Champion Industries 2000 Series Instruction Manual

ON
OFF
POWER
ON
OFF
POWER
WASH RINSE
Champion
5
WASH RINSE
ON
OFF
TURN OFF POWER BEFORE
SERVICING MACHINE
WARNI N G !
IN
CYCLE
POWER
START
6
79
WASH RINSE
ON
OFF
TURN OFF POWER BEFORE
SERVICING MACHINE
WARNI N G !
IN
CYCLE
POWER
START
321
4
180°F
20-22 PSI
minutes
Check the chemical levels in containers. Flip ON/OFF switch to ON position. The
switch will illuminate and the machine
will fill with water.
Wait 10 minutes for temperature gauge
to read 150°F/66°C .
Prescrap wares and load into rack.
Insert rack into machine and close
the doors.*
Check the final rinse pressure gauge
during the final rinse. The gauge
must indicate 20-22 PSI.
The Green In-cyle light will illuminate
and the machine will start a
60 second cycle.*
Flip ON/OFF switch to OFF position. The
switch will go out and the machine will
begin to drain.
Check the final rinse temperature gauge
during the final rinse. Minimum temperature
180°F/82°C.
The automatic electric drain valve will
remain open for 10 minutes and then
close automatically.**
*Opening the doors anytime during a cycle will pause
the cycle. Closing the doors will resume the cycle
where it left off.
** The Automatic Drain Cycle can be repeated after
10 minutes by turning the power switch ON
and then immediately OFF. The dishwasher will
drain for another 10 minutes and then turn OFF.
Form No. 114837 rev. B 1/23/13
2000 Series Dishwasher OPERATION
WASH RINSE
minutes
150°F
8

2000 Series Dishwasher CLEANING
Every 2 hours and at the end of the day
Flip ON/OFF switch to OFF
position. The machine will drain
automatically.
Push the power switch ON & immediately
to the OFF position to drain.
Remove the scrap screen support
filler plate. Remove the pump suction screen. Back flush the screens and plate in a remote sink. DO NOT strike
the screens against hard objects.
Clean the round drain screen
& flush the bottom of the tank.
Spray the interior of the machine
with fresh clean water. Remove the upper & lower spray arms and flush clean.
DO NOT spray the exterior of
the machine with water.
Wipe the exterior with mild detergent
and dry with soft cloth.
Remove the scrap screens from
the machine.
Reassemble machine and leave
hood open to aid in overnight drying.
DRY
OPEN
OVERNIGHT
1234
65 7 8
910 11 12
Form No. 114837 rev. B 1/23/13
ON
OFF
POWER
ON
OFF
POWER