Beltane Stoves FW5C HOLFORD User manual

Beltane Stoves
Eurostove Limited
Unit H1, Mendip Industrial estate,
Mendip road, Rooksbridge.
Somerset
BS26 2UG
Beltane
HOLFORD

2

Section Page No
1. List of components 4
2. Component Identification and Assembly 4
3. Installation Instructions 5
3.1 Warnings and important safety information 5
4. Installation Information 6-8
4.1 Chimney 6
4.2 Ventilation 6
4.3 Flue Draught 7
4.4 Connection to Chimney 7
4.5 Material Clearances 7
4.6 Fixing 7
4.7 Hearths 7
4.8 Commissioning & Handover 7-8
5. Technical Data 8
6. Operating Instructions 8-11
6.1 Air Controls 8
6.2 Cleaning 9
6.3 Fuels 9
6.4 Notes on Wood Burning 9-10
6.5 Lighting the Stove 10
6.6 Re-fuelling 10
6.7 Shutting down 11
6.8 Maintenance 11
7. Safety Notes for your Guidance 11
8. Frequently Asked Questions 13
9. How to fit the Frame 14
3

Beltane
Secondary air control
Primary air control
and riddling arm
Tertiary air bar
Cast Iron Log retainer
Air cooled handle
4

5

6

500mm
7

Beltane
8

when burning coal
9

10

F IRES CAN BE DANGEROUS
•
•
•
•
•
•
11

400 mm
335 mm
500 mm
555mm
153mm
285
500mm
3 sided
frame
595mm
4 sided
frame
645mm
3 - FW5C Cassette Stove Dimensions
12

1 Do stoves require a chimney?
2 How do I clean the chimney?
3 Who should install my stove?
4 How do I regulate the heat output?
5 What warranty do I get?
A call out charge will
apply if our engineer attends any stove problem that is not related to product failure.
6 Where can I get spare parts?
7 Can the doors be left open while burning?
8 Why is the stove smoking when lit?
9 Why should I “Run in” my stove?
10 What is Over Firing?
Beltane
Beltane
Beltane
Annual service
The inside of the stove should be serviced /cleaned once a year. To clean the inside, remove all ash, soot and
tar residue from the combustion chamber. Remove insulated chamber panels and baffle, dirt and soot will
collect behind it and this must be cleaned out. Check the quality of all insulated panels and replace any which
are damaged or cracked, replace stove door rope cord in the door. Check glass is correctly positioned. The
stove, the flue pipe connection and the chimney should be checked regularly by a qualified engineer. The
chimney should also be checked for blockages before relighting the stove if it has not been used for an
extended period of time. The paint/ lacquer can wear thin in exposed places due to overheating. This, and
other lacquer damage, may be repaired using Senotherm paint/lacquer spray available from your Beltane
dealer.
13

Beltane Holford Frames - How to fit
The 3 and 4 sided frame for a Beltane Holford fits on the
inside face of the outer casing of the stove body. There are
tension clips on each side of the body to ensure the frame
when knocked in completely is securely located.
1) Ensure stove is fitted flush or 1 mm in front of opening.
Stove flange must be in line or 1 mm in front of surrounding
wall.
2) Locate frame by pushing the frame into place inside
tension clips each side and make sure it is located fully home
/ pushed in until flush with stove body . It easier to locate side
flanges of the frame from the bottom first.
The frame is now fitted
01.2019
14

15

To clean the outside of the stove use a dry cloth.
Warning Note
Properly installed, operated and maintained this stove will not emit fumes into the dwelling. Occasional
fumes from de-ashing and re-fuelling may occur. However, persistent fume emission is potentially
dangerous and must not be tolerated.
If fume emission does persist, then the following immediate action should be taken:-
(a) Open doors and windows to ventilate the room and then leave the premises.
(b) Let the fire go out.
(c) Check for flue or chimney blockage and clean if required
(d) Do not attempt to relight the fire until the cause of the fume emission has been identified and corrected. If
necessary seek expert advice.
The most common cause of fume emission is flueway or chimney blockage. For your own safety these must
be kept clean at all times.
CO Alarm
Your installer should have fitted a CO alarm in the same room as the appliance. If the alarm sounds
unexpectedly, follow the instructions given under “Warning Note” above.
Beltane Stoves
Eurostove Ltd, Unit H1,
Mendip Industrial Estate,
Mendip Road, Rooksbridge,
Somerset
BS26 2UG
Tel: [phone]
www. eurostove.co.uk
E-mail : [email protected]
Holford Manual: 25.01.2019 ver1.1