BouncePro TR-0201-168 User manual

14ft(4.26m) Trampoline with Enclosure Combo
Assembly, Installation, Care, Maintenance, and User Instructions
TR-0201-168


FOR CUSTOMER SERVICE OR REPLACEMENT PARTS, PLEASE CALL
TASMAN SPORTS : 1-800-333-061
DO NOT attempt somersaults or flips. Paralysis or death can result if you land on your head or neck!
No more than one person on the trampoline at a time. Multiple users increase the risk of injury.
Use trampoline only with mature, knowledgeable supervision.
These instructions are important to minimize chances of injury. Please read each of them
thoroughly before you assemble and use this trampoline. Retain this manual for future reference.
Maximum weight of the user shall NOT exceed 220lbs/100kg for this product.
Trampoline must be used with enclosure that is properly installed and maintained
Assembly Size: Φ426 x 280cm

NO SOMERSAULTS OR FLIPS –
PARALYSIS OR DEATH can result if you
land on your head or neck!
Do not use if in a
cast or have
previous leg, arm,
head, neck or
back injury.
No more than ONE user at a time
(maximum weight - 220 lbs/100 kg).
Inspect prior to use – check that the legs are properly attached and stable on the ground; no loose
springs; mat and enclosure net are in proper place and in good condition with no tears.
Do not allow
children under
six (6) year old to
use.
Remove all hard
or sharp objects
including jewelry,
eyeglasses,
sunglasses or
hairclips before
jumping.
Do not use
without the
consent of your
physician, if
pregnant.
Daily Pre-Inspection:
>Inspect legs for proper
attachment or cracks
>Inspect netting for tears
and sagging
>Inspect for loose or
damaged springs
>Inspect mat for tears or
worn stitching
>Inspect frame for sagging
or cracks

INTRODUCTION
Thank you for purchasing this product. This trampoline was designed and manufactured with quality
materials and craftsmanship, providing fun and exercise in the enjoyment of your own backyard.
It is very important that the owners and users of this trampoline have adequate knowledge of techniques
and rules for proper use. In particular, children must be supervised at all times by a knowledgeable and mature
adult while using the trampoline. Take precautions to prevent access to the trampoline by children when there
is no adult supervision. Also restrict access to any unauthorized users without your consent.
Carefully read and understand all of the instructions and warnings in the User Manual before assembling
and using this product. It is the responsibility of the owner of this trampoline to ensure that all users of this product
are fully informed on the proper use and the inherent risks of jumping on a trampoline. Failure to do so can result
in serious injury or death. In particular, under no circumstances should you attempt or allow flips, somersaults
or any similar conduct. Landing on the head or neck can cause serious injury, paralysis, or death, even when
landing in the middle of the mat. Also, do not allow more than one person on the trampoline under any
circumstances. Use by more than one person at the same time increases the chance of injury.
To reduce risks associated with users falling off the trampoline, enclosure netting must be properly
installed and used at all times. The trampoline enclosure must be closed during use to prevent the user from
falling off the trampoline. Your trampoline enclosure netting is manufactured with UV resistant material. Despite
this, exposure to harsh elements (sunlight, wind, moisture, animals, etc) will weaken the netting. The netting
and mat must be inspected prior to every use and maintained regularly as detailed in this User’s Manual.
Please also ensure proper placement of this product to avoid injuries. It is essential that the intended
site for this trampoline is completely flat and level. If the ground is uneven, this could cause movement in the
frame and stress on the joined sections of the frame that could damage the trampoline and/or can cause serious
injury. Do not position this trampoline on hard surface such as concrete, tarmac or paving. Suitable surfaces
include flat dirt or grass, sand or play area covered with an appropriate depth of play bark material, with no
obstructions above, below or near the product.
The product must not be used in windy conditions as wind can cause unexpected movement of the product.
Wind can cause the trampoline to be lifted off the ground and become airborne. This can present a danger to
individuals and to property. Winds can be especially strong in open areas, foothills, mountains, locations subject
to hurricanes and tornadoes, areas between homes that create wind tunnels and anywhere else where local
weather conditions can create high winds. We recommend that you anchor the trampoline or otherwise secure
the trampoline to prevent it from moving as a result of the wind. One possible way to anchor the trampoline is to
secure the trampoline to a concrete footing under each leg. We recommend consulting a local licensed contractor
to best determine how the anchor system should be constructed for your specific conditions. The licensed
contractor can also advise you of other options such as below ground installation. Even with anchors, a
trampoline can be lifted, just like anything else, by strong winds. If the winds are anticipated to be very strong,
the trampoline should be disassembled and stored away safely until the weather conditions improve. Damage
from the wind or other severe weather is not covered by the manufacturer’s warranty. Because the manufacturer
warranty does not cover wind or weather related damage and damage can be caused to your property or the
property of others by a windblown trampoline, it is strongly advised that you provide site specific anchoring
through a licensed local contractor.
Only genuine replacement parts sold through our authorized dealer are recommended.
Replacement parts from other sources may not have been designed, tested or manufactured to standards.
Because of this, Tasman Sports cannot guarantee the performance and safety of the product when non
genuine replacement parts are used. The use of non-genuine replacement parts may affect any warranty
claim on the product, as allowed by the law in your jurisdiction.
We warrant its products against defects in material and workmanship.Please refer to our warranty
policy at the back of this manual for details.
FOR CUSTOMER SERVICE OR REPLACEMENT PARTS, PLEASE CALL
TASMAN SPORTS : 1-800-333-061

