the safety of all third parties
while the hob is in use.
•
use of this product.
•
• Failure to follow the manuals instructions could result in
damage or serious injury.
• When this appliance is to be permanently installed the
who is registered with LPGSASA and that such installations
should comply with the requirements of SANS 10087-1 or
SANS 827 as applicable.
•
contact the manufacturer.
•
•
surface before operating.
•
•
• This appliance is not intended for operation with an external
•
•
• DO NOT place or use aerosol sprays near the hob.
•
LPG
•
•
when it is in use.
• Keep children and animals well away while the hob is in use.
• Parts of the hob will get extremely hot and could cause
•
should remain at the appliance at all times when it is alight.
• Ensure that the gas supply is turned OFF after use and
while the hob is unattended.
• Do not clean or maintain the appliance before it has been
switched off and is cool to the touch.
Thank you for your
purchase of this gas
hob.
Please read these
instructions carefully
before use and keep
them in a safe place
for future reference.
See installation section
on pages 5 - 7 for
more information

•
•
this appliance.
•
should not be allowed to use or play with this appliance.
• Keep children clear of this appliance while in use.
• Neither the Manufacturer nor their Agents can accept any
•
for commercial or professional use. This appliance is only
•
damage.
•
this appliance.

KEY
Notes marked with the
following;
Contain important
information.
Notes marked with the
following;
Contain cautions and
warnings.
INDEX
INDEX
WARRANTY
GENERAL INFORMATION
CONFIGURATION
CONTROLS
INSTALLATION
LEAK TEST
FITTING AND CHANGING THE GAS CYLINDER
OPERATING INSTRUCTIONS
FLASHBACK
CLEANING AND MAINTENANCE
TROUBLESHOOTING GUIDE
SPECIFICATIONS
AFTER SALES SERVICE
3
3
4
4
5 - 7
8
8 - 9
9 - 11
11
11 - 13
13 - 14
14 - 15
16

3
WARRANTY
PLEASE RETAIN YOUR PROOF OF PURCHASE FOR
WARRANTY CLAIMS.
ALVA warrants this appliance to be free of defects in material and
quality for a period of 12 months from date of original purchase.
unauthorized repair will not be warranted.
return the appliance to the retailer from whom it was purchased.
[e-mail]
GENERAL INFORMATION
according to these instructions.
your proof of purchase.
can obtain a new copy from your dealer or online at
Read Important Safety
Information at the
beginning of this
manual.
Not using gas and
or gas appliances
according to the
instructions is
extremely dangerous
and can lead to
property damage,
injury or death.

4
CONFIGURATION
CONTROLS
CONTROLS
Burner off position
Highest power setting and automatic ignition
Lowest power setting
Cast Iron Pan Supports
Control Knobs
Auxiliary Burner 1.0kW max ø55mm
Semi Rapid Burner 1.75kW max ø75mm
Rapid Burner 3.0kW max ø100mm
Wok Burner 3.3kW max ø130mm
GDH200, 60cm 4 burner hob
Pmax 7.8kW
GDH201, 90cm 5 burner hob
Pmax 10.8kW
GDH202, 30cm 2 burner hob
Pmax 4.95kW
Make sure that the
place you choose to
install the appliance
has easy access to
adequate ventilation.
Open a window
when the appliance
is operational for long
periods of time.
1
2
3
4
5
6
1
2
6
4
1
3
5
2
4
46
1
4
6
4
3
2

INSTALLATION
This appliance is designed for use with LPG ONLY. When this
appliance is to be permanently installed the installation should
LPGSASA and that such installations should comply with the
requirements of SANS 10087-1 or SANS 827 as applicable.
•
of the appliance and for the safety of the occupants in the
room in which the appliance is installed.
•
account of these characteristics.
• Surfaces of cabinets immediately adjacent to the hob should
be able to withstand temperature of up to 100°C without
delaminating or discolouring.
•
appliance.
•
are near the gas hob.
• Allow an unrestricted air space of at least 150mm at the
5
install the gas hob
4 BURNER HOB
2 BURNER HOB
5 BURNER HOB Note: This appliance is
designed for use with
a 2.8 kPa SANS 1237
regulator with SANS
.esohdevorppa2-6511
Using any other type
of regulator or hose is
extremely dangerous.
Regulator and hose
sold separately.
550mm
510mm
470mm
590mm
480mm
838mm
870mm
510mm
310mm
475mm
510mm
275mm

6
After installation the space under the hob must be at least 30mm.
The distance between the hob and the wall must be at least 35mm.
If an extractor hood is to be used the distance between the top of
the gas hob and the bottom of the hood must be at least 650mm.
•
•
•
•
gas bottle.
should be an insulation layer between the appliances bottom and
other components.
sealing strip must be attached to the underneath of the lip of the
under the hob.

NOTE: After installing and connecting the hose to the hob and
PERMANENT INSTALLATION
Failure to comply with the above will
render the warranty invalid.
installed appliance be sure that you fully understand:
1.
line to the hob.
2. The requirements for safe operation of the hob.
GAS:
(1) This appliance is designed for use only with LP gas.
(2) Important:
(3) Replace a Jet:
7
CLAMP
AND HOSE
NOZZLE

8
Foamy
bubbles
indicate a
leak
Connection
in assembly
LEAK TEST
• With the cylinder connected
•
equal parts soap and water
• A stream of bubbles forming
picture on left
•
and disconnect the hob from
the gas cylinder.
• Tighten the connection and
• If you are unsure or if you
place the cylinder outside in a
086 100 ALVA
(2582).
•
cylinder can lead to a high
dangerous and can result in
PRECAUTIONS
Leak test all
connections after each
tank refill.
NEVER check for
leaks with a match or
open flame.
Any LP Gas cylinder
not connected for use
must not be stored in
the vicinity of this or
any other appliance.
Connections to be leak tested
Regulator into cylinder
Hose to regulator
Hose to appliance
FITTING AND CHANGING THE GAS CYLINDER
1.
always ensure that the rubber seal on the Regulator is in
2.
other people.

9
DO NOT store or use
gasoline or other
and liquids in the
vicinity of this or any
other appliance.
screw the regulator onto the cylinder until it is fully engaged.
Hand-tighten only.
cannot be tampered with.
OPERATING INSTRUCTIONS
Insert 1 x D size battery in the battery compartment. This is the
power source for the automatic ignition.
AUTOMATIC IGNITION
The hob has an automatic ignition system.
1.
2.
before releasing.
3.

least 1 minute.
COOKING PANS
Use pans which are the
right size for each burner.
Do not use small pans on
must not touch the sides of
the pan.
10
and open a window or the door to the room. Wait at least one
minute before switching the burner on again.
NOTE: It is important to keep the appliance clean. If the
ignition electrodes are dirty, this may cause ignition
problems. Clean the ignition electrodes regularly with a
small, non-metallic brush. Take care to prevent the ignition
electrodes from sustaining any heavy knocks.
FLAME FAILURE DEVICE
Your hob is equipped with a safety system that cuts off the gas
will extinguish.
WARNING - RISK OF DEFLAGRATION
FOR YOUR SAFETY
IF YOU SMELL GAS
• Turn off the gas
supply at the
cylinder.
• Extinguish all
DO NOT operate
any electrical
appliances.
• Ventilate the
area.
• Check for leaks
(see LEAK TEST)
• If odour pesists,
contact your
dealer or local
gas supplier
immediately.
SWITCHING ON MANUALLY
1.
2.

CLEANING & MAINTENANCE
11
GENERAL
• Allow the hob and burners to cool down completely before
cleaning.
•
cleaners on any part of the hob.
• Frequent cleaning is recommended rather than an
EXTERIOR
•
allow easy access to the hob panel.
Place the pans on the pan
the burner. Pans should be
placed on the hob carefully.
Do not place large pans on
the burners near the control
temperature.
DO NOT use large
pots which may over
hang the body of this
hob.
DO NOT use pot
scourers or abrasive
this hob as these will
permanently mark the
hob.
•
•
few minutes.
• -
•

•
cloth.
• Rinse and dry well.
•
as possible as these may etch into metals if left unattended.
•
many years.
•
•
supports in a dishwasher.
CONTROL PANEL
•
• Wipe the control panel with a damp cloth and dry with a dry
lint free cloth.
•
IGNITION ELECTRODE & FLAME FAILURE SENSOR
•
12
Burner cap
Flame ring

13
PLACE THE BURNER CAP CORRECTLY
NOTE:
TROUBLE SHOOTING GUIDE
TROUBLE CAUSE REMEDY
Burner does not
ignite
•
is closed
• Hose is bent
• No gas supply
• Electronic
ignition is wet
• Battery is dead
•
• Straighten or
replace hose
• Replace gas
cylinder
• Clean and dry
ignition
• Replace battery

14
TROUBLE SHOOTING GUIDE
Strong gas
odour
•
hose
• Hose is
damaged
• Burner is not lit
• Examine hose
using soap
replace hose .
• Replace it
• Re-ignite burner
Combustion is
abnormal
•
supply
• Flame ports are
clogged
• Burner is not
in its correct
position
• Replace gas
cylinder
•
ports
• Place burner
components
in the right
position
If you are still unable
to correct the problem
with the information
in this guide, then
you need to contact
your nearest dealer or
manufacturer.
SPECIFICATIONS
Model GDH200
Description 60cm 4 Burner Gas Hob
Gas LPG
Ignition system
1 x D Battery
Jet Size 0.5mm x 1 - Auxiliary
0.62mm x 2 - Semi rapid
Gas consumption at Max 73g/h - Auxiliary burner
127g/h - Semi rapid burner
or property damage.
on this appliance.

15
Model GDH201
Description 90cm 5 Burner Gas Hob
Gas LPG
Ignition system
1 x D Battery
Jet Size 0.5mm x 1 - Auxiliary burner
0.62mm x 2 - Semi rapid burner
0.72mm x 1 - Rapid burner
Gas consumption at Max 73g/h - Auxiliary burner
127g/h - Semi rapid burner
204g/h - Rapid burner
or property damage.
on this appliance.
Model GDH202
Description 30cm 2 Burner Gas Hob
Gas LPG
Ignition system
1 x D Battery
Jet Size 0.62mm x 1 - Semi rapid burner
Gas consumption at Max 127g/h - Semi rapid burner
or property damage.
on this appliance.

AFTER SALES SERVICE
MANUFACTURED FOR AND DISTRIBUTED BY
P.O. Box 30014
Tel: [phone]
E-mail: [e-mail]
TOLL FREE NUMBER 086 100 ALVA (2582)
Should you experience
problems with this gas hob,
carry out the necessary
checks as per the Trouble
Shooting Guide. If you are
still unable to correct the
problem with the information
in this guide, then you
need to contact your nearest
dealer or manufacturer.