Jenn-Air 720-0337 User manual

STAINLESS STEEL LP GAS GRILL
MODEL NO.: 720-0337 ITEM NO: 242610
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated.
®
800 700
600
500
400
300
200
100
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE

SECTIONONE
SafetyInstructions
Placement of the Grill
SECTIONTWO
Side Shelf & Side Burner Assembly
Spice Tray Assembly
Side Burner Hose Quick-Connect Assembly
Side Shelf Handle & Battery Installation
Braking System Operations & Liquid Propane
Cylinder Retention System
TABLE OF CONTENTS
SECTION FIVE
Slide-Out Tray Locking & Propane Regulator
Hook-Up
SECTION THREE
GasHookUp
Leak Testing
Installer Final Check
SECTION FOUR
Operating Instructions
Lighting Instructions
Lighting Illustrations
To Match Light the Grill
Grill Lights
Using the Side Burner
Side Burner Igniter Wire Assembly
Care and Maintenance of Side Burner
Care and Maintenance of Grill
Troubleshooting
Exploded View
Parts List
SECTION SIX
Grilling Hints
Grill Cooking Chart
Grill Recipe Suggestions
SECTION SEVEN
Limited Warranty
1-5
5
6
7
8
9
10
11
12-13
13
14
15
16
17
18
19-20
21
21
22
23
24
25
26-27
28
28-30
31-32
33
WARNING
To reduce the risk of fire, burn hazard or other
injury, read this Care and Use Manual carefully
and completely before using your grill.

SAFETY INSTRUCTIONS
WARNING
1. Do not store spare liquid propane cylinders under or near this appliance.
2. Never fill the cylinder beyond 80 percent capacity.
3. If the information above is not followed exactly, a fire resulting in death or serious injury could
occur.
WARNING
Never attempt to use damaged or obstructed equipment. See your local liquid propane dealer for
repair.
WARNING
Check all gas supply fittings for leaks before each use. Do not use the grill until all connections
have been checked and do not leak. Do not smoke while leak testing. Never leak test with an open
flame.
WARNING
Do not try lighting this appliance without first reading
the “LIGHTING INSTRUCTIONS” section of this
manual.
WARNING
The rotisserie motor is equipped with a plug and
should be plugged directly into a properly grounded
receptacle in accordance with local codes or, in the
absence of local codes, with the National Electrical
Code, ANSI/NFPA 70, or the Canadian Electrical
Code, CSA C22.1. DO NOT cut or remove the
grounding prong from this plug. Keep any electrical
supply cord and the fuel supply hose away from any
heated surface. Keep the rotisserie motor electric
cord away from the heated surfaces of the grill. When
not in use remove and store the motor in a dry
location.
RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS
WARNING – Hazards or unsafe
practices which COULD result in severe
personal injury or death.
CAUTION – Hazards or unsafe practices
which COULD result in minor personal
injury.
WARNING
CAUTION
WARNING
Spiders and insects can nest inside the burners of
the grill and disrupt gas flow. This very dangerous
condition could cause a fire behind the valve panel,
thereby damaging the grill and making it unsafe for
operation.
Inspect the grill at least twice a year.
WARNING
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
WARNING
1. Do not store or use gasoline or other
flammable vapors and liquids in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any other
appliance.
WARNING
This grill is not intended to be installed in or on
recreational vehicles and/or boats.
1

SAFETY INSTRUCTIONS
WARNING
1. Attach the coupling half (socket) to the
gas supply line in accordance with
ANSI Z223.1/NFPA54 FUEL gas code.
2. Prior to inserting the plug, test the
connection for leaks following the leak
test instructions on page 13. After the
leak test is completed, rinse the
connection with clean water to remove
any corrosive residue.
3. Do not use open flame to test for leaks.
WARNING
When lighting, keep your face and hands as far
away from the grill as possible.
WARNING
Failure to properly place the burner over the
orifice could cause a fire to occur behind and
beneath the valve panel, thereby damaging the
grill and making it unsafe to operate.
WARNING
Do not leave the grill unattended while
cooking.
WARNING
Do not use the grill if the odor of gas is
present. Contact customer service at 1-800-
554-5799.
WARNING
Storage of an outdoor cooking gas appliance
indoor is permissible only if the cylinder is
disconnected and removed from the outdoor
cooking gas appliance.
WARNING
Cylinder must be stored outdoors out of the reach
of children and must not be stored in a building,
garage or any other enclosed area.
WARNING
Do not install this unit into combustible
enclosures. There should be a minimum
clearance of 24 inches from all sides to
combustible materials. Outdoor cooking
appliance shall not be used under
overhead combustible construction.
WARNING
A tank of approximately 12 inches in diameter by 18-
1/2 inches high is the maximum size LP gas tank to
use. You must use an OPD gas tank, which offers
an Overfill Prevention Device.
This safety feature prevents the tank from being
overfilled, which can cause malfunction of the LP gas
tank, regulator and/or grill.
CAUTION
When using the rotisserie burner, remove the
warming rack. High heat from the burner may
cause the warming rack to bend.
CAUTION
When using a match to light the grill make sure
to use the attached lighting rod.
CAUTION
Before cleaning, make sure the gas supply and
control knobs are in the “OFF” position and the
burners have cooled.
WARNING
Keep any electrical supply cord away from any
heated surface.
WARNING
Make sure the light switch is on “OFF” position
and power plug is disconnected from power
outlet prior to cleaning the glass cover.
.
WARNING
WARNING
To ensure continued protection against electric shock:
1. Connect to properly grounded outlets only.
2. Do not expose to rain.
3. Keep extension cord connections dry and off
the ground.
The light glass cover should not be in contact with
water or any other liquid when it’s warm. Sudden
change of temperature may cause cracks on glass
2

SAFETY INSTRUCTIONS
WARNING
Do not attempt to light the grill if gas odor is
present. Contact customer service at 1-800-554-
5799.
When lighting, keep your face and body as far
away from the burner as possible.
BEFORE LIGHTING
Inspect the gas supply hoses prior to turning on the
gas. If there is evidence of cuts, wear, or abrasion, it
must be replaced prior to use.
Only the pressure regulator and hose assembly
supplied with the unit should be used. Never
substitute regulators for those supplied with the grill.
Contact customer service for proper replacement.
Screw the regulator (type QCC1) onto the cylinder.
Leak check the hose and regulator connections with
a soap and water solution before operating the grill
(See “Leak Testing” instructions on page 13).
Do not turn “ON” the gas at the LP gas cylinder
unless the quick connect gas hose is properly
connected to the side burner gas pipe system and all
burner valves are in the “OFF” position.
USING THE SIDE BURNER
Inspect the gas supply hose prior to turning on
the gas. If there is evidence of cuts, wear or
abrasion, it must be replaced prior to use. Do not
use the side burner if gas odor is present.
Keep a spray bottle of soapy water near the grill
and check the connections before each use.
ROTISSERIE DRIVE MOTOR
To ensure continued protection against electric
shock:
Connect to properly grounded outlets only.
Keep extension cord connections dry and off the
ground.
Do not expose to rain.
Do not use indoors.
WARNING
If you smell gas:
1. Shut off gas to the grill.
2. Extinguish any open flames.
3. Open the top cover or lid.
4. If the odor continues, keep away from the
appliance and immediately call your gas
supplier or local fire department.
LP GAS CYLINDER WARNING
1. Do not store or use gasoline or other
flammable vapors and liquids in the vicinity of
this or any other appliance.
2. A liquid propane cylinder not connected for use
should not be stored in the vicinity of this or
any other appliance.
3. Do not store a spare liquid propane gas
cylinders under or near this appliance.
4. Never fill the cylinder beyond 80 percent
capacity.
5. Liquid propane cylinders must be fitted with an
Overfill Protection Device (OPD).
6. If the information above is not followed exactly,
a fire causing death or serious injury may
occur.
3