TABLE OF CONTENTS
Use trampoline only with adult supervision.
Do not attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis, or
death, even when landing in the middle of the mat.
Do not allow more than one person on the trampoline. Use by more than one person at the same time
increases the chance of injury.
Before you start to assemble….......................................................................................................................................... 1
Before using the product… .................................................................................................................................................1
Important Warnings...........................................................................................................................................................2-5
Important Instructions for Enclosure Netting and Mat .................................................................................................6-7
Trampoline and Enclosure Parts List ................................................................................................................................8
Hardware Parts List .............................................................................................................................................................9
Assembly and Installation Instructions............................................................................................................................10
Trampoline Frame Assembly...................................................................................................................................11-14
Trampoline Mat Assembly .......................................................................................................................................15-18
Frame Pad Assembly ....................................................................................................................................................19
Trampoline Enclosure Assembly ............................................................................................................................20-27
Disassembly of the Trampoline and Enclosure .............................................................................................................28
Moving the Trampoline and Enclosure .......................................................................................................................28
Care and Maintenance ......................................................................................................................................................29
Proper Use Instructions................................................................................................................................................30-31
Learning the fundamental trampoline skills...........................................................................................................32-33
Product Warranty ..........................................................................................................................................................34-35

BEFORE STARTING…
1
Use trampoline only with adult supervision.
Do not attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis, or
death, even when landing in the middle of the mat.
Do not allow more than one person on the trampoline. Use by more than one person at the same time
increases the chance of injury.
Carefully read and understand all of the instructions and warnings in this manual before
assembling and using this product. It is the responsibility of the owner of this trampoline to
ensure that all users of this product are fully informed on the proper use and the inherent risks
of jumping on a trampoline. Failure to do so can result in serious injury or death.
Before you start to assemble…
Check the package and make sure you have all of the parts listed in the Parts List section of this user
manual. IF ANY PARTS ARE MISSING, please call the Customer Service toll-free number listed on the
cover page for assistance.
Do not install or use the product if any parts are missing or damaged. Store in a safe place until ready to
install.
Make sure that you have plenty of space and a clean dry area suitable for the assembly of this trampoline.
IT IS ESSENTIAL THAT THE INTENDED SITE FOR THIS TRAMPOLINE IS COMPLETELY FLAT AND
LEVEL. If the ground is uneven, this could cause movement in the frame and stress on the joined sections
of the frame that could damage the trampoline and/or can cause serious injury.
Three adults are needed to assemble this trampoline.


