ChildLife Outback XL User manual

PG-MA-0029-02
817 Maxwell Avenue • Evansville, IN 47711 • 1-800-GO-SWING • www.escaladesports.com • ©2016 Escalade Sports
X L
O U T B A C K

Here are some maintenance tips required to insure safe enjoyment of your equipment for years to come.
A. At the beginning of each usage season and every two weeks during, check: nuts and bolts and tighten as needed,
swing seats, chains, ladders, slides, rope and wood components for signs of deterioration and replace if necessary.
B. On a yearly basis, we recommend that you coat your playset with a sealant or preservative. You may also want to spot
sand any areas prior to sealing. Be sure that the sealant you select is non-toxic and child safe.
C. Do not use line trimmers or “weed eaters” around your play equipment. The line will remove both stain and wood
from uprights and base pieces. Any damage resulting from this type of abuse is not covered under our limited
warranty.
D. Remove plastic swing seats and take indoors or do not use when the temperature drops below 0º F.
Welcome to our family of ready-to-build backyard play equipment. WOODPLAY playsets are designed with ease of
assembly in mind and we provide these step-by-step installation instructions.
After reading the information below, locate your structure site and carefully unpack parts. As you unpack your playset,
keep the parts identification sheet handy and become familiar with each part before beginning assembly. Remember that
a little extra time spent familiarizing yourself with the parts and instructions before you begin will help you avoid mistakes
and save you time later.
Choosing A Location For Your Playset
Do not install home playground equipment indoors,
or over concrete, asphalt, packed earth, grass, carpet
or any other hard surface. A fall onto a hard surface
can result in serious or fatal injury.
Responsible on-site adult supervision is one of the
most important contributions to children’s safety that
you can make. WOODPLAY strongly recommends on-
site adult supervision of children of all ages. Safe
swinging and climbing skills need to be taught to
children, just like any other physical activity.
The weight limit for any single user on WOODPLAY
play equipment is 200 pounds. Limit the number of
users to one on each swing. The tower portion of the
play system will accommodate four (4) additional
users.
When the time comes to disassemble and dispose of
the play equipment, do so in such a way that no
hazards will exist at the time the equipment is
discarded.
Maintaining Your Playset
I N T R O D U C T I O N
When selecting your structure site, always keep the
child’s safety in mind. Here are some recommendations
to help you create a safe play area.
A. The playset should be located on level ground. The
stationary components such as ladders and slides are
REQUIRED to be a minimum of six feet from any structure
or obstruction such as a fence, garage, house, tree or
overhanging branches, electrical wires or clotheslines.
Any swinging equipment is also to be a REQUIRED
minimum distance twice the height of the swing beam
away from these obstructions or structures as well. We
also recommend that you do not install your playset
near a lake, river, swimming pool or other water hazard.
B. The U.S. Consumer Product Safety Commission (CPSC)
recommends that you install and maintain a resilient
surface under your play equipment. The CPSC’s
Consumer Information Sheet for Playground Surfacing
Materials at the end of this manual. A resilient surface,
should be installed after the equipment has been
completely assembled according to these instructions.
The equipment must rest on solid ground. Please note
that this product has a maximum fall height of 8’.
Welcome to our family of ready-to-build backyard play equipment. WOODPLAY playsets are designed with ease of
assembly in mind and we provide these step-by-step installation instructions.
After reading the information below, locate your structure site and carefully unpack parts. As you unpack your playset,
keep the parts identification sheet handy and become familiar with each part before beginning assembly. Remember that
a little extra time spent familiarizing yourself with the parts and instructions before you begin will help you avoid mistakes
and save you time later.
Choosing A Location For Your Playset
I N T R O D U C T I O N
Do not install home playground equipment indoors,
or over concrete, asphalt, packed earth, grass, carpet
or any other hard surface. A fall onto a hard surface
can result in serious or fatal injury.
Responsible on-site adult supervision is one of the
most important contributions to children’s safety that
you can make. WOODPLAY strongly recommends on-
site adult supervision of children of all ages. Safe
swinging and climbing skills need to be taught to
children, just like any other physical activity.
The weight limit for any single user on WOODPLAY
play equipment is 200 pounds. Limit the number of
users to one on each swing. The tower portion of the
play system will accommodate four (4) additional
users.
When the time comes to disassemble and dispose of
the play equipment, do so in such a way that no
hazards will exist at the time the equipment is
discarded.
When selecting your structure site, always keep the
child’s safety in mind. Here are some recommendations
to help you create a safe play area.
A. The playset should be located on level ground. The
stationary components such as ladders and slides are
REQUIRED to be a minimum of six feet from any structure
or obstruction such as a fence, garage, house, tree or
overhanging branches, electrical wires or clotheslines.
Any swinging equipment is also to be a REQUIRED
minimum distance twice the height of the swing beam
away from these obstructions or structures as well. We
also recommend that you do not install your playset
near a lake, river, swimming pool or other water hazard.
B. The U.S. Consumer Product Safety Commission (CPSC)
recommends that you install and maintain a resilient
surface under your play equipment. The CPSC’s
Consumer Information Sheet for Playground Surfacing
Materials at the end of this manual. A resilient surface,
should be installed after the equipment has been
completely assembled according to these instructions.
The equipment must rest on solid ground. Please note
that this product has a maximum fall height of 8’.
If you have any questions about your playset, or are in need of replacement parts, call 1-800-GO-SWING.
Please keep these instructions for future reference.
2
If you have any questions about your playset, or are in need of replacement parts, call 1-800-GO-SWING.
Please keep these instructions for future reference.
2

