EvaKool TRAVELMATE User manual

TRAVELMATE FRIDGE FREEZER
Instruction Manual
1 | P a g e
Nexberg Pty Ltd T/a Evakool
16 Enterprise St CALOUNDRA
QLD 4551
Tel : [phone]
Fax: [phone]
Please read these instructions and the Safety section carefully before using
your refrigerator.
1．Safety Instructions Page 2
2．Notes on using the product Page 2
3．Operation Page 2-3
4．Cleaning and Maintenance Page 4
5．Troubleshooting Page 4
6．Error Codes Page 5
7．Technical Data Page 5
8．Packing List Page 5
9．Warranty Statement Page 6
10. Troubleshooting Diagram Page 7

TRAVELMATE FRIDGE FREEZER
Instruction Manual
2 | P a g e
Features:
Reliable cooling system –Domus compressor
Efficient electronic technology, low energy consumption
Multi-voltage system (DC 12-24 Volt) and (AC 100-120/220-240 Volt with Adaptor supplied)
Digital Battery Protection, protect your vehicle battery effectively
1. Safety Instructions
Warning: Do not touch exposed cables.
Warning: Do not use fridge if you suspect any connections could be wet.
When using the refrigerator in the vehicle or boat, please make sure the circuit being used is
fused.
Any installation of DC power sources should be handled by a qualified professional.
Make sure the source voltage is correct. The technical data label has the voltage data.
Do not place any electrical devices inside the refrigerator as moisture could harm these
devices.
2. Notes on using the product
Your refrigerator requires good ventilation, especially around the vents of the refrigerator;
allow a gap of at least 200mm around the vents and 100mm around the rest of the unit.
Avoid humidity: Humidity inside the appliance can form frost and impair cooling.
Do not allow frost to build up. Never clean the appliance using a hose and never submerge the
unit in any liquid.
Avoid placing your refrigerator near a heat source. This helps the refrigerator to work more
efficiently and keep the contents cool.
Place the refrigerator on a flat surface and away from any edges. When using the fridge in a
vehicle, please use a fastening device to secure it.
3. Operation
Power：The electronic control module controls the compressor motor and has the function of
a four stage battery protection. When the input voltage drops below the minimum, the
compressor will cut out; when the voltage comes back up to the cut-in value, the compressor
will restart automatically after a start delay.
Battery Protection: The Domus compressor requires over 11.0 Volts (12 Volt System) or
23.0 Volts (24V System) to operate. If the voltage drops below this the fridge will stop
running.

TRAVELMATE FRIDGE FREEZER
Instruction Manual
3 | P a g e
Cable Specification
The DC cables must have a suitable cross-section for their length, according to this table:
*Note: The length is from the battery to the refrigerator.
Using the Fridge
Temperature setting range：-20ºC～20ºC, -4ºF～68ºF；
Plug in the DC power cable. Use the ON/OFF switch to run the fridge. The unit will beep
three times, then the LED display on the control panel will light up and the interior
temperature will be displayed. This unit has a start delay of approximately 2 minutes before
the compressor will start.
Press SET and then press the △UP and ▽DOWN buttons to adjust the temperature. Press
the button △to increase while the button ▽to decrease the temperature. To lock in the
target temperature press set twice or leave for 5 seconds. The display board will display the
current temperature inside the unit after the target temperature is set. After approximately 5
minutes the displayed temperature will start to decrease.
If the power supply is cut off, the refrigerator will switch off automatically and then
automatically switch on again when the unit receives power.
To change the fridge between ºC and ºF. Hold SET and ▽DOWN at the same time until the
display changes.
To change the boost hold the SET button for 4 seconds and use the △UP and▽DOWN buttons
to adjust between ECO, BOOST andAUTO. ECO sets the compressor at 2000rpm to be used
in ambient conditions below 30ºC. BOOST sets the compressor at 2700rpm to be used in
ambient conditions above 30ºC.AUTO automatically sets the compressor based on the target
temperature set.
Cable Area
12V Max Cable
Length*
24V Max Cable
Length*
[mm2]
AWG
[m]
[ft.]
[m]
[ft.]
2.5
12
2.5
8
5
16
4
12
4
13
8
26
6
10
6
20
12
39
10
8
10
33
20
66

TRAVELMATE FRIDGE FREEZER
Instruction Manual
4 | P a g e
4. Cleaning and maintenance
Clean the appliance inside and out with a damp cloth every week. If it is dirty, use
sodium bicarbonate dissolved in lukewarm water to clean the unit.
Never use abrasive products, detergents or soap. After washing, rinse with clean water
and dry carefully. Do not leave the refrigerator off with food inside or lid closed.
Never clean the appliance under running water. Do not use abrasive cleaning agents or
hard objects during cleaning as these can damage the refrigerator.
5. Troubleshooting
The appliance is not turning on.
Check the power supply
Check whether the plug and the socket have a good connection.
Check whether the fuse has been burned out
Check whether the appliance has been turned on
The food inside is frozen.
The setting temperature is too low
Bad performance in refrigeration
Too much food been placed inside the refrigerator
The lid is unlocked/or open
The lid seal is broken
Problems arising from poor ventilation
There is too much warm product inside
There is no room around the fridge and vents
There is a heat source near the unit
The temperature setting is inappropriate
Hear the sound of water from inside the unit
This is normal, due to the flow of the refrigerant.
Unusual noise when refrigerator is working
The refrigerator is not placed on a level surface
Some part has come loose inside the refrigeration compartment (see a service agent)

