KNAUS SUN-TRAVELLER-TI 2004 User manual

Mrnulr KNAUS
Mosn HomE SIrN-TnevsunR-Tf
p
u
E
E
E
E
E
I!
!I
,*
{
f
www.knausowners.com

I: Cortrctws
Sncruox 0
II
rit KNAUS
0. Contents
1.
2.
_.1
2.2
__J
_.J. L
1.1
1.5
1.5.1
2.5.1
l.r.J
2.6
:. 1
2.8
J.
3.1
3.1.1
4.
-+. 1
l1
4.3
4.3.1
1.4
1.5
1.6
-l.i
1.7.1
1.1.2
la) !
+. /.t.1
1.i.2.2
1-tl
1.1.2.4
1.8
lo
Forerrord.....
Safetv Instructions . .
Safen'Devices
Safety hrstmctions fol Road Travel
General Safety hstructions . . .
Safeiy Instnrctions for Fitting Rear Carrier S,vstems
Safetv Ilstmctions fot'the Gas S1'stern
Fire Safetv
PreventiotiofFileHazards . . . . .
Fire Fighting
h Case of Fire .
Imporlant Notes for the Sanitary Area . . . .
Envirorunental Notes . .
Supplementarl Notes .
Description & Equipment
General ConstrLrction and Eq.ripmerrt of the \lobile Home
Seating Layout.
Before the Journev
Before the First Joumel'
Reeistedns the \'lobile Honre
Parvload
)t
2-1
2-6
2-6
1A
2-1
2-1
2-7
_-i
l
j3-r
1t
4-l
1-t
4-l
t1
E1
E1
x1
x1
Ej
8.1
Loading the N{obi}e Houe. .
Checking the N'lobile Home Belore Starting the Jottmey
Brakes .
TVre Pressure
.\djusting tlre Vehicle Seats . .
Base !'ehicle Seats . .
Ivlodel ,>Aguti MILAN( Vehicle Seat . '
Fonvard-Back Adjustrnent
Rotaq'Unit
Backrest Adjushlent
Annrest Adjustuient
Vehicle Lights .
Obtaining a Replacement Key . . .
t1
a--
4-1
4-5
.+-6
1-6
1-1
1-7
1-1
1-l
4-1
1-7
+-8
+-a
C ii{I
J
xj ,St.t-Tnq'rrtr:n-TI ,\ t.l :( )0 5 . G Ii- I (). : a()1 0-l
1-l
2-1
2-2
t-l
_-J
I
ff.arw* i.
www.knausowners.com

Conrynnrys
Szcrrox 0
5.1
5.2
5.3
6.
6.1
6.2
6.3
6.3.1
6.3.1
6.1
KNAUS
During the Journel'
Drivins \brrr Nlobile Honre
Refuelling the N,lobile Home
Changine a \\,-heel
After the Journel,
Palkins Brake
Setting Lrp the Mobile Honre.
Setting Up the lv{obile Houre with the Aid ol Support Leus (Accessoriesl
Extending the Supporl Legs. . .
Retracting the Support Legs . .
,{r,r,ning
Living
\"entilating the Mobile Home. .
Opening and Closing the Door fiom the Outside
Opening and Closins the Door fiom the Inside .
Openine,Closrngthe Roof Light . . .
Opening,Closins the Quafier \,'ent . . .
Opening Closing the Slidine \\:indorv
RE\'llsiar Electricai Roof \\iindou,
Opening Closing the Glass Dome .
Extending the Cover
Opening Closine the Nlosquito Blind .
Flat Screen Teler ision
Folding Dou'n and Adjusting tlie Television
Removing the Flat Screen Television
ClosingiQpsping Foldine Blind fol Hrltze Glass Roof .
Adjusting Aerial \'last
Extendable Rear Ladder
Sleeping.
6-l
6-l
6-1
6-1
6-l
6-2
5-l
5-t
-s-3
6-1
'7-l
7-1
7-2
7-2
1-3
1-3
7-1
1-4
7-5
1-6
7-,1
i-1
7-9
7- r0
1-n
--1.2
8-l
8-l
8-1
0f
()--
| 't
l
I -.1
_l
_I
_l
_l
_l
8.
8.1
8. 1.1
d._
9.
9.1
9.1
9.-l
Preparing for Sleeping .l
ti
_l
?o,
_1
Converting the Seating N{odule u,ith Hook-ln Table to a Bed
Illustration of the N{obile Home Floor Plan for Use Durine th )a_"- and at Nisht
Gas Supplr' 9-l
General Notes on the Gas Supplv . g- I
LPG. . . 9_2
Placing Gas Bottles in the Gas Locker 9_2
,tl
EI
I
t
0-2 \,u :a05 . GB-10:00,1 Sts-Tx.uzLt:n-TI
bf'
'!l
I
l
I
l
www.knausowners.com