In Addition, Adults Must:
• Not to walk close to, in front of, behind, or between
moving items.
• Not to twist the swing ropes, or loop them over the
top support bar, since this may reduce the strength
of the rope.
• Not to swing empty swing seats.
• Not to swing sideways into the path of adjacent
swings.
• Not to use the equipment in a manner other than
that for which it is intended.
• Not to get off the equipment while it is
in motion.
• Not to jump off the tower.
• Not to climb or swing when they are wet or when the
equipment is wet.
• Not to stand in the swing seats.
• Not to ride or leave bicycles or other toys in the
swing area.
• Not to use hammers, saws, nails, or wrenches on
the equipment.
• Not to swing so high that chains become slack, or
above the height of the swing support.
• Not to jump on a slide.
• Not to climb on top of the swing support.
• Not to attach to the playground equipment any item
that is not specifically designed for use with the
equipment, such as (but not limited to) jump ropes,
clotheslines, pet leashes, cables, and chains. These
may become strangulation hazards.
• To sit in the center of the swings with their full.
weight on the seats.
• To hold on to swings and climbers with.
both hands.
• To slide feet first, never head first..
• To watch for other children while swinging or playing.
near the equipment.
• Limit climbing and swinging heights to each child’s
ability.
• Verify that suspended climbing ropes are secured at
both ends.
• Verify that suspended climbing ropes cannot be
looped back on themselves.
• Dress children appropriately for play. Use well-fitting
shoes that do not have slippery soles.
Avoid ponchos, scarves, hoods, loose-fitting clothing,
neckties, and any clothing with a drawstring. Serious
injury could result should any part of the children’s
clothing become entangled in the equipment.
• Do not allow children to play wearing helmets.
• Remember that children are inventive. When they
develop games that are unsafe, be alert and change
the rules.
Teach Children:
S A F E T Y I N S T R U C T I O N S
3