Heavy gloves must be used to protect your hands from pinch points during assembly and goggles must be
worn to avoid injuries to the eyes.
Never modify the construction or the design of the product. Do not use any unauthorized parts with this
trampoline.
This pack may contain small parts and is not suitable for children under six (6) years of age to be nearby
during assembly.
IMPORTANT: Save this manual for future reference.
Before using the product…
Use of this trampoline requires constant adult supervision. Use the trampoline only with ADULT
supervision.
Ensure that the trampoline enclosure has been assembled correctly, as per the instructions in this manual
and that the zip and attachment system are fully attached before use.
Trampolines over 51cm tall are not recommended for use by children under 6 years of age.
There must be no more than one person at a time on the trampoline.
Maximum weight of the user shall NOT exceed100kg for this product.
This product is for household and family domestic use only– It is not for use in schools, playgrounds, rental
or commercial use.

IMPORTANT WARNINGS
2
Use trampoline only with adult supervision.
Do not attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis, or
death, even when landing in the middle of the mat.
Do not allow more than one person on the trampoline. Use by more than one person at the same time
increases the chance of injury.
Important Warnings
Only one user at any one time! Multiple users can cause loss of control, collision or falls on the trampoline.
This could result in serious injury to legs, arms, back, neck or head.
Do not use the trampoline when under the influence of alcohol, drugs or medication, which may impair the
jumper’s judgement.
Always consult your physician before performing any kind of physical activity.
Do not use the trampoline if you have high blood pressure.
Do not use the trampoline if you have a medical history of neck or back injuries or mental or physical
conditions that could cause injury.
Do not use if the user has any broken bones (casts) or has recently been in the hospital for extensive
treatments (operations, severe wounds, stitches, back injury or concussion).
Do not use when pregnant.
Do not use the trampoline during windy conditions or if the user or the trampoline surface is wet. These
conditions can cause the user to lose control and fall resulting in serious injury.
Children are often unable to identify hazards and do not have a well-developed ability to assess risk and
may, if left unsupervised, be at more risk of injury. Always supervise children while they are using the
trampoline.
Over-confidence can lead to injury. Learn fundamental bounces first before trying more complex
manoeuvres.
Inappropriate clothing can cause injury. Clothing should allow plenty of body movement without flapping
loosely and becoming a distraction to the jumper. Wear clothing free of drawstrings, hooks, loops or
anything that could get caught while using the trampoline and result in entanglement or strangulation.
Buckles, jewellery and belts should not be worn, as these may damage the trampoline mat or cause injury
to the jumper if they become caught in the fabric of the trampoline. Shoes should be removed as they may
damage the bed and increase the risk of injury.
Do not allow children under 6 years on the trampoline.
Allow only one person on the trampoline at any one time.
Active, competent supervision is essential—always supervise children while they are using the trampoline.
Ensure any pads (where they are required) covering the frame/suspension system are securely attached
at all times.
Ensure the enclosure is securely attached and in good condition at all times.
Check the trampoline before use and ensure it is in good condition. Replace any worn or broken parts.
Use only parts that are recommended by the manufacturer.
Make sure that the area around, underneath and above the trampoline is clear of objects that could
interfere with the person jumping. Do not allow children, pets, toys or other play equipment to be present
under the trampoline.
Adults should model safe use of trampolines when children are present.
Wear comfortable clothing that won’t become entangled in the trampoline’s components and become a
strangulation hazard. Do not wear jewellery or drawstrings/cords that can catch on the trampoline and
create a strangulation hazard. Remove shoes as they may damage the bed and increase the risk of injury.
Carefully read these warnings before using this product. Failure to follow
these warnings can result in serious injury or death.

