Kalee Lotus Exige S B00KD3G2DS Guide

Assembly Manual & User’s Guide
Battery Operated Ride-On Vehicle
Item No.: B00KD3G2DS
(KL-7011-12V)
Lotus Exige S
Adult Assembly Required
This manual contains safety instructions and important information which will
help you assemble the unit. Please keep this manual for future purposes.
WARNING:
Please read this manual carefully before assembly and use.
Produced under licence from Group Lotus plc. LOTUS, the Lotus Roundel, car names and all
associated logos and distinctive designs are trademarks of Group Lotus plc
Produit sous licence de Group Lotus plc. L’emblême LOTUS, les noms des véhicules et tous
logos et formes distinctives associés sont des marques déposées de Group Lotus plc

Age: 3 years and up
Maximum Capacity: 30kgs / 66lbs
Max Speed: 3.5-4.5km/h / 2.2-2.8 mph
Battery Type: Sealed lead-acid rechargeable, 12 Volt 7Ah
Charging time: Always charge the battery for 8-10 hours before first use
and when recharging is needed. Never charge for more
than 20 hours.
Power input for Charger: A/C 100-240 Volts 60 Hz
Power output to Battery: DC 14 Volts, 1000mA
Vehicle / Battery Specifications:
WARNING:
Use the toy only on flat surfaces, such as sidewalks, driveways or
playgrounds. Do not ride the vehicle in dangerous places such as busy
streets, roads or highways.
Never use near swimming pools or other bodies of water.
Never ride the vehicle in muddy or sandy areas. Never ride in hilly
areas or on steep slopes. This vehicle was made to operate on dry
leveled ground.
Never ride in the dark or in dimly lit areas.
Clean the vehicle only with a damp cloth and never submerge vehicle
in water or spray with water directly from a hose.
Only one child should ride this vehicle at a time.
Do not exceed the recommended weight limit of 66lbs.
To avoid suffocation of children please destroy all plastic bags after
assembly of the vehicle.
If vehicle is equipped with a forward / reverse switch, never press
this switch while vehicle is in motion. Always stop the vehicle before
switching directions.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10. The charger used for the vehicle are to be regularly examined for
damage to the cord, plug, enclosure and other parts, and in the event
of such damage, they must not be used until that damage had been
repaired.
11. The toy should be used with caution since skill is required to avoid
falls or collisions causing injury to the user or third parties.
2

3
CHARGING CAUTIONS:
- The charger is not a toy. Do not allow children to play with the
charger or to recharge the battery.
- Turn the power switch to “OFF” when charging.
- Before the first use, you should charge the battery for 8-10 hours.
Do not charge the battery for more than 20 hours to avoid
overheating the charger.
- It is normal for the charger to feel warm during charging. If the
charger feels very hot, stop charging, unplug the charger and check
the battery and charger.
- Use the charger in dry locations only.
- Regularly check the charger, battery and their connectors for
excessive wear or damage each time you charge the battery. If
damage or excessive wear is detected, do not use the charger or the
battery until you have replaced the worn or damaged part.
- Only use the charger specified by the manufacturer.
WARNING - Risk of fire. Do not by pass fuse. Replace only
with the correct amperage fuse.
BATTERY SAFETY WARNING:
- Only use the battery and charger supplied by the manufacturer.
- Do not connect the battery terminals directly together. This will cause
the battery to short-circuit.
- Never short-circuit the battery terminals or modify the electrical system.
Alterations may cause a fire resulting in serious injuries.
- Do not mix old and new batteries or batteries of different types.
- Remove batteries during long periods of non-use. Always remove
batteries from the product. Dispose of batteries safely. Do not dispose
of batteries in fires. The batteries may explode or leak.
- If removable, rechargeable batteries are used, they are only to be
charged under adult supervision.
- Recharge the battery fully before storage, then charge it every 3
months to extend the life of the battery.
- Only use the battery specified by the manufacturer.
The ride on vehicle is equipped with a built-in thermal circuit breaker.
The thermal circuit breaker is a self-resetting safety device which
automatically “trips” and shuts down the operation of the vehicle if it is
overloaded or the driving conditions are too severe. Once the circuit
breaker has tripped it will automatically reset itself after approximately
25 seconds and allow the rider to resume normal operation.
Caution:

Part List:
Part No. Description Qty
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
Body with Wheels
Steering Wheel
TM5x25x8 Screw
M5 Nut
TA4X12X7 Screw
Spoiler
Spoiler Bracket
Charger
Audio Line
Screwdriver
1 set
1pc
1 pc
1 pc
2pc
1pc
1pair
1pc
1pc
1pc
4
(Prefixed on steering column)
(Prefixed on steering column)
(Prefixed on the rear bumper)
(not included)

How to assemble the vehicle:
Step 1:
screwdriver(not included).
Spoiler Brackets properly.
Step 2:
3) and M5
Nut ( 4).
steering wheel column.
column and the hole on the base of
the steering wheel.
3) and M5
Nut ( 4), then tighten with screwdriver.
5
Unscrew the prefixed screw on the
back of the seat with a screwdriver.
Remove the seat, connect the loose
red wire plug to the terminal of the
breaker box.
Install the seat again.
Step 3:
WARNING:
To reduce the risk of injury, adult supervision
is required.
Never use on roadways, near motor vehicles,
on or near steep inclines or steps, swimming
pools or other bodies of water. Always wear
shoes and never allow more than 1 rider.
WARNING:
Contains small parts, sharp points and
sharp edges. Adult assembly required.
WARNING:
Choking Hazard! Contains small
parts. Not for children under 3 years old! WARNING:
This toy is unsuitable for children under
3 years due to its maximum speed.
WARNING:
Not to be used in traffic.

Charging the Battery:
The socket for charging the battery is
located near the seat.
Connect the charger plug into the DC jack,
then plug the charger into a household outlet.
charge more than 20 hours.
When the battery is fully charged, unplug the
charger and store it in a cool and dry place.
Operation of the Vehicle:
F/R Switch
MP3 Insert
Pedal Switch
Power Switch
P
Power Switch: Controls the vehicle
· Press the power switch when using the
vehicle.
· Release the power switch when not using
the vehicle.
1. Make sure the battery is fully charged and the
red plug is connected to the battery plug
under the seat.
2. Locate the direction switch to the right of the
steering wheel. Push the direction switch to
“F” and press the accelerator pedal, vehicle
will move forward. Headlights come on while
vehicle is moving forward.
3. To stop the vehicle remove foot from
accelerator pedal. When stopped pull the
direction switch to “B”, then press the
accelerator pedal, vehicle will move backward.
The taillight will come on while moving backward.
5. MP3 Plug-in: Plug in MP3 to play music.
4. Steering Wheel: Press the 4 buttons in
the middle for different driving sounds.
6

BOM List:
1. Bonnet/Hood
2. Radiator of front bumper
(middle)
3. Windscreen
4. Dashboard
5. Side bumper(left)
6. Body
7. Seat
8. Side bumper(right)
9. Side accessory
10. Steering wheel
11. Rearview mirror(left & right)
12. Front bumper support
13. Radiator
14. Head light receptacle
15. Head light
16. Front wheel
17. Wheel cover
18. Rear wheel
19. Side bumper adornment
20. Rear bumper support
21. Rear bumper accessory
22. Trunk lid
23. Rear bumper
24. Spoiler
25. Backrest
26. Spoiler Bracket (left & right)
27. Rear light receptacle
28. Rear light
29. Middle line lid
30. Charge lid
31. Exhaust pipe lid
32. Exhaust pipe
33. Radiator of rear bumper
7

