Kitchen Monkey KMSG-811 User manual

KMSG-811,KMSG-811/F, KMSG-811E
KMSG-811E/F, KMSG-813
Panini/Sandwich Grills


This manual contains important information regarding your
KM Kitchen Monkey unit. Please read this manual thoroughly prior to
equipment set-up, operation and maintenance. Failure to comply
with regular maintenance guidelines outlined in this manual may
void the warranty. PLEASE READ!

handle

WARNINGS
•Do not touch any hot surfaces
•Do not immerse unit, cord or plug in liquid at any time
•Unplug cord from outlet when not in use and before cleaning
•Plug only into a 3-hole grounded electrical outlet
•Do not operate unattended
•Do not use this unit for anything other than intended use
•Do not use outdoors
•Keep children and animals away from unit
•Always cook on a firm, dry and level surface at least 12” from walls or any other obstruction
•Do not use unit with a damaged cord or plug, in the event the appliance malfunctions, or has been damaged in any
manner
•Any incorrect installation, alterations, adjustments and/or improper maintenance can lead to property loss and injury.
All repairs should be done by authorized professionals only
•Ensure that the power supply you are using is adequate for continual grill usage and the voltage is correct.
•Do not jam materials or place heavy objects on grill, as this may cause damage.
In order to protect the plates of your new grill during transportation, a layer of food-
safe wax was coated on the surface prior to shipment. This wax is harmless, but must
be removed before you begin to use. To remove, preheat the grill until the wax
liquefies. Next, carefully wipe away the melted wax with a clean, soft cloth. Once all
of the wax is removed you can begin to use your grill.
TO USE
1. Plug the power cord into the appropriately rated outlet.
2. The power light will illuminate.
3. Once desired temperature is set, the Heating Indicator will come on. Warm-up time is approximately 7-8 minutes. The
Heating indicator will cycle at set temperature.
4. For normal use, it is recommended that the temperature range be 392℉-482℉.
5. When the surface reaches the designated temperature, lift top grill using black handle and lightly grease grill plates
with vegetable oil. Place food on grill and lightly press handle down. Excess oil will collect in the oil collection tray.
Remove food when cooked. The heaters will automatically cycle as needed.
CLEANING – NOTE: To maintain cleanliness and increase service life, the grills should be cleaned daily. Do not immerse
the grill in water or any other liquid.
1. Before cleaning or attempting to move grill, unplug and let the unit cool completely.
2. Wipe the entire unit with a clean soft cloth until it is completely dry.
3. To avoid damage, do not use abrasive cleaners or scouring pads.
4. If soap or chemical cleaners are used, be sure they are completely rinsed away with clear water immediately
after cleaning. Chemical residue could damage or corrode the surfaces of the unit.
5. Store in a dry clean area when not in use.
TROUBLESHOOTING
Problem Possible Causes Action
1. Grill plates do not heat
even though power
indicators are lit.
1. Defective
controller.
2. Defective heater(s).
1. Replace controller 2.
Replace heater(s).
2. Temperature cannot be
controlled.
1. Defective
temperature
controller.
1. Replace temperature
controller
3. Heating indicator
appears normal, but power
indicators are not lit.
1. Defective power
indicator(s)
1. Replace power
indicator(s)