IMPORTANT WARNINGS
3
Proper Play Conditions:
Always use the product in a well-lit area. Do not use without lighting during dawn, dusk or in complete
darkness!
The trampoline must be placed on a surface that is COMPLETELY FLAT AND LEVEL. If the ground is
uneven, this could cause movement in the frame and could cause stress on the joined sections of the
frame that could damage the trampoline and/or can cause serious injury.
DO NOT install or position this trampoline on a hard surface such as concrete, tarmac or paving. Suitable
surfaces are grass, sand or a play area covered with an appropriate depth of play bark material.
Children should be educated by responsible adults to always climb on and off the trampoline, and never
jump or bounce off. It is dangerous practice to jump or bounce from the trampoline when dismounting.
Never use springs or suspension elements as ‘hand grips’ when getting on and off the trampoline.
Learn fundamental bounces and body positions thoroughly before trying more advanced manoeuvrers. A
variety of trampoline activities can be carried out by performing the basic fundamentals in various series
and combinations, or performing one fundamental bounce after the other, with or without bounces
between them.
For further information or additional instructional material, contact the manufacturer or retailer. To learn
more advanced trampolining skills contact a suitable gymnastics/trampoline club.
Do not attempt or allow somersaults on the trampoline. Landing on your head or neck while doing
somersaults can cause serious injury, paralysis or even death.
Do not use the trampoline when wet. The mat will be slippery and make landing less sure.
Enclosure systems are designed to prevent users falling off the trampoline. Do not allow users to
intentionally bounce toward or off the barrier, as this can unbalance the trampoline and continual impact
may damage the enclosure.
Do not use a trampoline while under the influence of alcohol or drugs. Balance, perception and
assessment of risk will be affected and may lead to injury.
Do not use the trampoline as a springboard to other objects. Use the trampoline only for trampoline style
bouncing.
Focus your eyes on the edge of the trampoline. This will help control your bounce.
Place the trampoline on a flat level surface with impact attenuating properties such as grass and ensure
that it is sufficiently stable to prevent it from tipping over and/or blowing away. Sandbags or pegs may be
suitable anchorage devices.
Keep a minimum of 5 m overhead clearance when measured from the bed height to prevent users
inadvertently contacting overhead hazards such as electric wires, tree limbs and clotheslines.
Maintain a minimum clearance of 1.5 m on all sides of the trampoline. This area should not include
concrete, bitumen, brick or other hard surfaces as these can cause serious injuries if users fall off the
trampoline.

IMPORTANT WARNINGS
4
Appropriate Use Conditions:
Children must always be supervised while they are playing on the trampoline and must be instructed not to
use the trampoline in an inappropriate or hazardous manner. Take precautions to prevent access to the
trampoline by children when there is no adult supervision.
Restrict access to the trampoline by any unauthorized users without your consent.
Trampolines are rebounding devices, which propel the user to unaccustomed heights, and into a variety of
body movements. Rebounding off of the trampoline, striking the frame or hooks, or improperly landing on
the trampoline mat may cause serious injury.
Always start and maintain your jump at the center of the trampoline mat in order to reduce the risk of
landing on the frame or hooks or falling off the trampoline.
Avoid bouncing too high. Stay low until you can control your bounce and land consistently in the middle of
the trampoline mat.

Do not stand or jump on the hooks while using the trampoline. The hooks are not designed to support
such stress and weight. This can result in serious injuries and/or product damage. If you see any signs
of stretched or damaged straps or hooks, do not use the trampoline until replacement are properly
installed. Please contact our customer service representatives to order original manufacturer replacement
parts.
The trampoline is several feet off the ground. Jumping off the trampoline to the ground or any other
surface may result in injury. Smaller children may need assistance getting up onto or down from the
trampoline. Mounting and dismounting properly should be followed as a strict rule. Users should climb onto
the trampoline by placing their hands on the frame and stepping or rolling up onto the frame, across the
hooks and onto the mat. Do not step directly on the frame pad or grasp the frame pad when mounting or
dismounting the trampoline. To dismount, jumpers should walk to the side of the mat, bend over and place
their hands on the frame, then step from the mat to the ground. Users should always place their hands on
the frame while mounting or dismounting.
Do NOT use the trampoline as a springboard to jump onto other objects.
Remove all objects not designed for use with the trampoline from the trampoline before use. Do not let
children take toys or other items onto the trampoline.
Do not use the trampoline indoors, as this product is intended for outdoor home use only.
The product must not be used in windy conditions as wind can cause unexpected movement of the
product. Wind can cause the trampoline to be lifted off the ground and become airborne. This can present
a danger to individuals and to property. Winds can be especially strong in open areas, foothills, mountains,
locations subject to hurricanes and tornadoes, areas between homes that create wind tunnels and
anywhere else where local weather conditions can create high winds. We recommend that you anchor the
trampoline or otherwise secure the trampoline to prevent it from moving as a result of the wind. One
possible way to anchor the trampoline is to secure the trampoline to a concrete footing under each leg. We
recommend consulting a local licensed contractor to best determine how the anchor system should be
constructed for your specific conditions. The licensed contractor can also advise you of other options such
as below ground installation. Even with anchors, a trampoline can be lifted, just like anything else, by
strong winds. If the winds are anticipated to be very strong, the trampoline should be disassembled and
stored away safely until the weather conditions improve. Damage from the wind or other severe weather is
not covered by the manufacturer’s warranty.
Stop your bounce by flexing your knees as your feet come in contact with the trampoline bed. Learn this
skill before you attempt any others.
Avoid bouncing too high. Stay low until you can control your bounce and repeatedly land in the centre of
the trampoline.
Do not bounce immediately after a meal.
Ensure the trampoline frame and springs are fully covered by the frame pad to avoid any direct contact
with metal parts.

