InfraTec PIR uc 605 User manual



InfraTecGmbH
InfrarotsensorikundMesstechnik
GostritzerStraße61–63
01217Dresden/GERMANY
Phone+4935182876‐610
Fax+4935182876‐543
E‐mail[e-mail]
www.InfraTec.eu
©InfraTec09/2020(Allthestatedproductnamesandtrademarksremaininpropertyoftheirrespectiveowners.)
InfraTecinfraredLLC
5048TennysonPkwy.
PlanoTX75024/USA
Phone+1844‐226‐3722(tollfree)
E‐mailthermo@InfraTec‐infrared.com
www.InfraTec‐infrared.com

UserManual


PIRuc605


InfraredCameraModule








State:September2020




©InfraTecGmbH2020 1
TableofContents
1Introduction.......................................................................................................................................3
2NotesonSecuringtheDevice.............................................................................................................4
3TechnicalSpecificatios........................................................................................................................5
4Dimensions........................................................................................................................................6
5UnpackingandInspection..................................................................................................................7
6DesignationoftheCameraParts........................................................................................................8
6.1 FocusAdjustmentofthePIRuc605/20lens...............................................................................................8
7QuickStart.......................................................................................................................................10
7.1 Preparation................................................................................................................................................10
7.2 CameraSetup............................................................................................................................................10
7.3 NetworkAdapterSetting...........................................................................................................................10
7.4 SettingtheIPAddress................................................................................................................................11
7.5 ConnectingthePIRuc605withIRBIS®3.1*..............................................................................................11
8Maintenance....................................................................................................................................15
8.1 CleaningofLensesandProtectiveWindows.............................................................................................15
9EnvironmentalProtection................................................................................................................16
10 Service.............................................................................................................................................17




©InfraTecGmbH2020 3
1Introduction
Alllistedproductnamesandtrademarksremainthepropertyoftheirrespectiveowners.

Thismanualhasbeenpreparedwithduecare.Nevertheless,errorsandomissionscannotbecompletelyexcluded.

Furtherdevelopmentsinthesenseoftechnicalprogressarereserved.

Noliabilityisassumedfordamagesresultingfromnon‐observanceoftheinformationcontainedinthismanual.













InfraTecGmbH
InfrarotsensorikundMesstechnik
GostritzerStraße61–63
01217Dresden/GERMANY

Phone:+4935182876‐610
Fax:+4935182876‐543
E‐mail:[email protected]
Internet:www.InfraTec.de










Note
WithoutthewrittenconsentofInfraTecGmbH,nopartofthisusermanualmustbereproducedoredited,copied
ordistributedusingelectronicsystemsinanyform(print,copy,microfilmoranyotherprocedure).Thisusermanual
wasdevelopedapplyingduediligence.Noliabilityshallbeassumedforanydamagescausedbythenon‐observance
oftheinformationcontainedinthisusermanual.Allmentionedproductnamesandtrademarksshallremainthe
propertyoftheirrespectiveowners.

2NotesonSecuringtheDevice
©InfraTecGmbH2020 4

2NotesonSecuringtheDevice

ThePIRuc605isanopticalmeasuringdevice.Handleitwithcare.Avoidsoiling,especiallyontheoptical
surfaces.

Dependingonthedesignofthelensinterface,thedevicecomeswithprotectionclassIP40(screwthread).

Pleasenotetheinformationgiveninthetechnicaldata(seechapter4Dimensions–page6)andinthe
QuickStartGuide(seechapter7QuickStart–page10ff.)foruse,storageandtransportofthedevice.

WhentransportingthePIRuc605,useonlythesuppliedtransportationcase*ortransportpackaging*.

Pleasenotethatopeningthehousingofthecameraisonlyreservedtothemanufacturer.Any
manipulationbyotherpersonsisnotpermittedandwillinvalidatethewarranty.

OnlyuseaccessoriesorsparepartsexplicitlyrecommendedbythemanufacturerforthePIRuc605.
Otherwise,malfunctionordamagemayoccur.Warrantyclaimsareexcludedforanyresultingdamage.


