Nexa BALENO 2016 User manual

OWNER’S MANUAL & SERVICE BOOKLET
• Keep With Vehicle At All Times • Contains Important Information On Safety, Operation & Maintenance
Part No. 99011M68P04-74E
July, 2016 ENG
99011M68P04-74E
Service Division
MARUTI SUZUKI INDIA LIMITED
Palam Gurgaon Road, Gurgaon - 122 015 (Haryana)
www.marutisuzuki.com
CODE 01/07/16/5000

Part No. 99011M68P04-74E
July, 2016
This Owner Manual & Service Booklet applies to the BALENO series
© COPYRIGHT MARUTI SUZUKI INDIA LIMITED 2016 Note: The illustrated model is one of the BALENO Series.
produced by MARUTI SUZUKI INDIA LIMITED
#
For 24 X 7 assistance, contact Toll Free number 1800 200 6392
(NEXA)

Celerio CelerioCelerio
Dear Sir/Madam,
Thank you for choosing a Maruti Suzuki vehicle.
I hope our dealership team took good care while delivering the vehicle to you.
Your vehicle is equipped with state-of-the-art technologies. To get the best performance from
your vehicle (and ensure it is trouble-free), kindly get your vehicle serviced periodically, as per
the maintenance schedule in your Owner's Manual. Please make sure the service is done at a
Maruti Suzuki authorized workshop for best results.
For any accessories that you wish to fit on to your vehicle, please contact any of our authorized
dealers for assistance. Kindly appreciate that any tampering of wiring harness to fit
accessories may cause the vehicle to malfunction.
Thank you once again for choosing a Maruti Suzuki vehicle.
I wish you many years of safe and happy driving.
Pankaj Narula
MARUTI SUZUKI INDIA LIMITED
Palam Gurgaon Road,
Gurgaon-122015
www.marutisuzuki.com
Executive Director (Service)
Yours sincerely
(Pankaj Narula)

Vehicle may , meet with an
or due to
1. Installation of
- High wattage bulbs
- Non genuine lamps / horns
- Modified suspension / wheels
- Non genuine parts / accessories etc.
2. Retrofitment of LPG / CNG fuel systems/kits.
3. Usage of domestic LPG.
4. Short circuiting due to tampering of wiring harness.
CAUTION: DO NOT STORE OR CARRY INFLAMMABLE MATERIALS IN THE VEHICLE.
break-down
accident catch fire
Avoid driving into or starting the vehicle in a
heavily water logged area. Vehicle may break-
down or engine may fail due to
1. Water entry into the engine.
2. Short circuiting of the electrical systems.
If the vehicle is stuck in deep water,
start / crank the vehicle until the level of water
drops below the level of exhaust pipe.
NOTE:
IF THE VEHICLE IS SUBMERGED IN WATER, REPORT TO THE NEAREST
AUTHORIZED WORKSHOP.
do not
“WARNING”

VIN:
MODEL: OWNER
NAME &
ADDRESS
VARIANT:
COLOUR:
ENGINE NO.: CONTACT NO.
KEY NO.: E-mail ID:
INVOICE DATE:
SELLING
DEALER NAME
& CODE
ODOMETER READING KM
REGISTRATION NO.:
BATTERY MAKE:
DEALER
SHOWROOM
ADDRESS &
CONTACT NO.
(STAMP)
BATTERY NO.:
BATTERY BATCH
TYRE MAKE BATCH CODE
Front Right
CONTACT NO.
FOR SERVICE
APPOINTMENT
& SUPPORT
Front Left
Rear Right
Rear Left
Spare
For any assistance with regard to our product, please contact General Manager/Works Manager at any of our authorised Maruti Suzuki Nexa dealer/authorised
Maruti Suzuki Workshop. For additional enquiry you may contact our Regional Office or Service Department. The addresses and phone numbers are
given in Service Network section of this Manual / Service Network booklet.

68PH0-74E
F: .... FREE SERVICE, P:.... PAID SERVICE, W:.... WARRANTY JOB, A:.... ACCIDENTAL JOB
DATE OF
SERVICE
KIND OF
SERVICE
MILEAGE
(KM)
DESCRIPTION OF JOB NAME OF SERVICING DEALER/
MASS
JOB CARD NO. MECHANICS
SIGNATURE
MAINTENANCE SERVICE RECORDS

COST OF MATERIALS AND CONSUMABLES TO BE BORNE BY CUSTOMER
(1) Tyres (Air pressure, Abnormal wear, Damage)
(2) Wheels (Inspect)
Please see overleaf for special instructions
(1) All Latches, Hinges & Locks / Central
Locking (Operation)
(1) Battery electrolyte (Level, Leakage)
(2) Lighting System / Horn (Operation)
(3) Wiper (Operation)
(1) Operation of Brakes, clutch, Gear
shifting and Speedometer
(2) Body & Chassis noise
JOB MARK: √ : Checked OK, A: Adjust, C: Clean, R: Replace or Change, L: Lubricate, T: Tighten,
O: Rotate, I: Inspect and correct or replace if necessary
(CUSTOMER’S COPY)
WHICHEVER COMES FIRST
(1,000 KM or 1 MONTH)
(DEALER’S COPY) (1,000 KM or 1 MONTH)
Mechanic’s Signature
Service Manager’s Signature
Customer’s Signature
(1) Steering wheel (Play)
(2) All Rods & Arms (Loose, Damage, Wear)
(3) Power Steering System (Operation)
(4) Steering gear box (Inspect)
(5) Tilt/Telescopic (if equipped) steering (Operation)
Model Code*
Chassis No. :
Engine No. :
Mileage
Date of Invoice
Date of Inspection
Registration No.
Service Dealer Code/Mass Code
Customer Name
Address (Please write complete address)
(1) Brake fluid (Level, Leakage)
(2) Brake Pedal (Pedal to Carpet Clearance)
(3) Parking brake lever (Play)
(4) Brake hoses & pipes (Leakage, Damage)
* Model Code: Baleno (Petrol) : A1K412
Baleno (Diesel) : A1K413D
(1) Fuel filter, Fuel tank cap, Fuel lines and
connections (Leakage)
(2) Fuel Filter - Water Draining (Diesel)
(1) Struts / Shock Absorbers (Oil leakage)
(2) Rear spring (Damage)
(1) Engine Coolant (Level, Leakage)
(2) Engine Oil (Level, Leakage)
(3) Cooling System hoses & connections
(Leakage, Damage)
AIR-CONDITIONING
HEATING AND
(1) Drive belt (Tension)
(2) Check functioning of Recirculating flap
(3) Check all Hose Joints
(4) A/C filter element (Inspect)
1. Clutch Pedal (Play) (Petrol)
2. Clutch Slipping (Dragging, Damage)
3. Transmission Oil (Level, Leakage)
4. Gear Shifter Cable (Operation)
5. Clutch fluid (Level, Leakage) (Diesel)

Mechanic’s Signature
Service Manager’s Signature
Customer’s Signature
For Servicing Dealer/Mass
Model Code*
Chassis No. :
Engine No. :
Mileage
Date of Invoice
Date of Inspection
Registration No.
Service Dealer/Mass Code
Customer Name
Address (Please write complete address)

(CUSTOMER’S COPY)
COST OF MATERIALS AND CONSUMABLES TO BE BORNE BY CUSTOMER
1. Steering wheel (Play)
2. All Rods & Arms (Loose, Damage, Wear)
3. Power Steering System (Operation)
4. Steering gear box (Inspect)
5. Tilt / Telescopic (if equipped) steering (Operation)
1. Battery electrolyte (Level, Leakage)
2. Lighting System/Horn (Operation)
3. Wiring Harness Connections (Looseness)
4. Wiper (Operation)
1. All Latches, Hinges & Locks/Central Locking
(Operation/Lubrication)
2. All Chassis nuts & Bolts (Inspect)
3. Seat belt (Operation)
4. Seat latch, lever & knob (Operation)
Please see overleaf for special instructions
JOB MARK: √ : Checked OK, A: Adjust, C: Clean, R: Replace or Change, L: Lubricate, T: Tighten,
O: Rotate, I: Inspect and correct or replace if necessary
WHICHEVER COMES FIRST
(5,000 KM or 6 MONTHS)
Mechanic’s Signature
Service Manager’s Signature
Customer’s Signature
(DEALER’S COPY) (5,000 KM or 6 MONTHS)
Model Code*
Chassis No. :
Engine No. :
Mileage
Date of Invoice
Date of Inspection
Registration No.
Service Dealer/Mass Code
1. Engine Coolant (Level, Leakage)
2. Engine Oil (Level, Leakage)
3. Cooling System hoses & connections
(Leakage, Damage)
4. Exhaust System (Noise, Leakage)
5. PCV System (Hoses, Connections, Valve)
1. Brake fluid (Level, Leakage)
2. Brake Pedal (Pedal to Carpet Clearance)
3. Parking brake lever (Play)
4. Brake Disc and pad (Inspect)
5. Brake hoses & pipes (Leakage, Damage)
1. Tyres (Air pressure, Abnormal wear, Rotation)
2. Wheels (Inspect)
3. Front / Rear wheel Bearing (Loose, Damage)
1. Suspension Struts/Shock Absorbers (Oil leakage)
2. Suspension arms, Knuckle, Rear spring
(Damage, Loose)
3. All nuts & Bolts (Tighten)
AIR-CONDITIONING
1. Drive belt (Tension, Damage)
2. Check functioning of Recirculating flap
3. Check all Hose Joints
4. Tighten Compressor Mounting Bolts
5. Clean Condenser with low pressure water
6. A/C filter element (Inspect)
HEATING AND
1. Operation of Brakes, clutch, Gear
shifting and Speedometer
2. Body & Chassis noise
1. Air cleaner (Clean) (Petrol)
2. Fuel Filter, Fuel tank cap, Fuel lines and
connection (Leakage)
3. Fuel filter water draining (Diesel)
1. Clutch Pedal (Play) (Petrol)
2. Clutch Slipping (Dragging, Damage)
3. Transmission Oil (Level, Leakage)
4. Gear Shifter Cable (Operation)
5. Drive shaft boots (Damage)
6. Clutch fluid (Level, Leakage) (Diesel)
* Model Code: Baleno (Petrol) : A1K412
Baleno (Diesel) : A1K413D

Mechanic’s Signature
Service Manager’s Signature
Customer’s Signature
For Servicing Dealer/Mass
Model Code*
Chassis No. :
Engine No. :
Mileage
Date of Invoice
Date of Inspection
Registration No.
Service Dealer/Mass Code

(DEALER’S COPY) (10,000 KM or 12 MONTHS)
1. Steering wheel (Play)
2. All Rods & Arms (Loose, Damage, Wear)
3. Power Steering System (Operation)
4. Steering gear box (Inspect)
5. Tilt/Telescopic (if equipped) steering (Operation)
1. Battery electrolyte (Level, Leakage)
2. Lighting System/horn (Operation)
3. Wiring Harness Connections (Looseness)
4. Wiper (Operation)
1. Operation of Brakes, clutch, Gear
shifting and Speedometer
2. Body & Chassis noise
1. Tyres (Air pressure, Abnormal wear, Rotation)
2. Wheels (Inspect)
3. Front / Rear wheel Bearing (Loose, Damage)
1. Suspension Struts/Shock Absorbers (Oil leakage)
2. Suspension arms, Knuckle, Rear spring
(Damage, Loose)
3. All nuts & Bolts (Tighten)
Please see overleaf for special instructions
(CUSTOMER’S COPY)
WHICHEVER COMES FIRST
(10,000 KM or 12 MONTHS)
JOB MARK: √ : Checked OK, A: Adjust, C: Clean, R: Replace or Change, L: Lubricate, T: Tighten,
O: Rotate, I: Inspect and correct or replace if necessary
Mechanic’s Signature
Service Manager’s Signature
Customer’s Signature
Model Code*
Chassis No. :
Engine No. :
Mileage
Date of Invoice
Date of Inspection
Registration No.
Service Dealer/Mass Code
COST OF MATERIALS AND CONSUMABLES TO BE BORNE BY CUSTOMER
1. Air cleaner filter element (Clean)
2. Fuel Filter, Fuel tank cap, Fuel lines and
connection (Leakage)
3. Fuel filter - water draining (Diesel)
1. Brake fluid (Level, Leakage)
2. Brake Pedal (Pedal to Carpet Clearance)
3. Parking brake lever (Play)
4. Brake Disc & Pads (Inspect)
5. Brake hoses & pipes (Leakage, Damage)
6. Brake Drums & Shoes (Inspect)
1. Engine Coolant (Level, Leakage)
2. Cooling System hoses & connections
(Leakage, Damage)
3. Engine Oil & Oil filter (Replace)
4. Cylinder head bolts (Tight) (Petrol)
5. Engine Mounting and Manifold Fixing
(Noise, Leakage, Damage etc.)
1. Clutch Pedal (Play) (Petrol)
2. Clutch Slipping (Dragging, Damage)
3. Transmission Oil (Level, Leakage)
4. Gear Shifter Cable (Operation)
5. Drive shaft boots (Damage)
6. Clutch fluid (Level, Leakage) (Diesel)
1. All Latches, Hinges & Locks/Central Locking
(Operation/Lubrication)
2. All Chassis nuts & Bolts (Inspect)
3. Seat belt (Operation)
4. Seat latch, lever & knob (Operation)
AIR-CONDITIONING
1. Drive belt (Tension, Damage)
2. Check functioning of Recirculating flap
3. Check all Hose Joints
4. Tighten Compressor Mounting Bolts
5. Clean Condenser with low pressure water
6. A/C filter element (Inspect)
HEATING AND
* Model Code: Baleno (Petrol) : A1K412
Baleno (Diesel) : A1K413D

Mechanic’s Signature
Service Manager’s Signature
Customer’s Signature
Model Code*
Chassis No. :
Engine No. :
Mileage
Date of Invoice
Date of Inspection
Registration No.
Service Dealer/Mass Code
For Servicing Dealer/Mass

1
68PH0-74E
FOREWORD
This manual is an essential part of your
vehicle and should remain with the vehicle
when resold or otherwise transferred to a
new owner or operator. Please read this
manual carefully before operating your
new MARUTI SUZUKI and review the
manual from time to time. It contains
important information on safety, operation
and maintenance. You are invited to avail
the three Free Inspection Services as
described in the manual. Three free
inspection coupons are attached to this
manual. Please show this manual to your
dealer while you take your MARUTI
SUZUKI for any Service.
To prolong the life of your vehicle and
reduce maintenance cost, the periodic
maintenance must be carried out accord-
ing to “PERIODIC MAINTENANCE
SCHEDULE” described in “INSPECTION
AND MAINTENANCE” section of this man-
ual. It is essential for preventing trouble
and accidents to ensure your satisfaction
and safety.
Daily inspection and care as per “DAILY
INSPECTION CHECKLIST” described in
the “INSPECTION AND MAINTENANCE”
section of this manual is essential for pro-
longing the life of the vehicle and for safe
driving.
MARUTI SUZUKI INDIA LIMITED believes
in conservation and protection of Earth’s
natural resources.
To that end, we encourage every vehicle
owner to recycle, trade-in or properly dis-
pose of, as appropriate, used Engine Oil,
coolant and other fluids, batteries and
tyres etc.
MARUTI SUZUKI INDIA LIMITED
All information in this manual is based
on the latest product information avail-
able at the time of publication. Due to
improvements or other changes, there
may be discrepancies between informa-
tion in this manual and your vehicle.
MARUTI SUZUKI INDIA LIMITED
reserves the right to make production
changes at any time, without notice and
without incurring any obligation to
make the same or similar changes to
vehicles previously built or sold.
This vehicle may not comply with stan-
dards or regulations of other countries.
Before attempting to register this vehi-
cle in any other country, check all appli-
cable regulations and make any neces-
sary modifications.

2
68PH0-74E
IMPORTANT
WARNING/ CAUTION/NOTICE/
NOTE
Please read this manual and follow its
instructions carefully. To emphasize spe-
cial information, the symbol and the words
WARNING,CAUTION, NOTICE and
NOTE have special meanings. Pay particu-
lar attention to messages highlighted by
these signal words:
NOTE:
Indicates special information to make
maintenance easier or instructions clearer.
75F135
The circle with a slash in this manual
means “Don’t do this” or “Don’t let this hap-
pen”.
MODIFICATION WARN-
ING
WARNING
Indicates a potential hazard that
could result in death or serious
injury.
CAUTION
Indicates a potential hazard that
could result in minor or moderate
injury.
NOTICE
Indicates a potential hazard that
could result in vehicle damage.
WARNING
Do not modify your vehicle. Modifica-
tion could adversely affect safety,
handling, performance, or durability
and may violate governmental regula-
tions. In addition, damage or perfor-
mance problems resulting from
modification may not be covered
under warranty.
NOTICE
Improper installation of mobile com-
munication equipment such as cellu-
lar telephones, CB (Citizen’s Band)
radios or any other wireless transmit-
ters may cause electronic interfer-
ence with your vehicle’s ignition
system, resulting in vehicle perfor-
mance problems. Consult your MAR-
UTI SUZUKI dealer or qualified
service technician for advice.
NOTICE
Severe damage may be caused by
the use of either poor quality fuel
and/or lubricants not recommended
by MARUTI SUZUKI.

3
68PH0-74E
WARRANTY POLICY
Maruti Suzuki India Limited (hereinafter called “Maruti Suzuki”),
warrants that each new Maruti Suzuki vehicle distributed in India
by Maruti Suzuki and sold by an authorised Maruti Suzuki NEXA
dealer will be free, under normal use and service, from any
defects in material and workmanship at the time of manufacture
SUBJECT TO THE FOLLOWING TERMS AND CONDITIONS:
(1) Qualification:
To qualify for this warranty:
The Maruti Suzuki vehicle must be delivered by authorised Maruti
Suzuki NEXA dealer and serviced by authorised Maruti Suzuki
workshop.
(2) Term:
The term of the warranty shall be twenty-four (24) months or
40,000 kilometers (whichever occurs first) from the date of
invoice to the first owner.
(3) Maruti Suzuki Warranty Obligation:
If any defect(s) should be found in a Maruti Suzuki vehicle within
the term stipulated above, Maruti Suzuki’s only obligation is to
repair or replace at its sole discretion any part shown to be defec-
tive, with a new part or the equivalent at no cost to the owner for
parts or labour, when Maruti Suzuki acknowledges that such a
defect is attributable to faulty material or workmanship at the time
of manufacture. The owner is responsible for any repair or replace-
ments which are not covered by this warranty.
(4) Limitation:
This warranty shall not apply to:
(a) Normal maintenance service required other than the three
free services, including without limitation, oil and fluid
changes, headlight aiming, fastener retightening, wheel bal-
ancing, wheel alignment and tyre rotation, cleaning of injec-
tors, adjustments of carburettor, ignition timing, clutch and
valve clearance.
(b) The replacement of normal wear parts including without lim-
itation, bulbs, tyres and tubes, spark plugs, belts, hoses, fil-
ters, wiper blades, brushes, contact points, fuses, clutch
disc, brake shoes, brake pads, cable and all rubber parts
(except oil seal and glass run).
(c) Any vehicle which has been used for competition or racing.
(d) Any repairs or replacement required as a result of accidents
or collision.
(e) Any defects caused by misuse, negligence, abnormal use or
insufficient care.
(f) Any vehicle which has been modified or altered, including
without limitation, the installation of performance accesso-
ries.
(g) Any vehicle on which parts or accessories not approved by
Maruti Suzuki have been used.
(h) Any vehicle which has not been operated in accordance with
the operating instructions in this Owner’s Manual and Ser-
vice Booklet.
(i) Any vehicle which has not received, during the warranty term,
the service inspections prescribed in this Owner’s Manual
and Service Booklet.
(j) Any vehicle which has been assembled, disassembled,
adjusted or repaired by other than authorised Maruti Suzuki
workshop.
(k) Any vehicle which has been used for purposes other than
what it was designed for.

4
68PH0-74E
(l) Any damage or deterioration caused by industrial pollution
and bird droppings.
(m) Insignificant defects which do not affect the function of the
vehicle including without limitation, sound, vibration and fluid
seep.
(n) Any natural wear and tear including without limitation, aging
etc.
(o) Installation and usage of domestic LPG gas/LPG Cylinder.
(p) V-belts, hoses and gas leaks.
(q) Any vehicle retrofitted with LPG/CNG kits.
(5) Extent of Warranty:
This warranty is the entire written warranty given by Maruti Suzuki
for Maruti Suzuki vehicles and no dealer or its or his agent or
employee is authorised to extend or enlarge this warranty and no
dealer or its or his agent or employee is authorised to make any
oral warranty on Maruti Suzuki’s behalf.
Maruti Suzuki reserves the right to add any improvements or
change the design of any model at any time with no obligation to
make the same changes on units previously sold.
(6) Warranty Service:
To obtain warranty service, the complete vehicle must be pre-
sented at the owner’s expenses to any authorised Maruti Suzuki
workshop.
(7) Owner’s Warranty Responsibilities:
It is responsibility of each owner to:
– Have performed, at his own expenses, by an authorised
Maruti Suzuki workshop all the service inspections specified
in the Maruti Suzuki “Owner’s Manual and Service Booklet
and maintain adequate proof that such service inspections
have been performed.
– Make certain that the authorised Maruti Suzuki workshop
has certified the work on the “Maintenance Service Record”
page in the “Owner’s Manual and Service Booklet and
– Present the Maruti Suzuki “Owner’s Manual and Service
Booklet to the authorised Maruti Suzuki workshop whenever
requesting service inspections or warranty service.
If the “Owner’s Manual and Service Booklet” should be lost or
destroyed the owner should consult the authorised Maruti Suzuki
workshop from whom the vehicle was purchased for instructions
concerning replacement of the “Owner’s Manual and Service
Booklet”.
(8) Disclaimer of Consequential Damage:
Maruti Suzuki assumes no responsibility for loss of vehicle, loss of
time, inconvenience or any other indirect incidental or consequen-
tial damage resulting from the vehicle not being available to the
owner because of any defect covered by this warranty.
(9) Change of Owner
Even if ownership of the vehicle changes, the remaining warranty
period is effective for the new owner.

5
68PH0-74E
EMISSION WARRANTY POLICY
Maruti Suzuki offers the Emission Warranty on all Maruti Suzuki
vehicles (apart from the Regular Warranty and will run parallel to
the regular product warranty) only in four metropolitan cities (New
Delhi, Kolkata, Mumbai and Chennai) with effect from July 1st,
2001.
Terms:
The Emission Warranty will be applicable for 80,000 kms or 3
years (Whichever comes earlier) from the date of invoice to the
first owner. The remaining warranty terms will be valid in case of
any change in ownership provided the production of all valid docu-
ments.
Conditions:
1. Under Emission Warranty, Warranty claims will be admitted for
a prima-facie examination, in case vehicle fails to meet the
Emission Standard as specified in sub rule (2) of rule no. 115
of Central Motor Vehicles Rules (CMVR), 1989.
2. The warranty claims will only be accepted after examination
carried out by Maruti Suzuki or authorised Maruti Suzuki work-
shop which leads to firm conclusions that the
a) Original settings have not been tampered in any case.
b) Part (as given in Annexure - A) has a manufacturing defect.
c) Vehicle is unable to meet the Emission Standards (as given
in 1.), inspite of the vehicle having been maintained and
used in accordance with the instructions as specified in
Owner’s Manual and Service Booklet and the used fuel and
different oils (Engine oil, Transmission oil, Brake oil etc.) are
also as per specification.
3. The method of examination for deciding the warranty of the
parts will be at the sole discretion of Maruti Suzuki and autho-
rised Maruti Suzuki workshop and results of the examination
will be final and binding. If after examination, the warrantable
condition is not established, Maruti Suzuki and authorised
Maruti Suzuki workshop has the right to charge all, or part of
the cost of such examination.
4. Under Emission Warranty, the parts (as given in Annexure - A)
will be changed free of cost, but the consumables will be
charged as per actual.
5. If the part covered under Emission Warranty or the associated
parts, are not independently replaceable, on account of these
being integral parts of a complete assembly, Maruti Suzuki and
authorised Maruti Suzuki workshop will have the sole discre-
tion to replace either the entire assembly or by using some of
the parts of the system through suitable repairs or modifica-
tions.
6. Any consequential repairs or replacement of parts which may
be found necessary to establish compliance of Emission War-
ranty, will not be considered under warranty, unless the same is
under product warranty. The consumable will be charged as
per actual under such repair or replacement.
7. Maruti Suzuki will not be responsible for the cost of transporta-
tion of the vehicle to the nearest authorised Maruti Suzuki
workshop or any loss due to non-availability of the vehicle
during the period of lodging of a warranty claim and examina-
tion and/or repair by Maruti Suzuki workshop.
8. Maruti Suzuki will not be responsible for any penalty that may
be charged by statutory authorities on account of failure to
comply with the EMISSION STANDARDS.
9. Emission Warranty will not be affected by the change of owner,
provided all the documents are available.

6
68PH0-74E
10. All maintenance actions (as specified in the Owner’s Manual
and Service Booklet) need to be followed and recorded in the
manual for emission warranty.
11. The customer needs to produce the PUC (Pollution Under
Control) certificate valid for the period preceding the test
during which the failure is discovered. The receipts (for the
maintenance of the vehicle as per specification in Owner’s
Manual and Service Booklet from the date of original pur-
chase of the vehicle) will also be required.
Conditions under which the Emission Warranty is not
APPLICABLE
1. In the absence of valid PUC certificate.
2. Vehicle not serviced from authorised Maruti Suzuki workshop
as per the schedule specified in the Owner’s Manual.
3. Vehicle subjected to abnormal use (accident, motor race, ral-
lies or for the purpose of establishing the records etc).
4. Use of non MGP (Maruti Genuine Part).
5. Vehicle that has been tampered with.
6. Tampering with odometer so that the actual kilometer reading
cannot be determined.
7. Use of adulterated fuel and/or unspecified oils (Engine oil,
Transmission oil and Brake oil etc).
Annexure - A
List of parts covered under Emission Warranty
1. Fuel Injection Assembly, Pressure Regulator, Throttle Body
Assembly.
2. Electronic Control Module (ECM).
3. Intake Manifold.
4. EGR valve.
5. Ignition Coil.
6. Canister Assembly.
7. Vapour Liquid Seperator.
8. Fuel Tank and Filler Cap.
9. PCV (Positive Crankcase Ventilation) Valve.
10. Oil Filler Cap.
11. Catalytic Convertor.
12. Exhaust Manifold.
13. All Fuel Injection System related SENSORS.
14. High Pressure Fuel Pump.
15. Glow Plug.
16. Glow Plug Controller.

76MH1-74E
TABLE OF CONTENTS
FUEL RECOMMENDATION 1
BEFORE DRIVING 2
OPERATING YOUR VEHICLE 3
DRIVING TIPS 4
OTHER CONTROLS AND EQUIPMENT 5
VEHICLE LOADING AND TOWING 6
INSPECTION AND MAINTENANCE 7
EMERGENCY SERVICE 8
APPEARANCE CARE 9
GENERAL INFORMATION 10
SPECIFICATIONS 11