tl
I]
IJ KNAI'S
General Infonnation on the Gas Consumption
Gas Taps
Gas Taps for Cooker.and Refi-iserator
Gas Tap for Hot Water Boiler .
Outside Gas Connector
ConnectinsAppliances to the Outside Gas Connector
C'haneing the Gas Bottle .
Duomatic L Plus (gas regulatol set u'ith automatic changeover and remote display for the tu,o-bottle syste,.,,)
Irrstrucrionsforthe Dtrornaric .. ..
Lnportant Notes on the Use of the Duomatic
Changing the Gas Bottle on rhe Duomatic . .
Duontatic Remote Display.
Using the Duomatic in Sum_mer..
Using the Duomatic in \4,inter . .
\\ater Suppll
9-l
9-3
9-3
9-1
9-+
9-,5
9-6
9-6
9-6
o-
9-8
9-E
9-8
Conryunrys
Sncrrox 0
9.4
9.5
9.5. r
9.5.2
9.6
9"6.1
9.1
9.8
9.8. r
9.8.2
9.8.3
9.8.1
9.8.4.1
9.8.:1.2
10.
l0.l
10.2
r 0.3
10.4
10.5
ll.
1t.l
l 1.2
I 1.3
I 1..1
I r.5
1 1.6
I 1.7
I 1.7.1
I t.7.1
I 1.7.3
I 1.8
l 1.9
t2.
1t. I
i:.1.r
l:. t.1
Fresh \Vater Suppll.
\\hsteri,ater Disposal
t0-1
l0- r
10- i
10-l
1 0-2
I 0,2
I l-t
11-r
I l-l
j
J
l
_l
J
Empn,ing the \\ arer Svsrenl
Empn,ing the Fresh \\-ater Tanl
Empq'ing the \\ asteu.ater Tank
Porver Suppll
Porver Supplr. :30 \.{C llvlains)
Nlakine Elecrical conxecrion Betueen Mobile Honie and poiler point
Onboard Control
l2 \/DC Pouer Supply' in the Living Area
Protection of the Electrical Circuits in the Mobile Home
Electrical Supply
12 \DC Suppl."- flom Backup Battery and Charger
Backup Batterv
Chareer
Erample Sho*'ine Ho* to Calcurate Electncitl.cons.mption (usine 95 .{-h banery)
Electrical Circuit Diagram Kev Sun-Traveller_Tl 650 ME . . .
Electrical Circuit Diagram Kev Sun-Traveller_Tl 6_s0 NlF
Heating & Hot \}ater.
Trumatic C HeateriBoiler
Heatins u,itli Hot W-ater Requirenrenr . .
Heating * ithout Hot \\arer Requirentent
L
I
ri
1l--i
I i-b
I r-6
I l-6
1r-8
I 1-9
11-11
1r-ll
12-l
ll-l
ll- I
,l1
Stt Tx.u tLttn-TI 0-j
H
..I
J
J
J
J
J
J
.\|J:005. GB_10:001
www.knausowners.com