IMPORTANT WARNINGS
5
➢Use trampoline only with mature, knowledgeable adult supervision.
➢Do not attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis, or
death, even when landing in the middle of the mat.
➢Do not allow more than one person on the trampoline. Use by more than one person at the same time
increases the chance of injury.
➢Do not jump or step onto the frame pad as it was not designed to support the weight of a person.
➢Do not use the trampoline while holding or wearing any type of sharp or pointed objects such as jewelry,
watches, rings, eyewear and necklaces before using this product. This will prevent the jewelry from tearing
the mat or getting caught in the enclosure netting.
➢Do not wear loose fitting clothing that may catch or snag during play.
➢Never wear footwear (e.g. shoes) when using the trampoline.
➢Always tie back long hair so that it does not block user’s vision or get caught in the enclosure netting.
➢FRAME PADS –Frame pads are there to protect user from any fall or landing on the hooks and frame. On
no account should people be permitted to sit or stand on them when the trampoline is in use. You should
also make sure that smaller users do not use the inside edges of the pads as a “handle” when getting up
on to the trampoline.
➢Never use the trampoline without the frame pad being securely attached. Properly tie down the frame pad
before each use. Improper assembly of the frame pad may lead to injury!
➢Always check to ensure there are no obstructions or objects under the trampoline that could cause injury
or obstruct movement of jump mat. Also check that there are no pets or other people underneath the
trampoline.
➢Do not jump on the trampoline with a snowboard, skateboard, roller blades, bicycle or any other equipment.
DO NOT hold any foreign objects not authorized by the manufacturer in your hand and DO NOT place any
objects on the trampoline while anyone is jumping on it. Please be aware of your surroundings to ensure
there are no objects that could cause harm when you are playing on the trampoline.
➢The frame of your trampoline is made of steel and it will conduct electricity. No electrical equipment (lights,
heaters, extension cords, household appliances, etc.) should be permitted in or on the enclosure under
any circumstances to avoid the risk of electrocution.
Enclosure Netting and Mat –Appropriate Use Conditions
➢Children MUST NEVER be left unattended inside the enclosure at any time.
➢The enclosure is ONLY intended to be used to reduce the risk of injury from falling off the trampoline. Do
not intentionally kick, bounce against, climb on, hang from, jump over or crawl under the netting.
➢Enter and exit the enclosure only through the zipper door. Do not go through the gap between the netting
and the mat. Trying to exit this way poses a risk of strangulation, especially for young children.
➢The enclosure netting and mat must be inspected prior to each use. If there are any signs of weakness,
you must stop using the trampoline immediately, properly store the trampoline and restrict access by users
until authorized replacement netting or pad is installed. Please refer to the Trampoline Net & Pad –
Maintenance Requirements section contained in this manual for further details.
Carefully read these warnings before using this product. Failure to follow
these safety instructions can result in serious injury or death. 