PART NUMBER
RP-TWG-192
RP-TWG-216
RP-TWG-234
PG-HW-L015
PG-2X4-028-RLD
PG-2X4-061-HRS
PG-2X4-068-HRS
PG-4X4-010-RB
PG-4X4-020-BRL
PG-4X4-020-BRR
PG-4X4-026-BRR
PG-4X4-040-CP
PG-4X4-040-VPD-A
PG-4X4-069-BS
PG-4X4-092-VRS
PG-4X4-106-AA
PG-4X4-106-BSRL
PG-4X4-106-RLAA
PG-4X4-126-HRS-A
PG-4X6-017-BRL
PG-4X6-017-BRR
PG-4X6-138-DS
PG-HW-B013
PG-HW-L002
PG-HW-L009
PG-HW-L011
PG-HW-L013
PG-HW-N004
PG-HW-N005
PG-HW-W002
PG-HW-W004
PG-HW-W005
RW-4X4-025-FIL-A
RW-DEK-054-030
RW-DEK-054-029
VL-RFG-182-060
RP-TWG-162
RP-TWG-192
RP-TWG-216
DESCRIPTION
Ladder Rope for 5' Deck Height
Ladder Rope for 6' Deck Height
Ladder Rope for 7' Deck Height
3/8" X 5 1/2" Lag Screw
27 1/2" Rope Ladder Rung
60 5/8" Horizontal Roof Support
67 3/8" Horizontal Roof Support
10" Ramp Rope Block
20" - 45 Degree Angle Brace Left
20" - 45 Degree Angle Brace Right
26 1/2" 45 Degree Angle Brace Right
40 1/4" - Corner Post
40 1/4” - Vertical Panel Divider
69" Base Support
Vertical Roof Support
106" Accessory Arm
106" Base Support Rope Ladder
106" Rope Ladder
126" Horizontal Roof Support
17" - 30 Degree Angle Brace Left
17" - 30 Degree Angle Brace Right
108" Deck Support
1/2"-13 x 6" Hex Bolt
1/4" x 4.5" Lag Screw
1/4 x 3" Hex Lag Screw
3/8" X 3" Lag Screw
3/8" X 4" Lag Screw
1/2" Nylon Locknut
1/2"-13 Acorn Nut
1/4" Flat Washer
3/8" Flat Washer
1/2" Flat Washer
25" Ladder Filler
53 5/8" Deck - 30 1/8 Wide
53 5/8” Deck - 29 Wide
182" x 60" Vinyl Roof
Climbing Wall Rope for 5' Deck Height
Climbing Wall Rope for 6' Deck Height
Climbing Wall Rope for 7' Deck Height
QTY.
3
6
7
1
2
1
5
4
1
4
4
1
2
1
1
1
2
2
2
2
24
28
24
6
36
24
24
52
55
48
1
2
1
1
1
O U T B A C K X L P A R T S L I S T
4
NOTE: Woodplay playsets are sold in both Redwood and Chinese Cedar. All the part numbers in this manual with the
suffix “PG-“ are made of Chinese Cedar. If you have a Redwood set change the suffix to “PGR-“ to order redwood parts.

1/2" Flat Washer
PG-HW-W005
1/2"-13 x 6" HEX BOLT
PG-HW-B013
1/2" NYLON LOCKNUT
PG-HW-N004
1/2"-13 ACORN NUT
PG-HW-N005
3/8" Flat Washer
PG-HW-W004
3/8" X 4" Lag Screw
PG-HW-L013
3/8" X 5 1/2" Lag Screw
PG-HW-L015
3/8" X 3" Lag Screw
PG-HW-L011
1/4" Flat Washer
PG-HW-W002
1/4" x 4.5" LAG SCREW
PG-HW-L002
1/4 x 3" Hex Lag Screw
PG-HW-L009
3/8- 16 x 1.5" Socket Head Screw
PG-HW-B002
3/8"-16 X 1/2" T-NUT
PG-HW-N002
#8X2 1/2 PH FLAT HD WDSCR
PG-HW-S009
#14 X 1.5" Round Phil Head Screw
PG-HW-S013
O U T B A C K X L H A R D W A R E I D E N T I F I E R
Measurement taken from bottom of bolt head to the bottom of bolt
5
3/8" Narrow Flat Washer
PG-HW-W012
#10X2 1/2 PH FLAT HD WDSCR
PG-HW-S012