Con"ranrys
Szcruox 0b
KNAUS
ll.1 .-1
12. I .l
ll.l.5
12. 1 .6
t).1.1
12.2
12.1. I
12.2.1
11.1.3
I -.t.7
12.2.5
12.3
11.3. i
12.i.1.1
12.3. 1.1
I1.3. 1 .3
11.3.2
13.
13.1
14.
14.1
15.
15. l
15.1.1
15. 1.2
16.
16. I
t7.
t] .1
t].1
18.
13.1
18.1
Adjusting the HeateriBoiler. ' . .
Srvitching Off tlie Heaterr'Boiler .
Hot \\,ater Suppl,v Using the Tnurratic C . . . .
Hot \\ater Heating
Empt-vinu the Hot \\ater BoileL
Hot \later Central Heatin,s . . . .
Functions on the Control Panel . .
Enjolting the \\amth
Circulating hrmP
Expansion Vessel LlP4trJlull
Bleeding the Heating S)'stetr.r.
Hot \\ ater Suppl1' Using Alde Heater
Hot Water Heating
Hot \later Heating rvith LPG
Hot \\ater Heatine rvith 130 \lA'C . .
Hot \\ater Heating rvith LPG and 130 \:\C
Emprying Hot \\ater Boiler (.\lde Heaterl .
Cooking&Baking..
Using the Gas Cooker
Refrigerator R\I7605 L
Contlols.
Air Conditioning . .'
Operating the Air Conditiomn
Controls.
Adjustr.nent of the Direction of the Air Florv
ll-3
!11
1f I
I --t
11<
I t--1
t2-1
I 2-8
110
I l-9
1l- 10
t
t
r
L
t
i
I
b
1l- l4
13-l
l3- 1
14-1
1,+- I
l5-1
l5- I
I]-I
l 5-2
l6-l
16- I
t7 -l
l7- l
l7- I
1 i-l
t8-l
18- I
IQ:
Toilet
Thetford Unit
Winter Camping
General Notes on Winter Carrping . . . . .
Additionai Notes on \\'inter Camping . . . . .
Reconmrended Accessories fol Winter Camping
Laving Up
Temporarily Laf ing Up the Nlobile Home
La.v'ing Up the Nlobile Houe Over the \\'inter
0-1 \tJ :00i . GB- 10.200,| Sr,t-Txtt'nrrca-TI
I
HL
t
t
t
t
r
L
L
www.knausowners.com

-
Coxrynrws
Szcrrox 0
I
rrl
I
J
r1
ll
l
KNAUS
18.3
19.
19. 1
19.1.1
t9.2
19.1. i
19.3
19.1
19.5
19.5.1
19._5.2
20.
20. I
20.1
20.3
2r.
using the Nlobile Hone Again After La.ving Up Ternporarily or ovel the winter .
Cleaning & Care
Cleaning and Care of the Erterior of the lv{obile Hotne .
Cleaning Plastic Parts on the Exterior of the N{obile Home
Care and Cleaning of the Inside of the Nlobile Home .
Cleaning Plastic Parts lnside the lvlobile Home
Cleaning Acrylic Glass Windou's
Cale and Cleaning of the RoofWindou' .
Care and Cleaning of the Sun,\lvning . . .
Dealing rvith Nlould on the Arvning
Treatment of Stiff Zip Fasteuers .
Nlaintenance & Inspection
Sen'icins
Inten,als for Statutory Testing and Erhaust Gas lest
Sen ice Charr.
Troubleshooting and Fault Rectification . .
Specifications
T)'res .'
Genelal Notes on the T\tes
TVre Pressr.re Table . . .
Payload
\\'eights for Packages (Optional Equl
Explanations on the Payload Calculat
Mass in Running Order .
Basic Equipment
I 8-4
19-1
19- 1
I 9-l
I 9-3
1 9-3
19--+
1 9-5
1 9-r
19--
1 9-7
20-l
20- 1
20-1
27-l
^r', - I
t1 I
1t I
22-2
T.-3
1) O
11 0
1l o
lt-10
:l- l0
ll-l I
11 t1
;
l
pnrent ) and Accessories
lvlaximum Technicallv Pemrissible Laden lvlass
\\'eights of the Pairload
\\'eights of the Accessories . . .
\Veights ofthe Personal Equipment ,
Formula for the Pavload Calculation
Specilications and Floor Plan rvith Heating Diagram
Information & Tips
Stanrtory Tests . .
Accessories to be Carried on the \,ehicie in Case of Emercencv
EmeryencvTelephoneNtimbem .. . .
23-l
23- I
:J- )
)f 1
1I
)
i
J
23.
li. 1
_J.-
_-r.J
-tI
St:.Tattutn-TI LrJ )005. GB-10.:001 0-5
bE
'-1
l
I
;J
www.knausowners.com

b,
KNA:US :
Cort rnnrys
Srcrtot; 0
Checklist
24.
f I1
25.
Checkiist for Pelsonal Entries
Index
21-r
tt a
:+- -
25-1
-
:
-.
l.:
I
la
I
I
a.a
I
i
I.S
I
I
I
F.3
I
I
r-.
i
t1
I
l
u
I
Sc"-Tnq'etLrn-Tl]1.1 :00-: . GB- 10.:001
0-6
www.knausowners.com

Sncrtox I
FonnwoRD
,t
www.knausowners.com

J
Fonnwono
Srcrrux I
l
l
KNAUS
1. Foreword
\l,e wish yog all the best tbl your 1(,\ILIS n-robile hor-ne. Ybur >holiday horne ou u'heels< has been designed and manufactured
to give you the maxin-tut-t.t possible enjoyment.
please read througir this manual carefuil.v belore using the vehicle to ensrlre yoLI get tlte very best out of yottr mobile home.
Take the time to be able to enjoy the excelient comfofi anrl high technical standards of your n-robile hotle in a manner that is
as relaxed as possible.
Please pay particular attention to the salety information.
In addition to this manual vou shonld also farniliarise -vourself u,itir the separate manual fot the base vehicle alrd tl.re appliances
fitted.
If -vour. mobile hone is frtted u,ith optional equipment, observe the accompanying special pelmits and the lelated special
instructions.
To request maintenance and repair vu'ork and if you 1.rare any special questions. please call vour nearest 1i\7t''S dealer. The
staff at your authorised dealership u,il1 be happ1, to adt.ise and assist ,vou on ail maners relating to your KilAL'S product.
Only approvecl spare parts fi'on.r tire original manufacturer can ensure qualit-v and a perfect fit.
\\,e cannot ftilfi1 our \\,arrantv obligations according to the terms of our warrant-v if maintenance u'ork has been neglected or
carried out incorrectl),.
please send your completed warranty card to K|\tAaS TABBERT GROUP GTIBH to activate the w'arrantv.
This manual is only valid in so lar as tire mobiie home corresponds to the specifications described within.
J
,J
l
.J
J
J
l
l
J
ll
l
-t
fi
d
sf
*J
The mobile home specifications are particuiarly important
when rnaking enqiriries and ordering spare pafis. Nlodel name
Type designation
Year ofmanufacture
Chassis nunrber
/\
la
/--
e,
\bu rvill the data or.r the n.robiie home on the nameplate on the passenger's side on the B piilar.
We lvish you plenty ol leisure time enjoyment with yoLll' new 1i-\,lLS mobile hon.re.
Tne Mt.vlcE)IE,\'T
Therefore please rnake a note of the model. tvpe" the
.vear of manufacture and the chassis number of vour nerv
1i,\1LS mobile home rvithout delar.
St. *Tn.l'ttrcn-TI .VlJ:00:. GB-10.:001 1-1
J
@
www.knausowners.com

Sncruorv 2
I
O
SerarY /rrsTRUCTrotys
www.knausowners.com

:b
J KNAUS
Safefv Instructions
This section contains safet-v instructions that mr-rst be foilou,ed r.vhen operating the mobile home.
Tlte followirtg s),ntbols are usecl in this mailusl to clran'):our attentiotl to these instructiorts:
The Ir\ARNING and CAUTION syn-rbois are pdnted in front of the text to u'hich thev refer.
The NOTE symbol is printed after the text.
I
ISsnrv lxsrnucnoxs
Srcruox 2
)
Please notC in paiticuiar that we cannof accept aoy tinnilit-v for damage and
operatingproblemscausedb.r.ignoringirri'*anuaI.':.
This:safe$r s1'mbOl appears when operatingprocedqrys,must,beobserer€d,fu.funl,,*o,
CAUTIOI\:
This safety symbol appears when operating procedures must be observed in full to
prevent damage to propertl,.
NOTE:
This safety syrnbol appears rvhen the user must pav particular attention to technical
requirements.
NOTE:
It is imperative that instructions marked in this rvay are observed!
2-l
Srl.IRriztrn-Z
E
-'. ----<.._
ll ,-
pr-__3
ffi
\u :005 . GB-t0 :00.t
www.knausowners.com