TRAVELMATE FRIDGE FREEZER
Instruction Manual
5 | P a g e
6. Error Codes
The error codes are depicted by a number of flashes by the error light in a sequence every
four seconds.
Code
Reason / Solution
1 Flash
Low Voltage
-Please check the source voltage to ensure it is above
the cut out. Try lowering the voltage cut out setting to
L.
-The vehicle cabling may be inadequate/unsuitable,
please refer to cable specifications table for correct
cable thickness.
2 Flashes
Fan or compressor running issue
-Fan is drawing too manyAmps (Over 1Amp) –
Replace Fan.
-The compressor is drawing too many amps (Over 12
Amps)
-Possible Electronic Box or compressor fault –contact
Evakool or Service Agent
3 Flashes
The compressor speed is too low
-Reduce products / items inside unit
-Move unit to a lower ambient temperature
-Clean vents / ensure clear air flow over compressor
4 Flashes
Ambient Temperature too high
-Clean vents / ensure clear air flow
-Fan Fault –Replace fan
7. Technical Data (DC)
8. Packing List
Item
Fridge
AC
Adaptor
DC
Cable
Cover
User’s
guide
TM30
1
1
1
1
1
TM45
1
1
1
1
1
TM60
1
1
1
1
1

TRAVELMATE FRIDGE FREEZER
Instruction Manual
6 | P a g e
EVAKOOL TRAVELMATE FRIDGE FREEZER RANGE
Warranty Statement
TERMS & CONDITIONS
Nexberg Pty. Ltd. trading as EvaKool undertakes to the original purchaser that this product is sold free of defect in materials
and/or workmanship under normal use for a period of 24 months. Subject to the following: -
Ph: [phone]
16 Enterprise Street
CALOUNDRA QLD 4551
[e-mail]
•The warranty period commences from the date of
purchase by the original purchaser from an
authorised EvaKool dealer.
•EvaKool will honour this warranty on presentation
of proof of purchase of the unit to EvaKool or its
approved service agent. The service agent may be
requested to provide EvaKool with a photocopy of
the proof of purchase to obtain approval to
proceed prior to warranty being honored.
•Evakool will not be held responsible for any costs
incurred in making a warranty claim.
•Please telephone [phone] for the name of
an authorized service agent or refer to list provided.
It is the purchaser’s responsibility to freight the unit
to and from the service agent.
•EvaKool will not be held responsible for any
damage or loss suffered or cost incurred whilst
fridge is in transit.
•Warranty repairs may only be carried out by an
authorised service agent. EvaKool will not
reimburse repair claims carried out by
unauthorized service agents. Any unauthorized
tampering with any part of the unit will
automatically void the warranty.
•Service agents may charge a fee for viewing or
testing the unit. This is not covered by EvaKool or
this warranty and is payable at the service point
unless authorized by EvaKool.
•Any Evakool authorized service centre in Australia
will be able to carry out the service of your unit. If a
repair needs to be undertaken and is covered in
terms of this warranty a warranty authorization
number must be obtained prior to commencement
of any work.
•EvaKool will not accept a warranty claim if:
1. Modifications have been carried out to the unit
without EvaKool’s written authority.
2. Damage to or failure of the unit has been
caused in EvaKool’s opinion by incorrect,
extreme or unreasonable use.
3. Damage to or failure of the unit has been
caused in EvaKool’s opinion by misuse,
neglect, accident, impact or similar cause.
Refer the preventative maintenance
guidelines.
•EvaKool has total discretion on the variation of the
warranty terms.
•Our goods come with guarantees that cannot be
excluded under the Australian Consumer Law. You
are entitled to a replacement or refund for major
failure and for compensation for any other
reasonably foreseeable loss or damage. You are
also entitled to have the goods repaired or replaced
if the goods fail to be of acceptable quality and the
failure does not amount to a major failure.
•The above warranty conditions are in addition to
any other rights and/or remedies as per the
applicable law.
•Failure to follow the guidelines/recommendations
in this manual may void the warranty.
•This warranty cannot be varied by others.

TRAVELMATE FRIDGE FREEZER
Instruction Manual
7 | P a g e
COMPLETE THE ENCLOSED WARRANTY CARD AND
RETURN WITHIN THIRTY (30) DAYS OF PURCHASE

TRAVELMATE FRIDGE FREEZER
Instruction Manual
8 | P a g e