Chevrolet 210 User manual

210 Chevrolet Models Owner’s Manual
Including
Limited Warranty Information

WARNINGS & CAUTIONS
DDooccNNoo::21906532-210C04 RReevv::00 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000044
WARNINGS AND CAUTIONS
This manual contains WARNINGS against operating
procedures which could result in an accident or bodily injury.
The manual also contains CAUTIONS against procedures
which could result in damage to your vehicle.
If you do not read the entire manual you may miss important
information. Observe all Warnings & Cautions.

WARNINGS & CAUTIONS
DDooccNNoo::21906532-210C04 RReevv::00 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000044
WARNINGS:
SEAT BELTS:
Only forward facing seats equipped with factory installed seat belts are to be occupied while the vehicle is in
motion. All passengers must be seated in these seats only, with the seat belts fastened while the vehicle is in
motion.
TV:
If your vehicle is equipped with an optional flat screen TV, the TV must be off and in the stored position
during travel.
LPG:
L.P.G. tanks shall not be placed or stored inside your vehicle. L.P.G. tanks are equipped with safety devices
which relieve excessive presser by discharging gas to the atmosphere.
To reduce the danger of fire or explosion do not store gasoline or other flammable liquids inside your vehicle.
Ensure you purchase L.P.G. From a reputable L.P.G. facility. Contaminated L.P.G. Is common cause of system
failure.
Do not refuel the L.P.G. tank to more than 80% of its capacity.
The L.P.G. tank valve must be closed and ALL PILOT LIGHTS, APPLIANCES, AND THEIR IGNITERS (see Operating
Instructions) SHALL BE TURNED OFF during refueling of motor fuel tank and/or the L.P.G. tank. Only qualified
personnel should refuel your L.P.G. tank.
APPLIANCES:
It is not safe to use cooking appliances for space heating purposes due to the danger of asphyxiation.
The L.P.G. Stove needs fresh air for its safe operation.
Portable fuel burning equipment, including wood or charcoal grills and stoves, should not be used inside
your vehicle. Use of this type of equipment inside your vehicle may cause fire or asphyxiation.
L.P.G. LEAK DETECTOR:
Do not block air circulation in the area where the L.P.G. Leak Detector is located.
Battery disconnect switch must be in the “ON” position for the L.P.G. detector to function.
CARBON MONOXIDE LEAK DETECTOR:
Do not block air circulation in the area where the carbon monoxide leak detector is located.
Battery disconnect switch must be in the “ON” position for the Carbon Monoxide Leak Detector to function.

WARNINGS & CAUTIONS
DDooccNNoo::21906532-210C04 RReevv::00 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000044
110 VOLT ELECTRICAL SERVICING:
Prior to servicing the 110 volt Galley GFCI & Audio/Video cabinet interior receptacles, unplug the output lead
from the power inverter.
EXTERIOR ACCESS DOORS:
Ensure power cord and city water line are disconnected and in their stored positions before vehicle is put in
motion.
CAUTIONS:
CLOVERLEAF DINING TABLE:
Cloverleaf dining table is heavy, lift while bending knees.
EXTRA COUNTER SPACE:
Make sure the stove is off and has cooled prior to lowering the stove cover.
TV:
When the vehicle is in motion it is recommended that the TV be “OFF” and in the stored position. The thumb
tab should be in place to secure the TV in the stored position.
AUXILIARY BATTERY:
Battery acid can burn skin and clothing. Protective eye wear and gloves should be worn when handling
batteries.
REPLACING THE AUXILIARY BATTERY:
Ensure that the inverter is disconnected prior to disconnecting the auxiliary battery.
GENERATOR:
When launching a boat, using your Roadtrek, it is important to know that the generator must not be
submerged in water.
WASTE WATER STORAGE AND DUMPING SYSTEM:
Ensure that both the black and gray water gate valves are closed (inward position) before using the waste
water system.
Under moderate subfreezing conditions, antifreeze is required in the exterior fresh water tank, black and gray
waste water tanks. Antifreeze should be used at a 50% water and 50% antifreeze ratio.
THE WARNINGS AND CAUTIONS IN THE QUICK REFERENCE ARE AN OVERVIEW AND
THERE ARE MORE NOTES AND INSTRUCTIONS WITHIN THIS MANUAL.