Grill KMSG-811EB
Circuit diagram

Grill KMSG-811B
Circuit diagram

Grill KMSG-813B
Circuit diagram

SG-811E
SG-811
SG-811E
VER811

SG-813
VER811VER811

Sandwich Grills - KMSG-811, KMSG-811/F, KMSG-811E, KMSG-811E/F, KMSG-813
Reference
Number
KMSG-811/F and
KMSG-811
Part Number
KMSG-811E/F and
KMSG-811E Part Number
KMSG-813
Part Number Description
1 DF6SG-1 DF6SG-1 DF6SG-1 Heat Indicator - Orange
2TH-1201 TH-1201 TH-1201 Thermostat Regulator
3 DF6SG-3 DF6SG-3 DF6SG-3 Power Indicator - Green
4Body
5 SG-5 SG-5 SG-5 Torsional Spring w/Screws
6 SG-6 SG1E-6 SG-6 Back Axis
7 SG-7 SG-7 SG-7 Adjustbale Tension Base w/Screw
8SG1-8 SG1E-8 SG3-8 Axis Cover
9 SG-9 SG-9 SG-9 Axis Holding Pin
10 SG-10 SG-10 SG-10 Power Supply Cord
11 Bottom Plate - Cast Iron
12 Top Plate Cover w/ Screws
13 Upper Mounting Plate
14 Top Plate - Cast Iron
15 SG-15 SG1E-15 SG-15 Upper Heating Element
16 SG-16 SG-16 SG-16 Wire Tube
17 SG-17 SG1E-17 SG-17 Upper Axis w/Clips
19 SG-19 SG1E-19 SG-19 Handle Frame with Grip
20 SG1-20 SG1E-20 SG3-20 Oil Collector
21 Lower Mounting Plate
22 SG-22 SG-22 SG-22 Rubber Foot
23 Element Plate
24 SG-24 SG1E-24 SG-24 Bottom Heating Element
25 Bottom Cover w/Screws
26 SG-26 SG-26 SG-26 Thermostat Knob
27 SG-27 SG-27 SG-27 Screw for Back Axis/Handle

Kitchen Monkey Equipment One Year Limited Warranty
Kitchen Monkey Equipment warrants its equipment against defects in materials and workmanship, subject to the
following conditions:
Kitchen Monkey Equipment is warranted for one year, effective from the date of purchase by the original owner. A copy
of the original receipt or other proof of purchase is required to obtain warranty coverage. This warranty applies to the
original owner only, and is not assignable.
Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at
Kitchen Monkey Equipment's discretion, such product will be repaired, replaced with a refurbished unit, or replaced
with a new unit by Kitchen Monkey Equipment, after defective unit has been inspected and defect has been confirmed.
Kitchen Monkey Equipment does not assume any liability for extended delays in replacing any item beyond its control.
This warranty does not apply to rubber and non-metallic synthetic parts that may need to be replaced due to normal usage,
wear or lack of preventative maintenance.
This warranty covers products shipped into the 48 contiguous United States, Hawaii, and metropolitan areas of Alaska
and Canada. Warranty coverage on products used outside the 48 contiguous United States, Hawaii and metropolitan
areas of Alaska and Canada may vary.
The following conditions are not covered by warranty:
• Equipment failure relating to improper installation, improper utility connection or supply and problems due to improper
ventilation.
• Equipment that has not properly been maintained, damage from improper cleaning, and water damage to controls.
• Equipment that has not been used in an appropriate manner, or has been subject to misuse, neglect, abuse, accident,
alteration, negligence, damage during transit, delivery or installation, fire, flood, riot, or act of God.
• Equipment that has the model number or serial number removed or altered.
• Equipment on which the security seal has been broken.
If the equipment has been changed, altered, modified, or repaired without express written permission from ACE, then the
manufacturer shall not be liable for any damages to any person or to any property, which may result from the use of this
equipment thereafter.
This equipment is intended for commercial use only and this warranty is void if equipment is used in other than a
commercial application.
For warranty and non-warranty related issues, technical support, purchase replacement parts and warranty registration
visit www.kitchen-monkey.com. Please have your model number, serial number and proof of purchase ready. It is not
necessary to contact the place where you originally purchased your product from.
“THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL WARRANTIES EXPRESSED OR IMPLIED
INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILTY OR FITNESS FOR PARTICULAR
PURPOSES AND CONSTITUES THE ENTIRE LIABILITY OF ACE. IN NO EVENT DOES THE LIMITED
WARRANTY EXTEND BEYOND THE TERMS STATED HEREIN.”