GREENLINE GREENLINE 33 User manual

OWNER’S MANUAL
GREENLINE 33
Revision 04 19-03-2012

Greenline 33 II

Greenline 33 III
TABLE OF CONTENTS GREENLINE 33
1. INTRODUCTION...................................................................................................................1
2. SPECIFICATION & WARRANTIES ...........................................................................................4
SPECIFICATION ................................................................................................................................... 4
WARRANTY GUIDELINES .................................................................................................................... 7
BUILDER’S PLATE.............................................................................................................................. 14
REGISTRATION DETAILS ................................................................................................................... 15
COMMISSIONING DISTRIBUTOR ...................................................................................................... 15
3. SAFETY .............................................................................................................................. 16
LIFE RAFT STORAGE.......................................................................................................................... 16
SAFETY EQUIPMENT......................................................................................................................... 17
MAN OVERBOARD PREVENTION AND RECOVERY ........................................................................... 18
LPG SYSTEM...................................................................................................................................... 19
SAFETY DIRECTIONS CONCERNING GAS STOVE ............................................................................... 20
FIGHT AGAINST FIRE & EMERGENCY EXITS...................................................................................... 22
BILGE STRIPPING .............................................................................................................................. 26
EMERGENCY CONTROL .................................................................................................................... 28
4. HULL ................................................................................................................................. 29
THROUGH HULL FITTINGS................................................................................................................ 29
SEACOCK........................................................................................................................................... 30
HULL MAINTENANCE........................................................................................................................ 30
DRY DOCKING................................................................................................................................... 31
GEL-COAT REPAIRS INSTRUCTION.................................................................................................... 31
5. DECK ................................................................................................................................. 33
DECK LAYOUT ................................................................................................................................... 33
MOORING......................................................................................................................................... 34
TOWAGE........................................................................................................................................... 34
ANCHORING ..................................................................................................................................... 35
RADAR .............................................................................................................................................. 36
SWIMMING PLATFORM ................................................................................................................... 36
DECK MAINTENANCE ....................................................................................................................... 38
6. ACCOMODATIONS............................................................................................................. 39
MAINTENANCE................................................................................................................................. 39
FABRICS ............................................................................................................................................ 40
7. PLUMBING ........................................................................................................................ 41
WATER TANK FILLING....................................................................................................................... 44
FRESH WATER SYSTEM..................................................................................................................... 46
TOILET OPERATION .......................................................................................................................... 46
GAS SYSTEM ..................................................................................................................................... 47
WATER DISCHARGE.......................................................................................................................... 47
SANITARY APPLIANCE OPERATION .................................................................................................. 48
8. ELECTRICAL SYSTEM .......................................................................................................... 49
ARRIVING ON THE BOAT .................................................................................................................. 49
SELECTING ELECTRIC or DIESEL DRIVE ............................................................................................. 52

Greenline 33 IV
HYBRID DATA DISPLAY INTERFACE - DDI.......................................................................................... 54
BATTERY MONITORING - BMV ........................................................................................................ 55
PHOENIX MULTI CONTROL INVERTER / CHARGER.......................................................................... 56
SOLAR PANELS.................................................................................................................................. 60
PARALLEL SWITCH............................................................................................................................ 60
SWITCHES......................................................................................................................................... 61
FUSES................................................................................................................................................ 62
POWER SOURCES ............................................................................................................................. 71
SHORE POWER ................................................................................................................................. 73
BATTERIES ........................................................................................................................................ 74
MAINTENANCE AND ADDITIONAL WARNINGS................................................................................ 74
9. ENGINE & STEERING GEAR................................................................................................. 77
ENGINES ........................................................................................................................................... 77
ENGINE OPERATION:........................................................................................................................ 78
VENTILATION SYSTEM...................................................................................................................... 79
DETERMINATION OF MAXIMUM PROPULSION POWER RATING .................................................... 79
DASH BOARD / CONTROL LEVER...................................................................................................... 79
VISIBILITY IN THE STEERING STATION .............................................................................................. 80
PROPELLERS ..................................................................................................................................... 81
ANODE.............................................................................................................................................. 81
FUEL SYSTEM.................................................................................................................................... 82
FUEL TANK........................................................................................................................................ 82
FUEL FILTER ...................................................................................................................................... 84
FUEL.................................................................................................................................................. 84
STEERING.......................................................................................................................................... 85
10. LAUNCHING....................................................................................................................... 87
LAUNCHING HINTS ........................................................................................................................... 87
11. LAYING UP AND WINTER PRECAUTIONS ............................................................................ 89
LAYING UP ........................................................................................................................................ 89
PROTECTION AND MAINTEINANCE.................................................................................................. 89
LiPo BATTERY BANK –WINTER STORAGE ........................................................................................ 91
12. APPENDIX A: Wiring diagrams ........................................................................................... 95
13. APPENDIX B: List of errors displayed by Hybrid monitor..................................................... 96
IG ERROR LISTING............................................................................................................................. 96
AC ERROR LISTING............................................................................................................................ 97
14. NOTES............................................................................................................................. 101

