Century Heating BANFF HES80 Assembly instructions

BANFF
Freestanding
Electric Stove
Model: HES80
Installation Instructions and
Homeowners Manual
CFM Home Products
2695 Meadowvale Blvd. • Mississauga, Ontario, Canada L5N 8A3
800-668-5323
INSTALLER: DO NOT DISCARD THIS MANUAL - LEAVE FOR HOMEOWNER S190006 6/04 Rev. 0
INSTALLER / CONSUMER
SAFETY INFORMATION
PLEASE READ THIS MANUAL
BEFORE INSTALLING AND
USING APPLIANCE
WARNING!
IF THE INFORMATION IN THIS
MANUAL IS NOT FOLLOWED
EXACTLY, AN ELECTRICAL SHOCK
OR FIRE MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL
INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY
Service must be performed by a qual-
ified service agency.
DO NOT STORE OR USE
GASOLINE OR OTHER
FLAMMABLE VAPORS OR
LIQUIDS IN THE VICINITY OF
THIS OR ANY OTHER
APPLIANCE.
C US

2S190006
Table of Contents
PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS
BEFORE USING THIS APPLIANCE
Thank you and congratulations on your purchase of a CFM Home Products stove.
IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these
instructions may result in a possible electric shock, fire hazard and will void the warranty.
Installation Instructions
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Locating Your Stove . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Stove Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Clearance to Combustibles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Hearth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Electrical Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Fan Kit Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Service Instructions
Replacing Light Bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Maintenance of Motors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Electrical Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Operating Instructions
On/Off Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Heater Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

3
S190006
Installation Instructions
General
1. Read all instructions before using this appliance.
2. This appliance is hot when in use. To avoid burns,
do not let bare skin touch hot surfaces. If provided,
use handles when moving this appliance. Keep
combustible materials, such as furniture, pillows,
bedding, papers, clothes and curtains at least 3 feet
(914mm) from the front of this appliance.
3. CAUTION: Extreme caution is necessary when
any heater is used by or near children or
invalids and whenever the heater is left operat-
ing unattended.
4. If possible always unplug this appliance when not in
use.
5. Do not operate any heater with a damaged cord or
plug or after the appliance malfunctions, has been
dropped or damaged in any manner.
6. Any repairs to this appliance should be carried out
by a qualified service person.
7. Under no circumstances should this appliance be
modified. Parts having to be removed for servicing
must be replaced prior to operating this stove
again.
8. Do not use outdoors.
9. This heater is not intended for use in bathrooms,
laundry areas and similar indoor locations. Never
locate this appliance where it may fall into a bathtub
or other water container.
10.Do not run cord under carpeting. Do not cover cord
with throw rugs, runners or the like. Arrange cord
away from traffic areas and where it will not be
tripped over.
11.To disconnect this appliance, turn controls to the off
position, then remove plug from outlet.
12.Connect to properly grounded outlets only.
13.This appliance, when installed must be electrically
grounded in accordance with local codes, with the
current CSA C22.1 Canadian Electrical codes or for
USA installations, follow local codes and the
National Electric Code, ANSI/NFPA No. 70.
14.Do not insert or allow foreign objects to enter any
ventilation or exhaust opening as this may cause an
electric shock, fire or damage the appliance.
15.To prevent possible fire, do not block air intakes or
exhaust in any manner. Do not use on soft sur-
faces, like a bed, where openings may become
blocked.
16.This appliance has hot and arcing or sparking parts
inside. Do not use it in areas where gasoline, paint
or flammable liquids are used or stored. This appli-
ance should not be used as a drying rack for cloth-
ing, nor should Christmas stockings or decorations
be hung on or near it.
17.Use this appliance only as described in this manual.
Any other use not recommended by the manufac-
turer may cause fire, electric shock or injury to per-
sons.
18.Avoid the use of an extension cord because the
extension cord may overheat and cause a risk of
fire. However, if you have to use an extension cord,
the cord shall be No. 14 AWG minimum size and
rated not less than 1875 Watts. The extension cord
must be a three wire cord with grounding type plug
and cord connector. The extension cord shall not be
more than 20 feet (6m) in length.
19.SAVE THESE INSTRUCTIONS.
Locating Your Stove
Your new freestanding electric stove may be installed
virtually anywhere in your home. However, when
choosing a location for your new stove, ensure that
the general instructions are followed. Also, for best
effect, install the stove away from direct sunlight.