Sapnrv lxsrnrrcrtoxs
Sncnox 2KNAUS
2.1 Safet-v Devices
partic,lar attentior.r should be paid to tire safetl, devices litted to -vour nrobile home. These safety devices uusl be reeularly
checked to ensure that thel, o.. rro.king corr.ectl,v'. The mobile home must not be operated if the safetl' devices are malfunctior.r-
ing or not t'orking.
2.2 Safety Instructions for Road Travel
:-= The mobile home must be officiall,v registered'
= The rT-robiie irome is designed for a maxin-run-r speed of 110 km h'
A marimum speed of 130 kmh is shou'r.r in the vehicle registratior.r document.
ln Germanl'the admissible top speed for mobile irot.ues is:
rr
i
F
I
r
L.
I
Urban areas
C)utside urban areas: to 3.5 tonnes total u'eight
over 3.5 tonxes total u'eight
to 3.5 tonnes total u'eight
over 3.5 tonnes total rveiglrt 50 km/h
50 knVh
100 knr,/h
80 km/h
r
L
r
r
r
t_
r
On motonvays: to 3.5 tonnes total rveight no speed lirnit
oter 3.5 tonnes total u'eiglit 80 kn h
:= it is basically permitted to carry persons in the living area of the mobile home during the journey iu accordancs \\'ith
Germantrafficregulatio,s.Hou,everthesepersorr..nu1,'onlyrideonti-reseatsdesignatedforthispurpose(seesection3'f i
Seating Arrangement). persons facing fonvard in the iiving ur.u of the mobile home uhile the vehicle is in motion must
rvear the three-poir.rt seat belrs. persons seatecl facing the rear in the living area of the mobile home must also wear seat belts
if seat belts ale fitted.
:_= Due to the vehicle height yog need to be au,are of the mobile hor-ne"s vulnerabilitl'to side r'r'inds during the jouruey'
r. Note the maximum technically permissible laden mass (see vehicle certificate. no. 15 ) and maxilrunl technically permis-
sible axle loads (no. l6).
t- Tllepayloadistobedistributedever.rll,thoughouttl.renlobilehome(seesectioll'1'3ff Pa.vload)'
:: During the jourle,v all seats must be tulned to face the direction of travel and locked in place'
:-.= Priorto starting a journey,, ally support legs used (accessories) urttst be raised and locked'
['
['
t
r
r
2-2 il
,t
I
i
g;69'6**iv s :corvrn s ri*s*
t,tJ :005 . GB-t0.)001 Stv-TnlxLrcn-TI
E
A
www.knausowners.com

Smnru fxsrnrrcruoxs
Srcrrcx 2
l
l
J
l
J
J
J
=l
,l
,l
J
J
l
J
J
J
J
l
-l
KNAUS
r--u' The entrv door must be closed before stalting a jortrtler"
:; If accessories are fitte<i this rvill alterthe dimer-rsions. the total rveight aud tl.re handling of tl.re rr.robile hon.re. Sttcli accesso-
ries n.ra,v har.,e to be enterecl in the r.'el-ricle docurreuts to cor.nply u'ith regulatiot]s.
i__- Before starting a journey alrvavs check that the toilet. bath and cupboard doors. drarvet's and al1 flaps. u'rndow's and roof
lights ale closed and that the refrigerator door latch is secr-tre'
: = \\,'hen parliing the mobile hor-r.re. pttll the palking brake on as far as it u'i1l go'
: -- Use',1'heel cliocks if parking on a slope.
:-,.- In u,'ir.tter clear tl.re roof of ice and sttou' before driving off.
i=' Never use sno\l. cl.rains on tr.robile homes fitted rvith aluminir'rm rvheels'
:= Ifthevehicleistransported(e.g.bytrain. lorr,v).therel.riclemustbeioadedinthedirectionoftravell
2.3 General Safefi Instructions
:_: Alu.a).s ensllre there is adequate ventilation rvhen residing in the mobiie home. Forced ail vents in the roof lights must
ner.erbe obstructed (e.g. by'r,,.inter mats) or sealed because of the risk of suffocation flour increased CO (carbon monox-
ide) levels in the air.
;... you must read the individual manuals for all installed systerns (e.g. gas heater. gas cooker. refrigerator etc.) and the base
vehicle (engine, brakes etc.).
:--= Note the headroom of the sliding door and the heights of the driver and passenger doors'
i,,: Close all doors and u'indorvs when leaving the vehicle.
:= Take care not to datnage the outer skin of the mobile home!
:= Avoid localised loads (e.S.kneeling) as far as possible if 1,ou need to go onto the roof of the mobile.hornel
:= Walk only in the horizostal ar.eas of t1're n-robile home roof and w'ear soft-soied shoes (e.g. trainers or punlps)! Avoid
u,alking on the roof rvith textured-soled footu,ear as an-v stones embedded in tire soles u'ill dent the outer skin of the n.robile
hornel
r,r Takeextracautionrvhenrvalkir.rgoveltheroofoftheyel.ricleu4renu,etolic-v'.Tirereisadangerofslippingorfallingoffl
I
-l
-l Sr .r,7k..rr zrrn- 11 ,\tJ:005 - GB-10.:001
tA
www.knausowners.com

SapETt' Ixsrnucrtoxs
Secrton, 2KNAUS
2.3.1 Safety Instructions for Fitting Rear Carrier S-vstems
CAUTION:
After fitting rear carrier s1'stems alx'ays note the follorving:
r= that the load is attached and secured to the rear carrier according to instructions!
l= the admissible payload capacitl, of the rear carrier is not exceeded!
l= that the axle load distribution and the total rveight of the mobile home will be altered!
l= that the handling and braking of the mobile home will be altered!
NOTE:
In Gerrnanl,remorable rear carrier s1'stems need notbe enteredinthevehicle documents!
:= Onl,v har,e rear carrier svstenls fitted b.v authorised u,orkshops for safetv reasonsl
\bur nearest /L\,lLS dealer u'il1 be glad to infonn you about this.
Safety Instructions for the Gas System
I{OTE:
The overall gas sl,stem is designed for an operating pressure of 30 millibar [mbarl!
;.: Any installations or modificatious to the gas systenr must be carried out b1'quaiified specialistsl
::." The LPG (liquefied petroleum -uas) system is inspected bi, an engineer before it leaves the factory. The gas system must be
re-inspected every 2 years and follou'ing an-v modifications and reprirs.
:-; The regulators ar.rd flue pipes must also be checked regularll,l Inspections mr.rst be recorded on the test certificate accord-
ing to DIGW \\ror*sl.reet G 601 .
:--: Q$ss1vs reler.ant r.rational legislation outside Geru.rany!
;.- The operator is so1el1, responsible fol ensurir.rg the checks are carried outl
i;i:r
I
;5
I
L
I
t
r-i
t
.;
I
t
r
r
r
r
r
r
t
2.4
1.1 Sr.t-Tn-u'rum-TI
i -
;l
t_
I
I
l_
a3
I
t
I
l
I
I
L
!=
1
I
L-
I
t
G
b
G
,\t-t :()05 . GB-10.2()04
www.knausowners.com

j
.J KNAUS
Sepsrv fxsrnrrcrrotvs
Sncrtox 2
.i
.J
,l
Gas bottles must be kept in the gas locker rvhere they must be held upright and secured to prevent them from spinning rout.rdl
The gas locker must be hen.r.reticall."- sealed lrom the interior of the mobile hortte and there mttst be a ventilation opening at
or imn.rediatel-v abor.e the floor of at least 100 cml. This must never be coveled!
Onl,v use pressure reglrlators u,ith a safet,v valve I Othel regulators are not permittedl Cotinect the regulator to tl.re gas bottle
carefulll, by hancl (do not rlse spatmers. pliers or similar). The tlueaded fittings on tire ges regtllator have left-l.rand threads.
Use a de-icing system for the regulator for temperatut'es belorv 5 "C (e.g.Eis-Ex).
.,J WARIYING: . i
,'
FaUure to observe these instructions r*ill result in a potentialll' lethal
situation due to laif of o*1'g.n uoA tn* possible production 'of
;;;;;i;;; ""o p;#,;;.;;ffi;;;;;.id; iCoyr':. '' A
.J
.l
.]
J
,]
I
t!
.tI
E!
I
:
L!
-r.l
--t
When using the gas cooker votl must open a roof light. a u indou or the doorsl
The 6-robile home must neler be heated u.ith radiant ireaters and other appliances that take their cornbustion air from the
interior of the vehiciel
r= When sr.r,itching on gas appliances rvhich are ignited by pressing a button. it must be ensured that this automatically retllrns
to its original position after pressingl
:-.- Never seal the forced air vents in the roof lightl
:-= The flue pipe from the gas heatel must be rising along its er.rtire length and be fastened secr,irely ir.r place with clips and gas
flr.re pipe supports if necessaryl
:--=: The flue pipe mnst be properlrv connected and sealed to the gas heatel and to the flue. and mtist not be dama-qed in any way.
= Flue pipes from heaters must be r-nade of stainless steel.
:-r Before starting up tl.re gas heater remove an-v dirt and sno.uv from tl.re flue and the combnstion air ir.rlets to prevent carbon
monoxide (CO) in the exhar.rst gas increasin,g to an inadmissible levell
:- Appliances wllich operate u'ith gas must not be used u,hile retirellinc or in e garagel
. i Operate the gas svstem only rvitl.r propane, butane or a r.nir of the nvo gas typesl Propane can gasify dorvn to -32 oC. butane
only dou,n to 0 'C.
:-= The gas bottle stop valve must be closed rvl.rile travelling if no appliances are irt use !
:,: Always close the appliar.rce -sas tap u,lten vou have linished using a gas appliance!
:,.= lf the mobile horne is uot to be Lrsed for a long period close tl.re gas bottle stop valve on the gas bottlel
*l
I
, -t
I
l
St':,Tat'ttt,e n-TI 2-5
E
\lJ :005 , GB-t0:00r
www.knausowners.com

Sernry Ixsrnrrcruoxs
Srcrrcx 2
Do not store electrical der,ices (e.g. batteries) andr ol devices u'l.rich forn, a source of ignition in the gas iockell
Electrical leads n-ra1,or.rl.v be fed through the gas locker if insulated. Do not fasten u'ith clipsl
b
K'UAUS
F
lir
F
Et
=!
IL
LT
I
L
f
L
L:!
I
L
If 1'ou suspect a gas leak, proceed imruediatell' as followsl , i
ssClose gas bottle stop valve! . : ,,,, ''
r AYoid ignifion sources of an1, sori incl. na*ea names or,srnokingl
rrror.ioe,*ouiaiioothroughtheroom!.,.,,,..,
i:=Clearthedangbr,areal I I 1,,' r , i
,=lrfor* thi campsite superintendent hnd the fire service'if
' o*a"rruryl ., ,
r
L
t
2.5
2.5.1
Fire Safet-v
Prevention of Fire Hazards
I
r
r
r
t
t
t
r
r
r
L
:: All repairs and modifications to the electrical oI LPG svstems and eqr.ripment must be carried out by trained persorurell
:: Never leave childreu unattended in the mobile hon.rel
:= Keep flanimable matelials atvay from heating and cookirlg appliancesl
:: Never r,rse portable heating or cooking appliancesl
2.5.2 Fire Fighting
:-.= It is recommended to alu'ays carrv a l-kg dry pou,cier fire extinguisher in the n-robile homel rhis extiuguisl.rer must be
approved, tested and kept u'ithin eas-v reach.
l-" Thefireextinguishermgstbeciieckedregularl-vbyapprovedtraiuedpersouuel(makeauote oftheinspectiol.rdate)!
NOTE:
The gas sl,stem must be started again b-v* a gas engineer after being checked'
2-6 \tJ:005. GR-10.:()01 Srs.Tntrtt-Ltn-TI
A
A
www.knausowners.com

I
J
l
J
ll
J
S,qrnrv lxsrnucnoxs
Srcruox 2
KNAUS
2.5.3 In Case of Fire
r:- E\racuate all t'ehicle occupants!
:: Srvitch off the electrical porver suppll'and discomect from the mains!
:,-- Immediately close gas bottle stop valve!
=' Sound the alarm ar.rd cail the fire servicel
:,- Tr1'to put out tiie fire if thrs is possible u'ithor-rt riskl
r.- Be au.are of the location and use of emergenc,u- exitsl
:,- Keep errergency exits clearl
:-,: Follou, the instructious for ttse of the fire extinguishel I
2.6 Important Notes for the Sanitan'Area
CAUTION:
r= The wet cubicle is onll- allon'ed to tre used for showering in conjunction with a
sholver curtain or a shon'er door!
r The toilet cubicle is onlv allox'ed to the cleaned w{th a damp cloth!
)1 Environmental Notes
Collect all opelating fluids 1e.g. |.rbricants, spent oil and detergents)in sr.ritable cotttainers and dispose of correctly!
Never dispose of *'asteu,ater of anl,kind or domestic refuse in the gulter or in the countrvside.
Ahvays enlpt-v the \\,aste\\,ater tank and the Thetford unit at disposal fhcilities otr tire caupsite or at specially designated
disposal facilities. Obsen'e to\\'n and district regulations and ask about disposal faciiities.
Use an environmentalll" friendly and biologicall-v degradable WC chernical in sn.rall doses.
Separate don'restic refuse into glass. r.r.retal tins. plastic and vnet reftrse.
J
J
,]
I
I
,l
I
Lt
I
'l-l
I
,,i!
-1I
I
,L,
:LJ
TJ
,-!
)_7
Sr .r' Iar r rlrrt- 11 ,\{J:0()_;. GB-I0:001
E
www.knausowners.com

2.8 Supplementary Notes
Read the folloxting broclrtres fr.om the AD-4C y,hich form supplementat), information to tlris handbook:
E- >Freies Campen r-rnd Ubernachten in Etrropa<
il >\'erkehrsbestimmungen fiil Gespanne und WbhrunobiIe in Europa<
i >Besondere Verkehrsbestimmungen frir C ampingfahrzett ge in Deutsclrland<
S,qpnrv fxsrnucrtoxs
Sncnox 2KNAUS
: -= Never dispose of don-restic refuse in r,,'aste bins ir.r cal parks. Ask about disposal facilities in tou,ns and districts.
:.: If residing for a lorr_u period iu a tou,n or district. look for a speciall-v designated parking piace for mobile hornes. Ask about
parking facilities in to\\us or districts.
;-.- Turn off tlie vehicle engine u,hen parked. The engine operatinu Ietllperatltre is reaclied n.rost effectivell' by drir,ing fast.
r.!
:
rE
_
rfB
L
P
l
L
r
L
Fr,
l
L
lr;
L
r-;
I
t
lli
L
lr,
L
ln
{
L
f''
L
f"
L
t'
L
r;
I
l;
2-8 v.t :005 . GB-t0.)001 St*InlrrurR-7'
www.knausowners.com

Sncrrox 3
affi
W
D as cRrPrrort & E gtnruta xr
www.knausowners.com

.T
J
lKNAUS
J
J
l
J
.J
l
J
I
I
ll
l
l
I
J
l-ii
,1
I
3.
3.1
Description & EquiPment
General Construction and Equipment of the Mobile Home
3 A RENAULT flat-bed chassis is used as the base r-ehicle for tlie In';LS n.robile 1.rome. \bu u'ill find furlher information on
the base vehicle in the separate mar.tual supplied b1'the manufacturer.
O The separatel_v lockable gas locker is integlated in the rear of the mobile home. The gas locker is insulated and hermetically
sealed from the rnterior of the mobile home'
3 The lower rear area of the mobile home forms a strikilg plastic lighting panel.
3 The mobile home is fitted u'ith a 3rd brake light.
C The front part ofthe body is closed by the Hutze area.
C A so-called flat floor is used for the mobile home's floor constructior-r. This has a total thickness of 40 rnm and is insulated
rvith polystyrene.
C The mobile l1on-re bodf is a,rsandu'ich construction<, u'ith a total thickless of up to -10 mn-r. The sandrvich consists of a
glued and compressed alun-rinium oritel skin. poly,st,vrene insulatin-e n.raterial. rvooden panelling and the interior rvall. The
gtui"g is a special feature of this t1.pe of construction. \!'e use an adhesive u,hich penetrates about 5 mrr into both sides of
the polystyrene. therebl. cross-linking the material. The result is not just a sttrface join but also a homogenous bond
bet.ul'een the components. Combined with precision workmanship. this process guaralltees optimal thermal insulation of
the mobile home.
3 The double-skin GFRP roof (GFRP: glass fibre reinforce plastic) on the mobile home is a single piece ar.rd is mauufacnrred
using a vaculrlll process. An additional surface coating (gel coat) is applied to the top layer of the GFRP during manltfacture.
3 Another leature of the K\lLlS mobile home is the wooden and PU panelling of the side rvalls. both in the contouring of the
mobile home and ir.r all essential recesses. 'ul,inclovn,s and doors. This panelling lends the sidelvalls a considerably increased
stability.
C The furnishings are manufactured entirel-v from higl-r quality materials. The t,vpe of finish ensures that fr"rrniture surfaces
are simple and easy to keep clean.
3 Particular anentiorl is also paid to the securing of the furniture in all Ii,\lLS r.uobile homes. To enable the absorption of
correspondinglv large torces. multi-laminated plvu,ood strips are fastened to the sideu'alls at certain places. Because tl.rese
artachment points are incorporated during actual manufacture of tire sideu,alls thev ensttre a high level of strength.
3 Al1 cupboard arld locker doors are fitted rvith high-qualiti, locks to prevent un$'anted opening. All door fittings used in the
n-robile home have been chosen rvith great care. Here again, onll'the r.erv best quality is used.
3 The interior of tlie mobile home t-eatiu'es - depending on the model - a penltatlently installed rear bed aud one ol'more seat
modules which can be easily convefted into sleepin_u berths.
C Spacior,rs storage lockers are integrated abo',,e the rear bed the seat r-nodules and the kitchen range.
Drscntprlox & EQuwruaxr
Srcruox 3
Sr.-vTxlztte a-TI 3-l
.\tJ :()t)i . G B- I 0.: t)a1
www.knausowners.com