TABLE OF CONTENTS
DDooccNNoo::21906532-210C04 RReevv::00 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000044BB--11
Introduction ____________________________________________________________________________________________ A-0
Weight Ratings __________________________________________________________________________________________ A-1
Specifications (Automotive/Motorhome) ____________________________________________________________________A-2
Appliance Log __________________________________________________________________________________________A-3
Daily Living ____________________________________________________________________________________________ B-1
Captain’s Seats __________________________________________________________________________________________ B-1
Seat Belt Usage __________________________________________________________________________________________ B-1
Cloverleaf Dining Table ____________________________________________________________________________________ B-2
Dinette Table ____________________________________________________________________________________________ B-3
SSlleeeeppiinnggFFaacciilliittiieess________________________________________________________________________________________ B-4
Rear Twin Beds ____________________________________________________________________________________ B-4
Rear King-Bed ____________________________________________________________________________________ B-5
Front Lounge Seats ________________________________________________________________________________ B-6
WWaasshhrroooommaannddPPrriivvaaccyyAArreeaa________________________________________________________________________________ B-7
Rear Privacy Doors ________________________________________________________________________________B-7
WWaasshhrroooommFFaacciilliittiieess______________________________________________________________________________________ B-8
Toilet ____________________________________________________________________________________________ B-8
Stand-up Aisle Shower______________________________________________________________________________ B-8
Extra Counter Space ______________________________________________________________________________________ B-9
TV______________________________________________________________________________________________________ B-9
EExxtteerriioorrAAcccceessssDDoooorrss____________________________________________________________________________________ B-10
Driver Side Access Doors __________________________________________________________________________ B-10
L.P.G. (Liquid Propane Gas) Access Door ______________________________________________________________ B-11
Passenger Side Access Doors________________________________________________________________________ B-11
Auxiliary Battery ________________________________________________________________________________________ B-12
Replacing the Auxiliary Battery______________________________________________________________________________B-12
Spare Tire Storage________________________________________________________________________________________ B-13
Continental Spare Tire Kit __________________________________________________________________________________B-13
Caution Note (Mineralling) ________________________________________________________________________________B-13
Floor Plan & Appliance Location __________________________________________________________________________ C-1
Elevation (210-Popular Chevrolet)____________________________________________________________________________ C-1
Floor Plan with Appliance Location (210-Popular Chevrolet) ______________________________________________________ C-2
Electrical System ________________________________________________________________________________________ E-1
110 / 12V Charger ________________________________________________________________________________________ E-1
External Electrical Source Connection ________________________________________________________________________ E-1
Generator ______________________________________________________________________________________________ E-1
Built-in 110 V Heat Pump - Air Conditioner ____________________________________________________________________ E-1
Television ________________________________________________________________________________________________E-2
Monitor Panel ____________________________________________________________________________________________ E-2
Auxiliary Battery and Isolator ______________________________________________________________________________ E-3
Automotive Battery________________________________________________________________________________________ E-3
Interior Cab Light ________________________________________________________________________________________ E-3
Range Hood Exhaust Fan __________________________________________________________________________________ E-3
Water Heater ____________________________________________________________________________________________E-3
Rear Storage Light ________________________________________________________________________________________E-3
Electrical System Legend __________________________________________________________________________________ E-4
Electrical System Schematics ____________________________________________________________________________ E-5 - E-6
L.P.G. (Liquid Propane Gas) & Safety System ________________________________________________________________ F-1
L.P.G. Tank________________________________________________________________________________________________ F-2
Appliances ______________________________________________________________________________________________ F-2
Refueling Procedures ______________________________________________________________________________________ F-2
Regulator ________________________________________________________________________________________________ F-2
L.P.G. Leak Detector________________________________________________________________________________________ F-3
Carbon Monoxide Leak Detector ____________________________________________________________________________ F-3
Smoke Detector __________________________________________________________________________________________ F-3
L.P.G. System Schematic (210-Popular Chevrolet) ______________________________________________________________ F-4