22¹⁄₂" (572 mm)
24¹⁄₄" (616 mm)
14¹⁄₄"
(362 mm)
14¹⁄₄" (362 mm)
27⁷⁄₈"
(708 mm)
13¹⁄₂" (343 mm)
4S190006
Stove Dimensions

5
S190006
Clearance to Combustibles
Back . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2” (51 mm)
Sides . . . . . . . . . . . . . . . . . . . . . . . . . . . .6” (153 mm)
Floor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0” (0 mm)
Top . . . . . . . . . . . . . . . . . . . . . . . . . . . .24” (610 mm)
Hearth
Ahearth is not mandatory, but is recommended for
aesthetic purposes. We recommend a noncombustible
hearth which does not obstruct heater openings.
Electric Specifications
Voltage . . . . . . . . . . . . . . . . . . . . . . . .120V AC/60Hz
Total Amps . . . . . . . . . . . . . . . . . . . . . . .12.20 Amps
Total Watts . . . . . . . . . . . . . . . . . . . . . . . .1460 Watts
Heater Ratings . . . . . . . . . . . . . . . . . . . .1300 Watts
Electrical Connection
A15 Amp, 120 Volt, 60 Hz circuit with a properly
grounded outlet is required. Preferably, the appliance
will be on a dedicated circuit as other appliances on
the same circuit may cause the circuit breaker to trip
or the fuse to blow when the heater is in operation.
The unit comes standard with a 6’ (1.8m) long three
wire cord, exiting from the rear of the stove. Plan the
installation to avoid the use of an extension cord. If an
extension cord must be used, it must be a minimum
14AWG, three wire with grounding type plug connector
and rated not less than 1875 Watts. The cord shall not
be more than 20’ (6m) in length.
WARNING: Electrical outlet wiring must
comply with local building codes and
other applicable regulations to reduce the
risk of fire, electrical shock and injury to
persons.
WARNING: Do not use this stove if any
part of it has been under water.
Immediately call a qualified service tech-
nician to inspect the stove and replace
any part of the electrical system.
Fan Kit Installation
When installed, the heater must be elec-
trically connected and grounded in accor-
dance with local codes, or in th absence
of local codes, with ANSI/NFPA No. 70.
NOTE: 110/120 electric power is required to operate
blower (fan).
Be sure to leave sufficient excess wire in case minor
adjustments are required.
Any electrical re-wiring of this fan must be done by a
qualified electrician.
Turn off all power before installation.
CAUTION: Be careful not to touch or bend the flame
generator.
1. Remove panel from back of pedestal
2. Install the fan through the opening at the back of
the pedestal. Place fan assembly as far forward as
possible, inserting long flange through slot in front
panel. (Fig. 1)
3. Use two screws provided to secure fan assembly to
base of pedestal. (Fig. 2)
4. From front of unit, attach brass handle to front of
fan assembly flange. (Fig. 3)
5. Plug in grounded service cord to a convenient wall
receptacle.
6. Replace rear panel in pedestal.
Slot
ST824
Fig. 1 Insert flange through slot in front panel.