Greenline 33 V
TABLE OF FIGURES
Figure 1: Boat main dimensions ........................................................................................................................ 6
Figure 2: Boat examination report .................................................................................................................... 9
Figure 3: Engine examination certificate (VW SDI 75-5) ................................................................................. 10
Figure 4: Engine examination certificate ( VW TDI 165-5) .............................................................................. 11
Figure 5: Declaration of Conformity ................................................................................................................ 12
Figure 6: Builders certificate plate................................................................................................................... 14
Figure 7: Liferaft storage location ................................................................................................................... 16
Figure 8: Working deck area plan.................................................................................................................... 18
Figure 9: LPG system plan............................................................................................................................... 19
Figure 10: Fire extinguishers positions & Emergency exits ............................................................................ 22
Figure 11: Table of symbols............................................................................................................................. 25
Figure 12: Automatic bilge pump with automatic switch ............................................................................... 26
Figure 13: Manual bilge pump with integral handle in cockpit....................................................................... 26
Figure 14: Bilge pump system plan.................................................................................................................. 27
Figure 15: Base position for emergency tiller.................................................................................................. 28
Figure 16: Thru hull fitting positions ............................................................................................................... 29
Figure 17: Deck layout ..................................................................................................................................... 33
Figure 18: Anchor winch with chain stopper................................................................................................... 35
Figure 19: Manual switch for el. platform....................................................................................................... 37
Figure 20: Latch on the platform..................................................................................................................... 37
Figure 21: Accomodations............................................................................................................................... 39
Figure 22: Sea water plumbing........................................................................................................................ 41
Figure 23: Fresh water plumbing..................................................................................................................... 42
Figure 24: Grey water plumbing...................................................................................................................... 43
Figure 25: Black water plumbing ..................................................................................................................... 44
Figure 26: WATER deck filler on PORT side ..................................................................................................... 45
Figure 27: Fresh water pump .......................................................................................................................... 46
Figure 28: Engine with Hybrid drive ................................................................................................................ 77
Figure 29: Engine seawater inlet with water strainer ..................................................................................... 78
Figure 30: Engine compartment air intake...................................................................................................... 79
Figure 31: Engine compartment air outlet with exhaust blower .................................................................... 79
Figure 32: Engine control lever........................................................................................................................ 80
Figure 33: Propeller and anodes...................................................................................................................... 81
Figure 34: Fuel system..................................................................................................................................... 82
Figure 35: FUEL deck filler on STBD side ......................................................................................................... 83
Figure 36: Fuel pre-filter.................................................................................................................................. 84
Figure 37: Steering system .............................................................................................................................. 85

Greenline 33 VI
Figure 38: Position of hoisting cradle and straps ............................................................................................ 88