TABLE OF CONTENTS
DDooccNNoo::21906532-210C04 RReevv::00 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000044BB--11
Water Systems __________________________________________________________________________________________ G-1
Winter Mode Valve Position ________________________________________________________________________________ G-1
Winter Use ______________________________________________________________________________________________G-1
Summer Use Valve Position ________________________________________________________________________________ G-1
Water Systems (Summer & Winter mode)______________________________________________________________________ G-2
To De-Winterize __________________________________________________________________________________________ G-3
Fresh Water Tanks ________________________________________________________________________________________ G-4
Filling the Interior Fresh Water Tank __________________________________________________________________ G-4
Filling the Exterior Fresh Water Tank __________________________________________________________________ G-4
City Water Connection______________________________________________________________________________ G-5
Waste Water Storage and Dumping System ____________________________________________________________________ G-6
Waste Water Tank Preparation ______________________________________________________________________________G-6
Waste Water Tank Dumping ________________________________________________________________________________ G-7
Waste Water Tank Flushing ________________________________________________________________________________ G-8
Outside Shower __________________________________________________________________________________________ G-8
Potable Water System Draining ____________________________________________________________________________ G-8
Potable Water System Sanitizing ____________________________________________________________________________ G-9
Water System Winterizing __________________________________________________________________________________G-9
Water System Schematic __________________________________________________________________________________G-10
Owner Maintenance______________________________________________________________________________________ H-1
Fiberglass Maintenance ____________________________________________________________________________________ H-1
Exterior Washing__________________________________________________________________________________________ H-1
Other Maintenance ______________________________________________________________________________________ H-1
Winter Storage __________________________________________________________________________________________ H-1
Inside Your Vehicle ________________________________________________________________________________ H-1
Outside Your Vehicle ______________________________________________________________________________ H-1
Spring Start-Up __________________________________________________________________________________________ H-2
Tires____________________________________________________________________________________________________ H-2
Cargo Carrying Capacity __________________________________________________________________________________ H-2
Owner Maintenance Checks ________________________________________________________________________________ H-2
When You Stop for Fuel ____________________________________________________________________________ H-2
At Least Monthly __________________________________________________________________________________ H-2
At Least Once Every Three Months ____________________________________________________________________ H-2
At Least Twice A Year ______________________________________________________________________________ H-3
At Least Once A Year ______________________________________________________________________________ H-3
Auxiliary Battery __________________________________________________________________________________________ H-3
Aluminum Wheel Maintenance ______________________________________________________________________________ H-4
Limited Warranty Information ______________________________________________________________________________ I-1
Limited Warranty Definitions ________________________________________________________________________________ I-1
Home & Park Limited Warranty Registration Card ________________________________________________________________ I-1
Automotive Warranty - General Motors (Chevrolet Chassis) ________________________________________________________ I-1
Limited Warranty Information ________________________________________________________________________________ I-2
Automotive Customer Service & Roadside Assistance Numbers ____________________________________________________ I-2
Appliance Warranty ________________________________________________________________________________________ I-2
Home & Park Motorhomes Limited Warranty____________________________________________________________________ I-2
Customer Assistance ______________________________________________________________________________________ J-1
Reporting Safety Defects (U.S. Only) __________________________________________________________________________ J-1
Roadtrek Ambassador Potential Customer Referral Program for Roadtrek Owners ____________________________________ J-1
Roadtrek Club International ________________________________________________________________________________ J-2
Address, Phone & Facsimile Numbers, and E-mail ________________________________________________________________ J-2
Website ________________________________________________________________________________________________J-2
Obtaining Motorhome Service ____________________________________________________________________________ K-1
Roadtrek International Chapter FMCA / A Roadtrek Owners’ Club Membership Forms ____________________________ L-1
CChhaannggeeooffOOwwnneerrNNaammeeoorrAAddddrreessssForm ____________________________________________________________________ L-2
Potential Customer Referral Card __________________________________________________________________________ L-4

