Arsenal CS-AW8040 User manual

ARSEnAL
SUBWOOFER
CAISSON DE GRAVE
CS-AW8040
JVC
CS-AW8240
For Customer Use:
Enter below the Model No, and Serial
No, which
is located either on the rear
or bottom
of the speaker unit. Retain
this information for future reference.
Model No.
LVT1742-001A
INSTRUCTION MANUAL L...::s=eri=al N=O.========~
MANUEL D'INSTRUCTIONS
MANUAL
DE INSTRUCCIONES

3. Jump
2. Screw x10
Parts
Thank you for purchasing the ARSENAL Car Stereo Speaker. These Speakers can be
mounted
in the trunk of your vehicle. For the secure installation and perfect operation
of your speakers, please read the following carefully.
1. Grille
4. Fuse (10A) x 2
5. Hexagon socket
screw keys
For proper installation and use
1.Before connecting the speakers to the amplifier, confirm that the power has been
turned off. The click noise generated by the connection if the power
is on may
damage the speakers.
2.The amplifier and speakers should be connected between corresponding terminals,
i.e. left to left, and right to right, as well as "+" to "+", and "_" to "_". Connection with
reversed polarity will degrade the quality of stereo reproduction.
3. Do not subject the speakers to excessive input. The power handling capacity of the
CS-AW8240/CS-AW8040 is 1000 watts (R.M.S. MUSIC POWER). Any excessive
input may damage the speakers.
4.The CS-AW8240/CS-AW8040 has
an impedance of 20,40,80. Make sure that the
output impedance of the amplifier's speaker terminal
is rated at 20,40,80.
5.When cleaning the speakers, use asoft cloth and wipe the surface gently. Do not
apply thinner or solvent.
- 2 -

Dual 4n Application Diagrams
JUMPER JUMPER
~
InfMII BI-Amp """"
+ -4 Only .+ -
0000
SERIES PARALLEL
( 6nld Jodwnr • ]
1 Mono Amplifier
1Subwoofer
Jumper
set to Parallel
80(40+40) Load
40
SERIES PARALLEL
[ • Jumper Plug]
E3E3
Input Bi.......p Input
-+ _4OnI)'.+ _
0000
1 Mono Amplifier
1Subwoofer
Jumper
set to Series
80(40+40)
Load
SERIES PARALLEL
Bi-Amp Configuration 2 Mono Amplifiers
1Subwoofer Jumper
is Removed 40 Load
SERIES PARALLEL
Stereo
G
:~~----~y
8
1 2ch Amplifier
1Subwoofer
Jumper
is Removed
40 Load
JUMPER JUMPER
40 80 40
ISERIES PARALLEL
( • Jumper Plug) I
'E3E31
\-
"- ," ...
1,0 (r"O 0
I: SERIES PARALLEL
II ( • Jumper PlUg]
E3F=3
\1
- ,,- -
6 (cf"o 0
Mono ,r--- c- --. ",.--.
40 80 40
G
40
8---- ... - ---,-
1 Mono Amplifier
2Subwoofers
Jumper
set to Series
Subwoofers
wired in Parallel
40 Load
JUMPER JUMPER JUMPER
JUMPER
SERIES PARALLEL
( • Jumper PlUg]
I
E3E3
Input 81.".". InpuI
+ -4OnI)'''+ -
0000
JUMPER
IISERIES
PARALLEL
I ( • Jumper Plug )
I ,
1E3E3
Input IIht.mp Input
+ -4 Only Ho -
booo
JUMPER
,
I, SERIES PARALLEL
\ ( • Jumper Plug)
I "
~E3
l\
·... ,.;"- ," ...
+ -4Onrr.+ -
o ,0 0 0
Mono 1'--' r- -- r--
G 40 80 40 ... .; ... 40 80 40
8 2.60
JUMPER
1 Mono Amplifier
3Subwoofers
Jumper
set to Series
Subwoofers
wired in Parallel
2.60 Load
SERIES PARALLEL
( • Jumper Plug ]1
',
F=-lE---=l
~ ~r~ .. ~"!'"
10tQ(QQI
SERIES PARALLEL I
I( • Jumper P1"l1 ]
l'E3E3
1\\6~~o6i1
II
\
SERIES PARALLEL
( • :umpe: Plug JI
\~fliJ
Mono ",I"""-"-?=-=--"'=--=..,-==t~
C\ 4Q 80 40
I.!J 20
8---- ..... ---- .... ----- ...... ----~
1 Mono Amplifier
4Subwoofers
Jumper
set to Series
Subwoofers
wired in Parallel
20 Load
- 3 -