Greenline 33 VII
TABLE OF PICTURES (ELECTRICAL SYSTEM)
Picture 1: ENGINE and SERVICE main switch................................................................................................... 49
Picture 2: HYBRID DRIVE and HYBRID/HOUSE main battery switch ............................................................... 50
Picture 3: BOWTHRUSTER (optional) switch in the cabin ............................................................................... 50
Picture 4: 24h CONSUMERS on the right side; 230Vac CONSUMERS on the left side .................................... 50
Picture 5: INVERTER switch –Phoenix multi control on the dashboard ......................................................... 51
Picture 6: Phoenix multi control...................................................................................................................... 56
Picture 7: Parallel switch ................................................................................................................................. 60
Picture 8: 12V main switches .......................................................................................................................... 62
Picture 9: Bowthruster switch ......................................................................................................................... 62
Picture 10: 48V main hybrid switch................................................................................................................. 62
Picture 11: Location of AC/DC panel ............................................................................................................... 63
Picture 12: AC/DC panel .................................................................................................................................. 63
Picture 13: Main 12V power box ..................................................................................................................... 67
Picture 14: Service box fuses........................................................................................................................... 67
Picture 15: Mooring box fuses......................................................................................................................... 68
Picture 16: Mooring box (located under the bed in the cabin); anchor winch fuse ....................................... 68
Picture 17: Shore power fuse .......................................................................................................................... 69
Picture 18: LiPo battery bank main fuse.......................................................................................................... 69
Picture 19: Hybrid box fuses............................................................................................................................ 70
Picture 20: Hybrid control unit main fuse ....................................................................................................... 70
Picture 21: 12V socket on console................................................................................................................... 71
Picture 22: Kitchen 230V sockets .................................................................................................................... 72
Picture 23: Salon 230V sockets above port locker .......................................................................................... 72
Picture 24: Cabin 230V sockets under the port bed........................................................................................ 72
Picture 25: Toilet 230V socket......................................................................................................................... 72
Picture 26: Shore power cable (230V input) and main fuse............................................................................ 73

Greenline 33 1
1. INTRODUCTION
INTRODUCTION FOR THE OWNER'S MANUAL
This manual has been compiled to help you to operate your craft with safety and pleasure. It contains details
of the craft; the equipment supplied or fitted its systems and information on its operation. Please read it
carefully, and familiarise yourself with the craft before using it.
This owner’s manual is not a course on boating safety or seamanship. If this is your first craft, or you are
changing to a type of craft you are not familiar with, for your own comfort and safety, please ensure that you
obtain handling and operating experience before "assuming command" of the craft. Your dealer or national
sailing federation or yacht club will be pleased to advise you of local sea schools, or competent instructors.
Ensure that the anticipated wind and sea conditions will correspond to the design category of your craft, and
that you and your crew are able to handle the craft in these conditions.
Even when your boat is categorised for them, the sea and wind conditions corresponding to the design
categories A, B, and C range from severe storm conditions for Category A, to strong conditions, for top of
category C, open to the hazards of a freak wave or gust, and are therefore dangerous conditions, where only a
competent, fit and trained crew using a well maintained craft can satisfactorily operate.
This owner's manual is not a detailed maintenance or trouble shooting guide. In case of difficulty, refer to the
boat builder or his representative. If a maintenance manual is provided, use it for the craft's maintenance.
Always use trained and competent people for maintenance, fixing or modifications. Modifications that may
affect the safety characteristics of the craft shall be assessed, executed and documented by competent
people. The boat builder cannot be held responsible for modifications he has not approved.
In some countries a driving licence or authorisation are required, or specific regulations are in force.
Always maintain your craft properly and make allowance for the deterioration that will occur in time and as a
result of heavy use or misuse of the craft.
Any craft –no matter how strong it may be, can be severely damaged if not used properly. This is not
compatible with safe boating. Always adjust the speed and direction of the craft to sea conditions.
If your craft is fitted with a life raft, read carefully its operating manual. The craft should have onboard the
appropriate safety equipment (lifejackets harness, etc.) according to the type of craft, weather conditions,
etc., these equipments are mandatory in some countries. The crew should be familiar with the use of all safety
equipment and emergency manoeuvring (man overboard recovery, towing, etc), sailing schools and clubs
regularly organise drill sessions.
All persons should wear a suitable buoyancy aid (Life jacket/Personal Floatation Device) when on deck. Note
that in some countries it is a legal requirement to wear a buoyancy aid that complies with their national
regulations at all times.
This manual is meant to help you enjoy and sail your boat comfortably and safely. It includes hints about the
boat, the equipment and systems delivered or installed and operation and maintenance guidance. Before you
put to sea, read it carefully if you really want to have fun and avoid damage and trouble. Read carefully and
make yourself at home on the boat, before you sail it.
We keep improving our boats as we want you to benefit from technological breakthroughs, new equipment or
materials and our own experience; therefore, the characteristics and information provided may vary without
notice or updating obligation.