1WARNING: Disconnect power before
attempting any maintenance or cleaning
to reduce the risk of fire, electrical shock
or personal injury.
Maintenance of Motors
The motors used on the fan and the flame generator
assembly are prelubricated for extended bearing life
and require no further lubrication. However, periodic
cleaning/vacuuming of the fan/heater unit is recom-
mended. WARNING: Make sure the power is turned
off before proceeding.
Service Instructions
Replacing Light Bulbs
This stove uses two clear 120 Volt, 60 Watt, E-12
socket base light bulbs (small base, chandelier candle-
type). The 60 Watt bulbs are located under the log
set/ember bed. For convenience, if one of the bulbs
burns out, it may be a good idea to replace both of the
light bulbs.
1. Turn off power to the unit by unplugging the power
cord.
2. Let stove cool if it has been operating.
3. Remove rear access panel from back of pedestal to
expose light bulbs.
6S190006
Fan Assembly ST818
Fig. 2 Secure fan assembly to base of pedestal.
Fig. 3 Attach brass handle to front of unit.
CAUTION: Be careful not to touch or bend the flame
generator.
4. Examine the bulbs to determine which bulb needs
to be replaced.
5. Unscrew defective bulb(s).
6. Install new 60 Watt light bulb(s).
7. Replace rear access panel. Plug power cord into
wall outlet.
WARNING: Do not exceed 60 watts per
bulb. Use of higher rated bulbs may result
in a fire, causing property damage or per-
sonal injury.

7
S190006
Heater Control
The heater control acts to turn the heater on and off as
well as setting the comfort level in the room. Turning
the knob clockwise from the off position will place the
heater into operation. The further the knob is rotated
clockwise, the higher the set point temperature. turning
the knob counterclockwise will lower the set point tem-
perature. Turning it all the way counterclockwise will
turn the heater function off.
Main On/Off Switch
The On/Off switch supplies power to all of the func-
tions of the stove. It is located at the top rear of the
unit.
WARNING: During any service of this appliance,
the power to the unit must be turned off. It is not
acceptable to use the “On/Off” switch to meet this
requirement.
7
If repairing or replacing any electrical component or wiring, the original wire routing, color coding
and securing locations must be followed.
WIRE#1 BLACK
WIRE#2 BLACK
WIRE#3 BLACK
HOT
SPEED CONTROL
REMOTE RECEIVER
WIRE#4 BLACK
BLACK WIRE
RED LINE OUTPUT
WHITE WIRE
MOTOR
FLAME
GENERATOR
RED WIRE
-
+
+
-
BLACK WIRE
WIRE #7 WHITE
WIRE #8 WHITE
HEATER
MOTOR
WIRE #9 WHITE
WIRE #10 WHITE
WIRE#5 BLACK
RED LINE INPUT
WIRE#6 BLACK
WIRE#11 RED RED WIRE
BLUE WIRE
SWITCH OFF/ON
THERMOSTAT
GREEN WIRE
SPEED CONTROL
SWITCH
ORANGE WIRE
ORANGE/BROWN WIRE
BROWN WIRE
HEATER
BLACK WIRE
BLACK WIRE
WHITE
BLACK
l
o
Electrical Wiring Diagram
Any electrical repairs or rewiring of this unit should be carried out by a licensed electrician in accordance with
national and local codes.
Operating Instructions
Heater Control Flame Control
On/Off Switch
Fig. 4 HES80 controls.

