Hyundai KONA Electric 2023 User manual

Battery low-
voltage
Hyundai KONA
SUV, 5 doors
From April 2023
Airbag Stored gas
inflator Seat belt
pretensioner SRS control unit
Gas strut /
Preloaded
spring
High strength
zone Fuel tank
Driver only
Optional
12V
48V
Li-ion
12V
Li-ion
ID No. KMH-SX2-RS-I-5-202308 Version No.
01 Version date: 08/2023 Page 1 of 4

①
②
ID No. KMH-SX2-RS-I-5-202308 Version No.
01 Version date: 08/2023 Page 2 of 4
1. Identification / recognition
3. Disable direct hazards / safety regulations
Lifting points under the vehicle:
Low Voltage 12V battery:
2. Immobilisation / stabilisation / lifting
Immobilization:
Access:
Disabling:
Turn the ignition
switch off Access to battery
shown above Disconnect the
negative(-) terminal Disconnect the
positve(+) terminal
Chock the wheels and pull the
switch to set the parking brake.
For automatic
vehicles, while
depressing the
brake pedal shift
the lever to P(park)
position or press P
button to make
vehicle in P
position
Pull the release lever to
unlatch the hood. The hood
should pop open slightly.
Raise the hood slightly,
push the secondary latch
up (1) inside of the hood
center and lift the hood (2)
12V Battery in the engine
room
Brand Logo Name
Model name
Wheel Drive emblem

R-1234yf
R-134a
Button
ID No. KMH-SX2-RS-I-5-202308 Version No.
01 Version date: 08/2023 Page 3 of 4
4. Access to the occupants
LI ION
WHEN COOLANT LEAKS FROM THE BATTERY PACK, IT CAN BECOME UNSTABLE
WITHRISK OF THERMAL RUNAWAY. CHECK BATTERY PACK TEMPERATURE WITH
THERMAL IMAGING CAMERA
Steering column adjustment: Seat adjustment:
Glass: Vehicle body:
MANUAL POWER
Hardened Steel:
48V [LI ION] Battery:
Access:
Disabling:
Disconnect 12V battery (shown on page 2) in the hood
Wait 10min and get
access to the 48V
battery shown above
Disconnect 12V (+)
cable from 48V battery
pack
Disconnect 48V (-)
cable and (+) cable in
order and BMS ESTN
wire
47l
max.
1. Laminated
2. Tempered
3. Tempered
4. Tempered
5. Tempered
48V
12V 500g 450g
Open tailgate Remove the luggage
cover Remove luggage
foam
12V
Tailgate:
Use a long flat object (Key) to
unlock the tailgate from inside.
Engine Room
5. Stored energy / liquids / gases / solids

OK 1
2
Not
OK
ID No. KMH-SX2-RS-I-5-202308 Version No.
01 Version date: 08/2023 Page 4 of 4
6. In case of fire
7. In case of submersion
8. Towing / transportation / storage
Do not touch any of the 48V components or cables, as doing so poses an
electrocution hazard. Work on the vehicle only after the vehicle has been pulled
out of the water.
Gas strut!
Risk of missile effect of hood and tailgate.
BATTERY RE-IGNITION!
10. Explanation of pictograms used
Corrosives General warning
sign
Explosive
Use thermal
Infrared camera Bonnet
Hazardous to the
human health Flammable
Acute toxicity
Environmental
hazard
Boot
Air-conditioning
component
Gasoline vehicle Fuel tank content
gasoline/ethanol
Notice: The use of wheel dollies
or flatbed is recommended. Use
a wheel lift or flatbed equipment.
Notice : Do not tow with sling-
type equipment (1). Do not tow
the vehicle with the front wheels
on the ground as this may cause
damage to the vehicle (2).
Use large amount of water
Towing hock located in the tool
case in the tailgate
Optional
Dolly
Dolly