Greenline 33 2
This manual is designed in accordance with the ISO 10240 Standard requirements.
DEGREES OF DANGERS
The following degrees of danger are used in the manual:
DANGER!
Denotes an extreme intrinsic hazard exists which would result in high
probability of death or irreparable injury if proper precautions are not
taken.
WARNING!
Denotes a hazard exists which can result in injury or death if proper
precautions are not taken.
CAUTION!
Denotes a reminder of safety practices or directs attention to unsafe
practices which could result in personal injury or damage to the boat or
components.
This is a broad-line manual which may describe equipment or accessories, or address subjects which do not
concern your boat; in case of doubt, you should check with the inventory submitted upon delivery of your
boat.
If this is your first boat or if you are changing to a boat type which is new to you, before "taking command",
get some training on boat control and sailing, to ensure your safety and comfort. Your dealer, international
sailing association, or yacht club will be pleased to suggest local sailing schools or professional instructors.
Even if everything has been provided for and designed for the safety of the boat and the safety of her users, do
not forget that sailing highly depends on the weather conditions, the sea condition and that only an
experienced and very fit crew, handling a well-maintained boat can sail satisfactorily.
The sea and wind conditions that correspond to the design categories (A, B or C) are changeable and are
dependent on the hazards of unusually strong waves or gusty winds. Therefore a total safety cannot be
guaranteed, even if your boat meets the requirements of a category.
Always listen to the weather forecast before you go out to sea.
Make sure that the sea and wind conditions will correspond to the category of your boat, and that you and
your crew are able to handle the boat in these conditions.
The sea and the water are not the natural environment of Man and one has only to respect their laws and
strength. Adapt the use you make of your boat to her condition; your boat wears out with time and use.
Any boat, however solid she may be, may be severely damaged if badly used. This is not compatible with a
secure navigation. Always adapt the speed and direction of the boat to the conditions of the sea.
The " COLREG ", an international regulation in order to prevent collision at sea, published by the International
Maritime Organization, specifies the helm and course regulations, the navigation lights etc.. all over the world.
Make sure you know these regulations and you have on board a manual that explain them.
In numerous countries, a licence, an authorization or a training course are requested. Make sure you have this
legal authorization before you use the boat.

Greenline 33 3
Always apply to an experienced professional for the maintenance, the assembly of accessories and minor
modifications. The written authorization of the builder or of his legal representative is compulsory for the
modifications that alter the specifications of the boat particularly the vertical layout of the masses (fitting of
radar, change of engine, etc...).
For the essential or optional equipments (engine, electronics ....), please refer to their respective manuals
delivered with the boat.
The users of this boat are informed of the following:
-The entire crew must have an appropriate training;
-The boat must not be loaded more than the maximum load recommended by the builder (in particular
as for the total weight of the food supplies, of the different equipments that are not supplied by the
builder and the weight of the persons on board) and this load must be properly distributed;
-The water of the bilges must be kept at its minimum;
-The stability is reduced when you add some weight in the upper parts;
-In case of rough sea, the hatches, lockers and doors must be closed in order to minimize the risk of
water coming in;
-The stability may be reduced when you tow a boat or when you lift heavy weights with the davits or
the boom;
-Breaking waves are important dangers to stability;
-The crew must be familiar with the use of all the safety equipment (harness, flares, life- raft, etc...) and
the emergency safety handlings (man overboard fishing out, towing, etc...).
PLEASE KEEP THIS MANUAL IN A SECURE PLACE, AND HAND IT OVER TO THE NEW OWNER WHEN YOU SELL
THE CRAFT."