Chad Valley 367/7423 Owner's manual

Double Swing Set
Assembly & User Instructions - Please keep for future reference 367/7423
Important - Please read these instructions fully before assembly or use.
These instructions contain important information which will help you get the best from your
product and ensure safe and correct assembly, use and maintenance.
Important
Maximum user
weight: 45kg
Age: 3 - 8years Tips: It will take 2 adults
around 30 minutes to
assemble.
If you need help or have damaged or missing parts, call the Customer Helpline:([phone]

Contents
Warnings
Parts
Assembly Instructions
Care and Maintenance
2-3
4
5-9
10
1

Warnings
Important –Please read these instructions fully before assembly or use.
Please read this instruction manual before you start to
assemble or use this swing set. You must follow all of the
safety instructions while using this equipment. Be absolutely
sure that the surface on which this swing set is set up on
is properly surfaced with fine sand, wood chips or double
shredded bark mulch .Do not use this swing set on hard
packed soil ,concrete or any other kind of hard surface.
Read all cautionary statements on pages 2 and 3 before
using this equipment.
WARNING
2
WARNING
YOUR CHILD`S SAFETY DEPENDS
ON YOU!
Suitable for children aged 3-8 years.
WARNING! Not suitable for children under the age of 36
months because of small part(s)-choking hazard.
Adult supervision is required at all times whilst the
product is in use. Never leave children
unattended during play.
Only one child per seat at any one time.
For outdoor use.
Check all nuts, bolts and fittings for tightness and tighten
if required.
Check all coverings for bolts and sharp edges and
replace when required.
Oil all metallic moving parts.
Check swing seats, ropes and other means of
attachments for evidence of deterioration. Replace
when required in accordance with the manufacture’s
instructions.
Please take note: As an extra precaution, check this toy
regularly for sings of wear and damage.
Place the product on a level surface at least 2 metres
from any structures or obstructions such as a fence,
garage, house, overhanging branches, laundry line or
electrical wires.
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
For safety reasons, this swing MUST be anchored into
the ground.
Anchors shall be placed level with or under the ground
in order to reduce the risk of tripping.
Ensure the child is not facing the sun when on the
swing.
Leave all fittings finger-tight until assembly is complete,
for ease of construction. The tighten firmly.
This item is not for adults or children weighing more
than 45kg.
DO NOT install the product on concrete, asphalt or hard
surfaces.
DO NOT allow children to stand on the swing seats.
DO NOT allow children to get off the swings while they
are still moving.
DO NOT twist swing ropes of wrap them over the top
bar.
DO NOT allow loose, hooded or baggy clothes to be
worn since children can get trapped and may be unable
to free themselves.
DO NOT allow children to climb on this equipment.
DO NOT allow children to wander into the play area
when the equipment is in use.
Swing must not exceed an angle of 60 degrees from the
ground.
Failure to assemble and maintain this item as per these
instructions may cause injury to the user.
Packaging materials are not toys. Please remove al
packaging and packing tags/wires before giving this toy
to your child.
Adult assembly required.
For use under adult supervision.
Maintenance to be carried out under the direct
supervision of a responsible adult.
For family domestic use only .
Once assembly is complete, carefully check the
equipment before use. If you find any problems, do not
allow children to use the equipment until it is fit for use.

Safety Information
Important –Please read these instructions fully before assembly or use.
3
Do not let children use the equipment until it has been
fully assembled.
Remove all assembly tools once fully assembled.
This product accommodates no more than 2 children.
Do not attach items to the equipment that are not
specifically designed for use with this product. Such as,
but not limited to cables skipping ropes and chains as
they may cause strangulation hazards.
Not suitable for hiring or commercial use.
Never use the equipment in any manner other than
intended.
Do not use the product when temperature are expected
to drop below 0. Remove all plastic parts and place
indoors after each use.
Shredded bark mulch, wood chips, fine sand of fine
gravel are considered to be acceptable shock-absorbing
surfaces when installed and maintained at a sufficient
depth under and around playground equipment.
However each material is only effective when properly
maintained. Material should be checked periodically and
replenished to maintain correct depth as determined
necessary for your equipment. Otherwise serious
injuries may occur form a fall.
Please keep assembly and installation instruction for
further reference.
●
●
●
●
●
●
●
●
●
●
●Warning. Only for domestic use.

Parts
Please Check you have all the parts fittings listed below
If you have damaged or missing parts,
call the Customer Helpline: ([phone]
4
Note: The quantities below are the correct amount to complete the assembly. In some cases more fittings
may be supplied than are required.
Ruler - Use this ruler to help correctly identify the bolts/screws
1
Beam x 1pcs
2
Beam x 1pcs
8
Anchor x 4pcs
4
Leg x 2pcs
3
Leg x 2pcs
6
Leg x 4pcs
5
Rail x 2pcs
7
Seat x 2pcs
9
C i scp4x pa Plast
x 2 (M8x62) x 4 (M8x54)
x 4
BA
G
I
H
x 1(6mm)
x 24 (Ф19xФ8.5 mm)
C
x 4 (Ф19xФ8.5mm)
D
x 14 (M8)
E
x 14 (Ф13.5xФ8.5mm)
F
x 1 (10&13)
(M8 x114mm)
DBLSW-LEG-LFT
DBLSW-LEG-RGT
SW-BEAM
SW-BEAMSHORT
SW-RAIL
DBLSW-LEG-BTM
SW-SEAT2
SW-ANCHOR2
SW-CAP
GEN-BOLTM8X62
GEN-ARCWASH-M8
GEN-FLATWASH-19X8.5
GEN-CAPNUT-M8 GEN-SPRWASH-M8
GEN-
UBOLTM8X114 GEN-ALWR6MM
GEN-SPAN5-11-13
GEN-BOLTM8X54

Assembly Instructions
Step 1
5
Figure 1
A
x 2pcs x 4pcs
J
x 2pcs
E
x 2pcs
C
Connect Beams (1)and (2)
together. No need to secure with
screws in this step.
Attach Legs (3) and (4) to Beam
(1) and (2) as shown in Figure
1.The legs need to be inversed on
the two sides of the swing frame.
4
3
A
C
C
F
E
X 2
34
3
4
2
1

Assembly Instructions
Step 2
6
Figure 2
G
x 4pcs
C
x 16pcs x 8pcs
E
x 8pcs
J
Attach swing Seats (7) to Beam
(1) and (2) as shown in Figure 2.
34
43
7
7
2
1
G
C
C
F
E
1
X 4

Step 3
7
Assembly Instructions
Insert Legs (6) into Legs(3) and (4)
and secure together with Rail (5)
as shown in the enlarged diagram.
Note:
-Plastic cap (9) needs to be
inserted into rail (5) before securing
the bolt.
-Rail (5) needs to be attached to
the outer sides of the swing frame.
After finishing all steps above go
over the entire unit and tighten all
bolts.
Figure 3
C
x 4pcs
D
x 4pcs x 4pcs
E
x 4pcs
B
x 4pcs
J
34
43
6
6
6
6
5
5
2
1
6
9
5FE
D
B
C
X 4

Step 4
8
Ground
30cm Depth
30cm
Width
Concrete
6
8
Attach anchors (8) to the
bottom of legs (6) as shown in
Figure 4
Assembly Instructions

9
SEAT ADJUSTABLE GUIDE
THE LENGTH OF THE ROPE IS ADJUSTABLE FOR THE HEIGHT OF THE CHILD
THROUGH THE SEAT CONNECTOR.
TO ADJUST, LOOSEN THE KNOT ON THE SEAT CONNECTOR, PULL ROPE
THROUGH THE HOLES AND TIGHTEN AGAIN.
MAKE SURE THAT THE KNOTS ARE TIGHT AND THAT BOTH ROPES ARE
ADJUSTED SO THAT THE SEAT IS HORIZONTAL.
IMPORTANT: MINIMUM CLEARANCE BETWEEN THE FOOTREST/SEAT
AND THE GROUND SHOULD BE 35 CM.
Assembly Instructions

10
Care and Maintenance
General
This Double Swing Set was designed and
manufactured with quality materials and
craftsmanship.
Inspect regularly for:
C H E C K A L L N U T S A N D B O LT S T W I C E
MONTHLY DURING THE USAGE SEASON FOR
TIGHTNESS AND TIGHTEN AS REQUIRED.
IT IS PARTICULARLY IMPORTANT THAT THIS
PROCEDURE BE FOLLOWED AT THE BEGINNING
OF EACH SEASON.
Never use pliers to tighten up screws –these can
cause damage to both the paintwork and the special
anti-corrosion plating.
Tighten all nuts and bolts securely. Replace as
needed. If not checked regularly, bolts can be loose
or missed and components can become detached and
cause injuries.
Check the unit at the beginning of the usage season
and monthly thereafter for evidence of deterioration.
Immediately remove and replace any items that
appear to be weak or broken. Contact Customer
Support for replacement parts.
Check all covers designed for bolts and sharp edges
regularly to be certain they are present and in good
condition. Replace as needed. It is particularly
use each season.
Inspect handle bar, hardware, and etc., for proper
closure and for signs of wear, deterioration, rust and/
or damage. Replace as needed.
Lubric ate all metalli c moving parts monthly
during the usage season. Applying a light coat of
automobile wax to all metal tubing surfaces will help
protect your unit and add to its longevity. Sand any
rusted areas of the metal tubing and repaint using a
non-lead based paint.
Remove plastic seats and store indoors, or do not
use when the temperature drops below 32°F/0°C.
Check unit for scuffs, burrs, sharp edges and any
other defects that may occur from assembly, abuse,
shipping or everyday use. Burrs and sharp edges
may be filed down until smooth and covered with
duct tape if necessary.
WARNING! Not suitable for
children under 3 years due to
small parts, chocking hazard.
To help maintain the products appearance,
occasionally clean the seats and metal framework
with a damp cloth lightly – but DO NOT use
abrasive chemical cleaners.
When the time comes to disassemble and dispose
of this product, please completely disassemble the
unit and discard of it in a safe place and manner
so as not to present any hazard to any individual. It
is important to check and maintain the main parts
at regular intervals.If these checks are not carried
out,the toy could overturn or otherwise become a
hazard.Whenever practical,the instructions shall
IMPORTANT!KEEP FOR FUTURE REFERENCE.
WARNING!
Suitable for children aged 3-8 years. Not
suitable for children under the age of 36
months because of small part(s)-choking
hazard. Packaging materials are not toys.
Please remove all packaging and packing
tags/wires before giving this toy to your
child. This item is not for adults or children
weighi ng m or e th an 45kg. Fo r fami ly
domestic use only.Suitable for outdoor use.
It is important that children be supervised at
all times . Do not leave children unattended.
Packaging materials are not toys.
([phone]:enilpleH remotsuC eht llac,strap gnissim ro degamad evah ro pleh deen uoy fI
Produced for Chad Valley Toys. Argos Ltd. Country of origin: China
Address: 489 - 499 Avebury Boulevard, Central Milton Keynes, MK9 2NW. www.argos.co.uk
SP-19-SW2R001-ARGOS-16001
If correct care and maintenance is taken, it will
provide users with longer usage for exercise,
fun and enjoyment.