108" Deck Support
PG-4X6-138-DS
106" Base Support Rope Ladder
PG-4X4-106-BSRL
Vertical Roof Support
PG-4X4-092-VRS
106" Accessory Arm
PG-4X4-106-AA
126" Horizontal Roof Support
PG-4X4-126-HRS-A
106" Rope Ladder
PG-4X4-106-RLAA
O U T B A C K X L P A R T S I D E N T I F I E R
6
40 1/4" Vertical Panel Divider
PG-4X4-040-VPD-A
NOTE: Woodplay playsets are sold in both Redwood and Chinese Cedar. All the part numbers in this manual with the
suffix “PG-“ are made of Chinese Cedar. If you have a Redwood set change the suffix to “PGR-“ to order redwood parts.

17" - 30 Degree Angle Brace Right
PG-4X6-017-BRR
17" - 30 Degree Angle Brace Left
PG-4X6-017-BRL
26 1/2" 45 Degree Angle Brace Right
PG-4X4-026-BRR 20" - 45 Degree Angle Brace Left
PG-4X4-020-BRL 20" - 45 Degree Angle Brace Right
PG-4X4-020-BRR
60 5/8" Horizontal Roof Support
PG-2X4-061-HRS
67 3/8" Horizontal Roof Support
PG-2X4-068-HRS
69" Base Support
PG-4X4-069-BS 40 1/4" - Corner Post
PG-4X4-040-CP
10" Ramp Rope Block
PG-4X4-010-RB
O U T B A C K X L P A R T S I D E N T I F I E R
7
182" x 60" Vinyl Roof
VL-RFG-182-060
27 1/2" Rope Ladder Rung
PG-2X4-028-RLD

25" PANEL TOP
PG-2X4-025-PBT
25" PANEL BOTTOM DRILLED
PG-2X4-025-PBB-A
2 x 3 x 30-1/4 PANEL RUNG
PG-2X3-030-PR
25" PANEL BOTTOM
PG-2X4-025-PBB
PARTS FOR SIDE PANEL:
PART NUMBER
PG-2X4-025-PBT
PG-2X4-025-PBB-A
PG-2X3-030-PR
PG-2X4-025-PBB
PG-HW-W002
PG-HW-L009
PG-HW-S009
DESCRIPTION
25" Panel Top
25" Panel Bottom Drilled
2 X 3 X 30-1/4 Panel Rung
25" Panel Bottom
1/4" Flat Washer
1/4 X 3" Hex Lag Screw
#8x2 1/2 Ph Flat Hd Wdscr
QTY.
1
1
5
1
2
2
20
O U T B A C K X L P A R T S I D E N T I F I E R
8
PARTS FOR DECK:
PART NUMBER
PG-2X6-054-DEK
PG-2X4-054-DEK
PG-2X6-030-BB
PG-2X4-028-BB
PG-HW-S009
DESCRIPTION
53 5/8" Deck / Picnic Tbl Board
53 5/8" Deck / Picnic Tbl Board
30" Deck Backboard
27 1/2" Deck Backboard
#8X2 1/2 PH FLAT HD WDSCR
QTY.
4
2
1
2
36

69" Chain Ladder Rail
PG-4X4-069-CL
69" Step Chain Ladder Rail Left
PG-4X4-069-STP-CHN-L
69" Step Chain Ladder Rail Right
PG-4X4-069-STP-CHN-R
SPLIT LADDER FOR 5’ DECK:
18 1/4 Ladder Step
PG-2X6-018-STP
43" ROUND RUNG
PG-ST-0011
62 1/8 x 20 1/8" Chain Ladder Split
ST-CHLAD76-SP
PART NUMBER
PG-4X4-069-STP-CHN-R
PG-4X4-069-STP-CHN-L
PG-4X4-069-CL
ST-CHLAD76-SP
PG-ST-0011
PG-2X6-018-STP
PG-HW-W002
PG-HW-L002
DESCRIPTION
69" Step Chain Ladder Rail Right
69" Step Chain Ladder Rail Left
69" Chain Ladder Rail
62 1/8 X 20 1/8" Chain Ladder Split
43" Round Rung
18 1/4 Ladder Step
1/4" Flat Washer
1/4" X 4.5" Lag Screw
QTY.
1
1
1
1
2
4
16
16
9

