Panasonic Nv-gs150eg User manual

rights reserved. Unauthorized copying and

distribution is a violation of law.

NV-GS150E

NV-GS150EG

NV-GS150EB

NV-GS150EP

NV-GS150GC

NV-GS150GN

NV-GS150GCD

NV-GS140E

NV-GS140EG

NV-GS140EB

NV-GS140EP

NV-GS158GK

VOL.1

A-MECHANISM

Colour

(S)....................Silver Type

Digital Video Camera / Recorder

ORDER NO.VM0502004C8

Downloaded From VideoCamera-Manual.com Manuals

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

1 Service Information Regarding Simultaneous Exchange of

MONITOR C.B.A. and LCD PANEL UNIT of NV-GS150, GS140

and GS158 4

1.1. Overview 4

1.2. How to Distinguish the Types of MONITOR C.B.A. and

LCD PANEL UNIT. 4

1.3. Difference Comparison Chart 5

1.4. Attention for exchange the MONITOR C.B.A.. 5

1.5. Attention for exchange the LCD PANEL UNIT. 5

2 INTRODUCTION 6

2.1. INTRODUCTION 6

2.2. ABOUT LEAD FREE SOLDER (PbF) 7

3 CAUTION FOR AC CORD (VJA0940 TYPE) 8

3.1. INFORMATION FOR YOUR SAFETY 8

3.2. CAUTION FOR AC MAINS LEAD 8

4 HOW TO REPLACE THE LITHIUM BATTERY (PROCEDURE) 9

5 ADJUSTMENT PROCEDURES 10

5.1. DISASSEMBLE FLOW CHART 10

5.2. DISASSEMBLY PROCEDURES 11

5.3. DISASSEMBLY PROCEDURES MECHA. UNIT 18

5.4. DISASSEMBLY PROCEDURES OF CAMERA LENS UNIT

6 SERVICE CAUTION 23

6.1. HOW TO DISCHARGE THE CAPACITOR ON FRONT

C.B.A. 23

6.2. EEPROM DATA FOR SPARE PARTS OF THE MAIN

C.B.A. 23

6.3. SERVICE EXTENSION CABLES. 23

6.4. LOCATION FOR CONNECTORS OF THE MAIN C.B.A. &

SUB C.B.A. 25

7 ELECTRICAL ADJUSTMENT PROCEDURES 27

7.1. COMPUTER ASSISTED ADJUSTMENT SYSTEM <

TATSUJIN > ADJUSTMENT. 27

7.2. SET-UP MANUAL FOR DV-Camcorder. 27

7.3. SET UP PC-EVR ADJUSTMENT PROGRAM 30

7.4. INITIAL GUIDELINE 31

8 MECHANICAL ADJUSTMENT PROCEDURES 32

8.1. ADJUSTMENT ITEM 32

8.2. ADJUSTMENT PROCEDURES 32

9 SERVICE MODE 34

9.1. ERROR DISPLAY 34

9.2. SERVICE MENU 35

10 WAVEFORM TABLE 36

11 SCHEMATIC DIAGRAM 37

11.1. OVERALL SCHEMATIC DIAGRAM 37

11.2. INTERCONNECTION SCHEMATIC DIAGRAM 38

11.3. SIDE (L) FLEX. CARD / CASSETTE COVER

SCHEMATIC DIAGRAM 40

11.4. LCD HINGE (MONITOR FLEX.) SCHEMATIC DIAGRAM

11.5. REAR OPERATION UNIT SCHEMATIC DIAGRAM 40

11.6. EVF SCHEMATIC DIAGRAM 40

11.7. CCD FLEX. CARD SCHEMATIC DIAGRAM 41

11.8. FRONT SCHEMATIC DIAGRAM 42

11.9. JACK SCHEMATIC DIAGRAM 43

11.10. SIDE (R) / LCD DET. SCHEMATIC DIAGRAM 44

11.11. MONITOR SCHEMATIC DIAGRAM 45

12 CIRCUIT BOARD ASSEMBLIES 47

12.1. EVF C.B.A. 47

12.2. LCD DET. C.B.A. 47

12.3. SIDE (R) C.B.A. 47

12.4. CCD FLEX. CARD C.B.A. 48

12.5. FRONT C.B.A. 49

12.6. JACK C.B.A. 50

12.7. MONITOR C.B.A. 51

13 EXPLODED VIEWS 53

13.1. FRAME & CASING SECTION (1) 53

13.2. FRAME & CASING SECTION (2) 54

13.3. LCD SECTION 55

13.4. CAMERA LENS SECTION 56

13.5. VCR MECHANISM SECTION 57

13.6. PACKING PARTS & ACCESSORIES SECTION 58

14 REPLACEMENT PARTS LIST 59

14.1. FRAME & CASING SECTION (1) PARTS LIST 59

14.2. FRAME & CASING SECTION (2) PARTS LIST 59

14.3. LCD SECTION PARTS LIST 60

14.4. CAMERA LENS SECTION PARTS LIST 60

14.5. VCR MECHANISM SECTION PARTS LIST 60

14.6. PACKING PARTS & ACCESSORIES SECTION PARTS

LIST 60

14.7. ELECTRICAL REPLACEMENT PARTS LIST 61

CONTENTS

Page Page

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

1 Service Information Regarding Simultaneous Exchange

of MONITOR C.B.A. and LCD PANEL UNIT of NV-GS150,

GS140 and GS158

1.1. Overview

DVC model NV-GS150, GS140 and GS158 will be manufactured 4 distinctly different MONITOR C.B.A. and 2 distinctly different

LCD PANEL UNIT.

These 4 version of MONITOR C.B.A. will be referred to as C.B.A. type “A”, “B”, “C” and “D”.

These 2 version of LCD PANEL UNIT will be referred to as UNIT type “A” and “B”.

There are not the exchangeability between the “A”, “B”, “C” and “D” of MONITOR C.B.A..

There are not the exchangeability between the “A” and “B” of LCD PANEL UNIT.

MONITOR C.B.A. and LCD PANEL UNIT supply it the kit.

(Do not supply it in one of each individually MONITOR C.B.A. and LCD PANEL UNIT.)

1.2. How to Distinguish the Types of MONITOR C.B.A. and LCD PANEL

UNIT.

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

1.3. Difference Comparison Chart

1.4. Attention for exchange the MONITOR C.B.A..

In the case that the LCD PANEL UNIT is TYPE “A”.

Replace the chip resistor of R901 and R910 to the chip resistor that is doing the same pack to the kit.

R901 ERJ3RBD182 →ERJ3GEY0R00

R910 ERJ3RBD822 →ERJ3RBD682

In the case that the LCD PANEL UNIT is TYPE “B”.

Exchange only the MONITOR C.B.A..

1.5. Attention for exchange the LCD PANEL UNIT.

In the case that the MONITOR C.B.A. is TYPE “A” and “B”.

Replace the chip resistor of R901 and R910 to the chip resistor that is doing the same pack to the kit.

R901 ERJ3RBD182 →ERJ3GEY0R00

R910 ERJ3RBD822 →ERJ3RBD682

In the case that the MONITOR C.B.A. is TYPE “C” and “D”.

Exchange only the LCD PANEL UNIT.

CAUTION:

It does the confirmation of the MONITOR C.B.A. and LCD PANEL UNIT without fail on the occasion of the repair and please

do the part exchange.

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

2 INTRODUCTION

2.1. INTRODUCTION

This service manual contains technical information which will allow service personnel´s to understand and service this

model.Please place orders using the parts list and not the drawing reference numbers.

If the circuit is changed or modified, this information will be followed by supplement service manual to be filed with original service

manual.

Note 1:

These movie camera uses AC Adaptor VSK0651A or VSK0651B.

Note 2:

1) This service manual does not contain the following information, because of the impossibility of sevicing at component level.

1.Schematic Diagram, Block Diagram and C.B.A. layout of Main C.B.A./ Sub C.B.A.

2.Parts List for individual parts of Main C.B.A./ Sub C.B.A.

2) The following category is/are recycle module part. Please send it/them to Central Repair Center.

*Main C.B.A. (VEP03G73B: NV-GS150E/EG/EB/EP, VEP03G73C: NV-GS150GC/GN/GCD,

VEP03G73G: NV-GS140 SERIES,VEP03G73D: NV-GS158GK)

*Sub C.B.A. (VEP23612B: NV-GS150 SERIES, NV-GS140 SERIES, NV-GS158GK)

When a part replacement is required for repairing each Main C.B.A., replace the assembly parts.

(Main C.B.A. and Sub C.B.A.)

The following circuits are contained in Main C.B.A.

1.Main Connection Circuit

2.AVIO Circuit

3.Video Circuit

4.Power Circuit

5.Control Circuit

The following circuits are contained in Sub C.B.A.

1.Sub Connection Circuit

2.LCD Circuit

3.Lens Drive Circuit

4.Sub Power Circuit

5.Camera Circuit

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

2.2. ABOUT LEAD FREE SOLDER (PbF)

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

3 CAUTION FOR AC CORD

(VJA0940 TYPE)

3.1. INFORMATION FOR YOUR

SAFETY

IMPORTANT

Your attention is drawn to the fact that recording of pre-

recorded tapes or discs or other published or broadcast

material may infringe copyright laws.

WARNING

To reduce the risk of fire or shock hazard, do not expose

this equipment to rain or moisture.

CAUTION

To reduce the risk of fire or shock hazard and annoying

interference, use the recommended accessories only.

FOR YOUR SAFETY

DO NOT REMOVE THE OUTER COVER

To prevent electric shock, do not remove the cover. No user

serviceable parts inside. Refer servicing to qualified service

personnel.

3.2. CAUTION FOR AC MAINS

LEAD

For your safety, please read the following text carefully.

This appliance is supplied with a moulded three-pin mains plug

for your safety and convenience.

A 5-ampere fuse is fitted in this plug.

Should the fuse need to be replaced please ensure that the

replacement fuse has a rating of 5 amperes and it is approved

by ASTA or BSI to BS1362

Check for the ASRA mark or the BSI mark on the body of the

fuse.

If the plug contains a removable fuse cover you must ensure

that it is refitted when the fuse is replaced.

If you lose the fuse cover, the plug must not be used until a

replacement cover is obtained.

A replacement fuse cover can be purchased from your local

Panasonic Dealer.

If the fitted moulded plug is unsuitable for the socket outlet in

your home then the fuse should be removed and the plug cut

off and disposed of safety.

There is a danger of severe electrical shock if the cut off plug

is inserted into any 13-ampere socket.

If a new plug is to be fitted please observe the wiring code as

shown below.

If in any doubt, please consult a qualified electrician.

3.2.1. Important

The wires in this mains lead are coloured in accordance with

the following code:

Blue Neutral

Brown Live

As the colours of the wires in the mains lead of this appliance

may not correspond with the coloured markings identifying the

terminals in your plug, proceed as follows:

The wire which is coloured BLUE must be connected to the

terminal in the plug which is marked with the letter N or

coloured BLACK.

The wire which is coloured BROWN must be connected to the

terminal in the plug which is marked with the letter L or coloured

RED.

Under no circumstances should either of these wires be

connected to the earth terminal of the three pin plug, marked

with the letter E or the Earth Symbol.

3.2.2. Before use

remove the Connector Cover as follows.

3.2.3. How to replace the Fuse

1.Remove the Fuse Cover with a screwdriver.

2.Replace the fuse and attach the Fuse cover.

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

4 HOW TO REPLACE THE LITHIUM BATTERY

(PROCEDURE)

1.Remove the Side Case (L) C.B.A.. (Refer to Disassembly Procedures.)

2.Unsolder the Lithium Battery “ML-621S/F9D” and then replace the new one. (See Fig. B1.)

3.Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type.

Fig. B1

Note:

The lithium battery is a critical component. (Type No.: N9ZZ00000288.)

It must never be subjected to excessive heat or discharge.

It must therefore only be fitted in equipment designed specifically for its use.

Replacement batteries must be of the same type and manufacture.

They must be fitted in the same manner and location as the original battery, with the correct polarity contacts observed.

Do not attempt to re-charge the old battery or re-use it for any other purpose.

It should be disposed of in waste products destined for burial rather than incineration.

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

5 ADJUSTMENT PROCEDURES

5.1. DISASSEMBLE FLOW CHART

This flow chart indicates the disassembly steps the cabinet parts, C.B.A. and Mecha. Unit in order to access to be serviced. When

reinstalling, perform the steps in the reverse order.

Fig. F1

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

5.2. DISASSEMBLY PROCEDURES

Flow-Chart for Disassembly Procedure

No. Item / Part Fig. Removal (Screw,Connector,Flex. &

Other)

1 Front Case

Unit Fig. D2 Remove the Grip Belt Piece with the

procedure of arrow 1,2,3.

Fig. D3 1-Screw (A)

Fig. D4 Open the LCD Unit

1-Screw (B), 2-Screws (C)

Fig. D5 1-Connector FP4801

Front Case Unit

2 Side Case (R)

Unit Fig. D6 2-Screws (D)

Fig. D7 2-Screws (E), 1-Screw (F)

Fig. D8 2-Connectors FP602, FP6503

Side Case (R) Unit

3 Lens Unit Fig. D9 1-Screw (G)

2-Connectors FP201, FP701

Lens Unit

4 EVF/Rear

Operation

Unit,.Sub

C.B.A

Fig. D10 1-Screw (H), 2-Screws (I), 1-Screw (J)

4-Connectors FP601, FP1001,

FP3402, FP6502

EVF/Rear Operation Unit

2-Connectors FP304, PS3001

Sub C.B.A.

5 Main C.B.A. Fig. D11 8-Connectors FP2201, FP2202,

FP2203, FP2204, FP5001,

FP6501,FP6504, FP6505

1-Screw (K)

4-Tabs

Main C.B.A.

6 Mecha. Unit Fig. D12 Open the Cassette Cover

3-Screws (L)

Mecha. Unit

7 Jack C.B.A. Fig. D13 1-Screw (M), 1-Screw (N), 1-Screw (O)

Jack C.B.A.

8 Front C.B.A. Fig. D14 5-Screws (P)

3-Tabs

Front C.B.A.

9 Monitor C.B.A. Fig. D15 1-Screw (Q), 3-Screws (R)

Rear Cover

Fig. D16 Turning the LCD Unit

2-Screws (S)

LCD Unit

Fig. D17 2-Screws (T)

6-Tabs

LCD Case (Upper) Unit

Fig. D18 1-Connector FP902

LCD Hinge Unit

Fig. D19 1-Connector FP901

2-Tabs

Monitor C.B.A.

10 EVF C.B.A. Fig. D20 View ADJ. Unit is Drawn

1-Screw (U)

Rear Operation Unit

Fig. D21 1-Screw (V)

2-Tabs

EVF Hold Piece

Fig. D22 2-Screws (W)

2-Tabs

View ADJ. Unit

2-Screws (X), 2-Slide Spacers (Y)

1-Connector FP801

EVF LCD Unit

Fig. D23 2-Screws (Z)

EVF Plate / Click Spring

Fig. D24 1-Connector FP802

3-Tabs

EVF C.B.A.

Fig. D1

Fig. D2

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. D3

Fig. D4

Fig. D5

Fig. D6

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. D7

Fig. D8

Fig. D9

Fig. D10

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. D11

Fig. D12

Fig. D13

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. D14

Fig. D15

Fig. D16

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. D17

Fig. D18

Fig. D19

Fig. D20

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. D21

Fig. D22

Fig. D23

Fig. D24

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

5.3. DISASSEMBLY PROCEDURES MECHA. UNIT

Flow-Chart for Disasswmbly Procedures

No. Item / Part Fig. Removal (Screw, Connector, Flex. & Other)

1 Cassette Up Unit Fig. M1 It makes the mechanism position in Eject condition (For Battery)

Fig. M2 3-Screws (A)

Fig. M3 3-Tabs

I remove the piece arrangement unit from rail department

2 Cylinder Unit Fig. M4 1-Screw (B)

Fig. M5 3-Screw (C)

Cylinder Unit

Fig. M1

Fig. M2

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. M3

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals

Fig. M4

Fig. M5

NV-GS150E / NV-GS150EG / NV-GS150EB / NV-GS150EP / NV-GS150GC / NV-GS150GN / NV-GS150GCD / NV-GS140E / NV-GS140EG / NV-GS140EB / NV-GS140EP / NV-GS158GK

Downloaded From VideoCamera-Manual.com Manuals