Eyolf G30 60 User manual

WEB Polyester Sling
25mm
MBS 40 kN
0321 Carefully read these instructions before using
this product and keep this manual for your records.
WEB Sling approved to:
EN 795:2012 Type B and ANSI Z359.1:2007
Product # G30 60 – length 60cm
Product # G30 90 – length 90cm
Product # G30 120 – length 120cm
Product # G30 150 – length 150cm
Product # G30 180 – length 180cm
EN
Personal protective equipment against
falls from a height.
General requirements for instructions
for use, maintenance, periodic
examination, repair, marking and
packaging as per EN 365:2004
Warning

Working at height and all forms of activity conducted at
height are dangerous and can lead to serious injury or
death.
It is important to be medically fit to use the equipment as
this can effect the safety in normal or emergency use.
The information provided in this manual contains
important information which should be understood
before the item is used. The information must be
provided to the customer by the retailer in the language
of the country this product is sold.
Improper use of equipment can result in serious injury or
death. It is the responsibility of the user to obtain proper
training in rope techniques and safety prior to any
activity at height and use of such equipment.
It is the users responsibility to ensure that there is a
rescue plan in place to deal with any emergencies that
could arise during the work.
Strengths quoted are when the product is tested new
and are in accordance with the manufacture’s test
methods or to the appropriate standard. Any weights
and measurements are approximate.
Do not make any alterations or additions to the
equipment without the manufacturer’s prior written
consent, and any repair shall only be done by
manufacturer.

Sling - This product has been designed for your protec-
tion and therefore it is a personal protective equipment
(PPE). However, always remember that no item of PPE
can provide full protection and care must always be
taken while carrying out the risk-related activity.
This sling is for anchoring while climbing, mountaineer-
ing, rescuing, etc. (in normal climatic conditions). Use only
as instructed and with compatible items of equipment.
Check that the safe function of any one component
within a system will not interfere with safe function of
this sling or another. Twists in the webbing can cause
problems, weakness, serious injury or death.
Compatibility - Make sure that each item in an assembly
is compatible as they may interfere with each other.
Equipment used together should have the CE symbol on
them, such as EN 355 for energy absorbers or EN 364 for
carabiners.
This sling is only to be used personal fall protection
equipment and not for lifting equipment.
Anchoring - Under normal circumstances the WEB Sling
is for one user at a time only.
The viability of any installation should be verifiable by a
qualified engineer.
Any fall arrest anchorage used should be able to
withstand a force of 22kN.
When sling is used as an anchor for a fall arrest system,
the user shall be equipped with a means of limiting the
dynamic forces exerted on the user during the arrest of a
fall to a maximum of 6kN.
The structure must at least hold 12kN.
Safety - The safety provided by this sling depends on its
strength and the skill of the user. The strength will be
reduced through the age, wear, tear, abrasion, cuts, high
impact loads, tight/sharp edges, very high or low
temperatures, knots, some chemicals (e.g. alkalis, oils,
cleaning products, etc.), UV or failure to store and
maintain as recommended. This list is not exhaustive.
Any sling subjected to a minor fall should be examined
and discarded if there is any sign of defect or any doubts
about safety.
Lifespan - This is difficult to estimate but we advise as
follows: Do not use more than ten years after the date of
manufacture or five years after its first use, whichever
come first. Assuming you have used the correct storage,
the working life can vary between a single use in extreme
circumstances (e.g. highly chemical environment, serious
fall). UV light including sunlight will reduce the working life
significantly.
Inspection - It is recommended that the sling is marked
with the date of the next or last inspection.
Before each use visually inspect to ensure the product is in
serviceable condition and operates correctly. An
examination should be carried out at least every 6 months
by a competent person. These inspections should be
recorded. Pay particular attention to cuts and frays on the
edges, areas of potentially high wear and sewn parts. If
found any compromises disregard the product.
When carrying out an inspection pay attention to the
points as stated in the inspection form.
It is essential for safety that equipment is withdrawn from
use immediately should:
Any doubt arise about its condition for safe use or;
Any product subjected to a major fall and not used again
until confirmed in writing by a competent person that it is
acceptable to do so.
Before each use visually inspect to ensure the product is in
serviceable condition and operates correctly. If any
compromises are found do not use the product and retire
it.
Tensile Strength - The tensile strength of this product is
40kN and is calculated using the 3-Sigma method.
Markings and/or symbols
On our label you will find:
Product name and size
DOM (date of Manufacture) in year and month
Serial # - Individual serial # or batch # [360st product]
CE mark, which stands for "Conformité Européenne"
("European Conformity").
EN 795 B is the European standard to which the product
is certified.
ANSI is the standard for the U.S.A. and stands for
American National Standard Institute 
Note: It is the resellers responsibility to provide instructions
for use, for maintenance, for periodic examination and for
repair in the language of the country in which the product
is to be used.
Warranty - Equipment offered by Eyolf Inc. are warrant-
ed against factory defects in workmanship and materials
for a period of two years from date of installation or use
by the owner, provided that this period shall not exceed
two years from the date of shipment. Upon notice in
writing, Eyolf Inc. will promptly repair or replace all
defective items. Eyolf Inc reserves the right to elect to
have any defective item returned to its plant for inspec-
tion before making a repair or replacement. This warran-
ty does not cover equipment damages resulting from
abuse, damage in transit, or other damage beyond the
control of Eyolf Inc. This warranty applies only to the
original purchaser and is only one of applicable to our
products, and is lieu of all other warranties, expressed or
implied.
CERTIFICATION BODY AND ONGOING ASSESSMENTS OF
ARTICLE 11B AGAINST EC DIRECTIVE 89/686/EEC
SATRA Technology Centre Wyndham Way
Telford Way Industrial Estate
KETTERING Northamptonshire
NN16 8SD UK
SATRA Identification number: 0321
Eyolf Inc.
820 Gartshore St., Unit 9
PO Box 418
Fergus ON - N1M 2W8 Canada
Tel [phone]
Fax [phone]
Email [email protected]
Eyolf Benelux BV
Willy den Oudenstraat 17
3056 AD Rotterdam, The Netherlands
Tel [phone]
Email [email protected]
WWW.EYOLF.CA
Date: Nov 2017
Doc: G30 - WEB sling - Rev 6

INSPECTION RECORD
Owner:
Address:
Product:
Model:
Serial #:
DoM:
First use:
Reason for entry inspection or repair Defects noted, repairs carried
out and other information
YEAR 1
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 2
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 3
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 4
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 5
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 6
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 7
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 8
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 9
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:
YEAR 10
INSPECTION RECORD
DATE:
RESULT:
INSPECTOR SIGNATURE:

PPE Inspection form
How to inspect your slings.
Doc: Inspection form - Slings Rev: 9 - Date: 2017-11
Copyright 2017 - Eyolf Inc
If there is any doubt or failure, the harness should not be used.
Visual check of the safety components:
Readable labels present? (Age of harness)
Check webbing (cuts, burns, wear, chemical marks, other damage) Check stitching (cut, worn, coloured or disorderd threads) Check attachment points (deformation, cracks, wear, corrosion, burrs, marks)
Check buckles (deformation, allignment, cracks, wear, corrosion, marks)
Check compatibility of connector
Check condition of protective components
(covers, etc.)
Operational check Check webbing and buckles are in the right position Check adjustments
Check length is correct
Owner: Model:
In Service:
Serial #: Date of first use:Date of inspection:
Yes No
Comments: