Jacuzzi J Series User manual

!) (
CERTIFIED
www.ahridirectory.org
TM
Heat Pump Pool Heaters
AHRI Standard 1160
J-SERIES HEAT PUMP

LEADING EDGE TECHNOLOGY
Consistentiy heat your pool and extend your swimming season with our full line of
heat pumps! The most efficient way to heat your pool or spa! 100% pure, commer-
cial-grade titanium heat exchanger, innovative silent series product design.
Exclusive titanium heat exchanger is impervious to pool chemistry
Air management system maximizes heat
Small footprint - ideal for above ground pools!
Compatible with remote system controls
JACUZZI® J-SERIES
Commercial Grade Pool Heat Pumps
Save up to $2,000 annually.
Extend the life of the heat
pump.
Reduce noise!
JHX140 JHX127
JHX85 JHX60

SPECIFICATIONS
Save Up to 85% over the cost of gas heating!
Heat Exchanger Construction
JHX140 JHX127 JHX85 JHX60
Temp Control
Ideal for Pools up to: (Gallons)
Voltage Required
Operating Current
Recommended Circuit Breaker
Maximum Circuit Breaker
Refrigerant
Minimum Water Flow Rate
Maximum Water Flow Rate
Dimensions (WxDxH)
Net Weight (LBS)
Shipping Weight (LBS)
Performance Testing Results
TITANIUM TITANIUM TITANIUM TITANIUM
DIGITAL DIGITAL DIGITAL DIGITAL
45,000 40,000 25,000 16,000
2 & 3 Wire 2 & 3 Wire 2 & 3 Wire 2 & 3 Wire
5.8 5.8 5.8 5.8COP
140,000 127,000 85,000 60,00080*/80*/80*
80*/80*/80*
50*/80*/63*
5.4 5.3 5.4 5.4COP
130,000 118,000 75,000 54,000
4.0 4.0 4.0 4.0COP
85,000 79,000 52,000 40,000
208/230 V 208/230 V 208/230 V 208/230 V
32 AMPS 29 AMPS 26 AMPS 20 AMPS
50 AMPS 50 AMPS 40 AMPS 25 AMPS
60 AMPS 60AMPS 50 AMPS 30 AMPS
R410A R410A R410A R410A
25 GPM 25 GPM 25 GPM 25 GPM
80 GPM 80 GPM 80 GPM 80 GPM
33" X 36" X 45" 35" X 35" X 43" 31" X 31" X 34" 31" X 31" X 31"
310 290 206 190
335 310 245 229
LPM Part Number 85452 85451 85450 TBD

Save
Money
Our app tells you how much you're spending to
heat your pool, so you can adjust your heating
schedule and save!
No
Surprises
Something wrong with your heater or pump? Find
out in real time with custom emails and
notifications sent to your phone.
Stay
Connected
Monitor and mangae your pool's heater and pump,
24/7, with the iOptimizerTM App or Control Centre
- Wherever you are
Jump
Right In
Set schedules to ensure your pool is ready to
enjoy when you're ready, or adjust it manually for
an unplanned swim!
Contact
877-278-2797
Email
[email protected]
$
!
AUTOMATION
AUTOMATION

Attention Installer
NOTICE: Read all instructions before installation.
Unit is Pre-wired for 230 only!
If 208 Volts, please follow the instructions below:
ALL INSTALLATION AND WORK MUST BE PERFORMED BY A CERTIFIED ELECTRICIAN AND
PER ALL LOCAL BUILDING AND ELECTRICAL CODES.
WARNING: Before hooking up power to the main contactor, make sure the proper connections have been made
to match the supply voltage on the supplied transformer. Using a voltmeter determine what the incoming voltage
is. If 208V supply is being used, disconnect the factory lead (1) and reconnect it on (2) as noted in the pictures
below. Failure to do so will result in voiding warranty, damage to the unit, fire, injury, or possibly even death.
(1) 230V (Red) OR (2) 208V (Orange) (5) COM (Black) COM (Red) 208V (Black) OR 230V (Black)
(6) 0V (Blue) (8) 12V (Grey) (10) 24V (Blue) (Blue) 24V (Blue)
Water Pressure Switch Adjustments: Plumbing Setups are Different – A simple adjustment of the
water pressure switch may be needed. If the “FLO” or “FL3” code appears when pool pump is on or if the unit
does not indicate “FLO” when pool pump is off, please call 1-877-278-2797 for detailed instructions.
FIELD WIRING: NOTICE: To aid in field wiring, see the Figure 1 below. Incoming power is to be connected
to L1 and L2 as shown. To insure proper connections tighten the screws securely to 40-45 in-lbs (4.5-5 N-m). After
L1 & L2 Lugs are torqued, move wire side to side to settle wire strands, then torque again. Failure to do so may
result in wires becoming loose which can result in voiding warranty, damage to the unit, fire, injury, or death.
Bonding & Grounding the Unit are Required. Danger: Failure to do so will result in voiding warranty,
damage to the unit, fire, injury, or possibly even death.
Notice: Please remove these instruction from the Electrical area and store with proof of purchase.

Unit Setups:
Heat Pumps Require the Following: (Please See Owner’s Manual for All Details)
-Water Flow, Water Flow & Water Flow!!! (Require: 25 to 80GPM & Recommend: 40 to 80GPM) (Vary per Model)
-Proper Voltage (Switch Wire Location on Transformer if 208 Volts) See details on other side of this Document.
-Proper Ground and Bond per NEC Requirements.
-Level Pad & Allowance for Condensation Drainage
-Installed Outside with Clearance around the Heat Pump for Maintenance and Air Flow.
-No Roof Drainage on Heat Pump
-Any Additional Heater(s) (Solar, LP, Natural, etc…) much be Downstream of Heat Pump(s).
-Any Chemicals added (Chlorinators, Salt Generators, etc…) must be added Downstream of any
Heater(s) with a Check Valve Separating them.
Commercial & Multiple Heater Setups:
-Water Flow, Water Flow & Water Flow!!! (Require: 25 to 80GPM & Recommend: 40 to 80GPM) (Vary per Model)
*Please Note: Due to Health Code Requirements Requiring a Mandatory GPM, Some Circumstances
Request Restrict the Water Flowing throughout the Heat Pump(s) to Increase the Total Required GPM
for the System… aka: HP Code. This can Results in Improper Water Flow Flowing throughout the Heat
Pump(s) which can Result in High Electric Bills, Voiding Warranty, Loss of Performance, Over Heating
the Heat Pump(s), Damage to the Unit, Fire, Injury, or Possibly Even Death. It is Required to keep
warranty to have a Commercial Water Flow Switch on All Commercial Heat Pumps. A Commercial
Water Flow Switch will Help Guarantee a Longer, Better Life & Performance of your Heat Pump(s).
-Call 1-877-278-2797 to obtain a Commercial Water Flow Switch with part # CWFSK.
-Proper Voltage (Switch Wire Location on Transformer if 208 Volts) See details on other side of this Document.
*** Failure to do so will result in voiding warranty, damage to the unit overtime due to Overheating Components, fire, injury,
or possibly even death.***
-Proper Ground and Bond per NEC Requirements. *** Failure to do so will result in voiding warranty, damage to
the unit, fire, injury, or possibly even death.***
-Level Pad & Allowance for Condensation Drainage.
-Installed Outside with Clearance around the Heat Pump for Maintenance and Air Flow. ***Please Note:
When Installing 2 Heat Pumps side-by-side, the Coil Clearance increases to 24” between Heat Pumps.
-No Direct Roof Drainage on Heat Pump.
-Any Additional Heater(s) (Solar, LP, Natural, etc…) must be Downstream of Heat Pump(s).
-Any Chemicals added (Chlorinators, Salt Generators, etc…) must be added Downstream of any
Heater(s) with a Check Valve Separating them.
-For any questions regarding Plumbing Recommendations, Please Call Manufacture.
Winterizing: After shutting Down the Pool and (or) Spa with All Water Removed from the Plumbing/
PVC, Disconnect the Supplied Unions on the Front of the Heat Pump. Use an Air Blower to Blow the
Water Out of the Heat Pump. The Air Blower has to be High Volume, but Low Pressure (like a Shop
Vacuum in Reverse). Blow into the Inlet until the Water stops coming out of the Outlet, then Blow into
the Outlet until water stops coming out of the Inlet. Cycle back and forth until No Water coming out in
Any Direction. Start the Unions back on the Heat Pump to Prevent Dirt, Debris, Foreign Objects and (or)
Bugs, Snakes, Mice, Lizards, Frogs, etc… from Entering the Heat Pump Plumbing.
***For More Details: Please Refer to Owner’s Manual or Contact the Manufacture with the Supplied
Number on your Heat Pump Serial # Decal with the Serial # Available. Thank you***

REMINDER: Keep your dated proof of purchase for warranty purposes! Attach it to this manual or file it for safekeeping.
'PSQBSUTQSPEVDUTFSWJDFJOGPSNBUJPO
DBMM 772782797
CoOtents
*NQPSUBOU4BGFUZ*OTUSVDUJPOT
*OTUBMMBUJPO1SPDFEVSFT
6OJU*OTQFDUJPO
6OJU-PDBUJPO
1MVNCJOH
#BTJD)FBU1VNQ0QFSBUJPO 
&MFDUSJDBM$POOFDUJPOT
&MFDUSPOJD5FNQ$POUSPMT
%FTDSJQUJPO
#VUUPOT
8BUFS5FNQ4FU1PJOU         
$POOFDUJOHUPB3FNPUF4ZTUFN  
)JHI5FNQFSBUVSF-PDL0VU3
."/6"-5&.1$0/530-4
%FTDSJQUJPO
*OEJDBUPS-JHIUT                
8BUFS5FNQFSBUVSF4FU1PJOU. . . . . . . 
4FMFDUJOH'VODUJPOBMJUZPG6OJU   
0QFSBUJPO  
"DUJWBUJOHBOE4FUUJOH4ZTUFN
3VO5JNF
"QQMJDBUJPO(VJEFMJOFT
.BJOUFOBODF
$POEFOTBUJPO
1PPM#MBOLFUT
4FBTPOBM4IVUEPXOT
1PPM0QFOJOHT
8FBUIFS$POEJUJPOT
5SPVCMFTIPPUJOH(VJEF
%JBHOPTUJDT 
%JBHSBNT    
/PUFT
8BSSBOUZ
Important Safety
Instructions
3&"%"/%'0--08"--*/4536$5*0/4
SAFETY GUIDELINES
5IJTNBOVBMDPOUBJOTJOGPSNBUJPOUIBUJT
WFSZJNQPSUBOUUPLOPXBOEVOEFSTUBOE
5IJTJOGPSNBUJPOJTQSPWJEFEGPS4"'&5:
BOEUP13&7&/5&26*1.&/5130#-&.4
5PIFMQSFDPHOJ[FUIJTJOGPSNBUJPO
PCTFSWFUIFGPMMPXJOHTZNCPMT
Warning indicates a
potentially
hazardous situation which, if not avoided,
could result in death or serious injury.
Caution indicates a
potentially
hazardous situation which, if not avoided,
may result in minor or moderate injury.
Notice indicates
important
information, that if not followed, may
cause damage to equipment.
CALIFORNIA PROPOSITION 65
This product or
its power cord may
contain chemicals known to the State
of California to cause cancer and birth
defects or other reproductive harm.
Wash hands after handling.
GENERAL SAFETY INFORMATION
t5IFXBUFSJOBQPPMPSUVCTIPVME
OFWFSFYDFFE'$"XBUFS
UFNQFSBUVSFJOFYDFTTPG'JT
DPOTJEFSFEVOTBGFGPSBMMQFSTPOT-PXFS
XBUFSUFNQFSBUVSFTBSFSFDPNNFOEFE
GPSFYUFOEFEVTFFYDFFEJOH
NJOVUFTBOEZPVOHDIJMESFO
t&YDFTTJWFXBUFSUFNQFSBUVSFTIBWFB
IJHIQPUFOUJBMGPSDBVTJOHGFUBMEBNBHF
EVSJOHUIFFBSMZNPOUITPGQSFHOBODZ
1SFHOBOUPSQPTTJCMZQSFHOBOU
XPNFOTIPVMEMJNJUQPPMPSUVCXBUFS
UFNQFSBUVSFTUP'$
t "MDPIPMESVHTPSNFEJDBUJPOTIPVME
OPUCFVTFECFGPSFPSEVSJOHQPPMPS
UVCVTFTJODFUIFJSVTFNBZMFBEUP
VODPOTDJPVTOFTTXJUIUIFQPTTJCJMJUZ
PGESPXOJOH
t0CFTFQFSTPOTBOEQFSTPOTXJUIB
NFEJDBMIJTUPSZPGIFBSUEJTFBTFMPXPS
IJHICMPPEQSFTTVSFDJSDVMBUPSZTZTUFN
QSPCMFNTPSEJBCFUFTTIPVMEDPOTVMUB
QIZTJDJBOCFGPSFVTJOHBQPPMPSUVC
t 1FSTPOTVTJOHNFEJDBUJPOTIPVME
DPOTVMUBQIZTJDJBOCFGPSFVTJOHB
QPPMPSUVCTJODFTPNFNFEJDBUJPO
NBZJOEVDFESPXTJOFTTXIJMFPUIFS
NFEJDBUJPONBZBGGFDUIFBSUSBUF
CMPPEQSFTTVSFBOEDJSDVMBUJPO
t1SPMPOHFEJNNFSTJPOJOIPUXBUFSNBZ
JOEVDFIZQFSUIFSNJB)ZQFSUIFSNJB
PDDVSTXIFOUIFJOUFSOBMUFNQFSBUVSFPG
UIFCPEZSFBDIFTBMFWFMTFWFSBMEFHSFFT
BCPWFUIFOPSNBMCPEZUFNQFSBUVSFPG
'5IFTZNQUPNTPGIZQFSUIFSNJB
JODMVEFEJ[[JOFTTGBJOUJOHESPXTJOFTT
MFUIBSHZBOEBOJODSFBTFJOUIFJOUFSOBM
UFNQFSBUVSFPGUIFCPEZ5IFFGGFDUTPG
IZQFSUIFSNJBJODMVEFVOBXBSFOFTTPG
JNQFOEJOHIB[BSEGBJMVSFUPQFSDFJWF
IFBUGBJMVSFUPSFDPHOJ[FUIFOFFEUP
FYJUQPPMPSUVCQIZTJDBMJOBCJMJUZUPFYJU
QPPMPSUVCGFUBMEBNBHFJOQSFHOBOU
XPNFOBOEVODPOTDJPVTOFTTSFTVMUJOH
JOBEBOHFSPGESPXOJOH
t #FDBVTFUIFUPMFSBODFPGXBUFS
UFNQFSBUVSFSFHVMBUJOHEFWJDFT
NBZWBSZBTNVDIBT'$
ZPVTIPVMENFBTVSFUIFXBUFS
UFNQFSBUVSFBUTFWFSBMMPDBUJPOT
VTJOHBOBDDVSBUFUIFSNPNFUFS
CFGPSFFOUFSJOHBQPPMPSUVC
SAVE THESE INSTRUCTIONS.
Installation Procedures
UNIT INSPECTION
*OTQFDUZPVSVOJUWFSZDBSFGVMMZCFGPSF
JOTUBMMJOH.BLFTVSFUIFSFIBTCFFOOP
EBNBHFUPUIFFWBQPSBUPSmOTPSUIFSF
BSFOPQVODUVSFTPSPJMTPBLFEBSFBTPO
UIFCPY5IJTXPVMEJOEJDBUFEBNBHF
UPUIFSFGSJHFSBUJPOTZTUFNBOETIPVME
CFSFKFDUFEJNNFEJBUFMZ
Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described.
Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or
property damage! Retain instructions for future reference.
Operating Instructions
Heat Pump Pool and Spa Heater

THE UNIT MUST BE TRANSPORTED IN THE UP-
RIGHT POSITION AT ALL TIMES AND MUST
NOT BE DROPPED OR TAILGATED. DAMAGE
TO THE UNIT DURING TRANSPORTATION
IS NOT THE RESPONSIBILITY OF THE
MANUFACTURER. IF UNIT IS CLOSER THAN
18 INCHES, THE MANUFACTURER IS NOT
RESPONSIBLE FOR BAD, WORN OR SEIZED
FAN MOTORS AND CAPACITORS.
*UJTUIFIPNFPXOFSTSFTQPOTJCJMJUZ
UPSFNPWFBOZPCTUSVDUJPOTBUUIFJS
PXODPTUCFGPSFBOZTDIFEVMFE
NBJOUFOBODFXPSLJTQFSGPSNFE*GOPU
EPOFUIFIPNFPXOFSJTSFTQPOTJCMF
GPSBOZBEEJUJPOBMDPTUPGGFFTBOEJG
OPUQBJEUIFUIFXBSSBOUZXJMMCFWPJE
UNIT LOCATION
0ODFUIFVOJUIBTCFFOJOTQFDUFEBOE
DMFBSFEPGBOZUSBOTQPSUBUJPOEBNBHF
JUJTOPXUJNFUPMPDBUFUIFQPPMIFBUFS
*UJTWFSZJNQPSUBOUUPVOEFSTUBOE
UIFMPDBUJPOPGUIFVOJUGPSUIFCFTU
QFSGPSNBODFPGPQFSBUJPO4FF'JHVSF
GPSMPDBUJPOSFDPNNFOEBUJPOT
If unit is closer
than 18 inches, the
manufacturer is not responsible for bad,
worn or seized fan motors and capacitors.
"NJOJNVNPGJODIFTPGDMFBSBODF
CFUXFFOUIFFWBQPSBUPSDPJMTBOETISVCT
GFODFTXBMMTFUDNVTUCFNBJOUBJOFE
GPSBEFRVBUFBJSJOUBLF"NJOJNVNPG
GFFUPGWFSUJDBMDMFBSBODFCFUXFFOUIF
UPQPGUIFVOJUBOEBOZSPPGPWFSIBOHPS
PUIFSPCTUSVDUJPOTNVTUCFNBJOUBJOFEJO
PSEFSUPQSFWFOUUIFSFDJSDVMBUJPOPGDPME
BJSCBDLJOUPUIFFWBQPSBUPSDPJMT5IJT
JTUPNBJOUBJOUIFFGmDJFODZPGUIFVOJU
"NJOJNVNPGJODIFTPGDMFBSBODF
CFUXFFOUIFGSPOUPGUIFVOJUBDDFTT
QBOFMBSFBBOEBOZPCTUSVDUJPONVTU
CFNBJOUBJOFEUPBMMPXNBJOUFOBODF
POUIFVOJUXIFOOFDFTTBSZ5IFVOJU
NVTUCFMPDBUFEPOBTPMJEMFWFMTVSGBDF
BNJOJNVNPGJODIFTYJODIFTGPS
QSPQFSESBJOBHF.BLFTVSFBOZTQSJOLMFS
IFBETBSFOPUEJSFDUMZTQSBZJOHXBUFSPO
UIFVOJU8IJMFIFBUQVNQTBSFNBEF
GPSBOPVUEPPSFOWJSPONFOUUIFZBSF
OPUEFTJHOFEUPIBWFTQSJOLMFSXBUFS
DPOTUBOUMZTQSBZJOHUIFN
NOTE: This type of constant watering
directly on the unit can void your
warranty.
$POEFOTBUJPOESBJOIPMFTBSFQSPWJEFE
JOBMMVOJUTGPSBEFRVBUFSFNPWBMPG
DPOEFOTBUJPOBOESBJOXBUFS ALL
UNITS WILL HAVE CONDENSATION.
THIS SHOULD NOT BE MISTAKEN FOR
A LEAK IN THE UNIT.
PLUMBING
8IFSFGSFF[JOH
XFBUIFSJT
FODPVOUFSFEUIFEFUBDIBCMF
DPOOFDUJPOVOJPOQSPWJEFENVTU
CFJOTUBMMFEJNNFEJBUFMZBEKBDFOUUP
UIFIFBUFSUPGBDJMJUBUFTFSWJDJOHBOE
ESBJOJOHPGUIFIFBUFYDIBOHFS
Draining is necessary to prevent
damage to the condenser shell and coil
due to the expansion of freezing water.
'PSQSPQFSXJOUFSJ[JOHESBJOBMMXBUFS
CZCMPXJOHBOZSFNBJOJOHXBUFS
UISPVHIUIFJOMFUBOEPVUMFUCPUI
EJSFDUJPOTXJUIMPXQSFTTVSFIJHI
WPMVNFBJSnPXBTJOVTJOHBXFUESZ
WBDJOSFWFSTF5IFNJOJNVNXBUFS
DJSDVMBUJPODBQBDJUZGMPXJOHUISPVHI
UIFQPPMIFBUFSJTHBMMPOTQFS
NJOVUF5IFXBUFSDBQBDJUZJT
HBMMPOTQFSNJOVUFPOBMMNPEFMT
Intentional setting of the water FLow
outside of these guidelines will void
the warranty.
%POPUJOTUBMMBXBUFSTIVUPGGWBMWFJO
UIFQJQJOHGSPNUIFPVUMFUPGUIFQPPM
IFBUFSUPUIFQPPMPSUVC)PXFWFS
BDIFDLWBMWFUIBUEPFTOPUJODMVEFB
TIVUPGGGFBUVSFNBZCFJOTUBMMFEGPS
DPOWFOJFODFEVSJOHTFSWJDJOH
"DIFDLWBMWFJTSFRVJSFECFUXFFOUIF
VOJUBOEBDIMPSJOBUPS5IFDIMPSJOBUPS
NVTUCFEPXOTUSFBNPGUIFIFBU
QVNQ'BJMVSFUPEPTPNBZWPJEUIF
XBSSBOUZ
*GZPVIBWFBOJOnPPSDMFBOJOH
TZTUFNQMFBTFUBLFOPUFPGBOZTQFDJBM
QMVNCJOHSFRVJSFNFOUTUPPQFSBUFBMM
VOJUTFGGFDUJWFMZ
'JHVSFTIPXTUIFSFDPNNFOEFE
JOTUBMMBUJPOMBZPVU
NOTE: Do not place chlorine tablets,
or any other chemicals directly in
skimmer basket. Doing this will void
the warranty.
ELECTRICAL CONNECTIONS
All wiring and
electrical connections
must be performed by a qualified
electrician. Installations must be in
accordance with local and national codes.
Installation
Procedures (continued)
2
0QFSBUJOH*OTUSVDUJPOT
Figure 2 - Recommended
installation layout
Figure 1 -
Unit Location
JO
.JO
JO.JO
6/*0/4
4)650''7"-7&
#:1"44
7"-7&
*/
065
$)-03*/"503
'*-5&3
$)&$,
7"-7& 8"3.
8"5&3
06550
100- $0-%
8"5&3
*/'30.100-
100-
16.1
JO
.JO
JO
.JO
GU.JO
IF INSTALLING MORE THAN
ONE UNIT, CALL TO GET ALL
INSTALLATION SPECS
HEAT PUMPS ARE TO BE INSTALLED OUTSIDE.
NO CHEMICAL TANKS SHOULD BE LOCATED
WITHIN 5 FT. OF THE HEAT PUMP.

Overheating, short-
circuiting and fire
damage will result from inadequate wiring.
"MMVOJUTBSFFRVJQQFEXJUIBOFMFDUSJDBM
XJSJOHTDIFNBUJDJOTJEFUIFFMFDUSJDBM
QBOFM*GUIJTJTNJTTJOHQMFBTFDPOUBDUUIF
GBDUPSZBU772782797UPPCUBJOPOF
6OJUTUIBUBSFFRVJQQFEXJUIB
7"$USBOTGPSNFSVOJUNVTUCFXJSFEUP
NBUDIUIFTVQQMZQPXFSWPMUBHF3FGFS
UPUIFXJSJOHTDIFNBUJDJO'JHVSFPO
QBHFGPSQSPQFSDPOOFDUJWJUZ
Failure to do so could cause
overheating, short-circuiting, fire
damage and will also void the
Warranty.
1PXFS-BOE-MFBETBSFDPOOFDUFE
UPUIFSJHIUTJEFPGDPOUBDUPS5IFTFBSF
UPCFUPSRVFEUPJOMCT
Failure to torque
the L1 and L2 leads
may cause overheating or short-
circuiting which could result in fire
damage, serious injury or even death.
Failure to torque the leads will also
void the warranty.
1PPM)FBUFSJTUPCFJOTUBMMFEJO
BDDPSEBODFXJUI"SUJDMFPGUIF
/BUJPOBM&MFDUSJDBM$PEF/&$/'1"
BOEXJUIJOUIFSFRVJSFNFOUTPGBMM
MPDBMDPEFTIBWJOHKVSJTEJDUJPO
Electronic Temp.
Controls
DESCRIPTION
t 5IFDPOUSPMMPDBUFEPOUIFGSPOU
PGZPVSIFBUQVNQIBTBMBSHF
UISFFDIBSBDUFSEJTQMBZGPSUIF
XBUFSUFNQFSBUVSFTFUQPJOUTBOE
EJBHOPTUJDTTFFmHVSFGPSGSPOU
QBOFMBQQFBSBODF5IFUISFFCVUUPO
LFZQBEJODMVEFT4&561BSSPXBOE
%08/BSSPXCVUUPOT-&%JOEJDBUPST
OFYUUPUIFEJTQMBZTIPXJGUIFIFBU
QVNQJTJOUIFQPPMNPEFPSJOUIF
TQBNPEFBOEJGUIFVOJUJTSVOOJOH
#6550/4
1SFTTUIF4&5CVUUPOUPDIBOHFCFUXFFO
NPEFTBOEVTFUIFVQBOEEPXOBSSPXT
UPDIBOHFUIFTFMFDUFENPEFTTFUUJOHT
.PEFTBWBJMBCMFBSF
POLBMMPXTZPVUPDIBOHFUIFQPPM
XBUFSUFNQFSBUVSFTFUQPJOU
SPABMMPXTZPVUPDIBOHFUIFTQB
XBUFSUFNQFSBUVSFTFUQPJOU
P-SDIBOHFTCFUXFFOQPPMBOETQB
TFUUJOHT-&%TPOGSPOUQBOFMXJMM
JOEJDBUFDVSSFOUNPEFTFMFDUFE
F-CEJTQMBZUFNQFSBUVSFJO
'BISFOIFJUPS$FMTJVT
5$&6OJUTPOMZ
FILVTFEUPTFUTZTUFNSVOUJNF
)$6OJUTPOMZ
8"5&35&.1&3"563&4&510*/5
5FNQFSBUVSFTFUQPJOUSBOHFJT0''BOE
¡'UP¡'GPS10-NPEF'PS41"NPEF
TFUQPJOUSBOHFJT0''BOE¡'UP¡'
1VTIJOHUIF61BSSPXPS%08/BSSPX
CVUUPOTXJMMQSPNQUUIFDPOUSPMUPEJTQMBZ
UIFDVSSFOUTFUQPJOUJOUIFDVSSFOUNPEF
$POUJOVJOHUPQSFTTUIF61PS%08/
CVUUPOTXJMMBMMPXUIFTFUQPJOUWBMVFTUP
TDSPMMVOUJMUIFEFTJSFETFUQPJOUJTSFBDIFE
0ODFUIFOFXTFUQPJOUIBTCFFOSFBDIFE
TUPQQSFTTJOHUIF61PS%08/CVUUPOT
0ODFUIFVOJUUPHHMFTCBDLUPUIFDVSSFOU
XBUFSUFNQFSBUVSFEJTQMBZUIFTFUQPJOU
JTFOUFSFE5IFDPOUSPMTIBWFBGFBUVSF
DBMMFEi4FU1PJOU.FNPSZ3FUFOUJPOw*G
UIFQPXFSJTSFNPWFEGSPNUIFVOJUJU
SFUBJOTUIFMBTUTFUQPJOUEJTQMBZFE
$0//&$5*/(50"3&.05&4:45&.
5IJT1PPM)FBUFSJTDPNQBUJCMFXJUIBMM
LOPXOSFNPUFTZTUFNTJOUIFJOEVTUSZ
1MFBTFWJFXUIFXJSJOHEJBHSBNPOQBHF
UPTFFIPXUPDPOOFDUSFNPUFTZTUFNT
UPUIF&MFDUSPOJD5FNQFSBUVSF$POUSPMMFS
'PSXJSFSFNPUFT
 1VTITFUCVUUPOUPFOUFSVTFSTNFOV
 #SJOHVQi10-wTFUUJOHBOEBSSPX
UFNQFSBUVSFEPXOVOUJMQPPMTFUUJOH
SFBETiPGGw
 #SJOHVQi41"wTFUUJOHBOEBSSPX
UFNQFSBUVSFVQVOUJMTQBTFUUJOH
SFBET
 4FUVOJUUPUIFi10-wNPEF
 $POOFDUSFNPUFTZTUFNXJUIXJSFT
UPUIF14UFSNJOBMPODPOUSPMCPBSE
TFFTQFDJmDNPEFMXJSJOHEJBHSBN
'PSXJSFSFNPUFT
 1VTITFUCVUUPOUPFOUFSVTFSTNFOV
 #SJOHVQi10-wTFUUJOHBOEVTF
BSSPXTUPTFMFDUEFTJSFEQPPM
UFNQFSBUVSF
 #SJOHVQi41"wTFUUJOHBOEVTFUIF
BSSPXTUPTFMFDUUIFEFTJSFETQB
UFNQFSBUVSF
 4FUVOJUUPUIFi10-wNPEF
 $POOFDUUIFDPNNPOBOEIJHIPS
TQBXJSFTUPUIFi14wUFSNJOBMTPO
DPOUSPMCPBSETFFTQFDJmDNPEFM
EJBHSBN-PXPSQPPMXJSFEPFTOPU
HFUDPOOFDUFE
3
Installation
Procedures (continued)
Figure 3 - Front Panel
)*()5&.1&3"563&-0$,065
:PVSIFBUQVNQJODMVEFTBTQFDJBM
GFBUVSFUPiMPDLwUIFIJHIUFNQFSBUVSF
TFUUJOHT5IJTFMJNJOBUFTUIFOFFEGPSB
UIFSNPTUBUMPDLCPY5IJTQSFWFOUT
VOBVUIPSJ[FEQFSTPOTGSPNBEKVTUJOH
UIFIFBUQVNQBCPWFUIFTFEFTJSFE
MJNJUT5PBDUJWBUFUIJTGFBUVSFQMFBTF
DBMM772782797EVSJOHCVTJOFTTIPVST
".UP1.&%5.POEBZUISPVHI
'SJEBZBOEXFXJMMCFHMBEUPBTTJTUJO
TFUUJOHVQUIJTGFBUVSF
FEATURES
"MMBQQMJDBCMFGFBUVSFTUPUIFTFNPEFMT
IBWFCFFODPWFSFEJOUIFQSFWJPVT
TFDUJPOT0UIFSNPEFMTGFBUVSFTBSF
EJTDVTTFEJOEFTJHOBUFETFDUJPOT
TVCTFRVFOUUPUIJTTFDUJPO

All wiring and
electrical connections
must be performed by a qualified
electrician. Installation must be in
accordance with local and national codes.
This section allows you to run the heat
pump at set intervals during the day. If
you have a time clock, and would like
to use it please refer to the Time Clock
Override section.
'PSUIF5$&GFBUVSFUPXPSLZPVSQPPM
QVNQNVTUCFXJSFEUPUIFIFBUQVNQ
4FFmHVSFGPSXJSJOHUIF5$&
GFBUVSF
t5IJTVOJUJTQSFQBSFEBUUIF
factory with the TCE feature
installed, but set to the “off”
position in the “FIL” mode. You
will need to set the hours of
run time for the pump and filter
system. See “activating and
setting system run time” below.
t 5IFGVODUJPOPGUIF5$&JTEPOF
UISPVHIBUJNJOHTFRVFODFPG
QFSJPETQFSIPVST:PVTFMFDUUIF
IPVSTGPSZPVSSFRVJSFEmMUFSQVNQ
SVOUJNFBOEUIFIFBUFSUBLFTDBSF
PGUIFSFTU*UEPFTUIJTCZEJWJEJOH
UIFTZTUFNSVOUJNFFRVBMMZPWFS
UIFQFSJPETUVSOJOHUIFQVNQ
4
0QFSBUJOH*OTUSVDUJPOT
SELECTING FUNCTIONALITY OF UNIT
TCE / TCO MODELS
(Serial # would have TCE if your model
applies).
5IJTVOJUJTDBQBCMFPGPQFSBUJOg
BTB5JNF$MPDL0WFSSJEF5$0PSBTUIF
5JNF$MPDL&MJNJOBUPS5$&*GZPV
BMSFBEZIBWFBUJNFDMPDLPOZPVS
TXJNNJOHQPPMBOEXPVMEMJLFUP
NBJOUBJOJUTOPSNBMPQFSBUJPOXJUI
UIFBEEFECFOFmUPGBIFBUQVNQ
UJNFDMPDLPWFSSJEFoQMFBTFSFWJFXUIF
TFDUJPOGPSUIF5JNF$MPDL0WFSSJEF*G
ZPVEPOPUPXOBUJNFDMPDLGPSZPVS
QPPMTZTUFNQMFBTFSFWJFXUIFTFDUJPO
GPSUIF5JNF$MPDL&MJNJOBUPS
TIME CLOCK ELIMINATOR (TCE)
OPERATION
1MFBTFSFBEUIFGVODUJPOTPGUIJT
GFBUVSFDBSFGVMMZ
Installation
Procedures (continued)
*OTUBMMBUJPO3FRVJSFNFOUT
*OTUBMMFSTNVTUVTFDFSUJGJFE&MFDUSJDJBOT
BOENVTUGPMMPX/&$SFRVJSFNFOUT
MPDBMMBXTBOEDPEFT&YBNQMFJO/&$
#POEJOH5IFNFUBMMJDQBSUTPG
BQPPMPVUEPPSTQBPSIPUUVC
TQFDJGJFEJO#TIBMMCF
FMFDUSJDBMMZCPOEFEUPBDPNNPO
CPOEJOHHSJECZBTPMJEDPOEVDUPSOPU
TNBMMFSUIBO"8(.FUBM
8JSJOH.FUIPETBOE&RVJQNFOU.FUBM
QJQJOHGJYFENFUBMQBSUTPCTFSWBUJPO
TUBOETUPXFSTQMBUGPSNTPSEJWJOH
TUSVDUVSFTBTXFMMBTNFUBMMJDTVSGBDFT
PGFMFDUSJDBMFRVJQNFOUMPDBUFEXJUIJO
GU1MFBTF/PUF"MXBZTVTFB
DFSUJGJFEFMFDUSJDJBOBOEGPMMPXBMMMPDBM
MBXTBOEDPEFTBMPOHXJUI/&$4PNF
MPDBMDPEFTBSFNPSFTUSJDUFYBNQMF*O
'MPSJEBBMMNFUBMJUFNTXJUIJOGU
OPUGU
'PS.VMUJ6OJU*OTUBMM3FGFSUP
%JBHSBNBU&OEPG%PDVNFOU POGPSUIPGUIFTQFDJmFESVO
UJNFBOEPGGUIFSFNBJOEFSPGUIF
QFSJPEVOMFTTBEEJUJPOBMIFBUJOH
JTSFRVJSFE5IFIFBUFSXJMMBMXBZT
PQFSBUFUIFTZTUFNPOBEBJMZCBTJT
GPSUIFBNPVOUPGSVOUJNFZPVIBWF
TFMFDUFE5IFUJNJOHTFRVFODFCFHJOT
