Forest garden Thyme User manual

THYME PLAYHOUSE
Issue 0218
PHTPA55
Instruction Reference
Important :
Assembly of this
product requires
a minimum of two
adults only.
Warning. Only for domestic use
Biocidal Product Regulation (EU 528/2012) Article 58 Information
This article contains timber treated with Tenalith, incorporating biocidal
products to give protection against wood destroying insects & wood rotting
fungi.
Contains: Basic copper carbonate (Copper (II) carbonate – Copper (II)
hydroxide (1:1)), Boric acid, Benzalkonium chloride.
Wear gloves when handling freshly treated wood. Avoid breathing dust when
cutting treated or untreated wood. Dispose of off-cuts responsibly – do not
burn.
Slipping, Tripping
& Falling
PH55APEX
Qty 2
Profile
PH55DP
PH55PP
PH55WP
Qty 2
55DRCILL
PH55 DRS
Qty 2
PH55RF
Qty 2
PH55FL
DRBLOCK
Qty 2
55PDBARGE
Qty 4
47x12x1440mm
55PDCSTRIP
Qty 4
55DRHANDLE
Qty 2
55ROOFSTRIP
Qty 2
20x12x1350mm
THKHINGE SAGFELT Qty 3
FELT
e f g
h
jkL
b c d
mn p
I
a
REQUIRED TOOLS: (NOT SUPPLIED)
TAPE MEASURE
SHARP KNIFE
DRILL/POZI DRIVE
SCREWDRIVER
SPIRIT LEVEL
HAMMER STEP LADDER
Fixing Pack (PHTPA55FP) Not to Scale
3.5 x35mm Screw Qty 48
3.0 x 25mm Screw Qty 37
q
r
t
p
3.5 x 50mm Screw Qty 4
Magnetic
Catch and Plate Qty 2
w
3.5 x 60mm Screw Qty 12
3.0 x 20mm Screw Qty 16
s
o
10mm
Clout Nail
Qty 60
u
v
Hinge Qty 4
x
3.5 x 40mm Screw Qty 12
PH55GWIN
Qty 3
IMPORTANT, RETAIN FOR FUTURE REFERENCE; READ
CAREFULLY
- This is pressure to ensure longevity of all timberbuilding treated
components and to protect against rot. This may leave a colour
difference on some parts that will even out as the moisture content
stabilises This will not need additional treatment..
- Timber is a natural material. It will shrink and swell as a result of
varying moisture content.
- Please keep all plastic bags and small parts away from children
- This product must be built on a level base and at least two metres
away from any structure or obstruction.
Warnings
-This product is for outdoor use only.
-This product is intended for use by children of up to age 10 years.
-Only for domestic use
Technical Help line: 7777 089 8.30 am and 5.00 pm Monday to0333
Friday.
In line with your statutory rights, please check all parts prior to
assembly, as assembly of damaged parts may be deemed to be
acceptance and this may affect the remedies you are entitled to.
The manufacturer does not accept any liability for injury or damage to
property caused by this product not being constructed in accordance
with our instructions or being altered in anyway.
Must
Pre-drill

Forest Garden Ltd, Unit 288 Hartlebury Trading Estate, Hartlebury, Worcestershire, DY10 4JB
b
a
a
e
q
Top View
Flush
q
c
qq
q q q
q
q
q
q
q
q
r
d
j
Flush
Flush
1
2
3
qq
aa
b
a
b
Please ensure
that
all the screws
locate
into the floor
bearers
underneath
Window Assembly
o
X
X
Flush

Forest Garden Ltd, Unit 288 Hartlebury Trading Estate, Hartlebury, Worcestershire, DY10 4JB
30mm
s
kk
Flush
Flush
Notch on
reverse
25mm
542mm
floor level
6mm
542mm
v
rx 3
7
8
9
Issue 0218
q
Flush
g
I
p
x 3
h
r
s
Ensure screws
locate in to the
ends of the
rafters
m
r
Roof flush at the back
Flush
Overhang
In line with the apex
Flush
n
p
sAttention
Take care
when cutting
or trimming
roof felt
4
5
6u
f
w
w
w
Tight &Flush
Brush off any
loose sand
particles once
the felt has
been
installed.

Maintenance:
- Make sure that there are no sharp edges or screw heads
protruding inside and out.
- Make sure that any sharp edges are sanded off before use.
- Make sure there are no splits, splinters, or protruding nails / screws
prior to each use.
- Before assembly shake the roof felt to remove any loose grit.
Regularly check
- All fixing are tight.
- All parts for evidence of deterioration and replace in accordance
with the manufacturers instructions.
- There are no splits, splinters, or protruding nails / screws prior to
each use.
15mm
Attention
Gaps must
be at least
13mm
rx 2
g
L
t
sx 2
tsx 2
10
11
12
qx 2
Flush with the
inside of the
corner strip.
Flush with
front of the
door framing
13mm
13mm
13mm