Dual XD230M Operating instructions

INSTALLATION/OWNER'S MANUAL
AM/FM/CD/PA Ready Receiver
XD230M

2
TYPICAL FRONT-LOAD DIN MOUNTING METHOD
Please read entire manual before installation.
Before You Start
•Disconnectnegativebatteryterminal.Consultaqualifiedtechnicianforinstructions.
•Avoidinstallingtheunitwhereitwouldbesubjecttohightemperatures,suchasfrom
directsunlight,orwhereitwouldbesubjecttodust,dirtorexcessivevibration.
Getting Started
•Remove2transitscrewslocated
ontopoftheunit.
•Insertthesuppliedkeysintothe
slotsasshown,andslidetheunit
outofthemountingsleeve.
•Installmountingsleeveinto
opening,bendingtabstosecure.
•Connectwiringharnessand
antenna.Consultaqualified
technicianifyouareunsure.
•Certainvehiclesmayrequirean
installationkitand/orwiring
harnessadapter(soldseparately).
•Testforcorrectoperationandslide
intomountingsleevetosecure.
•Snaptrimringintoplace.
XD230M INSTALLATION
Preparation

3
XD230M INSTALLATION
Wiring Diagram
FUSE
Whenreplacingthefuse,
makesurenewfuseisthe
correcttypeandamperage.
Usinganincorrectfuse
coulddamagetheradio.
TheXD230Musesone
10ampAGCfuselocated
in-line.

4
XD230M OPERATION
Control Locations
Eject
Mode
Volume/Audio/Setup
Tune/TrackUp
EQ
Loudness
Display
AuxiliaryInput
Local/Distance
Play/Pause
Preset 6
1
2
3
4
5
6
7
8
9
10
11
Preset 5
Preset 4
Preset3/Intro
Preset2/Random
Preset1/Repeat
AutoStore/PresetScan
Band
TunerScan
Mute
Tune/TrackDown
Power
12
13
14
15
16
17
18
19
20
1820 17 16 15 14 13 12 11
124 5 67
10
3
19 9 8
21
2122
22

Power On/Off
Mode
Auxiliary Input
Volume
Programmable
Turn-On Volume
Mute
Preset EQ Curves
Display
Set the Clock
12/24-hour Clock
General Operation
XD230M OPERATION
5
Press POWERoranyotherbutton(excepteject)toturnthe
uniton.Insertingadiscwillturntheunitonautomatically.
Press POWERtoturntheunitoff.
Press MODEtoselectbetweenTuner,CDplayerand
auxiliaryinput.Modesofoperationareindicatedinthe
display.
Note:CDmodewillnotappearunlessaCDisinserted.
Insert3.5mmplugtoconnecttheheadphoneorlineoutput
fromyourportableaudiodevice.
Adjustvolumeusingrotaryencoder(00-46).
Tosettheturn-onvolumelevel,pressandholdPOWER
for3secondstostorethecurrentlyselectedvolumelevel
inmemory."P-VOL"andthecurrentvolumelevelwill
momentarilyappearinthedisplay.Ifnovolumelevelis
programmed,theunitwillrememberthelastvolumelevel.
Press MUTEtosilencetheaudio.“MUTE”willflashinthe
display.PressMUTEagaintocancel.
Press EQ toselectbetweenPOP,JAZZ,CLASSIC,BEAT,
ROCKandOFF(default)equalizationcurves.Anyadjustment
totheBassorTreblesettingsautomaticallycancelsthe
currentEQcurve(ifoneisselected).
Press DISPtoselectbetweenclockanddifferenttypesof
information,suchasradiofrequencyortheCDtrack/elapsed
time information.
FromTunerorCDmode,pressandholdDISPuntiltheclock
beginstoflash,thenrelease.PressTUNE
nn
toadjust
thehoursandTUNE
ll
toadjusttheminutes.PressDISP
momentarilytosavetheselectedtime.
Theclockwilldisplay12-hourtimeinUSAfrequencyspacing
mode(10:00).InEuropeanfrequencyspacingmode,theclock
willdisplay24-hourtime(22:00).