IMPORTANT INSTRUCTIONS FOR ENCLOSURE NETTING AND MAT
6
Important Instructions for Enclosure Netting and Mat
1. Maintenance of Trampoline Enclosure Net, Mat and Pad
Enclosure nets and padding are prone to wear and tear like tires on a car. Gradual deterioration of
the material will occur; the speed of which will depend on the level of exposure to UV rays, airborne
pollution and outdoor weather conditions such as rain and wind.
The net and padding needs to be properly maintained and checked by following the
Maintenance Schedule set out in these instructions. When the material shows any signs of
weakness, you must stop using the trampoline immediately, properly store the trampoline and
restrict access by users until a new replacement net or padding is properly installed.
Official replacement nets and padding can be purchased by contacting our authorized customer
service by toll free number.
2. Maintenance Requirement for Enclosure Net
Your trampoline enclosure netting is manufactured with UV resistant material. Despite this
the netting is exposed to the outdoor elements including sunlight, wind, rain and wildlife.
The net surrounding the trampoline must be checked prior to each use. This includes, but is
not limited to inspecting the net for cracks, excess wear, brittleness, and stretching. Also inspect
all connections and the entire enclosure for overall integrity. The net must be immediately
replaced if it shows any signs of wear, damage, stretching, cracking, looseness, brittleness or
other losses in integrity. The following Maintenance Schedule must be followed:
IT IS RECOMMENDED THAT THE NET BE REPLACED ON A YEARLY BASIS UNDER NORMAL
USE, EVEN IF IT DOES NOT SHOW ANY VISIBLE SIGNS OF DAMAGE.
1 to 3 Months
3 to 6 Months
6 to 12 Months
Inspect the enclosure (net, net
hanger, and straps) prior to
every use.
Thorough inspection for UV
damage and prior to every use
for net, net hanger and straps.
Thorough inspection before
every use on net, net hanger,
straps, zippers, ties and strings.
Replace after 12 months or
earlier if necessary.
Failure to follow these instructions to ensure proper operational condition of
your trampoline may lead to serious injury or death.

If it produces any tear or cracking or ripping sound, then the net is unsafe and MUST be taken down
immediately. STOP USING THE TRAMPOLINE ENCLOSURE IF YOU FIND ANY SIGNS OF WEAR
OR TEARING ON THE NETTING.
Step 2 - Walk around the whole perimeter of the trampoline to visually check for material deterioration
or other damage.
3. Maintenance Requirement for Trampoline Pad
Walk around the whole perimeter of the trampoline to visually check for material deterioration, tears,
looseness, loss of elasticity or other damage in the pad.
It is recommended that you replace the trampoline enclosure net and pad every 12 months.
Replace the enclosure net and pad earlier if there are any signs of wear, tear, brittleness,
cracking, stretching or any other signs of weakness. New enclosure netting and pad can be
purchased through Tasman Sports authorized service center 1-800-333-061 .
IMPORTANT INSTRUCTIONS FOR ENCLOSURE NETTING AND MAT
7
How to Inspect the Trampoline Net for Proper Use
Always check the enclosure netting for signs of UV damage, deterioration, brittleness, cracking, and
tearing every time before using the trampoline and enclosure.
Step1 - Inspect the enclosure netting before EACH use for wear or tear by pinching and pulling a
section of the netting between fingers and pulling downward. Please see diagram below.

TRAMPOLINE AND ENCLOSURE PARTS LIST
8
Trampoline and Enclosure Parts List
Trampoline
Enclosure
Key
Number
Part Picture
Description
Quantity
1
Trampoline Mat, stitched with Triangle-
Rings
1
2
Frame Pad
1
3
Top Rail with Leg Sockets
6
4
Top Rail
6
5
Leg Base
6
6A
Vertical Leg Extensions
6
6B
Vertical Leg Extension with Indented
Hole
6
7
Spring
72
8
Trampoline Safety Instruction Placard
1
9
Spring Loading Tool
1
Key
Number
Part Picture
Description
Quantity
A2
Upper Frame Tube with Foam
6
A1
Lower Frame Tube with Foam
6
B
Enclosure Netting
1