BUUIFJOJUJBMTUBSUVQ
t *GZPVSQPPMJTBUPSBCPWFUIFEFTJSFE
PQFSBUJOHUFNQFSBUVSFUIFIFBUFS
XJMMSVOUIFTZTUFNUIFEFTJSFEIPVST
FBDIEBZBOETQSFBEUIFUJNFPVU
FWFOMZCFUXFFOUIFQFSJPET5IJT
NBLFTGPSCFUUFSmMUFSPQFSBUJPO
BOEBMMPXTUIFIFBUFSUPVQEBUFUIF
XBUFSUFNQFSBUVSFUJNFTQFSEBZ
t *GZPVSQPPMOFFETIFBUUIFIFBUFS
XJMMDPOUJOVFUPSVOUIFTZTUFNVOUJM
UIFEFTJSFEUFNQFSBUVSFJTNFU*G
UIFBNPVOUPGSVOUJNFFYDFFETB
QFSJPETSVOUJNFUIFFYDFTTUJNF
XJMMCFTVCUSBDUFEGSPNUIFOFYU
SVOQFSJPET1MFBTFOPUFUIBU
PODPMEBOEPSXJOEZEBZTUIF
VOJUDPVMESVOGPSMPOHUJNFTUP
HFOFSBUFBOENBJOUBJOUIFEFTJSFE
QPPMUFNQFSBUVSF1MFBTFTFFUIF
iBQQMJDBUJPOwTFDUJPOBCPVUiQPPM
CMBOLFUTwUPIFMQNBJOUBJOZPVS
QPPMTUFNQFSBUVSF
t 5IFUJNJOHGVODUJPOCVJMUJOUP
UIF5$&XJMMBMXBZTSVOUIFIFBU
QVNQGPSNJOVUFTFWFSZ
IPVSTUPEFUFSNJOFJGNPSFIFBU
JTOFFEFEUPNBJOUBJOUIFQPPMT
EFTJSFEUFNQFSBUVSFFWFOJGBMM
PGUIFBWBJMBCMFSVOUJNFXBTVTFE
JOQSFWJPVTDZDMFT5IJTQSPWJEFTB
DPVQMFPGBEEFECFOFmUT1PPMTXJMM
MPTFNPTUPGUIFJSIFBUBUOJHIUJGMFGU
VODPWFSFEIPXFWFSTJODFUIFVOJUJT
DIFDLJOHGPSBOEBEEJOHIFBUXIFO
OFFEFEJUQSFWFOUTMPOHSFDPWFSZ
UJNFTXIFODPNQBSFEUPOPO5$&
VOJUT5IFPUIFSCFOFmUJTUIBUTPNF
TUBUFTBOEFMFDUSJDVUJMJUZDPNQBOJFT
PGGFSBEJTDPVOUGPSPGGQFBLVTBHF
PGFMFDUSJDJUZ1MFBTFDPOUBDUZPVS
FMFDUSJDJUZQSPWJEFSJGZPVIBWF
RVFTUJPOT
t &YBNQMFPG5$&PQFSBUJPOoZPV
SFRVJSFUIFTZTUFNUPSVOGPS
IPVSTUPNFFUZPVSQPPMmMUFSJOH
OFFET5IJTNFBOTGPSFBDIPGUIF
QFSJPETUIFIFBUFSXJMMSVOUIF
TZTUFNGPSIPVSTBOEUIFOUVSOPGG
GPSIPVST*GUIFTZTUFNOFFEFE
UPSVOGPSIPVSTJOPOFPGUIF
QFSJPETUPSFBDIUIFEFTJSFEQPPM
UFNQFSBUVSFUIFOFYUQFSJPEXPVME
CFIPVSPOBOEIPVSTPGGVOMFTT
BEEJUJPOBMIFBUJOHJTOFFEFE5IF
DZDMFDPOUJOVFTGPSQFSJPETBOE
SFOFXTBUUIFFOEPGFBDIIPVST
1MFBTFDBMM772782797JGZPVOFFE
GVSUIFSDMBSJGJDBUJPOPGUIJTGFBUVSFT
PQFSBUJPO
Activating and Setting System Run
Time - TCE Operation
t 5PTFUUIFSVOUJNFPGUIFTZTUFN
QVTIUIFi4&5wCVUUPOSFQFBUFEMZ
VOUJMi'*-wEJTQMBZT5IFOVTJOHUIF
iVQwBOEiEPXOwBSSPXTZPVDBO
TFMFDUIPXNBOZUPUBMIPVSTBEBZ
ZPVXBOUUIFTZTUFNUPSVOGPSZPVS
QVNQBOEmMUSBUJPOOFFET5IF
SBOHFPGIPVSTJTiPGGwUPy
VQUPIPVSTUPiPOw"TEFTDSJCFE
CFGPSFUIFSVOUJNFXJMMUIFOCF
DBMDVMBUFEBOETQSFBEPVUPWFSUIF
UJNFQFSJPETGPSIPVST4FMFDUJOH
UIFiPOwQPTJUJPOXJMMSVOUIFQVNQ
BOEmMUFSTZTUFNDPOUJOVPVTMZ5IF
VOJUMFBWFTUIFGBDUPSZXJUIUIFi'*-w
NPEFTFUUPi0''w