ThePIRuc605mustnotbedirecteddirectlyatthesunorothersourcesofhighradiation(e.g.laser),either
wheninoperationorswitchedoff,asthismaycauseirreversiblemodificationstothemicrobolometer
detector.Theoriginofthesemodificationscanbeclearlyidentified.Themanufacturerdoesnotacceptany
guaranteefordamagecausedinthisway.

Furthermore,itisessentialtopreventthesunorotherhigh‐energyradiationsourcesfromenteringthe
fieldofviewofPIRuc605indirectlyviareflectingsurfaces!

Whennotinuse,alwaysattachthelenscapsuppliedwiththePIRuc605.

Donotremovethelensesinroomswithhighdustexposureorhumidity,asthespecifieddegreeof
protectioncannotbeguaranteedwhenthelensisremoved.



3TechnicalSpecificatios
©InfraTecGmbH2020 5
3TechnicalSpecificatios
Spectralrange(8…14)μm
Pitch17μm
DetectortypeUncooledmicrobolometerfocalplanearray
Detectorformat(IRpixels)(640×480)
Temperaturemeasurementrange(‐20...135)°C/(0...400)°C
Measurementaccuracy±5K(0...100)°C,±5%(<0bzw.>100)°C
Temperatureresolutionat30°C≤0,06K
IRframerate25Hz(640×480)
ImagestorageOnharddiskofcontrolPC(notebook)
FocusManually
Lensfocallength5mm**,10mm,20mm,50mm
DatainterfaceEthernetRJ45,100BaseT
TriggerSoftware‐Trigger
Tripodconnection1/4"‐photothread
Powersupply12(9…15)VDC
Powerconsumption<3W
Storagetemperature(‐45…65)°C
Operatingtemperature(‐20…60)°C
DegreeofprotectionIP40
Dimensions(55,8×44×46)mm(withoutlens)
Weight<110g(withoutlens)
ProtectivehousingRobustmetalhousing
Evaluationandanalysissoftware*IRBIS®3.1plus*,IRBIS®3.1professional*,IRBIS®3.1online*,SDK
V4*(LabVIEW*,MATLAB*)
**Temperatureresolutiondiffers


LensesFocallength(mm)FOV(°)IFOV(mrad)
Superwideanglelens5(95×78)3,40
Wideangle10(59×46)1,77
Normallens20(32×24)0,89
TelephotoLens50(12×9)0,34


4Dimensions
©InfraTecGmbH2020 6
4Dimensions



Fig.1HousingdimensionsofthePIRuc605

100BaseT
Interface
Powersupply,DC12V
I/Oortriggerinterface

5UnpackingandInspection
©InfraTecGmbH2020 7
5UnpackingandInspection
PleasecheckthatallcomponentsofthePIRuc605arecompleteandundamagedafterreceipt.Anydamagemust
bereportedtothesupplierimmediately.

ThePIRuc605systemisdeliveredinatransportcase*ortransportpackaging*.


Fig.2Casecontentsunpacked(dependingonequipment)

Componentsincludedinthebasicpackage
1IRcameramodulePIRuc605withlens
2Lenscover
3PowersupplyunitDC12V
4Adapterforcamerapowersupplyunit
5PlugforI/Oortriggerinterface*
6Mountingplugforpowersupply
73‐leggedtabletripod
81mEthernetcablewithRJ45plug
9Transportcase/Transportpackaging

Optionalequipment*
ThermographysoftwareoftheIRBIS®family



1
2
3
4
5
6
7
8
9

6DesignationoftheCameraParts
©InfraTecGmbH2020 8

6DesignationoftheCameraParts

Fig.3Viewofrearside


Fig.4Lenssideandsideview


6.1 FocusAdjustmentofthePIRuc605/20lens


1Thelockingringisusedtofixthefocussetting
2Focusingofthelensiscarriedoutbyturningthelens(left/right)


100BaseTinterface
Powersuppy,DC12V
I/Oortriggerinterface*
Lens
Housing(IP40)
1
2