83 3/4" Step - Chain Ladder Rail Right
PG-4X6-084-STP-CHN-R
81 3/4" Step / Chain Ladder Rail Left
PG-4X6-082-STP-CHN-L 83 3/4" Rung - Chain Ladder Rail Left
PG-4X6-084-RNG-CHN-L
SPLIT LADDER FOR 6’ DECK:
43" ROUND RUNG
PG-ST-0011
62 1/8 x 20 1/8" Chain Ladder Split
ST-CHLAD76-SP
18 1/4" Ladder Step
PG-2X8-018-STP
24" ROUND RUNG
PG-ST-0010
PART NUMBER
PG-4X6-084-STP-CHN-R
PG-4X6-082-STP-CHN-L
PG-ST-0011
PG-4X6-084-RNG-CHN-L
ST-CHLAD76-SP
PG-2X8-018-STP
PG-ST-0010
PG-HW-W002
PG-HW-L002
DESCRIPTION
83 3/4" Step - Chain Ladder Rail Right
81 3/4" Step / Chain Ladder Rail Left
43" Round Rung
83 3/4" Rung - Chain Ladder Rail Left
62 1/8 X 20 1/8" Chain Ladder Split
18 1/4" Ladder Step
24" Round Rung
1/4" Flat Washer
1/4" X 4.5" Lag Screw
QTY.
1
1
2
1
1
5
1
20
20
10

98 1/2" Step - Chain Ladder Rail Right
PG-4X6-099-STP-CHN-R 98 1/2" Rung - Chain Ladder Rail Left
PG-4X6-099-RNG-CHN-L
97 1/4" Step- Chain Ladder Rail Left
PG-4X6-097-STP-CHN-L
SPLIT LADDER FOR 7’ DECK:
18 1/4" Ladder Step
PG-2X8-018-STP
43" ROUND RUNG
PG-ST-0011
86 7/8 x 20 1/8 Chain Ladder
ST-CHLAD99-SP
PART NUMBER
PG-4X6-099-STP-CHN-R
PG-4X6-097-STP-CHN-L
PG-ST-0011
PG-4X6-099-RNG-CHN-L
ST-CHLAD99-SP
PG-2X8-018-STP
PG-HW-W002
PG-HW-L002
Description
98 1/2" Step - Chain Ladder Rail Right
97 1/4" Step- Chain Ladder Rail Left
43" Round Rung
98 1/2" Rung - Chain Ladder Rail Left
86 7/8 X 20 1/8 Chain Ladder
18 1/4" Ladder Step
1/4" Flat Washer
1/4" X 4.5" Lag Screw
QTY.
1
1
2
1
1
6
24
24
11

47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-D
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-B
69" Climbing Wall Rail
PG-4X4-069-CWR
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-A
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-C
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-E
PART NUMBER
PG-4X4-069-CWR
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-C
PG-546-047-CWB-D
PG-546-047-CWB-E
PG-HW-N002
PG-HW-B002
PG-HW-W012
PG-HW-W002
PG-HW-S013
PG-HW-S009
PG-AC-0003
Description
69" Climbing Wall Rail
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
3/8"-16 X 1/2" T-nut
3/8- 16 X 1.5" Socket Head Screw
3/8” Narrow Flat Washer
1/4" Flat Washer
#14 X 1.5" Round Phil Head Screw
#8x2 1/2 Ph Flat Hd Wdscr
Climbing Rock
QTY.
2
3
3
1
4
1
16
16
16
16
16
48
16
CLIMBING WALL FOR 5’ DECK:
CLIMBING ROCK
PG-AC-0003
12