8S190006
1 YEAR WARRANTY
For Century Heating Electric Stove
BASIC WARRANTY:
CFM Home Products (hereinafter referred to collectively as
the "Company") warrants that your new Century Heating
stove is free from manufacturing and material defects for
a period of one year from date of installation, subject to
the following conditions and limitations.
1. This electric stove must be installed and operated at all
times in accordance with the Installation and Operating
instructions furnished with the product. Any alteration, willful
abuse, accident, or misuse of the product shall nullify this
warranty.
2. This warranty is non-transferrable, and is made to the origi-
nal owner, provided that the purchase was made through
an authorized supplier of the Company.
3. This warranty is limited to the repair or replacement of
part(s) found to be defective in material or workmanship,
provided that such part(s) have been subjected to normal
conditions of use and service, after said defect is confirmed
by the Company's inspection.
4. This warranty does not cover the lightbulb(s) included
with the stove.
5. The Company may, at its discretion, fully discharge all obli-
gations with respect to this warranty by refunding the
wholesale price of the defective part(s).
6. Any installation, labour, construction, transportation, or
other related costs/expenses arising from defective part(s),
repair, replacement, or otherwise of same, will not be cov-
ered by this warranty, nor shall the Company assume
responsibility for same. Further, the Company will not be
responsible for any incidental, indirect, or consequential
damages, except as provided by law.
7. All other warranties - expressed or implied - with respect to
the product, its components and accessories, or any obliga-
tions/liabilities on the part of the Company are hereby
expressly excluded.
8. The Company neither assumes, nor authorizes any third
party to assume, on its behalf, any other liabilities with
respect to the sale of this Norther Flame product.
9. The warranties as outlined within this document do not
apply to non-CFM Home Products accessories used in con-
junction with the installation of this product.
This warranty is void if:
a) The stove has been operated in atmospheres contami
nated by chlorine, fluorine or other damaging chemicals.
b) The stove is subjected to prolonged periods of damp
ness or condensation.
c) Any alteration, willful abuse, accident, or misuse of the
product.
IF WARRANTY SERVICE IS NEEDED . . .
1) Contact your supplier. Make sure you have your warranty,
your sales receipt, and the model/serial number of your
CFM Home Products product.
2) DO NOT ATTEMPT TO DO ANY SERVICE WORK YOUR-
SELF.
GARANTIE DE BASE:
CFM Home Products (aux présentes nommée la "Société")
garantit votre nouveau poêle électrique Northern Flame
contre tous défauts de fabrication et de matières premières
pour une période d'un an à compter de la date d'installa-
tion, sujet aux conditions et limitations suivantes.
1. Le poêle electrique doit être installé par un entrepreneur de
service autorisé et compétent. Il doit être installé et utilisé
en tout temps selon les instructions d'installation et de fonc-
tionnement fournies avec le produit. Toute altération, abus
volontaire, accident ou mauvais usage du produit annulera
cette garantie.
2. Cette garantie n'est pas transférable et est offerte à l'a-
cheteur au détail d'origine, à condition que l'achat soit effec-
tué par l'entremise d'un détaillant autorisé de la Société.
3. Cette garantie est limitée à la réparation ou au remplace-
ment de(des) pièce(s) trouvée(s) défectueuse(s) en
matières premières ou main-d'oeuvre, à condition que les-
dites pièces aient été sujettes aux conditions normales
d'usage et de service, après que ledit défaut a été confirmé
par une inspection par la Société.
4. Cette Garantie ne couvre pas les ampoules inclus dans le
poêle électrique.
5. La Société peut, à sa discrétion, se décharger entièrement
de toutes obligations se rapportant à cette garantie en rem-
boursant le prix de gros de la(des) pièce(s) défectueuse(s).
6. Tous les frais/dépenses d'installation, de main-d'oeuvre, de
construction, de transport ou autres causés par une (des)
pièce(s) défectueuse(s), une réparation, un remplacement
ou autre, ne seront pas couverts sous cette garantie, et la
Société n'assume aucune responsabilité pour ceux-ci. De
plus, la Société ne pourra être tenue responsable pour tous
dommages fortuits ou indirects sauf la ou prévu par la loi.
7. Toutes autres garanties, exprimées ou sous-entendues, en
ce qui a trait au produit, ses composants et accessiores, ou
toutes obligations/responsabilités de la part de la Société
sont aux présentes expressment excluses.
8. La Société n'assume et n'autorise personne à assumer, en
son nom, toutes responsabilités en ce qui a trait à la vente
de ce produit Majestic Fireplaces.
9. Les garanties, telles que décrites dans ce document, ne
s'appliquent accessoires non CFM Home Products utilisés
conjointement pour l'installation de ce produit.
Cette garantie est nulle si:
a) Le poêle a été utilisé dans une atmosphère contaminée
par du chlore, du fluor ou tous autres produits chim
iques.
b) Le poêle est assujetti à de longues périodes d'humidité
ou de condensation.
c) Toute altération, abus volontaire, accident ou mauvais
usage du produit annulera cette garantie.
SI UN SERVICE SOUS GARANTIE EST REQUIS . . .
1) Communiquez avec votre détaillant. Assurez-vous que
vous avez votre garantie, votre reçu de caisse ainsi que le
numéro de modèle/série de votre produit CFM Home
Products.
2) NE TENTEZ PAS D'EFFECTUER DES REPARATIONS
VOUS-MEME.