COROCORD PERFORMER ARCH 8220 User manual

Foundation A: 1,20 x 1,20 x 0,70m (2x)
Quality of concrete: C25/30 (B25)
Please note the advice to the foundation plan.
Please inquire for current standards.
8220: PERFORMER ARCH
Foundation plan
Detail Mastfoot steel arch + fixing post for climbing wall
Ground level
Also by usage of rubber
surfacing an overall
coverage of 40 cm has to
be considerd!
subsequently drilled
during installation
optional: ductwork
ca. Ø250mm l=800mm
optional: ductwork
(for example made out
of PE)
Fixing joint A
A842061-51
Fixing post
A842125-51
scale 1:20
scale 1:50

The concrete for the foundations must be prepared in accordance with the strength class conforming to German
standard C 25/30 (B 25), f ok,cube = 30N/mm2. The concrete must have a flowing consistency.
The concrete must be compacted during grouting by vibration, tamping, beating or puddling. In the post area,
compacting must be carried out with special care. Please note the specified setting times.
The concrete for the post foundations is to be built into the foundation holes WITHOUT formwork, if there is solid
ground. If foundations have to be produced with formwork, the ground surrounding around shoul be well
compressed after moulding.
The measurements of the foundations = 1.20 x 1.20 x 0.70m
centre of steel post to steel post = 6.00m
centre of foundation to foundation = 5.60m
have to be strictly followed, maximum deviation ± 2 cm
The post have to be set up into the foundation holes before concreting. Please take care that the posts are placed
vertically.
To make the installation easier and faster two ductworks (for example PE pipes) can be set into the concrete blocks
(provided on site). Please ensure that the inner diameter is sufficient [min. Ø 250mm]. After the foundations have
hardened, the post have to be placed upright in the conduits. In a second work step the space between the empty
pipe and post has to be filled up with concrete.
All concrete foundations must be covered with minimum 40cm of impact attenuating material. The upper edges of
the foundations must be well bevelled or rounded off. In no case water may collect on the surface of the
foundations. Also by usage of rubber surfacing an overall coverage of 40cm has to be considered.
The indicated dimensions for the post foundations apply only to solid ground of average weight-bearing capacity. In
case of new earth filling and loose ground the foundation dimensions have to be increased.
Conceptual custom design - actual components may vary
23.02.2010
8220: PERFORMER ARCH
Advice to the Foundation plan

EN1176/AS4685
ASTM F1487/CSA Z614

12 1
2
3
4
5
6
7
8
9
10
11
Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH/ [email protected] / www.corocord.com
1/128220
Installation instruction
Montageanleitung
Instructions de montage
Indicaciones de montaje
Istruzioni di montaggio
Montagehandleiding
Monteringsanvisning
Monteringsvejledning
Инструкция по установке
Asennusohje

110 mm
Copyright 19.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.de
2/128220
A842061-51 (3x)
A842007-52 (4x)
OBV-1912022-A2 (6x) 601100312 (6x) 201305013024 (18x) 200707412055 (6x) 200304312050 (4x) 920-12 (4x)
A842000-52 (2x)340707612105 (4x)
B822001-0301 (1x)
A842121-51 (1x)
A842120-51 (2x)
N842027-06 (1x)
A842075-128 (3x)
A842061-51 (1x)
A842125-51 (1x)
AC84200-99 +

Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH/ [email protected] / www.corocord.de
3/128220
2x
T50
1x
1x
1x
1x
2x
Ø 19mm
1x1x

A
B
A
0.80
0.25
Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.com
4/12
8220
1)
2)
A
A842007-52 (4x)
B
A842000-52 (2x)
A842120-51 A842121-51
A842120-51

12 1
2
3
4
5
6
7
8
9
10
11
Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.de
5/128220

2.2)
2.1) 2.2) 2.3)1.1)1.2)1.3)1.4)1.5)1.6)
1.1 3,30 4,15 1,05
1.2 2,80 3,10 2,05
1.3 2,45 2,65 2,55
1.4 1,65 1,65 3,50
1.5 0,75 0,75 4,40
1.6 0,65 0,65 4,55
2.1 3,30 4,15 1,05
2.2 3,00 3,50 1,70
2.3 0,65 0,65 4,55
? m
? m
? m
Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.de
6/128220

Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.de
7/128220

Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.com
8/12
8220
1)
1.1)
A842075-128 (2x)
C
201305013024 (12x)
B
601100312 (4x)
A
OBV-1912022-A2 (4x)
D
200707412055 (4x)
2.1)
1.1)
2.1)
C
B
A
A
D
C
C
D

Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.com
9/12
8220
A842075-128 (1x)
C
201305013024 (6x)
B
601100312 (2x)
A
OBV-1912022-A2 (2x)
D
200707412055 (2x)
C
B
A
A
D
C
C
D
2)
1.3)
1.3)

Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.com
10/12
8220
A842075-128 (1x)
C
201305013024 (6x)
B
601100312 (2x)
A
OBV-1912022-A2 (2x)
D
200707412055 (2x)
3)
2.2)
2.2)
C
B
A
A
D
C
C
D

Copyright 12.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.com
11/12
8220
A842075-128 (2x)
C
201305013024 (12x)
B
601100312 (4x)
A
OBV-1912022-A2 (4x)
D
200707412055 (4x)
4)
1.6)
1.6)
2.3)
2.3)
C
B
A
A
D
C
C
D

0.35
0.28
10
24
100
125
Copyright 19.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.com
8220 12/12
A842075-128 (3x)
C
201305013024 (18x)
B
601100312 (6x)
A
OBV-1912022-A2 (6x)
D
200707412055 (6x)
200304312050 (4x)
E
920-12 (4x)
F
A842061-51 (4x)
H
G
340707612105 (4x)
5)
C
BA
A
D
C
C
D
1.3)
1.4)
1.5)
A842125-51 (1x)

XX XXXX
EN1176
XXX www.kompan.com
A100-42
V100-10
A10089-18
XX XXXX
EN1176
XXX
A62518-06
A10016-06
A
400010
D
A62518-06
C
210160
B
A10089-18
F
A100-42
E
A
A
D
D
C
C
C
C
B
B
F
F
E
E
Copyright 20.09.2011 by Corocord Raumnetz GmbH
COROCORD Raumnetz GmbH / [email protected] / www.corocord.com
8220