HARDWARE PARTS LIST
9
Hardware Parts List
Key
Number
Part Picture
Description
Quantity
C
Bolt (M8x87mm)
6
D
Wrench
1
E
Gap Spacer
12
F
Bolt (M8x84mm)
6
G
Spring Lock Washer
12
H
Cap Nut
12
I
Self-Locking Screw
18
J
Arc Washer
12
K
Allen Wrench
1
L
Cord
8
M
Enclosure Tube Washer
6
O
End Cap
6
10
Small Spring Lock Washer
12
11
Tube Cap
6

ASSEMBLY AND INSTALLATION INSTRUCTIONS
10
Assembly and Installation Instructions
During periods of non-use, this trampoline and trampoline enclosure can be easily
disassembled and stored by reversing the order of installation.
Three people are recommended to assemble the trampoline and trampoline enclosure.
Protective gloves must be used during assembly to avoid injuries during installation.
Protective goggles must be worn to avoid injuries to the eyes.
For appropriate use of the trampoline, please assemble the trampoline in a location that meets the
following conditions:
Adequate overhead clearance is needed. A minimum of 24ft (7.3 meters) from ground level is
recommended. Provide clearance for wires, tree limbs and other possible hazards.
Lateral clearance is essential. Place the trampoline away from walls, structures, fences and other
play areas. Maintain a clear space on all sides of the trampoline.
Place the trampoline on a flat and level surface before use.
Do not install this trampoline on hard surfaces. Suitable surfaces include grass or sand.
Use the trampoline in a well-lit area. Artificial illumination may be required for shady areas.
The trampoline should be installed in an area where access can be restricted from unauthorized
and unsupervised use.
Ensure there is nothing beneath the trampoline that could cause injury or obstruct movement of jump mat.
Remove any obstructions from beneath the trampoline.
The trampoline enclosure is only to be used as an enclosure for a trampoline of a size for which
the enclosure is designed.
The owner and supervisors of the trampoline are responsible to make all users aware of
practices specified in the use instructions section.
Users may become entangled in or strangled by loose cords or in gaps between trampoline and
enclosure. Keep enclosure tightly fastened to the trampoline in accordance with the
manufacturer’s instructions. Failure to properly assemble and maintain a tight, secure
trampoline/enclosure boundary may result in serious injury, strangulation, or death.
If you do not follow these guidelines, you increase the risk of injury or death.
PRIOR TO ASSEMBLING
Before assembly, please ensure that you have all the parts required to assemble the product. If you
are missing any parts, please contact our Customer Support agents.
Please do not use unauthorized parts to assemble the trampoline. This may damage the
integrity of the product and will void the manufacturer’s warranty.
DO NOT use electric power tools to tighten or loosen bolts and screws as this can damage the
hardware.
Review all steps before assembly and read all precautions before using this
product. Failure to do so can result in serious injury or death.

TRAMPOLINE FRAME ASSEMBLY
11
Trampoline Frame Assembly
BEFORE YOU BEGIN: Review all steps before assembly and read all precautions before using the
trampoline. At least two adults are required to assemble this trampoline. Protective gloves should be used
during assembly to avoid injuries during installation. Goggles should be worn to avoid injuries to the eyes.
Step 1 –Frame Assembly
Locate the following 30 pieces of steel tubing parts that are needed to assemble the trampoline frame:
6 - Top Rail with Leg Sockets (# 3)
6 - Top Rails (# 4)
6 - Leg Bases (# 5)
6 - Vertical Leg Extensions (# 6A)
6 - Vertical Leg Extension with Indented Hole (# 6B)
Lay out all the parts on dry flat surface as shown below.
Make sure that you have plenty of space and a clean dry area suitable for the assembly of this trampoline. IT IS
ESSENTIAL THAT THE INTENDED SITE FOR THIS TRAMPOLINE IS COMPLETELY FLAT AND LEVEL. If the ground is uneven
this could cause movement in the frame and could cause stress on the joined sections of the frame that could damage
the trampoline and/or can cause serious injury. Make sure the trampoline is assembled where it is to be used. The
trampoline should not be moved after completion.