83 3/4" Climbing Wall Rail Left
PG-4X6-084-CWRL
83 3/4" Climbing Wall Rail Right
PG-4X6-084-CWRR 47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-A
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-B
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-D 47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-E
47" x 1 x 3 1/2 Climb Wall Board Rip CLIMBING ROCK
PG-AC-0003
PG-546-047-CWB-R
CLIMBING WALL FOR 6’ DECK:
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-C
PART NUMBER
PG-4X6-084-CWRR
PG-4X6-084-CWRL
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-D
PG-546-047-CWB-C
PG-546-047-CWB-E
PG-546-047-CWB-R
PG-HW-B002
PG-HW-W012
PG-HW-S013
PG-HW-W002
PG-HW-S009
PG-HW-N002
PG-AC-0003
Description
83 3/4" Climbing Wall Rail Right
83 3/4" Climbing Wall Rail Left
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 3 1/2 Climb Wall Board Rip
3/8-16 X 1.5" Socket Head Screw
3/8” Narrow Flat Washer
#14 X 1.5" Round Phil Head Screw
1/4" Flat Washer
#8x2 1/2 Ph Flat Hd Wdscr
3/8"-16 X 1/2" T-nut
Climbing Rock
QTY.
1
1
5
4
2
2
1
1
16
16
16
16
60
16
16
13

47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-C
98 1/2" Climbing Wall Rail Left
PG-4X6-099-CWRL
98 1/2" Climbing Wall Rail Right
PG-4X6-099-CWRR
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-E
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-D
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB-A
47" x 1 x 5 1/2 Climbing Wall Board
PG-546-047-CWB
PART NUMBER
PG-4X6-099-CWRR
PG-4X6-099-CWRL
PG-546-047-CWB-E
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-C
PG-546-047-CWB-D
PG-546-047-CWB
PG-HW-W002
PG-HW-W012
PG-HW-S013
PG-HW-B002
PG-HW-N002
PG-HW-S009
PG-AC-0003
Description
98 1/2" Climbing Wall Rail Right
98 1/2" Climbing Wall Rail Left
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
47" X 1 X 5 1/2 Climbing Wall Board
1/4" Flat Washer
3/8” Narrow Flat Washer
#14 X 1.5" Round Phil Head Screw
3/8- 16 X 1.5" Socket Head Screw
3/8"-16 X 1/2" T-nut
#8x2 1/2 Ph Flat Hd Wdscr
Climbing Rock
QTY.
1
1
1
3
5
3
4
1
20
20
20
20
20
68
20
CLIMBING WALL FOR 7’ DECK:
CLIMBING ROCK
PG-AC-0003
14

PG-HW-S013
#14 X 1.5" Round
Phil Head Screw
PG-HW-B002
3/8- 16 x 1.5"
Socket Head
Screw
PG-HW-W002
1/4" Flat Washer
CLIMBING ROCK
ASSEMBLY OF CLIMBING WALL FOR 5’ DECK:
47"
PG-546-047-CWB-D
PG-HW-N002
3/8"-16 X 1/2" T-NUT
PG-HW-S009
#8X2 1/2 PH FLAT
HD WDSCR
PG-546-047-CWB-D
PG-546-047-CWB-C
PG-546-047-CWB-B
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-D
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-D
PG-546-047-CWB-E
PG-546-047-CWB-A
69" Climbing Wall Rail
PG-4X4-069-CWR
69" Climbing Wall Rail
PG-4X4-069-CWR
Wall Rail
15
PG-HW-W012
3/8” Narrow
Flat Washer
1"
SIDE VIEW