Front & Rear Baffle Boards (x 2)
A
~ Left &Right Sides (x 2)
CS-AW8040 CS-AW8240
A
15-13/32 inch (391.7 mm)
16-13/32 inch (417.1 mm)
B
15-13/32 inch (391.7 mm)
16-13/32 inch (417.1 mm)
C
11-29/32 inch (302.8 mm)
315.5 mm (12-13/32 inch)
D
9-4/32 inch (232 mm)
10-14/32 inch (275.9 mm)
E
9-23/32 inch (247 mm)
11-10/32 inch (295 mm)
F 4/32 inch (3 mm)
4/32 inch (3 mm)
•To install the sealed enclosure
When the speaker cannot be attached in the car, make the sealed enclosure as recommended in the table below-20 mm (3/4 inch) MDF
is also recommended for the enclosure materials.
•To install the ported enclosure
When the speaker cannot be attached in the car, make the sealed enclosure as recommended in the table below-20 mm (3/4 inch) MDF
is also recommended for the enclosure materials. CS-AW8040 CS-AW8240
A
14-13/32 inch (366.3 mm)
14-29/32 inch (379 mm)
B 18-13/32 inch (467.9 mm)
19-13/32 inch (493.3 mm)
C
14-13/32 inch (366.3 mm)
15-13/32 inch (391.7 mm)
D
9-23/32 inch (247 mm)
10-14/32 inch (275.9 mm)
E
9-23/32 inch (247 mm) 11-10/32 inch (295 mm)
F 4/32 inch (3 mm)
4/32 inch (3 mm)
Front & Rear Baffle Boards (x 2) G 1 inch (25.4
mm)
H 13 inch (330.2 mm)
1inch (25.4 mm)
14 inch (355.6 mm)
I13-19/32 inch (345.4 mm)
G
- 4 -
13-16/32 inch (342.9 mm)
Left &Right Sides (x 2)

Parameters CS·AW8040 CS-AW8240 NOTES
parallel series parallel series
Nominal Impedance ( )
40+40
40 +40
SPL (dB,1W/1M) 82.52 dB 82.65 dB
86.14dB 86.19 dB SPL :Sound pressure level
Displacement (Liter) 0.138
ft3
0.202 ft3
Hole Cutout Diameter (mm) Dia. 233 mm Dia. 277 mm
Hole Cutout Diameter (inch) Dia. 9 - 6/32 inch Dia. 10 -29/32 inch
Mounting Depth (mm) 175 mm 195.8 mm
Mounting Depth (inch) 6 - 28/32 inch 7 - 23/32 inch
Re ()
1.980 7.810 1.990 7.870 Re : DC voice coil resistance
BL (T.M) 7.69 15.19 8.73 17.47
BL :Product of Flux density and
Effective Voicecoil-wire length
Vas (Liter) 19.4 L19.9 L46.04 L46.1 L
Vas: Volume ofair equal to the driver
compliance
Vas (CuFt) 0.69
ft3 0.7 ft3 1.63 ft3 1.63 ft3
Me (g) 128.943 g126.267 9137.361 9137.381 9Me :Effective mass
D(cm) Dia.19.75
cm Dia. 24.15 cm D : Effective cone diameter
Fs (Hz) 39.5 Hz 39.4 Hz 35.5 Hz 35.5 Hz Fs :Driver free air resonance
Qms 9.244 9.295 8.404 8.401 Qms : Q of driver at Fs considering
only non-electrical resistance
Qes 1.068 1.057 0.799 0.79 Qes : Q of driver at Fs considering
only electrical resistance
Qts 0.957 0.948 0.73 0.722 Qts :Total Qof driver at Fs
Pe [max.) (W)
1000W 1000W
Pe[max.) :Maximum continuous input
power
Xmax.(mm) 17.05 mm 17.05 mm Xmax. :Maximum effective voicecoil
travel without distortion
Freq.Responce (Hz) 23
-500 Hz 20 -500 Hz
Magnet Mass (g) 2140.95 92926.8 g
Maqnet Mass (oz)
75.520z 103.240z
Voice Coil(Aluminum)Dia.(mm) Dia. 80.54 mm Dia. 80.54 mm
Voice Coil(Aluminum)Dia.(inch) Dia. 3 - 5/32 inch Dia. 3 - 5/32 inch
Hvc (mm) 44.1
mm 44.1 mm Hvc :Voice coil Height
Hag (mm)
10 mm 10 mm Haa :Gao Heiaht
- 5 -

( Santoprene Surround 1
Air Vented
Aluminum
Cast Basket
Integlated Dual-Layer
Cone construction
Woven Tinsel Lead
(Patent Pending)
Rapid Fire Impedance
Selector Speaker Terminal
( Patent Pending)
[4 (2+2) Layer Voice Coils 1
[Heat Transfer Silicon 1
[ Aero Vent Bottom Plate 1
T3 Chassis (Thermal Transfer Technology)
Aluminum Voice
Coil Former
Dual Stacked
Strontium Magnet
Oia. 10-14/32 inch [26S
rn
ml
Oia. 10-26/32 inch [275 mm]
-- ------------------
[)~c9.-4/32inch[23196 mm]
CS-AW8040
I
--~
J
E
E
'" I'-
-14 -
Oia. 12-12/32 in~J3.14.-rTlmJ_
______ ~a 12-24/32_inch[ 324 m"'.1
,-~~I
c- Oia. 10-28/32 inch [275.94 mm lJ
CS-AW8240
E
E
Ol
"' N
'"
E
E
<Xl
.,;
'"

./
~
...
.. ..
.. ./
/'
/
/
/
/ ./
/~
I
I\\\\
"-
" #
"-
'....... /"'"
......... ----------
\
/'
/
\
/~ \
\\I
~
I
\,<........
I
'-
~
I
'---
"",
/
-?
/'
/'
/'
/_----=:::::'
, <
,
-15 -

TO OUR VALUED CUSTOMER --
THANK YOU FOR PURCHASING THIS JVC PRODUCT.
WE WANT TO HELP YOU ACHIEVE APERFECT EXPERIENCE.
NEED HELP ON HOWTO HOOK UP?
NEED ASSISTANCE ON HOWTO OPERATE?
NEEDTO LOCATE AJVC SERVICE CENTER?
LIKE TO PURCHASE ACCESSORIES?
JVC®IS HERETO HELP!
TOLL FREE: 1(800)252-5722
http://www.jvc.com
Remember to retain your Bill of Sale for Warranty Service.
--- Do not attempt to service the product yourself
Caution
To prevent electrical shock, do not open the cabinet.
There are no user serviceable parts inside.
Please refer to qualified service personnel for repairs.
~ EN, FR, SP
©2007 Victor Company of Japan, Limited Printed
in China

Thank you for purchasing
Instructions
Fold so opening is at the top.
Tape in middle or on front.
Please do not send products or other
correspondence to this address.
JVC AMERICAS CORP
1700 Valley Road
Wayne, NJ 07470
307C
JVC®
PO BOX 9580
PEORIA IL 61612-9580
II I II
PLACE
FIRST-CLASS
STAMP
HERE
1.11"".11.11","11,,1,11,1",1.1,1"1,11,"1"1.11.,,,1.,11
PRODUCT REGISTRATION CARD/QUESTIONNAIRE
I us CUSTOMERS ONLY I
Registering your product will allow us to contact you in the unlikely
event aproduct safety notification is required.
This form is for Product Registration purposes only. Failure to return
this form does not diminish your rights during the warranty period.
THANK YOU FOR PURCHASING THIS JVC PRODUCT
REGISTER ONLINE AT: WWW.JVC.COM

.Ive" Product Registration
First Name:
Last Name:
Address:
Apt#"
City:
State:
Zip:
Phone:
Email Address:
IMPORTANT: Please fill-out and return in
10days or Log to JVC.com
and register On-Line
Thank you! We appreciate your responses to this questionnaire.
The information you choose to share with us will be used by JVC to offer you
product information and other communications that may interest you.
If you prefer not to be contacted about these special offers, please check here. { }
Date of Purchase
Model Number
Serial Number
Purchase Price
Dealer
1) Did you:
-Purchase this product your self?
-Receive this product as agift?
2) Is this Product:
-The first product of this type you have ever owned?
- A replacement for asimilar JVC product?
- A replacement for asimilar product made
by another
company?
-
An addition to asimilar product you are still using?
3) What factors most influenced your
decision to purchase this product?
-JVC brand reputation
-Previous experience with JVC products
-Price
-Specific product features
-Style/appearance
-Salesperson's recommendation
-Friend/relative's recommendation
-Warranty coverage
-Other
4) How did you learn about this product?
-Magazine Advertisement
-Newspaper Advertisement
-TV/Radio Announcement
-Product Brochure
-Direct Mail
-Mail Order Catalog
-Friend/Relative Recommendations
-Salesperson/Store Recommendation
-Internet
-Dealer Event
-Other
BT-51041-1
(0406)
5) Your Gender:
-Male
-Female
6) Your Marital Status
-Married
-Single
7) What is your approximate annual
household income level?
-Under $25,000
-$25,000 -$49,000
-$50,000 -$74,000
-$75,000 -$99,000
-$100,000 and over
Comments:
JVCThanks you for completing this
questionnaire.
Your responses will help us reach you with
offers that mayinterest you.
If you prefernot to receive these offers
please check here { }
Printed in China