6
PressvolumeknobmomentarilytoselectbetweenVolume
(default),Bass,Treble&Balance.
PressvolumeknobuntilBASappearsthenrotateencoder
left/righttoadjust(-6minimum/+6maximum).
PressvolumeknobuntilTREappearsthenrotateencoder
left/righttoadjust(-6minimum/+6maximum).
PressvolumeknobuntilBALappearsthenrotateencoder
left/righttoadjust(BALL12-BAL00-BALR12).
BAL00representsequalbalance
IndividualBassandTreblesettingsareretainedinmemoryfor
Tuner,CDandAUXmodes.ThisallowsyoutosavetheBass
andTreblesettingsseparatelyforeachmode.
Note:
AnyadjustmenttotheBassorTreblesettingsautomatically
cancelsthecurrentEQcurve(ifoneisselected).
Pressandholdthevolumeknobformorethan3secondsto
accessthesetupmenu.Pressthevolumeknobmomentarilyto
selectbetweenthemenufunctionsandrotatethevolumeknob
left/righttoadjustoractivatethedesiredfunction.
Audio
Bass
Treble
Balance
Source Audio Memory
Setup Menu
XD230M OPERATION
General Operation
Setup Menu
Menu Function Options Action
Tuner Frequency
Spacing
FREQUSA ProgramstheunittoUSAtunerspacing.
(200kHzforFMand10kHzforAM)
FREQEUR ProgramstheunittoEuropeantunerspacing.
(50kHzforFMand9kHzforAM)
Beep
Confirmation
BEEPOFF Disablestheconfirmationbeep.
BEEPON Enablestheconfirmationbeep.

7
XD230M OPERATION
Press TUNE
nn
or TUNE
ll
momentarilytomoveradio
frequencyupordownonestepatatime.Pressandholdto
advancequickly.
Press TUNE
nn
or TUNE
ll
foronesecond,then
releasetoseekthenextstrongeststation.
Press SCANtopreviewstrongstationsonthecurrentband,
pausingforfivesecondsateach.PressSCANagainto
cancel.
Press BANDtoselectbetweenFM1,FM2,FM3,AM1and
AM2bands.
Upto18FMstationsand12AMstationscanbestored.To
storeastation,selectthedesiredbandandstation.Press
andholdthedesiredpresetbutton(1-6)formorethan
twoseconds.Whenstored,thepresetnumberwillappearin
thedisplay.Thestationcanberecalledanytimebypressing
thecorrespondingpresetbutton.
Press AS/PSformorethantwosecondstoautomatically
storethesixstrongeststationsinthecurrentband.
Automaticlocaltuningisactivatedduringtheinitialband
scan.
Press AS/PSforlessthantwosecondstoscanpresets1-6
onthecurrentband,pausingforfivesecondsateach.Press
AS/PSagaintocancel.
Thisunithasamanualtuning,seektuningandAS/PS
lockoutfeature.Seetroubleshootingsection.
Manual Tuning
Seek Tuning
Scan Tuning
Band
Storing and Recalling
Station Presets
Automatically Store
Stations
Preset Scan
NOTE:
AM/FM Tuner Operation

8
XD230M OPERATION
Insert CD
Eject CD
Track Select
Fast Forward and Reverse
Pause
Scan
Repeat
Random
CD-R/CD-RW Compatibility
Withthelabelfacingup,insertastandardsizeCDintothe
CDslot.TheCDwillautomaticallybeginplayback.
Press EJECTtoejecttheCD.Theunitwillchangetoprevious
modeofoperation(TunerorAUX).Ifthediscisnotremoved
within10seconds,theunitwillreloadthedisc.Theunitdoes
nothavetobeturnedontoejectCD.NOTE:Thisunithasan
EjectCDlockoutfeature.Seetroubleshootingsection.
Press TRACK
ll
toskiptothebeginningofthenexttrack.
Press TRACK
nn
toreturntothebeginningofthecurrent
track.PressingTRACK
nn
againskipstothebeginningof
theprevioustrack.
PressandholdTRACK
ll
or TRACK
nn
tofastforward
orreverseatrack.
Press
l
/ II totemporarilystopCDplayback.
Press
l
/ II againtoresumeplayback.
Press INT toplaythefirst10secondsofeachtrack.
Press INTagaintocancel.
Press RPTtocontinuouslyrepeatselectedtrack.
Press RPTagaintocancel.
Press RDMtoplayalltracksinrandomorder.PressRDM
againtocancel.Randommodeisretainedinmemorywhen
selectingbetweenTuner,CDandAUXmodesandwhenthe
unitisturnedon/off.
SomeCD-RsandCD-RWsmaybeincompatiblewiththis
unit,dependingonmediatypeandrecordingmethod.In
addition,thefollowingCDsmaybeincompatiblewiththis
unit:
CDsexposedtoextremetemperaturesordirectsunlightfor
extendedperiodsoftime,CDsrecordedinwhicharecording
sessionfailedorare-recordingwasattemptedand,or
encryptedorcopy-protectedCDswhichdonotconformto
theaudioCD-DAredbookrecordingstandard.
CD Player Operation

9
XD230M OPERATION
FCC Compliance
ThisdevicecomplieswithPart15oftheFCCRules.Operationissubjecttothefollowing
twoconditions:
(1)thisdevicemaynotcauseharmfulinterference,and
(2)thisdevicemustacceptanyinterferencereceived,includinginterferencethatmay
causeundesiredoperation.
Warning:Changesormodificationstothisunitnotexpresslyapprovedbytheparty
responsibleforcompliancecouldvoidtheuser’sauthoritytooperatetheequipment.
Note:ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassB
digitaldevice,pursuanttoPart15oftheFCCRules.Theselimitsaredesignedtoprovide
reasonableprotectionagainstharmfulinterferenceinaresidentialinstallation.This
equipmentgenerates,usesandcanradiateradiofrequencyenergyand,ifnotinstalled
andusedinaccordancewiththeinstructions,maycauseharmfulinterferencetoradio
communications.However,thereisnoguaranteethatinterferencewillnotoccurina
particularinstallation.Ifthisequipmentdoescauseharmfulinterferencetoradioor
televisionreception,whichcanbedeterminedbyturningtheequipmentoffandon,the
userisencouragedtotrytocorrecttheinterferencebyoneormoreofthefollowing
measures:
• Reorientorrelocatethereceivingantenna.
• Increasetheseparationbetweentheequipmentandreceiver.
• Connecttheequipmentintoanoutletonacircuitdifferentfromthattowhichthe
receiverisconnected.
• Consultthedealeroranexperiencedradio/TVtechnicianforhelp.

Problem Cause Action
Unit will not turn on
(no power)
Yellowwirenotconnectedorincorrectvoltage
Redwirenotconnectedorincorrectvoltage
Checkconnectionsforproper
voltage(11~16VDC)
Blackwirenotconnected Checkconnectiontoground
Fuseblown Replacefuse
Unit has power
(but no sound)
Speakerwiresnotconnected Checkconnectionsatspeakers
Oneormorespeakerwirestouchingeach
otherortouchingchassisground
Insulateallbarespeakerwiresfrom
eachotherandchassisground
Unit blows fuses
Yelloworredwiretouchingchassisground Checkforpinchedwire
Speakerwirestouchingchassisground Checkforpinchedwire
Incorrectfuserating Usefusewithcorrectrating
Unit will not tune, seek or
autostore (AS/PS) stations
UnithasManualTuningLockoutfeature
enabled
Seeyoursupervisorforthecode
Excessive skipping
Unitisnotmountedcorrectlyorbackstrapis
notsecure
Checkmountingsleeveand
backstrapsupport
Physicaldefectinmedia(CD,CD-RorCD-RW) Checkmediaforscratches
ERROR 1 appears
on display
Discreaderror Press EJECT
ERROR 2 appears
on display
Focuserrorordiscisinupsidedown Press EJECT
Unit will not accept
a disc
CDmechanismpositionoutofalignment PressandholdEJECT for3seconds
toresetCDmechanismposition
CDtransitscrewsstillinplace Remove2transitscrewslocatedon
topoftheunit
Unit will not eject
a disc
UnithasEjectCDLockoutfeatureenabled Seeyoursupervisorforthecode
XD230M OPERATION
Troubleshooting
10
CEA-2006PowerStandardSpecifications
(reference:14.4VDC+/-0.2V,20Hz~20kHz)
PowerOutput:18WattsRMSx4channelsat4ohmsand<1%THD+N
SignaltoNoiseRatio:80dBA(reference:1wattinto4ohms)