47"
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-D
PG-546-047-CWB-C
PG-546-047-CWB-B
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-D
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-A
PG-546-047-CWB-C
PG-546-047-CWB-A
PG-546-047-CWB-E
PG-546-047-CWB-R
PG-HW-S009
#8X2 1/2 PH FLAT
HD WDSCR
PG-HW-N002
3/8"-16 X 1/2" T-NUT
ASSEMBLY OF CLIMBING WALL FOR 6’ DECK:
83 3/4" Climbing Wall Rail Right
PG-4X6-084-CWRR
83 3/4" Climbing
PG-4X6-084-CWRL
Wall Rail Left
16
PG-HW-B002
3/8-16 x 1.5" Socket
Head Screw
PG-HW-S013
#14 X 1.5" Round
Phil Head Screw
PG-HW-W002
1/4" Flat Washer
CLIMBING ROCK
PG-HW-W012
3/8” Narrow
Flat Washer
2"
SIDE VIEW

47"
PG-HW-S009
#8X2 1/2 PH FLAT
HD WDSCR
PG-546-047-CWB-B
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-D
PG-546-047-CWB-B
PG-546-047-CWB-A
PG-546-047-CWB-E
PG-546-047-CWB
PG-546-047-CWB-D
ASSEMBLY OF CLIMBING WALL FOR 7’ DECK:
98 1/2" Climbing
Wall Rail Left
PG-4X6-099-CWRL
98 1/2" Climbing Wall Rail Right
PG-4X6-099-CWRR
17
PG-546-047-CWB-C
PG-546-047-CWB-D
PG-546-047-CWB-B
PG-546-047-CWB-C
PG-546-047-CWB-A
PG-546-047-CWB-B
PG-546-047-CWB-D
PG-546-047-CWB-C
PG-HW-S013
#14 X 1.5" Round
Phil Head Screw
PG-HW-W002
1/4" Flat Washer
PG-HW-B002
3/8-16 x 1.5"
Socket Head Screw
CLIMBING ROCK
PG-HW-W012
3/8” Narrow
Flat Washer
2-3/8"
SIDE VIEW
PG-HW-N002
3/8"-16 X 1/2" T-NUT

3/8" X 5 1/2" Lag Screw
3/8" X 4" Lag Screw
3/8" Flat Washer
3/8" Flat Washer
3/8" X 4" Lag Screw
PG-4X4-069-BS
69" Base Support
PG-4X4-020-BRR
20" - 45 Degree
Angle Brace Right
18
SIDE VIEW
2"

PG-HW-L002
1/4" x 4.5" LAG SCREW
PG-HW-W002
1/4" Flat Washer
PG-4X4-069-STP-CHN-R
69" Step Chain Ladder Rail Right
PG-ST-0011
43" ROUND
RUNG
PG-2X6-018-STP
18 1/4 Ladder Step
PG-4X4-069-STP-CHN-L
69" Step Chain Ladder Rail Left
ASSEMBLY OF SPLIT LADDER FOR 5’ DECK:
PG-4X4-069-CL
69" Chain Ladder Rail
ST-CHLAD76-SP
62 1/8 x 20 1/8" Chain
Ladder Split
19
47” Finished Width
SIDE VIEW
Center Step
within Ladder

PG-ST-0011
43" ROUND
RUNG
PG-2X8-018-STP
18 1/4" Ladder Step
PG-HW-L002
1/4" x 4.5" LAG SCREW
PG-HW-W002
1/4" Flat Washer
PG-4X6-082-STP-CHN-L
81 3/4" Step / Chain
Ladder Rail Left
PG-4X6-084-STP-CHN-R
83 3/4" Step - Chain Ladder Rail Right
ASSEMBLY OF SPLIT LADDER FOR 6’ DECK:
20
PG-ST-0010
24" ROUND RUNG
PG-4X6-084-RNG-CHN-L
83 3/4" Rung - Chain
Ladder Rail Left
ST-CHLAD76-SP
62 1/8 x 20 1/8"
Chain Ladder Split
47” Finished Width
SIDE VIEW
Center Step
within Ladder