Maintaining your vehicle:
It is a parents responsibility to check main parts of the vehicle before
use. Regularly examine the vehicle for potential hazards, such as the
battery, charge cable, cord and plug. Ensure screws are tightened. If
there are any damages, the vehicle must not be used until these
damages have been properly repaired or replaced.
Occasionally use a lightweight oil to lubricate moving parts such as
the wheels and steering linkages.
Keep the vehicle in an upturned position, do not overturn or incline it.
It is recommended to store the vehicle indoors when not in use. If
stored outdoors, the vehicle needs to be covered by a tarp for
protection against weather elements.
This toy should be kept away from fire. Keep the vehicle away from
sources of heat, such as stoves and heaters. Plastic parts may melt.
While charging ensure all flammable liquids are well away from the
vehicle.
ADULTS ONLY to recharge the battery after each use. Recharge the
battery at least once a month when the vehicle is not being used.
Use a soft, dry cloth to clean vehicle.
DO NOT use any chemical liquids to clean the plastic surface of the
vehicle.
DO NOT wash the vehicle with soap and water.
DO NOT drive the vehicle in rainy or snowy weather. Water will
damage the motor, electric system and battery.
When not in use all electrical sources should be turned off. Press the
power switch to the "OFF" position to turn the power off. Also
disconnect the battery connection under the seat.
Please do not change the structure of this product and circuit system.
DO NOT use the vehicle for other purposes except riding.
8

Safety Precautions:
1. While riding, adult supervision is required at all times.
2. Always wear a helmet when riding.
3. Do not ride near roads or on the footpath.
4. It is not recommended to drive the vehicle on wet surfaces or on
slopes greater than 15 degrees.
5. It is recommended to ride this vehicle on smooth surfaces only.
6. Do not use this vehicle outdoors when it is raining.
7. Make sure you come to a complete stop before changing directions
from forward to reverse.
8. Don't allow children to operate the charger or play with the battery.
9. Clean the vehicle with a dry cloth only.
10. Please follow the correct weight and age limits allowed to driver
this vehicle.
11. It is prohibited to change the circuit or add other electric parts.
12. Adults must teach their children about safe driving procedures.
13. Please turn the power off when not in use.
14. Check the seat to ensure it has been fitted and secured with a bolt
before driving.
15. Inspect all wires and connections of the vehicle perodically.
16. Charging the battery should only be done by adults.
17. Charging plug is located the bottom of the vehicle.
18. In order to avoid accidents, please ensure the vehicle is safe before
driving.
19. Do not let any child touch the wheels or be near them when the
vehicle is moving.
9

10
Trouble Shooting Tips:
Problem: The vehicle does not turn on
If the car is not functioning at all please follow these troubleshooting steps listed below.
After each step, please put the car in forward gear and step on the pedal to see if the
car will move.
1. Charger: Unplug the charger completely from the car. The car will not work if the
charger is plugged in to the car.
2. Battery Connection: There is a battery cover that goes over the battery to hide the
positive and negative wires. Undo the bar that holds the battery down to release the
cover. Once the cover is loose, check the positive and negative wire to see if they are
properly connected. You may also pull lightly on each wire to see if they are
connected.
3. F/R Switch: Us a Phillip screw driver and undo the screws that hold down Forward
and Reverse switch. Pull the switch out and you should see wires running into the back
of the switch. Use your hand and push each individual wires into the socket.
4. Foot Pedal Switch: Turn the car on its side, and you will see a foot pedal cover
where the foot pedal switch is. There should be 3 screws holding down that cover.
Once the cover is off you will see wires leading into the F/R switch. Use your hands to
push each individual wires into the switch and see if it runs.
Problem: The motor turns but the car is not moving
If you can hear the motor turning but the car is not moving or you hear a grinding sound
coming from the gearbox, please contact Kalee Customer Service Support.
Problem: The vehicle runs slowly:
If the car is not functioning at its normal speed, please recharge the battery for another 8 to 10
hours. If it does not resolve the issue, please contact Kalee Customer Service Support.
Customer Service:
Made in China
You can help protect the environment! Please
non-working electrical equipments to an appriate
Manufactured by:
Kalee Children’s Products Co., Ltd. Quanzhou
Wuli Industrial Zone, Jinjiang, Fujian, China
www.kalee.com
If you have any missing or damaged parts or need assembly assistance,
please contact our service center directly. Do not return this product to the retailer,
they do not stock replacement parts.
Support Website: http://support.bigtoysusa.com
Support Phone: 715-955-4237
Other Kalee Golf Car manuals