TRAMPOLINE FRAME ASSEMBLY
12
Step 2 –Leg Support and Top Rail with Leg Socket Assembly
At this point, two people will be needed to assemble the trampoline.
Connect Vertical Leg Extensions (# 6A and # 6B) to Leg Base (# 5) as shown below (the assembled parts
will be hereinafter referred to as “Leg Support”).
Lift two sets of the assembled Leg Supports to a vertical (standing) position. Connect one end of Top Rail
with Leg Socket (# 3) to Vertical Leg Extension (# 6A) and the other side to Vertical Leg Extension with
Indented Hole (# 6B) as shown below. Repeat in the same manner to assemble all Leg Supports.
Hint: Make sure the larger indented hole on Vertical Leg Extension (# 6B) is facing outward. This is
important for installing the enclosure later.
Leg Support
DO NOT PLACE HANDS NEAR
THEOPENING WHEN
CONNECTING THE TUBES.
WEAR PROTECTIVE GLOVES
TO PROTECT FROM INJURIES
DURINGASSEMBLY.
Vertical Leg Extension
with Indented Hole

TRAMPOLINE FRAME ASSEMBLY
13
Step 3 –Top Rail Assembly
Complete the trampoline frame by inserting all of the Top Rails (# 4) in between Top Rail with
Leg Sockets (# 3) as shown below.
DO NOT PLACE HANDS NEAR
THE OPENING WHEN
CONNECTING THE TUBES.
WEAR PROTECTIVE GLOVES
TO PROTECT FROM INJURIES
DURING ASSEMBLY.
Larger hole

TRAMPOLINE FRAME ASSEMBLY
14
Step 4 –Secure Leg Support to Top Rail
Secure Vertical Leg Extension (# 6A) to the frame using Self-Locking Screw (# I), Small Spring Lock
Washer (# 10) and Allen Wrench (# K) as shown below. If the holes do not match up, rotate Vertical Leg
Extension back and forth until the holes are aligned. Repeat in the same manner for all Leg Supports.
NOTE: Do not over-tighten the screws at this point. The screws should only be tightened all the way
after all the springs have been installed in later steps
Hint: Make sure the holes on all the steel tubing parts are aligned and the larger indented hole on #6B is
facing outward. This is important for installing the enclosure later.

TRAMPOLINE MAT ASSEMBLY
15
Trampoline Mat Assembly
When attaching the springs, do not place your hands, arms, legs or any other body part close to the connector
points (i.e. joints connecting the steel tubes). The connector points can become pinch points as the trampoline
springs tighten up. Wear heavy duty working gloves to protect your hands from injuries during installation by the
springs and protective goggles to avoid injuries to the eyes. Be steady when installing the springs as it can
rebound and fly off if you inadvertently let go when not hooked properly. Make sure no children are playing
nearby when installing the trampoline.
Step 5 –Spring Assembly
To install the springs, hook one end of the Spring (# 7) into the triangle-ring on the Mat (# 1), then pull the
other end with the Spring Loading Tool (# 9) underhand and latch it into the corresponding hole on the
frame. Tap on the spring with the handle of the Spring Loading Tool to make sure it is securely latched.
There are a total of 72 springs, For even distribution of spring tension and ease of assembly, the springs
must always be installed on opposite sides of the mat in an alternating manner, i.e. 1, then 37, followed by
19 and 55 as shown below. Hint: The number of triangle-rings sewn onto the Mat is equal to the number
of holes on the frame. If you notice that you have miscounted a hole or triangle-ring, remove and reinstall
the springs as necessary while maintaining an even distribution of tension as explained above.

TRAMPOLINE MAT ASSEMBLY
16
Step 6 –Spring Assembly
Continue to attach springs in the same manner. For even distribution of tension and ease of assembly,
the springs must be placed on opposite sides of the mat in an alternating manner, i.e. 10 then 46, 28 then
64, etc. In addition to the previously installed springs, you should now have springs at 10, 28, 46 and 64
as shown below.