INTRODUCTION
DDooccNNoo::21906532-210C04 RReevv::00 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000044AA--00
A WORD TO ROADTREK OWNERS...
This manual has been prepared to acquaint you with the operation, maintenance and warranties of your new
Roadtrek Motorhome Van. Your vehicle has been designed, engineered and manufactured to provide you with
the utmost in pleasure, dependability and quality. It is important that you read the contents of this manual, that of
the Chevrolet chassis and those of other components, and follow the instructions and recommendations contained
in each to help assure the most enjoyable and trouble free operation of your vehicle.
We would like to take this opportunity to thank you for selecting a Roadtrek product and assure you of our
continuing commitment to your recreational vehicle pleasure, safety and satisfaction.
INTRODUCTION
This manual has been written to provide you with the information required to properly operate and maintain your
new Roadtrek. After reading this manual, be sure to keep it in your vehicle as a reference.Your Roadtrek dealer will
be glad to answer any further questions about the operation of your vehicle.
IMPORTANT
Every reasonable precaution has been undertaken in the preparation of this manual resulting in the utmost
accuracy possible at the time of publication. However, due to the continuing improvement and refinement of our
products and normal changes in information and procedures, Home & Park shall assume no responsibility
whatsoever for errors or omissions in the manual’s contents.
Further, Home & Park shall not be held liable or assume any obligations or responsibilities whatsoever for any loss,
damage or injury directly or indirectly caused by, arising or resulting from, or as a consequence of the use or
nonuse of the information contained herein or the operation or non-operation of any items mentioned herein. And
finally, Home & Park shall be indemnified and saved harmless from all losses, expenses, claims and demands
whatsoever.

INTRODUCTION
DDooccNNoo::21906532-210C04 RReevv::00 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000044A-1
Weight Ratings
Gross Vehicle Weight Rating (GVWR): is the maximum
permissible weight of this vehicle when fully loaded. It
includes all weight at the vehicle axle(s).
Unloaded Vehicle Weight (UVW): is the weight of this
motorhome as manufactured at the factory. It includes all
weight at the vehicle axle(s). If applicable, it also includes full
generator fluids, including fuel, engine oil and coolants.
Cargo Carrying Capacity (CCC): is equal to GVWR minus
each of the following: UVW, full fresh (potable) water weight
(including water heater), and full LP-Gas weight and SCWR.
Gross Combined Weight Rating (GCWR): means the
maximum allowable loaded weight of this motorhome and
any towed trailer or towed vehicle.
Canadian Models - Seating Capacity Weight Rating (SCWR)
US Models - Sleeping Capacity Weight Rating (SCWR): is
the manufacturer’s designated number of sleeping positions
multiplied by 154 pounds (70 kilograms).
Gross Axle Weight Rating (GAWR): is the value specified as
the load carrying capacity of a single axle system, as
measured at the tire-ground interfaces.
Towing Guidelines: Consult Chevrolet Owners Manual(s) for
specific weighing instructions and towing guidelines
including auxiliary brake requirements for any towed trailer
or towed vehicle.
Weighing Procedure: Prior to weighing each unit, the fuel
tank must be full, as well as the fresh water tank. All tires
must be of equal pressure, and any snow must be removed.
Note the weighing must be done on level ground!
Equipment: 2 Portable Scales (including electrical power source), 2 wooden ramps, lift and pressure gauge.
Alternate: D.O.T. approved customer scales
Note: Wooden ramps must be equal to or less than 1/8” of the height of the scales being used.
Procedure:
1) Fill Fuel Tank
2) Fill Fresh Water Tank
3) Measure all tire pressures and equalize if necessary
4) Place wooden ramps below rear wheels (using lift or driving onto ramps for levelling vehicle; N/A if
commercial scales used)
5) Place scales under front wheels
6) Record scale readings
7) Repeat for rear wheels
Sample of Canadian Weight label:
Sample of US Weight label: